Sinterizazio-atmosferaren eragina M graduko (ASP 30 ... - Euskara
Sinterizazio-atmosferaren eragina M graduko (ASP 30 ... - Euskara Sinterizazio-atmosferaren eragina M graduko (ASP 30 ... - Euskara
TABLE I Chemical analysis of as-received steel powders, wt-% C Si Cr O CO V Cu Mn Mo Ni P S W Px30 1 .33 0 .31 4 .28 488ppm 8 .70 3 .32 0 .08 0 .23 5 .14 0 .29 0 .024 0 .015 6 .63 Px30S 1 .29 0 .20 4 .03 667ppm 8 .45 2 .96 0 .09 0 .64 4 .83 0 .21 0 .022 0 .22 6 .25 TABLE II Sieve analysis of as-received steel powders powders Particle size (um) +150 +110 -+75 +63 +45 Px30 cumulative fraction (%) 0 .65 14 .85 25 .1 22 .9 Px30S cumulative fraction (%) 0 .09 9 .46 28 .4 66 .0
TABLE III Carbon, Nitrogen . and Oxygen contents and density at optimum sintering temperatu] Condition C N O Density Temperature (% wt) q/cc (°C) Px30 Powder 1 .37 0 .015 0 .075 Px30S Powder 1 .29 NE 0 .0667 Px30 +0 .2%C Powder 1 .57 NE NE Px30S+0 .2%C Powder 1 .50 0 .0065 0 .18 GAS sintered Px30 1 .24 0 .76 0 .025 8 .11 1230 Px30S 1 .27 0 .453 0 .161 8 .01 1230 Px30+0 .2%C 1 .55 0 .71 0 .038 8 .00 1205 Px30S+0 .2%C 1 .43 0 .436 0 .0708 7 .95 1210 VACUUM sintered Px30 1 .29 0 .012 0 .012 8 .04 1260 Px30S 1 .26 0 .0074 0 .0088 7 .94 1255 Px30+0 .2%C 1 .49 0 .012 0 .014 7 .92 1250 Px30S+0 .2%C 1 .43 0 .0081 0 .0176 7 .97 1240
- Page 299: PUBLICACIONES . Publicaciones gener
- Page 303 and 304: 306 Urr uibeaskoa et al . Metallogr
- Page 305 and 306: 308 Urrutibeaskoa et al . Metallogr
- Page 307 and 308: 310 Urrutibeaskoa et al . Metallogr
- Page 309: 312 Urrutibeaskoa et al . Metallogr
- Page 314 and 315: Figure 1 Microstructure of T42 + 0.
- Page 316 and 317: Figure 3 Microstructure of T15 (1 .
- Page 318 and 319: . . . 4 --s-- r a- 10 im Figure 5 M
- Page 320 and 321: TABLE V Chemical analysis of M 23 C
- Page 324 and 325: AVOIDING GRAIN GROWTH DURING THE SU
- Page 326 and 327: 90 o GT42 80 o e GT42C VT42 * VT42C
- Page 328 and 329: The presence of these MX carbonitri
- Page 332 and 333: Publishing & Editorial The Institut
- Page 334 and 335: INTRODUCTION Work carried out in th
- Page 336 and 337: etter than 5 Pa during the sinterin
- Page 338 and 339: gas atmosphere (see Table IV for qu
- Page 340 and 341: - Needle type : observed only at hi
- Page 342 and 343: -1o- (18) . These values would give
- Page 344 and 345: Chemical composition of primary car
- Page 346 and 347: CONCLUSIONS 1 . Addition of free ca
- Page 348 and 349: Vasco, 1987, Bilbao, España . 13 .
- Page 352 and 353: TABLE IV Austenite grain size and p
- Page 354 and 355: TABLE VII Chemical composition of C
- Page 356 and 357: 8 .5 8 `/ U) 7 c o 6 .5 6 5 .5 1 1
- Page 358 and 359: Fig . 3 : Microstructure at the opt
- Page 360 and 361: L Ú y i3 70 60 30 - L 2 0 r- i Q L
- Page 362 and 363: Frecuency (%) 100 90 - 80 70 - 60 -
- Page 364 and 365: Frecuency (%) 100 90 - 80 - 70 - 60
- Page 366 and 367: Fig. 8 a) Eutectic type carbides .
- Page 369 and 370: March 10, 1992 Mr . J . J . Urcola
- Page 371 and 372: INTRODUCTION Work carried out in th
- Page 373 and 374: sintered is observed in Table II .
- Page 375 and 376: DISCUSSION Densification Kinetics .
- Page 377 and 378: particle size smaller than 1 µm, w
- Page 379 and 380: primary carbides present in the mic
- Page 381 and 382: REFERENCES : 1 . F .L. Jaegger and
- Page 383 and 384: CONDICION I C N (%owt) (%wt) O (%wt
- Page 385 and 386: CONDICION Temperatura de sintetizad
- Page 387 and 388: 1 a v~ 00 v~ N 0o N ( £ m3/2) kLIS
- Page 389 and 390: u ( £ m0/ 2 ) xi ISNEIQ J 0 N M r-
- Page 391 and 392: Fig . 5 . Microstructure of T15 spe
- Page 393 and 394: N + D X O 0 0 0 0 0 0 0 I_ \o cn m
- Page 395 and 396: O ó P .4 W ~ C7 3 ,a o z N ~ .~ á
- Page 397 and 398: Q O x á á á 0 0 0 0 0 0 0 VI) L
- Page 399 and 400: ∎ ∎ o In o Ln o ~n tt M M N N (
TABLE III<br />
Carbon, Nitrogen . and Oxygen contents and density at optimum sintering temperatu]<br />
Condition C N O Density Temperature<br />
(% wt) q/cc (°C)<br />
Px<strong>30</strong> Powder 1 .37 0 .015 0 .075<br />
Px<strong>30</strong>S Powder 1 .29 NE 0 .0667<br />
Px<strong>30</strong> +0 .2%C Powder 1 .57 NE NE<br />
Px<strong>30</strong>S+0 .2%C Powder 1 .50 0 .0065 0 .18<br />
GAS sintered<br />
Px<strong>30</strong> 1 .24 0 .76 0 .025 8 .11 12<strong>30</strong><br />
Px<strong>30</strong>S 1 .27 0 .453 0 .161 8 .01 12<strong>30</strong><br />
Px<strong>30</strong>+0 .2%C 1 .55 0 .71 0 .038 8 .00 1205<br />
Px<strong>30</strong>S+0 .2%C 1 .43 0 .436 0 .0708 7 .95 1210<br />
VACUUM sintered<br />
Px<strong>30</strong> 1 .29 0 .012 0 .012 8 .04 1260<br />
Px<strong>30</strong>S 1 .26 0 .0074 0 .0088 7 .94 1255<br />
Px<strong>30</strong>+0 .2%C 1 .49 0 .012 0 .014 7 .92 1250<br />
Px<strong>30</strong>S+0 .2%C 1 .43 0 .0081 0 .0176 7 .97 1240