safety data sheet 790 - EGO - Dichtstoffwerke

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 1 of 7
SECTION 1: Identification of the substance/mixture and of the company/undertaking
Product identifier
Product group:
EGOCON 790
Primer
Relevant identified uses of the substance or mixture and uses advised against
Use of the substance/mixture
Primer for Silicone Sealant
Details of the supplier of the safety data sheet
Company name:
Street:
Place:
Post-office box:
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Lilienthalstraße 7
D-82205 Gilching
1347
D-82198 Gilching
Telephone: +49 8105 217-0 Telefax:+49 8105 217-37
e-mail: Paulus@ego.de
Contact person: Mrs. Paulus
Telephone: - 34
Internet:
Responsible Department:
Emergency telephone:
SECTION 2: Hazards identification
http://www.ego.de
export
Classification of the substance or mixture
Label elements
+49 89 19240
Indications of danger : Highly flammable, Harmful, Irritant, Dangerous for the environment
R-phrases:
Highly flammable.
Irritating to eyes and skin.
Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Harmful: may cause lung damage if swallowed.
Vapours may cause drowsiness and dizziness.
Danger symbols: F - Highly flammable; Xn - Harmful; N - Dangerous for the environment
F - Highly flammable Xn - Harmful N - Dangerous for the
environment
Hazardous components which must be listed on the label
C7-C10 Isoalkane
R phrases
11 Highly flammable.
36/38 Irritating to eyes and skin.
51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
65 Harmful: may cause lung damage if swallowed.
67 Vapours may cause drowsiness and dizziness.
Revision No: 1,00 GB - EN
Revision date: 01.09.2011

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 2 of 7
S phrases
02 Keep out of the reach of children.
09 Keep container in a well-ventilated place.
16 Keep away from sources of ignition - No smoking.
23 Do not breathe vapour .
56 Dispose of this material and its container at hazardous or special waste collection point.
61 Avoid release to the environment. Refer to special instructions / Safety data sheets.
62 If swallowed, do not induce vomiting: seek medical advice immediately and show this container
or label.
SECTION 3: Composition/information on ingredients
Mixtures
Chemical characterization
silanes and siloxanes with functional groups + auxiliary material in solvent
Hazardous components
EC No Chemical name
CAS No
Classification
Index No
GHS classification
REACH No
292-458-5
90622-56-3
227-006-8
5593-70-4
203-625-9
108-88-3
601-021-00-3
201-083-8
78-10-4
014-005-00-0
C7-C10 Isoalkane
F, Xn, Xi, N R11-38-65-67-51-53
Titantetrabutanolat
Xi R10-38-41
toluene
F, Repr. Cat. 3, Xn, Xi R11-63-48/20-65-38-67
Flam. Liq. 2, Repr. 2, Asp. Tox. 1, STOT RE 2, Skin Irrit. 2, STOT SE 3; H225 H361d
*** H304 H373 ** H315 H336
ethyl silicate, tetraethyl silicate
Xn, Xi R10-20-36/37
Full text of R- and H-phrases: see section 16.
SECTION 4: First aid measures
Description of first aid measures
Flam. Liq. 3, Acute Tox. 4, Eye Irrit. 2, STOT SE 3; H226 H332 H319 H335
After inhalation
Move to fresh air in case of accidental inhalation of vapours. If not breathing, give artificial
respiration.
If you feel unwell, seek medical advice (show the label where possible).
After contact with skin
Wash off with soap and water. Take off all contaminated clothing immediately.
After contact with eyes
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.
After ingestion
Do NOT induce vomiting. Danger of inhalation Show this safety data sheet to the doctor in
attendance.
Revision No: 1,00 GB - EN
Revision date: 01.09.2011
Quantity
> 75 %
< 10 %
< 5 %
< 2,5 %

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 3 of 7
SECTION 5: Firefighting measures
Extinguishing media
Suitable extinguishing media
Water spray, Dry powder, Foam, Carbon dioxide (CO2).
Extinguishing media which must not be used for safety reasons
High volume water jet
Special hazards arising from the substance or mixture
Combustion may provoke smoke emission.
Advice for firefighters
In the event of fire, wear self-contained breathing apparatus.
Additional information
Standard procedure for chemical fires.
SECTION 6: Accidental release measures
Personal precautions, protective equipment and emergency procedures
Use personal protective equipment. Do not breathe vapours or spray mist. Ensure adequate
ventilation, especially in confined areas. Avoid contact with skin and eyes.
Environmental precautions
Do not flush into surface water or sanitary sewer system. Inform the responsible authorities in case of
gas leakage, or of entry into waterways, soil or drains.
Methods and material for containment and cleaning up
Use mechanical handling equipment. Soak up with inert absorbent material (e.g. sand, silica gel, acid
binder, universal binder, sawdust). Treat recovered material as described in the section "Disposal
considerations".
Reference to other sections
Remove all sources of ignition.
SECTION 7: Handling and storage
Precautions for safe handling
Advice on safe handling
Provide sufficient air exchange and/or exhaust in work rooms.
Advice on protection against fire and explosion
Take measures to prevent the build up of electrostatic charge.
Processing may lead to evolution of flammable volatiles. Vapours may form explosive mixtures with
air.
Keep away from sources of ignition - No smoking.
Keep product and empty container away from heat and sources of ignition.
Conditions for safe storage, including any incompatibilities
Requirements for storage rooms and vessels
Keep containers tightly closed in a dry, cool and well-ventilated place.
Advice on storage compatibility
No special precautions required.
Further information on storage conditions
Keep containers dry and tightly closed to avoid moisture absorption and contamination.
SECTION 8: Exposure controls/personal protection
Revision No: 1,00 GB - EN
Revision date: 01.09.2011

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 4 of 7
Control parameters
Exposure limits (EH40)
CAS No Chemical name
ml/m³ mg/m³ F/ml Category
Origin
71-36-3 Butan-1-ol
-
- TWA (8 h) WEL
50 154 STEL (15 min) WEL
64-17-5 Ethanol
1000 1920 TWA (8 h) WEL
- - STEL (15 min) WEL
108-88-3 Toluene
50 191 TWA (8 h) WEL
Exposure controls
100 384 STEL (15 min) WEL
Protective and hygiene measures
When using, do not eat, drink or smoke. Do not breathe vapours or spray mist. Avoid contact with the
skin and the eyes.
Respiratory protection
Ensure adequate ventilation, especially in confined areas. When workers are facing concentrations
above the exposure limit they must use appropriate certified respirators. (gas filter type A)
Hand protection
Solvent-resistant gloves (butyl-rubber)
Eye protection
Tightly fitting safety goggles
Skin protection
Protective suit
Environmental exposure controls
Avoid subsoil penetration. Do not flush into surface water or sanitary sewer system.
SECTION 9: Physical and chemical properties
Information on basic physical and chemical properties
Physical state:
Colour:
Odour:
liquid
light yellow
characteristic
pH-Value: ca. 7
Changes in the physical state
Melting point:
Boiling point:
Flash point:
Lower explosion limits:
Upper explosion limits:
Ignition temperature:
not applicable
116 - 142 °C
9 °C
0,9 vol. %
7,0 vol. %
420 °C
Vapour pressure:
(at 20 °C)
8 hPa
Density (at 20 °C): 0,75 g/cm³
Water solubility: insoluble
Test method
Revision No: 1,00 GB - EN
Revision date: 01.09.2011

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 5 of 7
Viscosity / dynamic:
(at 20 °C)
SECTION 10: Stability and reactivity
Reactivity
No dangerous reaction known under conditions of normal use.
Conditions to avoid
Heat, flames and sparks. humid air and water.
Incompatible materials
Oxidizing agents, Acids, Bases; Water.
Hazardous decomposition products
No decomposition if used as directed.
SECTION 11: Toxicological information
Information on toxicological effects
Acute toxicity
No data is available on the product itself.
CAS No
108-88-3 toluene
Chemical name
ca. 0,76 mPa·s
Exposure routes Method Dose Species
Source
dermal
78-10-4 ethyl silicate, tetraethyl silicate
oral
dermal
LD50 12200
mg/kg
Rabbit
GESTIS
LD50 6270 mg/kg Rat
GESTIS
LD50 5880 mg/kg Rabbit
GESTIS
Further information
Harmful by inhalation and in contact with skin. Repeated or prolonged contact with the preparation
may cause removal of natural fat from the skin resulting in non-allergic contact dermatitis and
absorption through the skin.
SECTION 12: Ecological information
Toxicity
Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
CAS No Chemical name
108-88-3
Aquatic toxicity Method Dose h Species
Source
toluene
Bioaccumulative potential
Acute fish toxicity LC50 13 mg/l 96 Carassius auratus
IUCLID
Acute algae toxicity ErC50 12,5 mg/l 72 Algen
GESTIS
Partition coefficient n-octanol/water
CAS No Chemical name
108-88-3 toluene 2,73
Results of PBT and vPvB assessment
Log Pow
Revision No: 1,00 GB - EN
Revision date: 01.09.2011

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 6 of 7
This mixture contains no substance considered to be persistent, bioaccumulating nor toxic (PBT).
SECTION 13: Disposal considerations
Waste treatment methods
Advice on disposal
Can be incinerated, when in compliance with local regulations.
Contaminated packaging
Empty remaining contents. Dispose of in accordance with local regulations.
SECTION 14: Transport information
Land transport (ADR/RID)
UN number:
UN proper shipping name:
Transport hazard class(es):
Packing group:
Hazard No:
1993
1993 - Flammable liquid, n.o.s.
3
II
33
Other applicable information (land transport)
Contains C7-C10 Isoalkane
Marine transport
UN number:
UN proper shipping name:
Transport hazard class(es):
Packing group:
Marine pollutant:
1993
1993 - Flammable liquid, n.o.s.
3
II
ja
Other applicable information (marine transport)
Contains C7-C10 Isoalkane
Air transport
UN/ID number:
UN proper shipping name:
Transport hazard class(es):
Packing group:
Other applicable information (air transport)
Contains C7-C10 Isoalkane
SECTION 15: Regulatory information
1993
1993 - Flammable liquid, n.o.s.
3
II
Safety, health and environmental regulations/legislation specific for the substance or mixture
EU regulatory information
1999/13/EC (VOC):
National regulatory information
Water contaminating class (D):
SECTION 16: Other information
83 %
2 - water contaminating
Full text of R-phrases referred to under sections 2 and 3
10 Flammable.
Revision No: 1,00 GB - EN
Revision date: 01.09.2011

Safety Data Sheet
according to Regulation (EC) No 1907/2006
EGOCON 790
EGO Dichtstoffwerke GmbH & Co.Betriebs KG
Print date: 22.05.2012 Product code: 662
Page 7 of 7
11 Highly flammable.
20 Harmful by inhalation.
36/37 Irritating to eyes and respiratory system.
36/38 Irritating to eyes and skin.
38 Irritating to skin.
41 Risk of serious damage to eyes.
48/20 Harmful: danger of serious damage to health by prolonged exposure through inhalation.
51 Toxic to aquatic organisms.
51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
53 May cause long-term adverse effects in the aquatic environment.
63 Possible risk of harm to the unborn child.
65 Harmful: may cause lung damage if swallowed.
67 Vapours may cause drowsiness and dizziness.
Full text of H-Statements referred to under sections 2 and 3
H225 Highly flammable liquid and vapour.
H226 Flammable liquid and vapour.
H304 May be fatal if swallowed and enters airways.
H315 Causes skin irritation.
H318 Causes serious eye damage.
H319 Causes serious eye irritation.
H332 Harmful if inhaled.
H335 May cause respiratory irritation.
H336 May cause drowsiness or dizziness.
H361d Suspected of damaging the unborn child.
H373 May cause damage to organs through prolonged or repeated exposure.
H411 Toxic to aquatic life with long lasting effects.
Further Information
These data describe only the safety requirements for the product(s) and are based on our present
knowledge. However, they do not constitute a guarantee for any specific product features and shall
not establish a legally valid contractual relationship.
(The data for the hazardous ingredients were taken respectively from the last version of the sub-contractor's
safety data sheet.)
Revision No: 1,00 GB - EN
Revision date: 01.09.2011