Opel Astra HB (FlieÃƒÂŸheck) D Montage- und ... - Westfalia

More documents

Recommendations

Info

GBTowing hitch Without electrical setManufacturer: WESTFALIA-AUTOMOTIVE GmbH & Co. KG Westfalia order no.: 314 217Approval no. as per Guideline 94/20/EC: e13 00-0057Class: A50-X Model: 314 194Technical data: Maximum D-value: 8,0 kNMaximum nose weight: 75 kgArea of application: Vehicle manufacturer:Model:Model designation:OpelAstra HB (Hatchback)Opel Astra - F - CCT 92General information:The vehicle manufacturer’s specifications regarding trailer load and nose weight are decisivefor driving, and the values specified for the towing hitch must not be exceeded.The towing hitch serves for towing trailers fitted with ball couplings and for use with load carriersapproved for attachment to the towing hitch. Any use other than that specified is prohibited. Drivingwith a trailer must be adapted to the road conditions. The vehicle’s handling is affected when a traileris being towed. Follow the vehicle manufacturer’s instructions.The fixing points specified as standard must be observed.National guidelines concerning official approval of auxiliaries must be observed.These installation and operating instructions must be enclosed with the vehicle papers.Installation instructions:The towing hitch is a safety component and must only be installed by qualified personnel.Any alteration or conversion to the towing hitch is prohibited, and would lead to cancellation ofdesign certification.Remove insulating compound and underseal from vehicle (if present) in the area of the matingsurfaces of the towing hitch. Seal any bare bodywork and bores with anti-corrosive paint.Operating instructions:Again tighten all securing bolts of the towing hitch after approx. 1000 trailer km, observing specifiedtightening torques.The towing hitch must be kept clean and greased. However, if a stabilisation device, e.g.Westfalia “SSK”, is used, the towing hitch must be free from grease. Follow the instructions inthe relevant operating instructions.As soon as the towing hitch diameter is 49.0 mm or less at any point, it must no longer be usedfor safety reasons.After the towing hitch is fitted, the empty weight of the vehicle increases by 13 kg.18
Installation Instructions:GB1.) Remove the spare wheel and tool kit from the well in the floor pan. Remove the rear paneltrim and the rear bumper.2.) Lay reinforcement plate 2 on the floor of the luggage compartment and locate the 11 punchmarks for the fixing holes and 1 punch mark for the rubber grommet hole for the wiringharness.3.) Drill 2 ø 12-mm holes through the floor pan at positions „a" and „b". The holes are alreadypresent in the frame side members.4.) Drill ø 14-mm holes through the rear panel at positions „c" and through the floor pan atpositions „d".5.) Drill the hole for the wiring harness rubber grommet – to fit the size of the grommet – throughthe rear wall. The punch mark is already present.6.) Lay reinforcement plate 2 on the floor of the luggage compartment. Insert spacers 3 into theframe side members from below and bolt them loosely to reinforcement plate 2 at positions„a" and „b".7.) Hold towing bracket 1 against the rear panel from outside and bolt it loosely to the rear paneland reinforcement plate 2 at positions „c".8.) Bolt reinforcement plate 2 loosely to the floor pan at positions „d".9.) First tighten all the bolts at positions „c" at the rear panel and at positions „d" at the floorpan, and then the bolts at positions „a" and „b" to a tightening torque of 40 Nm.10.) Cut away the bumper as indicated by the small markings on the inside of the bumper.Note: Please contact your local Opel dealer to find out whether any modifications have to be madeto the vehicle (cooling system, suspension) when a towing bracket is mounted.Subject to alteration.19
Page 1 and 2: DCZDKEFFINGBGRINNLSPLMontage- und B
Page 3: DCZDKEFFINGBGRINNLSPLLieferbare Ers
Page 6 and 7: DAnhängevorrichtung (Kupplungskuge
Page 8 and 9: CZ Tažna zaøizeni bez elektropø
Page 10 and 11: DKAnhængertræk uden el-sætFabrik
Page 12 and 13: E Enganche juego eléctricoFabrican
Page 14 and 15: F Attelage sans kit électriqueMarq
Page 16 and 17: FIN Vetokoukut Ilman sähköosiaVal
Page 20 and 21: GR÷ø¦¯¼¯€¢ÿ €ªø¦ð¢
Page 22 and 23: IGancio di traino Senza kit elettri
Page 24: MINISTERO DEI TRASPORTI E DELLA NAV
Page 31 and 32: Monteringsveiledning:N1.) Ta reserv
Page 33 and 34: Montagehandleiding:NL1.) Neem het r
Page 35 and 36: Monteringsanvisning:S1.) Tag ut res
Page 37: PLInstrukcja monta¿u:1.) Wyj¹æ z

Opel Astra HB (FlieÃƒÂŸheck) D Montage- und ... - Westfalia

Create successful ePaper yourself

Delete template?

Save as template?