Sensor systems 2 AS-Interface

Recommendations

Info

VAG-PB-G4F-R4 Masters and Gateways Power Supplies, Extender, Repeaters Safety at work I/O Modules Control cabinet I/O Modules Field application Analogue modules Other modules Inductive sensors Photoelectric sensors Rotary encoders Accessories AS-Interface gateway Order code VAG-PB-G4F-R4 PROFIBUS gateway IP65 Features 40 AS-Interface certificate AS-Interface connection via flat cable and EMS standard bottom section (included delivery) Protection degree IP65 Voltage supply from AS-Interface Connection to PROFIBUS DP Commissioning, without PROFIBUS communication All AS-Interface functions can be called via PROFIBUS PLC functionality Error diagnostics via LEDs and LC display Parameterisation and monitor software Dimensions 66 31 Electrical connection AS-Interface + AS-Interface - Indicating/operating means PWR VAG-PB-G4F-R4 Subject to reasonable modifications due to technical advances. Copyright Pepperl+Fuchs, Printed in Germany Pepperl+Fuchs Group Tel.: Germany +49 621 776-0 USA +1 330 4253555 Singapore +65 67799091 Internet http://www.pepperl-fuchs.com . .. BUS ACTIVE µP U AS-i CONF.ERR. 80 102 AS-i ACTIVE PRG ENABLE PRJ MODE 1 6 2 7 3 8 4 9 5 10 PE VAG-PB-G4F-R4 Screen 90 RxD/TxD-P RxD/TxD-N GND +5 V Buttons Mode Set Cage clamp terminal block Power supply for terminating resistor DIPswitch 1 2 3 4 5 6 7 8 9 10 71 Issue date 2004-11-19 - Catalogue AS-Interface 2004/2005
Issue date 2004-11-19 - Catalogue AS-Interface 2004/2005 AS-Interface gateway Technical data General specifications AS-Interface specification Indicators/operating means V2.0 LED display, two-digit address display, error message LED BUS ACTIVE PROFIBUS master detected; LED green LED AS-i ACTIVE AS-Interface operation normal; LED green LED CONFIG ERR configuration error; LED red LED PWR voltage ON; LED green LED PRG ENABLE autom. programming; LED green LED PRG MODE projecting mode active; LED yellow LED U AS-i AS-Interface voltage; LED green Switch SET Selection and setting of a slave address Button MODE Electrical specifications Mode selection/save configuration Insulation voltage Ui ≥ 500 V Rated operational voltage Ue from AS-Interface Rated operational current Ie ≤ 180 mA from AS-Interface Interface Protocol PROFIBUS Interface type RS 485 Transfer rate Connection 9.6; 19.2; 44.44; 93.95; 187.5; 500; 1500 kBit/s self-synchronising PROFIBUS Cable gland M16 x 1.5 and cage spring terminals AS-Interface Ambient conditions cable piercing technique Ambient temperature 0 ... 55 °C (273 ... 328 K) Storage temperature Mechanical specifications -25 ... 85 °C (248 ... 358 K) Protection degree IP65 according to EN 60529 Mass 420 g Software The device is supplied with the configuration data files (GSD) as well as a restricted version of the AS-i Control Tools software. The software performs the addressing, programming and monitoring of the AS-Interface network. In addition, it contains an editor that creates programs for the integrated PLC functionality. The full version of the AS-i Control Tools is available as an accessory and features an expanded diagnostics monitor as well as a larger program memory for AS-Interface Control which makes it possible to detect faulty telegrams of slaves. A GSD file can be easily created for the PROFIBUS DP using the GSD assistant, whereby the size of the I/O windows can be conveniently adapted to the AS-Interface circuit's load and the AS-Interface configuration can be stored within the GSD file. A text file is also created, which documents the status of AS-Interface data in the gateway's I/O window. Note: The VAZ-PB-SIM accessory is required for the AS-i Control Tools. Function VAG-PB-G4F-R4 The VAG-PB-G4F-R4 is a complete PROFI- BUS slave designed for use in the field. The G4 field housing of the PROFIBUS gateway offers all the advantages of the serial master in this design. Two operating modes are available for the exchange of data across PROFIBUS DP: standard and expanded. In standard mode the gateway uses a fixed I/O configuration so that it can be put into operation without additional parameter assignment. In expanded mode the data structure can be optimised, enabling the user to define the data size sent to the PROFIBUS master. Owing to the reduction of required data, less I/O space is needed in the PLC. Two push buttons are used for address assignment, acceptance of the desired configuration, adjustment of the PROFIBUS address and baud rate. In configuration mode, all detected AS-Interface slaves are displayed on the 2-digit LCD. In normal operation, the LCD is blank unless the master detects a faulty AS-Interface slave.There are 7 LEDs on the front panel, showing the current status of the AS-Interface line. PLC Functionality The VAG-PB-G4F-R4 provides 16 kByte program memory, 8 kByte RAM, 1024 counters and 1024 timers for PLC functionality. These capacities suffice to process data on the AS- Interface. Thus the master can also be operated in "stand-alone" mode. The program processing time is 2 ms per 1000 word commands. The programming language is based on the STEP5 ® programming language. The AS-Interface CTRL functions (upload, download, start, stop, read and write internal memory) are available in expanded mode. Accessories VAZ-SW-ACT32 Full version of the AS-i Control Tools VAZ-PB-SIM PROFIBUS master simulator VAZ-G4-R4 Interface cable for direct connection of the master to a PC U-G1P Base for connection to round cable (EMS; AS-Interface only) VAZ-G4-B Blind plug PG7 Note U-G1F base is included with delivery Subject to reasonable modifications due to technical advances. Copyright Pepperl+Fuchs, Printed in Germany Pepperl+Fuchs Group Tel.: Germany +49 621 776-0 USA +1 330 4253555 Singapore +65 67799091 Internet http://www.pepperl-fuchs.com 41 Masters and Gateways Power Supplies, Extender, Repeaters Safety at work I/O Modules Control cabinet I/O Modules Field application Analogue modules Other modules Inductive sensors Photoelectric sensors Rotary encoders Accessories
Page 1 and 2: FACTORY AUTOMATION Sensor systems 2
Page 3 and 4: Issue date 2004-11-19 - Catalogue A
Page 35: Issue date 2004-11-19 - Catalogue A
Page 87 and 88:
Issue date 2004-11-19 - Catalogue A
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
VAZ-PB-SIM Issue date 2004-11-19 -
Page 309 and 310:
VAZ-R4-R2 Issue date 2004-11-19 - C
Page 311 and 312:
U-G1FA Issue date 2004-11-19 - Cata
Page 313 and 314:
U-G1FFA Issue date 2004-11-19 - Cat
Page 315 and 316:
U-G1PP Issue date 2004-11-19 - Cata
Page 317 and 318:
U-G3FF Issue date 2004-11-19 - Cata
Page 319 and 320:
VAZ-T1-FK-1M-PUR-V1-W Issue date 20
Page 321 and 322:
VAZ-T1-G2F Issue date 2004-11-19 -
Page 323 and 324:
VAZ-T1-FK-M20 Issue date 2004-11-19
Page 325 and 326:
VAZ-V1-B Issue date 2004-11-19 - Ca
Page 327 and 328:
VAZ-TERM Issue date 2004-11-19 - Ca
Page 329 and 330:
Page 331 and 332:
UPR-05 Issue date 2004-11-19 - Cata
Page 333 and 334:
Page 335 and 336:
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
Page 343 and 344:
Page 345 and 346:
Page 347 and 348:
Page 349 and 350:
Date of issue 2004-19-11 - Catalogu
Page 351 and 352:
Page 353 and 354:
Page 355 and 356:
show all

Sensor systems 2 AS-Interface

Create successful ePaper yourself

Delete template?

Save as template?