YVAA Style A Air-Cooled Screw Liquid Chillers ... - Johnson Controls

More documents

Recommendations

Info

SECTION 8 - MICROPANEL Print Key Operation The PRINT key is used to initiate a printout of current operating data (real time data), a complete history printout of all history (fault) buffers, a printout of all normal shutdowns (compressor cycling, chiller shutdown, etc.) or history (fault) data printout of a specific fault. History Buffer 1 will always be the most recent fault history printout. Printing may also be canceled by selecting the CANCEL PRINTING option. The following message is displayed when the PRINT key is pressed. PRINT CHOOSE PRINT REPORT ◄ ► XXXXXXXXXXXXXXXXXXXXX After pressing the PRINT key, the printout type is selected by pressing the ◄ (LEFT ARROW) or ► (RIGHT ARROW) keys until the desired printout is displayed. 124 PRINT KEY PRINT KEY LD10605 FORM 201.28-NM1.1 ISSUE DATE: 8/29/2012 The following table shows the available printout types. TABLE 12 - PRINTOUT TYPES PRINTOUT TYPES Operating Data (Default Selection) All History Buffers Normal Shutdowns History Buffer 1 History Buffer 2 History Buffer 3 History Buffer 4 History Buffer 5 History Buffer 6 History Buffer 7 History Buffer 8 History Buffer 9 History Buffer 10 Cancel Printing The specific printout is initiated by pressing the � (ENTER) key. JOHNSON CONTROLS
FORM 201.28-NM1.1 ISSUE DATE: 8/29/2012 A sample of the is shown below. The operating data printout is a snapshot of current system operating conditions when the printout was selected. The sample shows combined printouts of 2, 3, and 4 circuit units. The actual printout will only show data for the appropriate chiller type. Bold italic text below a line of print is not on the actual printout. Bold italic text indicates information that may not be available on all printouts or is additional information to help explain the difference in a 2/3 or 4 circuit printout. Operating Data Printout SYS 1 YORK INTERNATIONAL CORPORATION NOT RUNNING SYS 2 COMPRESSOR RUNNING <strong>YVAA</strong> SCREW CHILLER OPERATING DATA 2:04:14 PM 30 DEC 11 OPTIONS CHILLED LIQUID WATER LOCAL/REMOTE MODE REMOTE LEAD/LAG CONTROL AUTOMATIC REMOTE TEMP RESET DISABLED REMOTE CURRENT LIMIT 0 TO 10 V REMOTE SOUND LIMIT 4 TO 20 MA (if Sound Limiting enabled) LOW AMBIENT CUTOUT ENABLED PROGRAM VALUES SUCT PRESS CUTOUT 44 PSIG LOW AMBIENT CUTOUT 25.0 DEGF LEAVING LIQUID CUTOUT 36.0 DEGF MOTOR CURRENT LIMIT 100 %FLA PULLDOWN CURRENT LIMIT 100 %FLA PULLDOWN LIMIT TIME 0 MIN SUBCOOLING SETPOINT 12.0 DEGF UNIT ID NUMBER 0 SOUND LIMIT SETPOINT 100% (if Sound Limiting enabled) UNIT DATA SECTION 8 - MICROPANEL LEAVING LIQUID TEMP 49.0 DEGF RETURN LIQUID TEMP 58.2 DEGF TEMP RATE XXX.X DEGF/MIN COOLING RANGE 42.0+/-2.0 DEGF REMOTE SETPOINT 44.0 DEGF AMBIENT AIR TEMP 74.8 DEGF LEAD SYSTEM SYS 2 FLOW SWITCH ON EVAPORATOR PUMP RUN ON EVAPORATOR HEATER OFF ACTIVE REMOTE CONTROL NONE OPERATING HOURS 1=XXXXX, 2=XXXXX START COUNTER 1=XXXXX, 2=XXXXX SOFTWARE VERSION C.ACS.XX.00 VSD DATA ACTUAL FREQUENCY XXX.X HZ COMMAND FREQUENCY XXX.X HZ DC BUS VOLTAGE XXX VDC INTERNAL AMBIENT TEMP XXX.X DEGF COOLING SYSTEM STATUS XXX BASEPLATE TEMPS XXX XXX DEGF PRECHARGE SIGNAL XXX MOTOR OVERLOADS 1/2 XXX XXX AMPS SOFTWARE VERSION C.VSD.XX.00 UNIT SERIAL NUMBER YYYY XXXZZZ SYSTEM 1 DATA COMPRESSOR STATUS OFF RUN TIME 0- 0- 0- 0 D-H-M-S MOTOR CURRENT 0AMPS 0 %FLA SUCTION PRESSURE 125 PSIG DISCHARGE PRESSURE 131 PSIG OIL PRESSURE 130 PSIG CONDENSER LIQUID TEMP 68.4 DEGF DISCHARGE TEMPERATURE 68.8 DEGF OIL TEMPERATURE 68.8 DEGF SAT SUCTION TEMP 71.8 DEGF SUBCOOLING 3.4 DEGF SAT DISCHARGE TEMP 74.5 DEGF DISCHARGE SUPERHEAT 6.3 DEGF MOTOR TMP XXX.XXXX.XXXX.XDEGF COMPRESSOR SPEED XXX.X % FLASH TANK LEVEL > 512 ADC JOHNSON CONTROLS 125 8
Page 1 and 2:
AIR-COOLED SCREW LIQUID CHILLERS IN
Page 3 and 4:
FORM 201.28-NM1.1 ISSUE DATE: 8/29/
Page 5 and 6:
Page 7 and 8:
Page 9 and 10:
Page 11 and 12:
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74: FORM 201.28-NM1.1 ISSUE DATE: 8/29/
Page 75 and 76: FORM 201.28-NM1.1 SECTION 5 - TECHN
Page 77 and 78: FORM 201.28-NM1.1 SECTION 5 - TECHN
Page 123: FORM 201.28-NM1.1 ISSUE DATE: 8/29/
show all

YVAA Style A Air-Cooled Screw Liquid Chillers ... - Johnson Controls

Create successful ePaper yourself

Delete template?

Save as template?