pa1778data.pdf
pa1778data.pdf
pa1778data.pdf
You also want an ePaper? Increase the reach of your titles
YUMPU automatically turns print PDFs into web optimized ePapers that Google loves.
well at a rate of .4 gph.<br />
Construction date: 1979.<br />
Installation of equipment: 1979.<br />
U.S. STEEL DUQUESNE WORKS<br />
HAER No. PA-115<br />
(Page 201)<br />
J. Calcium Dispersant Tank: The 6 f -0" diameter x 10 f -0" high,<br />
2000 gallon capacity, calcium dispersant tank is located between<br />
the acid storage tank and the chemical feed pump house.<br />
Installation date: 1979.<br />
K. Gravity Filter Building: Laid out on a east-west axis, the<br />
40'-0" wide x 63'-0" long x 30*-0" high steel framed water<br />
filtration building is located 4'~0" south of the filter cake<br />
building. Built by the American Bridge Company on a concrete<br />
foundation, the building has a corrugated metal exterior and a<br />
flat roof. The southern corner of the building has been removed<br />
for road clearance.<br />
A 7'-3/4" wide x 34'-10 1/2" long x 21»-6" high DeLaval<br />
gravity filter is laid out on a east-west axis alongside the<br />
northern wall of the building. Constructed of steel plate, the<br />
filter is made up of four identical cells which are designed to<br />
remove suspended solids from raw water while maintaining a high<br />
flow rate through a filter. The filter consists of a top layer<br />
of anthracite coal and a bottom layer of sand, supported by<br />
several layers of graded gravel.<br />
A polymer feeding system for the gravity filter is located<br />
just west of it alongside the northern wall. It consists of two<br />
55 gallon polymer storage tanks which are connected to two 1/2 hp<br />
Milroyal A metering pumps.<br />
A 12'-6" diameter x 21'-6" high Delaval backwash holding<br />
tank is located south of the gravity filter near the southern<br />
wall of the building. A 7 1/2 hp motor-powered "Lightnin" mixer<br />
extends down through the center of the tank. Two 7 1/2 hp motor-<br />
powered Morris pumps rated at 180 gpm are located on the southern<br />
side of the tank. The pumps deliver slurry from the holding tank<br />
to the clarifier.<br />
Located just east of the gravity filter and backwash tank,<br />
and laid out on a north-south axis is a ll f -o" wide x 25 ! -0 long<br />
x 15'-0" deep concrete sump covered by grating. The sump is<br />
divided by a V-shaped weir into two sections. Extending from the<br />
northern section of the sump are two 3 0 hp motor powered Morris<br />
vertical cantilevered sump pumps rated at 1050 gpm. These pumps<br />
deliver backwash water to the gravity filters. Located above the<br />
southern section of the sump is a polymer feed system for the<br />
clarifier. The system consists of a small mixing tank, a feed<br />
tank, and a small (approximately 100 gpm) motor-powered pump.