Fresh IC - no running light_Layout 1 - Whale

More documents

Recommendations

Info

Annual Checks • Whale® advise that the boat's plumbing system is checked annually for leaks and obstructions. Also a pump electrics check is advisable. 12. TROUBLE SHOOTING Pump does not run No power to pump Fuse has blown Check power supply Attach leads / clean connections Replace fuse Blockage in pipework Check pipework for kinks Pump runs but no water appears Pump runs but will not switch off Pump cycles on and off periodically when all the taps are closed. Noisy operation Low flow Extra delay before pump switches off No water getting to pump Pressure relief valve too low Water leaking at outlet side of pump Water leaking at outlet side of pump Check the water tank is not empty. Check strainer is not blocked. Check all connections from tank to inlet of pump are secure - any air leaks will prevent prime Check water supply level and pressure relief settings. Ensure these are > 5 bar Check pipework/fittings for leaks and repair. Check system drain plugs are closed Check pipework/fittings for leaks and repair. Check system drain plugs are closed Check water supply level and pressure relief Pressure relief valve set too low settings. Ensure these are > 5 bar (73 psi) Water leaking at outlet side of pump Check pipework/fittings for leaks and repair. Check system drain plugs are closed. Pressure relief valve too low Pump drawing air See 'no water getting to pump' (above) Noise created by vibration Check pump is secured to solid surface. Check pump body is not in contact with hard surfaces. Locate away from interfering surfaces. Check pipework is securely supported Bore of pipework connection too Ensure 10mm minimum bore. small Power supply to pump Pipework/connections crushed due to over tightened jubilee clips Check power supply to pump uses correct gauge wire 2.5mm²/AWG 13) to give full voltage at pump. Check battery is not discharged Replace damaged connections Pump too far from water tank Pump is best situated beside water tank Water leaking at outlet side of pump Pump strainer clogged Accumulator Tank present on cold water circuit Check pipework/fittings for leaks and repair Check system drain plugs are closed Remove clear lid, rinse and replace to main strainer body (retain strainer mesh for lid) Remove accumulator tank NOTE- Expansion vessel on hot water circuit will delay pump deactivation 13. WINTERIZING If water is allowed to freeze in the system, serious damage to the pipe work and pump may occur. To best avoid this damage, completely drain the water system. 1. Drain the tank either using the pump or a drain valve. 2. Open all the faucets (including drain valve) and allow pump to purge the water from the system, and then turn the pump off.
3. Disconnect the pump and turn on to purge into an adequate basin. Only reconnect the pump when the water system is to be used. 4. Remember to leave all faucets including showers open to avoid any damage except for Whale Twist Deck Shower. 14. SERVICE SUPPORT DETAILS The following service kits are available for the Fresh IC: Spares Kit Part No: AK1319 - Replacement Strainer 15. PATENTS AND TRADEMARKS Whale® is a registered trademark of Munster Simms Engineering limited. Fresh IC is protected by the folowing patents: USA: 6,840,745 Canada: 2 380 465 UK: GB 1 222 392 France: FR 1 222 392 Italy: IT 1 222 392 Germany: DE 60018089.1(EP(DE) 1 222 392) Santoprene® is a registered trade name of Advanced Elastomer Systems, LP, an Exxonmobil Chemical Affiliate Delrin® Teflon® and Neoprene are registered trade names of Dupont Neumeurs and Co. Monprene® is a registered trade name of Technore Apex 16. WARRANTY STATEMENT This Whale ® product is covered by 1 year warranty. Please see enclosed document for details of our statement of limited warranty This product complies with all relevant European directives and standards. Please contact Whale® if further details are required. 17. EU DECLERATION OF CONFORMITY, STANDARDS & APPROVALS We hereby declare, under our sole responsibility, that the enclosed equipment complies with the provisions of the following EC Directives. Electromagnetic Compatibility Directive 2004/108/EC on the approximation of the laws of the Member States relating to electromagnetic compatibility. Low Voltage Directive 73/23/EEC amended by 93/68/EEC on the harmonization of the laws of the Member States relating to electrical equipment designed for use within certain voltage limits. CE mark affixed: 30/08/10 Basis on which conformity is declared The above equipment complies with the protection requirements of the EMC Directive and the principal elements of the safety objectives of the Low Voltage Directive. Standards applied ISO10133:2000 Extra-low voltage DC Installation EN55014-1:2006 EMC Emissions EN55014-2:1997+A2:2008 EMC Immunity EN28846 :1993 Ignition Protection ABYC-H23 Installation of Potable Water Signed Date: 30/08/10 Position: Engineering Director
Page 1 and 2: INSTALLATION AND OPERATION MANUAL W
Page 3 and 4: 3. PRINCIPLES OF OPERATION IC - Int
Page 5: • Fit an isolating switch with ad
Page 9 and 10: 3. PRINCIPES DE FONCTIONNEMENT IC -
Page 11 and 12: • Connectez le fil rouge au fil p
Page 13 and 14: 13. HIVERAGE Si de l'eau est amené
Page 15 and 16: 3. BETRIEBSRICHTLINIEN IC - Intelli
Page 17 and 18: Elektrische Verkabelung • Verwend
Page 19 and 20: den Wasserleitungen und der Pumpe e
Page 21 and 22: 3. PRINCIPI DI FUNZIONAMENTO IC - T
Page 23 and 24: ATTENZIONE! Pericolo di incendio. I
Page 25 and 26: 4. Ricordarsi di lasciare aperti tu
Page 27 and 28: 3. PRINCIPIOS DE FUNCIONAMIENTO IC
Page 29 and 30: interruptor aislante cuando nadie e
Page 31 and 32: sistema de agua. 1. Vacíe el depó
Page 33 and 34: 3. FUNKTIONSPRINCIP IC - intelligen
Page 35 and 36: • Använd vattentäta (IP65) kont
Page 37 and 38: 3. ur systemet. Stäng därefter av
Page 39 and 40: 3. TOIMINTAPERIAATTEET IC - Älykä
Page 41 and 42: • Käytä vesitiiviitä (IP65) li
Page 43 and 44: 2. Avaa kaikki hanat (myös tyhjenn

Fresh IC - no running light_Layout 1 - Whale

Create successful ePaper yourself

Delete template?

Save as template?