VW MKII A2 MK2 Golf Jetta Fox Service Manual - VAGLinks.com

More documents

Recommendations

Info

1081 VW Golf & Jetta Diagram 9 Windscreen wiper and washer - 1.05, 1.3 and 1.6 models. Golf, pre December 1985. Jetta pre July 1987 Diagram 10 Rear wiper and washer - 1.05, 1.3 and 1.6 models, pre December 1985 Diagram 11 Intake manifold preheater and automatic choke - 1.3 models, pre July 1986 12•26 Wiring diagrams
1081 VW Golf & Jetta 12 Diagram 12 Starter, alternator, battery and ignition system - 1.8 models with carburettor Diagram 13 Lighting switch, instrument and dash lights - 1.8 models, pre July 1987 Wiring diagrams 12•27
Page 1 and 2:
Chapter 1 Routine maintenance and s
Page 3 and 4:
CO content (%) 1.05 litre carburett
Page 5 and 6:
The maintenance intervals in this M
Page 7 and 8:
Maintenance - component location 1
Page 9 and 10:
Maintenance - component location 1
Page 11 and 12:
6 Fluid leakage and engine electric
Page 13 and 14:
9 The engine will turn over more ea
Page 15 and 16:
13 Wipe clean the distributor cap a
Page 17 and 18:
18.13 Using a chain wrench to unscr
Page 19 and 20:
25.3a Bend each brake hose to check
Page 21 and 22:
32.4b . . . loosen front mounting n
Page 23 and 24:
Chapter 2 Part A: Engine repair pro
Page 25 and 26:
1.3 litre: Inlet opens . . . . . .
Page 27 and 28:
difficulty is experienced, it may b
Page 29 and 30:
9 Cylinder head - removal 3 1 If th
Page 31 and 32:
11 Cylinder head - dismantling and
Page 33 and 34:
14.13a Withdrawing crankshaft rear
Page 35 and 36:
21 Crankshaft and bearings - examin
Page 37 and 38:
29.2 Fitting centre main bearing sh
Page 39 and 40:
35.9 Camshaft sprocket (later type)
Page 41 and 42:
Chapter 2 Part B: Engine repair pro
Page 43 and 44:
4.5 Two lengths of metal used to lo
Page 45 and 46:
9 Oil pump - refitting 3 Refitting
Page 47 and 48:
guide the cylinder head into positi
Page 49 and 50:
Chapter 2 Part C: Engine repair pro
Page 51 and 52:
Stem diameter: Inlet . . . . . . .
Page 53 and 54:
1 General information The 1.6 and 1
Page 55 and 56:
26 The engine/gearbox unit is now r
Page 57 and 58:
9.6 Intermediate sprocket timing ma
Page 59 and 60:
and tappet is required. Label the c
Page 61 and 62:
13.1 Sump, oil pump and oil filter
Page 63 and 64:
17 Oil filter - renewal Refer to Ch
Page 65 and 66:
30.3a Fitting flanged type centre m
Page 67 and 68:
etween the camshaft and intermediat
Page 69 and 70:
Chapter 2 Part D: Engine repair pro
Page 71 and 72:
1 General information The 1.8 litre
Page 73 and 74:
Chapter 3 Cooling, heating and air
Page 75 and 76:
1 Radiator 2 Fan ring 3 Expansion t
Page 77 and 78:
2.2 Removing expansion tank cap 2.4
Page 79 and 80:
Refitting 8 Refitting is a reversal
Page 81 and 82:
8.3a Pulling free heater/ventilatio
Page 83 and 84:
11 Air conditioning system compress
Page 85 and 86:
Chapter 4 Part A: Fuel and exhaust
Page 87 and 88:
Carburettor-1.6 litre Pierburg/Sole
Page 89 and 90:
3.6 Air cleaner components - 1.6 an
Page 91 and 92:
6.1 Fuel reservoir location - 1.3 l
Page 93 and 94:
etaining clip and then disconnect t
Page 95 and 96:
Fuel and exhaust systems - carburet
Page 97 and 98:
Page 99 and 100:
15.10 Idle speed (A) and mixture (B
Page 101 and 102:
15.53 Checking choke valve gap (wid
Page 103 and 104:
17.10 Accelerator pump check prepar
Page 105 and 106:
18.3a Unscrew the bolts . . . 18.3b
Page 107 and 108:
Page 109 and 110:
Chapter 4 Part B: Fuel and exhaust
Page 111 and 112:
Fuel supply The fuel pump operates
Page 113 and 114:
4 Switch off all electrical consume
Page 115 and 116:
12.5 Cold acceleration enrichment s
Page 117 and 118:
17 Pressure relief valve - removal,
Page 119 and 120:
Fuel and exhaust systems - K-Jetron
Page 121 and 122:
Chapter 4 Part C: Fuel and exhaust
Page 123 and 124:
1 To ignition control unit 2 Intake
Page 125 and 126:
6.3 Throttle valve switch adjustmen
Page 127 and 128:
Chapter 4 Part D: Fuel and exhaust
Page 129 and 130:
1.0b Mono-Jetronic system inlet man
Page 131 and 132:
distance of 4.0 mm by the operating
Page 133 and 134:
Chapter 4 Part E: Fuel and exhaust
Page 135 and 136:
3.4 CO analyser and connecting pipe
Page 137 and 138:
feed line attachment to the gravity
Page 139 and 140:
Chapter 4 Part F: Fuel and exhaust
Page 141 and 142:
A Front crankcase ventilation valve
Page 143 and 144:
12.1 Fuel pump and filter component
Page 145 and 146:
Chapter 5 Part A: Ignition system -
Page 147 and 148:
1.1b Contact breaker ignition syste
Page 149 and 150:
7.4 Crankshaft pulley mark (A) timi
Page 151 and 152:
Chapter 5 Part B: Ignition system -
Page 153 and 154:
Ignition system - transistorised ty
Page 155 and 156:
6.4a TDC blanking plug - manual gea
Page 157 and 158:
7.5 Vacuum unit removal 7.7 Hall se
Page 159 and 160:
Chapter 5 Part C: Ignition system -
Page 161 and 162:
6.2 Signal check method from Hall s
Page 163 and 164:
Chapter 5 Part D: Starting and char
Page 165 and 166:
4.3 Battery retaining clamp and bol
Page 167 and 168:
Chapter 9 Braking system Contents B
Page 169 and 170:
3 Use an Allen key and unscrew the
Page 171 and 172:
3.18 Rear brake caliper components
Page 173 and 174:
4.15 . . . followed by the outer wa
Page 175 and 176:
13 Refit the hydraulic pipe and tig
Page 177 and 178:
19 This method is particularly effe
Page 179 and 180:
Chapter 10 Suspension and steering
Page 181 and 182:
1081 VW Golf & Jetta 1.1 Front susp
Page 183 and 184:
3.2 Front suspension camber adjustm
Page 185 and 186:
8.4 Removing rear suspension strut
Page 187 and 188: 11.3b Removing steering wheel centr
Page 189 and 190: 14.4 Steering tie-rod bellows and r
Page 191 and 192: 1081 VW Golf & Jetta Suspension and
Page 193 and 194: Removal 2 To remove the pump unit,
Page 195 and 196: Chapter 11 Bodywork and fittings Co
Page 197 and 198: Repair of rust holes or gashes in b
Page 199 and 200: hand. A largish screwdriver will ju
Page 201 and 202: 14 Door trim panel - removal and re
Page 203 and 204: 15.3 Removing interior door handle
Page 205 and 206: 22.4 Front bumper bracket securing
Page 207 and 208: 6 Renew any retaining screw locatio
Page 209 and 210: 28.9 Sunroof adjustment dimensions
Page 211 and 212: 31.8 Front seat guide fixing - from
Page 213 and 214: Chapter 12 Body electrical systems
Page 215 and 216: k) Never use an ohmmeter of the typ
Page 217 and 218: 6 Headlamp range control - removal
Page 219 and 220: 4 If the indicators do not function
Page 221 and 222: 17.2a Instrument panel unit compone
Page 223 and 224: Component testing Voltage stabilise
Page 225 and 226: 3 Ease the wiper arm from the spind
Page 227 and 228: 29 Windscreen wiper linkage - remov
Page 229 and 230: 1081 VW Golf & Jetta Wiring diagram
Page 231 and 232: 1081 VW Golf & Jetta Wiring diagram
Page 233 and 234: Relays (typical) 1 Vacant 2 Intake
Page 235 and 236: 1081 VW Golf & Jetta Diagram 3 Ligh
Page 237: 1081 VW Golf & Jetta Diagram 7 Brak
Page 241 and 242: 1081 VW Golf & Jetta 12 Diagram 16
Page 243 and 244: 1081 VW Golf & Jetta Diagram 20 Ele
Page 261 and 262: 1081 VW Golf & Jetta Diagram 57 Glo
show all

VW MKII A2 MK2 Golf Jetta Fox Service Manual - VAGLinks.com

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?