VW MKII A2 MK2 Golf Jetta Fox Service Manual - VAGLinks.com

More documents

Recommendations

Info

2B•8 Engine repair procedures - 1.05 and 1.3 litre post August 1985 7 Press the tappet down using a wooden or plastic wedge (see illustration). 8 If free travel of the tappet exceeds that specified, the tappet must be renewed. 13 Engine - adjustments after major overhaul 2 If the valve tappets have been renewed, it is essential that no attempt to restart the engine is made for a minimum period of 30 minutes after installation. Failure to observe this precaution may result in engine damage caused by the valves contacting the pistons. 12.7 Checking hydraulic tappet free travel 1081 VW Golf & Jetta
Chapter 2 Part C: Engine repair procedures - 1.6 and 1.8 litre 8 valve Contents Camshaft - removal, examination and refitting . . . . . . . . . . . . . . . . . 10 Crankshaft and bearings - examination and renovation . . . . . . . . . . 22 Crankshaft and main bearings - refitting . . . . . . . . . . . . . . . . . . . . . . 30 Crankshaft and main bearings - removal . . . . . . . . . . . . . . . . . . . . . 15 Cylinder block/crankcase - examination and renovation . . . . . . . . . 23 Cylinder head - dismantling and overhaul . . . . . . . . . . . . . . . . . . . . . 12 Cylinder head - refitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 Cylinder head - removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Engine - adjustments after major overhaul . . . . . . . . . . . . . . . . . . . . 39 Engine - refitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 Engine - removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Engine ancillary components - removal . . . . . . . . . . . . . . . . . . . . . . 8 Engine ancillary components refitting . . . . . . . . . . . . . . . . . . . . . . . . 36 Engine dismantling - general information . . . . . . . . . . . . . . . . . . . . . 7 Engine reassembly - general information . . . . . . . . . . . . . . . . . . . . . 29 Engine/gearbox - separation and reconnection . . . . . . . . . . . . . . . . 6 Examination and renovation - general information . . . . . . . . . . . . . . 21 Flywheel/driveplate - examination and renovation . . . . . . . . . . . . . . 27 General information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Hydraulic bucket tappets - checking free travel (from August 1985) . . 38 Degrees of difficulty Easy, suitable for novice with little experience 1 Specifications Fairly easy, suitable for beginner with some experience 2 Fairly difficult, suitable for competent DIY mechanic General Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Four-cylinder in-line, water cooled, overhead camshaft Code: 1.6 litre: Without catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . EZ With catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RF 1.8 litre: Jetronic - fuel injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . EV Carburettor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GU GTi - January 1987 on: Without catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PB, GU With catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RH, RP, PF Firing order . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3-4-2 (No 1 at camshaft sprocket end) Displacement: 1.6 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1595 cc 1.8 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1781 cc Bore: 1.6 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81.0 mm 1.8 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81.0 mm Stroke: 1.6 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77.4 mm 1.8 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86.4 mm Compression ratio: 1.6 litre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9.0 to 1 1.8 litre Code RP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9.0 to 1 All other codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10.0 to 1 1081 VW Golf & Jetta 2C•1 Intermediate shaft - examination and renovation . . . . . . . . . . . . . . . 26 Intermediate shaft - refitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Intermediate shaft - removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Major operations only possible after removal of engine from vehicle . . 3 Major operations possible with engine in vehicle . . . . . . . . . . . . . . . 2 Method of engine removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Oil cooler - removal and refitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Oil filter - renewal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 Oil filter mounting - removal and refitting . . . . . . . . . . . . . . . . . . . . . 19 Oil pump - examination and renovation . . . . . . . . . . . . . . . . . . . . . . 25 Oil seals - renewal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Pistons and connecting rods - examination and renovation . . . . . . . 24 Pistons and connecting rods - refitting . . . . . . . . . . . . . . . . . . . . . . . 32 Pistons and connecting rods - removal . . . . . . . . . . . . . . . . . . . . . . . 14 Sump and oil pump - removal and refitting . . . . . . . . . . . . . . . . . . . . 13 Timing belt and sprockets - examination and renovation . . . . . . . . . 28 Timing belt and sprockets - refitting . . . . . . . . . . . . . . . . . . . . . . . . . 35 Timing belt and sprockets - removal . . . . . . . . . . . . . . . . . . . . . . . . . 9 Valve clearances - checking and adjustment (pre August 1985) . . . 33 3 Difficult, suitable for experienced DIY mechanic 4 Very difficult, suitable for expert DIY or professional 5 2C
Page 1 and 2: Chapter 1 Routine maintenance and s
Page 3 and 4: CO content (%) 1.05 litre carburett
Page 5 and 6: The maintenance intervals in this M
Page 7 and 8: Maintenance - component location 1
Page 9 and 10: Maintenance - component location 1
Page 11 and 12: 6 Fluid leakage and engine electric
Page 13 and 14: 9 The engine will turn over more ea
Page 15 and 16: 13 Wipe clean the distributor cap a
Page 17 and 18: 18.13 Using a chain wrench to unscr
Page 19 and 20: 25.3a Bend each brake hose to check
Page 21 and 22: 32.4b . . . loosen front mounting n
Page 23 and 24: Chapter 2 Part A: Engine repair pro
Page 25 and 26: 1.3 litre: Inlet opens . . . . . .
Page 27 and 28: difficulty is experienced, it may b
Page 29 and 30: 9 Cylinder head - removal 3 1 If th
Page 31 and 32: 11 Cylinder head - dismantling and
Page 33 and 34: 14.13a Withdrawing crankshaft rear
Page 35 and 36: 21 Crankshaft and bearings - examin
Page 37 and 38: 29.2 Fitting centre main bearing sh
Page 39 and 40: 35.9 Camshaft sprocket (later type)
Page 41 and 42: Chapter 2 Part B: Engine repair pro
Page 43 and 44: 4.5 Two lengths of metal used to lo
Page 45 and 46: 9 Oil pump - refitting 3 Refitting
Page 47: guide the cylinder head into positi
Page 51 and 52: Stem diameter: Inlet . . . . . . .
Page 53 and 54: 1 General information The 1.6 and 1
Page 55 and 56: 26 The engine/gearbox unit is now r
Page 57 and 58: 9.6 Intermediate sprocket timing ma
Page 59 and 60: and tappet is required. Label the c
Page 61 and 62: 13.1 Sump, oil pump and oil filter
Page 63 and 64: 17 Oil filter - renewal Refer to Ch
Page 65 and 66: 30.3a Fitting flanged type centre m
Page 67 and 68: etween the camshaft and intermediat
Page 69 and 70: Chapter 2 Part D: Engine repair pro
Page 71 and 72: 1 General information The 1.8 litre
Page 73 and 74: Chapter 3 Cooling, heating and air
Page 75 and 76: 1 Radiator 2 Fan ring 3 Expansion t
Page 77 and 78: 2.2 Removing expansion tank cap 2.4
Page 79 and 80: Refitting 8 Refitting is a reversal
Page 81 and 82: 8.3a Pulling free heater/ventilatio
Page 83 and 84: 11 Air conditioning system compress
Page 85 and 86: Chapter 4 Part A: Fuel and exhaust
Page 87 and 88: Carburettor-1.6 litre Pierburg/Sole
Page 89 and 90: 3.6 Air cleaner components - 1.6 an
Page 91 and 92: 6.1 Fuel reservoir location - 1.3 l
Page 93 and 94: etaining clip and then disconnect t
Page 95 and 96: Fuel and exhaust systems - carburet
Page 97 and 98: Fuel and exhaust systems - carburet
Page 99 and 100:
15.10 Idle speed (A) and mixture (B
Page 101 and 102:
15.53 Checking choke valve gap (wid
Page 103 and 104:
17.10 Accelerator pump check prepar
Page 105 and 106:
18.3a Unscrew the bolts . . . 18.3b
Page 107 and 108:
Fuel and exhaust systems - carburet
Page 109 and 110:
Chapter 4 Part B: Fuel and exhaust
Page 111 and 112:
Fuel supply The fuel pump operates
Page 113 and 114:
4 Switch off all electrical consume
Page 115 and 116:
12.5 Cold acceleration enrichment s
Page 117 and 118:
17 Pressure relief valve - removal,
Page 119 and 120:
Fuel and exhaust systems - K-Jetron
Page 121 and 122:
Chapter 4 Part C: Fuel and exhaust
Page 123 and 124:
1 To ignition control unit 2 Intake
Page 125 and 126:
6.3 Throttle valve switch adjustmen
Page 127 and 128:
Chapter 4 Part D: Fuel and exhaust
Page 129 and 130:
1.0b Mono-Jetronic system inlet man
Page 131 and 132:
distance of 4.0 mm by the operating
Page 133 and 134:
Chapter 4 Part E: Fuel and exhaust
Page 135 and 136:
3.4 CO analyser and connecting pipe
Page 137 and 138:
feed line attachment to the gravity
Page 139 and 140:
Chapter 4 Part F: Fuel and exhaust
Page 141 and 142:
A Front crankcase ventilation valve
Page 143 and 144:
12.1 Fuel pump and filter component
Page 145 and 146:
Chapter 5 Part A: Ignition system -
Page 147 and 148:
1.1b Contact breaker ignition syste
Page 149 and 150:
7.4 Crankshaft pulley mark (A) timi
Page 151 and 152:
Chapter 5 Part B: Ignition system -
Page 153 and 154:
Ignition system - transistorised ty
Page 155 and 156:
6.4a TDC blanking plug - manual gea
Page 157 and 158:
7.5 Vacuum unit removal 7.7 Hall se
Page 159 and 160:
Chapter 5 Part C: Ignition system -
Page 161 and 162:
6.2 Signal check method from Hall s
Page 163 and 164:
Chapter 5 Part D: Starting and char
Page 165 and 166:
4.3 Battery retaining clamp and bol
Page 167 and 168:
Chapter 9 Braking system Contents B
Page 169 and 170:
3 Use an Allen key and unscrew the
Page 171 and 172:
3.18 Rear brake caliper components
Page 173 and 174:
4.15 . . . followed by the outer wa
Page 175 and 176:
13 Refit the hydraulic pipe and tig
Page 177 and 178:
19 This method is particularly effe
Page 179 and 180:
Chapter 10 Suspension and steering
Page 181 and 182:
1081 VW Golf & Jetta 1.1 Front susp
Page 183 and 184:
3.2 Front suspension camber adjustm
Page 185 and 186:
8.4 Removing rear suspension strut
Page 187 and 188:
11.3b Removing steering wheel centr
Page 189 and 190:
14.4 Steering tie-rod bellows and r
Page 191 and 192:
1081 VW Golf & Jetta Suspension and
Page 193 and 194:
Removal 2 To remove the pump unit,
Page 195 and 196:
Chapter 11 Bodywork and fittings Co
Page 197 and 198:
Repair of rust holes or gashes in b
Page 199 and 200:
hand. A largish screwdriver will ju
Page 201 and 202:
14 Door trim panel - removal and re
Page 203 and 204:
15.3 Removing interior door handle
Page 205 and 206:
22.4 Front bumper bracket securing
Page 207 and 208:
6 Renew any retaining screw locatio
Page 209 and 210:
28.9 Sunroof adjustment dimensions
Page 211 and 212:
31.8 Front seat guide fixing - from
Page 213 and 214:
Chapter 12 Body electrical systems
Page 215 and 216:
k) Never use an ohmmeter of the typ
Page 217 and 218:
6 Headlamp range control - removal
Page 219 and 220:
4 If the indicators do not function
Page 221 and 222:
17.2a Instrument panel unit compone
Page 223 and 224:
Component testing Voltage stabilise
Page 225 and 226:
3 Ease the wiper arm from the spind
Page 227 and 228:
29 Windscreen wiper linkage - remov
Page 229 and 230:
1081 VW Golf & Jetta Wiring diagram
Page 231 and 232:
1081 VW Golf & Jetta Wiring diagram
Page 233 and 234:
Relays (typical) 1 Vacant 2 Intake
Page 235 and 236:
1081 VW Golf & Jetta Diagram 3 Ligh
Page 237 and 238:
1081 VW Golf & Jetta Diagram 7 Brak
Page 239 and 240:
1081 VW Golf & Jetta 12 Diagram 12
Page 241 and 242:
Page 243 and 244:
1081 VW Golf & Jetta Diagram 20 Ele
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
1081 VW Golf & Jetta Diagram 57 Glo
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
show all

VW MKII A2 MK2 Golf Jetta Fox Service Manual - VAGLinks.com

Create successful ePaper yourself

Delete template?

Save as template?