- Page 1 and 2:
Chapter 1 Routine maintenance and s
- Page 3 and 4:
CO content (%) 1.05 litre carburett
- Page 5 and 6:
The maintenance intervals in this M
- Page 7 and 8:
Maintenance - component location 1
- Page 9 and 10:
Maintenance - component location 1
- Page 11 and 12:
6 Fluid leakage and engine electric
- Page 13 and 14:
9 The engine will turn over more ea
- Page 15 and 16:
13 Wipe clean the distributor cap a
- Page 17 and 18:
18.13 Using a chain wrench to unscr
- Page 19 and 20:
25.3a Bend each brake hose to check
- Page 21 and 22:
32.4b . . . loosen front mounting n
- Page 23 and 24:
Chapter 2 Part A: Engine repair pro
- Page 25 and 26:
1.3 litre: Inlet opens . . . . . .
- Page 27 and 28:
difficulty is experienced, it may b
- Page 29 and 30:
9 Cylinder head - removal 3 1 If th
- Page 31 and 32:
11 Cylinder head - dismantling and
- Page 33 and 34:
14.13a Withdrawing crankshaft rear
- Page 35 and 36:
21 Crankshaft and bearings - examin
- Page 37 and 38:
29.2 Fitting centre main bearing sh
- Page 39 and 40:
35.9 Camshaft sprocket (later type)
- Page 41 and 42:
Chapter 2 Part B: Engine repair pro
- Page 43 and 44:
4.5 Two lengths of metal used to lo
- Page 45 and 46:
9 Oil pump - refitting 3 Refitting
- Page 47 and 48:
guide the cylinder head into positi
- Page 49 and 50:
Chapter 2 Part C: Engine repair pro
- Page 51 and 52:
Stem diameter: Inlet . . . . . . .
- Page 53 and 54:
1 General information The 1.6 and 1
- Page 55 and 56:
26 The engine/gearbox unit is now r
- Page 57 and 58:
9.6 Intermediate sprocket timing ma
- Page 59 and 60:
and tappet is required. Label the c
- Page 61 and 62:
13.1 Sump, oil pump and oil filter
- Page 63 and 64:
17 Oil filter - renewal Refer to Ch
- Page 65 and 66:
30.3a Fitting flanged type centre m
- Page 67 and 68:
etween the camshaft and intermediat
- Page 69 and 70:
Chapter 2 Part D: Engine repair pro
- Page 71 and 72:
1 General information The 1.8 litre
- Page 73 and 74:
Chapter 3 Cooling, heating and air
- Page 75 and 76:
1 Radiator 2 Fan ring 3 Expansion t
- Page 77 and 78:
2.2 Removing expansion tank cap 2.4
- Page 79 and 80:
Refitting 8 Refitting is a reversal
- Page 81 and 82:
8.3a Pulling free heater/ventilatio
- Page 83 and 84:
11 Air conditioning system compress
- Page 85 and 86:
Chapter 4 Part A: Fuel and exhaust
- Page 87 and 88:
Carburettor-1.6 litre Pierburg/Sole
- Page 89 and 90:
3.6 Air cleaner components - 1.6 an
- Page 91 and 92:
6.1 Fuel reservoir location - 1.3 l
- Page 93 and 94:
etaining clip and then disconnect t
- Page 95 and 96:
Fuel and exhaust systems - carburet
- Page 97 and 98:
Fuel and exhaust systems - carburet
- Page 99 and 100:
15.10 Idle speed (A) and mixture (B
- Page 101 and 102:
15.53 Checking choke valve gap (wid
- Page 103 and 104:
17.10 Accelerator pump check prepar
- Page 105 and 106:
18.3a Unscrew the bolts . . . 18.3b
- Page 107 and 108:
Fuel and exhaust systems - carburet
- Page 109 and 110:
Chapter 4 Part B: Fuel and exhaust
- Page 111 and 112:
Fuel supply The fuel pump operates
- Page 113 and 114:
4 Switch off all electrical consume
- Page 115 and 116:
12.5 Cold acceleration enrichment s
- Page 117 and 118:
17 Pressure relief valve - removal,
- Page 119 and 120:
Fuel and exhaust systems - K-Jetron
- Page 121 and 122:
Chapter 4 Part C: Fuel and exhaust
- Page 123 and 124:
1 To ignition control unit 2 Intake
- Page 125 and 126:
6.3 Throttle valve switch adjustmen
- Page 127 and 128:
Chapter 4 Part D: Fuel and exhaust
- Page 129 and 130:
1.0b Mono-Jetronic system inlet man
- Page 131 and 132:
distance of 4.0 mm by the operating
- Page 133 and 134:
Chapter 4 Part E: Fuel and exhaust
- Page 135 and 136:
3.4 CO analyser and connecting pipe
- Page 137 and 138:
feed line attachment to the gravity
- Page 139 and 140:
Chapter 4 Part F: Fuel and exhaust
- Page 141 and 142:
A Front crankcase ventilation valve
- Page 143 and 144:
12.1 Fuel pump and filter component
- Page 145 and 146:
Chapter 5 Part A: Ignition system -
- Page 147 and 148:
1.1b Contact breaker ignition syste
- Page 149 and 150: 7.4 Crankshaft pulley mark (A) timi
- Page 151 and 152: Chapter 5 Part B: Ignition system -
- Page 153 and 154: Ignition system - transistorised ty
- Page 155 and 156: 6.4a TDC blanking plug - manual gea
- Page 157 and 158: 7.5 Vacuum unit removal 7.7 Hall se
- Page 159 and 160: Chapter 5 Part C: Ignition system -
- Page 161 and 162: 6.2 Signal check method from Hall s
- Page 163 and 164: Chapter 5 Part D: Starting and char
- Page 165 and 166: 4.3 Battery retaining clamp and bol
- Page 167 and 168: Chapter 9 Braking system Contents B
- Page 169 and 170: 3 Use an Allen key and unscrew the
- Page 171 and 172: 3.18 Rear brake caliper components
- Page 173 and 174: 4.15 . . . followed by the outer wa
- Page 175 and 176: 13 Refit the hydraulic pipe and tig
- Page 177 and 178: 19 This method is particularly effe
- Page 179 and 180: Chapter 10 Suspension and steering
- Page 181 and 182: 1081 VW Golf & Jetta 1.1 Front susp
- Page 183 and 184: 3.2 Front suspension camber adjustm
- Page 185 and 186: 8.4 Removing rear suspension strut
- Page 187 and 188: 11.3b Removing steering wheel centr
- Page 189 and 190: 14.4 Steering tie-rod bellows and r
- Page 191 and 192: 1081 VW Golf & Jetta Suspension and
- Page 193 and 194: Removal 2 To remove the pump unit,
- Page 195 and 196: Chapter 11 Bodywork and fittings Co
- Page 197 and 198: Repair of rust holes or gashes in b
- Page 199: hand. A largish screwdriver will ju
- Page 203 and 204: 15.3 Removing interior door handle
- Page 205 and 206: 22.4 Front bumper bracket securing
- Page 207 and 208: 6 Renew any retaining screw locatio
- Page 209 and 210: 28.9 Sunroof adjustment dimensions
- Page 211 and 212: 31.8 Front seat guide fixing - from
- Page 213 and 214: Chapter 12 Body electrical systems
- Page 215 and 216: k) Never use an ohmmeter of the typ
- Page 217 and 218: 6 Headlamp range control - removal
- Page 219 and 220: 4 If the indicators do not function
- Page 221 and 222: 17.2a Instrument panel unit compone
- Page 223 and 224: Component testing Voltage stabilise
- Page 225 and 226: 3 Ease the wiper arm from the spind
- Page 227 and 228: 29 Windscreen wiper linkage - remov
- Page 229 and 230: 1081 VW Golf & Jetta Wiring diagram
- Page 231 and 232: 1081 VW Golf & Jetta Wiring diagram
- Page 233 and 234: Relays (typical) 1 Vacant 2 Intake
- Page 235 and 236: 1081 VW Golf & Jetta Diagram 3 Ligh
- Page 237 and 238: 1081 VW Golf & Jetta Diagram 7 Brak
- Page 239 and 240: 1081 VW Golf & Jetta 12 Diagram 12
- Page 241 and 242: 1081 VW Golf & Jetta 12 Diagram 16
- Page 243 and 244: 1081 VW Golf & Jetta Diagram 20 Ele
- Page 245 and 246: 1081 VW Golf & Jetta 12 Diagram 24
- Page 247 and 248: 1081 VW Golf & Jetta 12 Diagram 29
- Page 249 and 250: 1081 VW Golf & Jetta 12 Diagram 33
- Page 251 and 252:
1081 VW Golf & Jetta 12 Diagram 37
- Page 253 and 254:
1081 VW Golf & Jetta 12 Diagram 41
- Page 255 and 256:
1081 VW Golf & Jetta 12 Diagram 45
- Page 257 and 258:
1081 VW Golf & Jetta 12 Diagram 49
- Page 259 and 260:
1081 VW Golf & Jetta 12 Diagram 53
- Page 261 and 262:
1081 VW Golf & Jetta Diagram 57 Glo
- Page 263 and 264:
1081 VW Golf & Jetta 12 Diagram 61
- Page 265 and 266:
1081 VW Golf & Jetta 12 Diagram 65
- Page 267 and 268:
1081 VW Golf & Jetta 12 Diagram 69