service manual sacd/dvd receiver - Diagramas Gratis - Diagramas ...

SERVICE MANUAL
Ver 1.6 2004.03
HCD-S550/S880 is the amplifier, DVD/CD
player and tuner section in DAV-S550/S880.
9-874-135-07 Sony Corporation
2004C05-1 Home Audio Company
© 2004.03 Published by Sony Engineering Corporation
HCD-S550/S880
Photo: HCD-S550
AEP Model
UK Model
E Model
Australian Model
Chinese Model
Model Name Using Similar Mechanism NEW
Mechanism Type CDM72B-DVBU12
Base Unit Name DVBU12
Optical Traverse Unit Name DBU-1
SPECIFICATIONS
Amplifier section
S550:
Stereo mode 80 W + 80 W (4 ohms at 1 kHz, THD 10 %)
Surround mode Front: 80 W + 80 W
Center*: 80 W
Rear*: 80 W + 80 W (4 ohms at 1 kHz, THD 10 %)
Subwoofer*: 100 W (3 ohms at 100 Hz, THD 10 %)
S880:
Stereo mode 100 W + 100 W (3 ohms at 1 kHz, THD 10 %)
Surround mode Front: 100 W + 100 W
Center*: 100 W
Rear*: 100 W + 100 W (3 ohms at 1 kHz, THD 10 %)
Subwoofer*: 100 W (3 ohms at 100 Hz, THD 10 %)
* Depending on the sound field settings and the source, there may be no sound output.
Inputs (Analog) VIDEO 1, 2:
Sensitivity: 150 mV
Impedance: 50 kilohms
Inputs (Digital) VIDEO 2 (optical):
Sensitivity: –
Outputs (Analog) VIDEO 1 (AUDIO OUT):
Voltage: 2 V
Impedance: 1 kilohms
PHONES:
Accepts low- and high-impedance headphones
– Continued on next page –
SACD/DVD RECEIVER

HCD-S550/S880
Super Audio CD/DVD system
Laser Semiconductor laser
(Super Audio CD/DVD: λ = 650 nm)
(CD: λ = 780 nm)
Emission duration: continuous
Signal format system NTSC or NTSC/PAL
Frequency response (at 2 CH STEREO mode)
DVD (PCM): 2 Hz to 22 kHz (±1.0 dB)
CD: 2 Hz to 20 kHz (±1.0 dB)
Signal-to-noise ratio More than 80 dB (VIDEO 1 (AUDIO)
connectors only)
Harmonic distortion Less than 0.03 %
FM tuner section
System PLL quartz-locked digital synthesizer
system
Tuning range 87.5 – 108.0 MHz (50 kHz step)
Antenna FM wire antenna
Antenna terminals 75 ohms, unbalanced
Intermediate frequency 10.7 MHz
AM tuner section
System PLL quartz-locked digital synthesizer
system
Tuning range
European, Middle Eastern, and Philipinne models:
531 – 1,602 kHz (with the interval set at 9 kHz)
Other models: 531 – 1,602 kHz (with the interval set at 9 kHz)
530 – 1,710 kHz (with the interval set at 10 kHz)
Antenna Loop antenna
Intermediate frequency 450 KHz
Video section
Inputs Video: 1 Vp-p 75 ohms
Outputs Video: 1 Vp-p 75 ohms
S video:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
PB/CB, PR/CR: 0.7 Vp-p 75 ohms
General
Power requirements
European model:
.
230 V AC, 50/60 Hz
Australian and Asian models: 220 – 240 V AC, 50/60 Hz
Mexican model: 120 V AC, 60 Hz
Chinese model: 220 V AC, 50/60 Hz
Taiwan model: 110 – 120 V AC, 50/60 Hz
Other models:
Power consumption
110 – 240 V/220 – 240 V AC, 50/60 Hz
S550:
120 W (120 V AC) 120 W (230 V AC)
1 W (120 V AC) 2 W (230 V AC)
2
(at the Power Saving Mode)
Dimensions (approx.) 355 × 60 × 323 mm (14 × 2 3 /8 × 12 3 S880:
135 W (120 V AC) 135 W (230 V AC)
1 W (120 V AC) 2 W (230 V AC)
(at the Power Saving Mode)
/4 inches)
(w/h/d) incl. projecting parts
Mass (approx.) 3.8 kg (8 lb 7 oz)
Operating temperature 5˚C to 35˚C (41˚F to 95˚F)
Operating humidity 5 % to 90 %
Design and specifications are subject to change without notice
Self-diagnosis Function
(When letters/numbers appear in the
display)
When the self-diagnosis function is
activated to prevent the system from
malfunctioning. In this case a five-character
service number (e.g., C 13 00) with a
combination of a letter and digits appears on
the screen and the front panel display. Refer
to the following table.
First three
characters of
the service
number
C 13
C 31
SELF DIAGNOSIS FUNCTION
E XX
(xx is a number)
C:13:00
Cause and/or Corrective
Action
The disc is dirty.
, Clean the disc with a soft
cloth.
The disc is not inserted
correctly.
, Re-insert the disc
correctly.
To prevent a malfunction, the
system has performed the selfdiagnosis
function.
, Contact your nearest Sony
dealer or local authorized
Sony service facility and
give the 5-character
service number.
Example: E 61 10
Note: Refer to the “5. TEST MODE” (page 20) for another self-diagnosis
function.

Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged
by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
This appliance is classified as a
CLASS 1 LASER product. The label
is located on the bottom exterior.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
HCD-S550/S880
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs,
screws, and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale.
The Simpson 250 and Sanwa SH-63Trd are examples of a passive
VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2 V AC range are suitable. (See Fig. A)
0.15 µF
To Exposed Metal
Parts on Set
1.5 kΩ
AC
voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0
SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE
DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ
DE FONCTIONNEMENT. NE REMPLACER CES COM-
POSANTS QUE PAR DES PIÈCES SONY DONT LES
NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
3

HCD-S550/S880
Ver 1.4
SELF DIAGNOSIS FUNCTION .................................... 2
1. SERVICING NOTES ............................................... 5
2. GENERAL
Location of Controls ...................................................... 6
3. DISASSEMBLY
3-1. Disassembly Flow .......................................................... 9
3-2. Front Panel Section, Side Panel (L)/(R) ........................ 10
3-3. I/O Board ......................................................................... 10
3-4. SEL Board ....................................................................... 11
3-5. DVD Board...................................................................... 11
3-6. Mechanism Deck Section (CDM72B-DVBU12) .......... 12
3-7. POWER SW Board, DDCON Board ............................. 12
3-8. Power Board ................................................................... 13
3-9. AMP Board .................................................................... 13
3-10. Optical Pick-up (DVBU12) ........................................... 14
3-11. RELAY Board ................................................................ 14
3-12. Holder (AT) Assy, Retainer (Chassis) Block ................. 15
3-13. Belt (L2) ......................................................................... 15
3-14. Pulley (RTR) Assy ......................................................... 16
3-15. Belt (CK) ........................................................................ 16
3-16. Pulley (SPT) Assy .......................................................... 17
3-17. Belt (CK), Motor (CK) Assy (M751) ............................ 17
4. ASSEMBLY
4-1. How to Install Pulley (SPT) Assy .................................. 18
4-2. How to Install Pulley (RTR) Assy ................................. 18
4-3. How to Install Rotary Encoder (Mode) (S741) ............. 19
5. TEST MODE ............................................................. 20
6. ELECTRICAL ADJUSTMENT ........................... 27
7. DIAGRAMS
7-1. Block Diagram – RF SERVO Section – ....................... 28
7-2. Block Diagram – AUDIO (DSP) Section – .................. 29
7-3. Block Diagram – AUDIO OUT, PANEL Section – ..... 30
7-4. Block Diagram – VIDEO Section – ............................. 31
7-5. Block Diagram – MECHANISM DECK,
POWER SUPPLY Section – .......................................... 32
7-6. Note for Printed Wiring Boards and
Schematic Diagrams ...................................................... 33
7-7. Printed Wiring Boards – RF Section – ......................... 34
7-8. Schematic Diagram – RF Section –.............................. 35
7-9. Printed Wiring Boards
– MECHANISM DECK Section – ................................ 36
7-10. Schematic Diagram
– MECHANISM DECK Section – ................................ 37
7-11. Printed Wiring Board
– DVD Board (Component Side) – ............................... 38
7-12. Printed Wiring Board
– DVD Board (Conductor Side) – ................................. 39
7-13. Schematic Diagram – DVD Board (1/10) – ................. 40
7-14. Schematic Diagram – DVD Board (2/10) – ................. 41
7-15. Schematic Diagram – DVD Board (3/10) – ................. 42
7-16. Schematic Diagram – DVD Board (4/10) – ................. 43
7-17. Schematic Diagram – DVD Board (5/10) – ................. 44
7-18. Schematic Diagram – DVD Board (6/10) – ................. 45
7-19. Schematic Diagram – DVD Board (7/10) – ................. 46
7-20. Schematic Diagram – DVD Board (8/10) – ................. 47
7-21. Schematic Diagram – DVD Board (9/10) – ................. 48
7-22. Schematic Diagram – DVD Board (10/10) – ............... 49
4
TABLE OF CONTENTS
7-23. Printed Wiring Board – AMP Section (1/2) – .............. 50
7-24. Printed Wiring Boards – AMP Section (2/2) –............. 51
7-25. Schematic Diagram – AMP Section (1/2) – ................. 52
7-26. Schematic Diagram – AMP Section (2/2) – ................. 53
7-27. Printed Wiring Board – I/O Section (1/2) – .................. 54
7-28. Printed Wiring Boards – I/O Section (2/2) – ................ 55
7-29. Schematic Diagram – I/O Section (1/2) – .................... 56
7-30. Schematic Diagram – I/O Section (2/2) – .................... 57
7-31. Printed Wiring Boards
– DC-DC CONVERTER Section – ............................... 58
7-32. Schematic Diagram
– DC-DC CONVERTER Section – ............................... 59
7-33. Printed Wiring Boards – CONTROL Section – ........... 60
7-34. Schematic Diagram – CONTROL Section –................ 61
7-35. Printed Wiring Board – FL Board – ............................. 62
7-36. Schematic Diagram – FL Board – ................................ 63
7-37. Printed Wiring Board – POWER Section (1/2) – ......... 64
7-38. Printed Wiring Boards – POWER Section (2/2) – ....... 65
7-39. Schematic Diagram – POWER Section – .................... 66
7-40. IC Pin Function Description .......................................... 84
8. EXPLODED VIEWS
8-1. General Section ............................................................. 102
8-2. Front Panel Section-1.................................................... 103
8-3. Front Panel Section-2.................................................... 104
8-4. Chassis Section-1 .......................................................... 105
8-5. Chassis Section-2 .......................................................... 106
8-6. Chassis Section-3 .......................................................... 107
8-7. Chassis Section-4 .......................................................... 108
8-8. Mechanism Deck Section-1 (CDM72B-DVBU12)...... 109
8-9. Mechanism Deck Section-2 (CDM72A-DVBU12) ..... 110
8-10. Mechanism Deck Section-3 (CDM72A-DVBU12) ..... 111
8-11. Mechanism Deck Section-4 (CDM72A-DVBU12) ..... 112
8-12. Mechanism Deck Section-5 (CDM72A-DVBU12) ..... 113
8-13. Mechanism Deck Section-6 (CDM72A-DVBU12) ..... 114
8-14. Mechanism Deck Section-7 (CDM72A-DVBU12) ..... 115
8-15. Optical Pick-up Section (DVBU12) ............................. 116
9. ELECTRICAL PARTS LIST ............................. 117

NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
JIG ON REPAIRING
When repairing this set, etc., connect the extension cable as the
figure shown below.
RELEASING THE DISC SLOT LOCK
The disc slot lock function for the antitheft of an demonstration
disc in the store is equipped.
Releasing Procedure:
1. Press two buttons of A and x simultaneously for three seconds.
2. The message “UNLOCKED” is displayed and the slot is unlocked.
Note: When “LOCKED” is displayed, the slot lock is not released by
turning power on/off with the [POWER] button.
extension cable (with relay board)
(RELAY board-DVD board)
(Part No. J-2501-091-A)
SECTION 1
SERVICING NOTES
extension cable
(RF board-DVD board)
(Part No. J-2501-217-A)
extension cable
(DVD board-AMP board)
(Part No. J-8000-024-A)
extension cable
(DVD board-AMP board)
(Part No. J-2501-198-A)
HCD-S550/S880
Ver 1.6
CHECKING OF OPERATIONS WITH REMOTE COM-
MANDERS OF DIFFERENT MODELS
Some of the signal of remote commander vary between generation
of player.
Between DAV-S400/S500/S800/C450/C700/C900 and DAV-S550/
S880/C770/C900, remote commander signal codes of “FUNC-
TION”, “BAND”, “ST/MONO” and “MEMORY” are different.
Take notice of the above when you check the operation with remote
commanders of different models.
NOTE OF REPLACING THE DVD BOARD
When replacing the DVD board, since the adjustment value is not
set up correctly, “Drive Auto Adjustment” can’t be performed.
In this case, initialize Memory in the following procedures.
Procedure:
1. Set the test mode. (See page 20)
2. Press the [2] key of the remote commander, and set the “DRIVE
MANUAL OPERATION”. (See page 22)
3. Press the [6] key of the remote commander, and set the “2-6,
Memory Check”. (See page 24)
4. Press the [CLEAR] key of the remote commander, and initialize
Memory.
5

HCD-S550/S880
LOCATION OF CONTROLS
6
Front Panel
STANDBY
1 POWER switc
2 STANDBY indicator
3 Disc slot
4 A (Eject)
5 H (play)
6 X (pause)
7 x (stop)
8 ./> PREV/NEXT, PRESET –/+
Rear Panel
FRONT
R
FRONT
L
CENTER WOOFER
IMPEDANCE
USE
REAR
REAR WOOFER 3Ω
R
L EXCEPT
WOOFER 3Ω
SPEAKER
1 SPEAKER jacks
2 AM antenna
3 COMPONENT VIDEO OUT/SCAN
SELECT switch
4 VIDEO 1 jacks
5 VIDEO 2 jacks
SECTION 2
GENERAL
AM
SCAN SELECT
SELECTABLE
INTERLACE
FUNCTION BAND DISPLAY SOUND FIELD
9 PHONES jack
q; VOLUME control
qa SOUND FIELD –/+
qs DISPLAY
qd BAND
qf FUNCTION
qg Front panel display
qh (remote sensor)
AUDIO OUT VIDEO OUT AUDIO IN
VIDEO IN
R L
R
L
COAXIAL
OPTICAL
FM
75Ω
R
COMPONENT
VIDEO OUT
L
AUDIO IN VIDEO IN
VIDEO 1
DIGITAL
IN
Y PB/CB PR/CR VIDEO 2
COMPONENT VIDEO OUT
VIDEO
MONITOR
OUT
6 DIGITAL IN (OPTICAL) jack
7 MONITOR OUT (VIDEO/S VIDEO)
jacks
8 COMPONENT VIDEO OUT jacks
9 FM 75Ω COAXIAL antenna jack
This section is extracted from
instruction manual.
S VIDEO (DVD ONLY)
PHONES

Front Panel Display
When playing back a DVD
Current sound
PCM
DIGITAL
PRO LOGIC
Current surround
format
When playing back a Super Audio CD, CD, VIDEO CD, or MP3
Current sound
Playing status
SACD PCM TRACK INDEX M S
Playing status Current track number Playing time Current play mode
When listening to the radio
FM AM
Current band
Current title
number
Current chapter number
TITLE CHAPTER H M S
Current index number
(The index indicator does not appear
during Super Audio CD or MP3
playback.)
Playing time Current repeat mode
Preset number Monaural/Stereo effect
TUNED MONO ST
Current station
Lights up when you can
change the angle
Lights up during
PBC playback
(VIDEO CD only)
MHz
ANGLE
REPEAT 1
REPEAT 1
PROG PBC
SHUFFLE
HCD-S550/S880
7

HCD-S550/S880
8
Remote
1 2 3
4 5 6
7 8 9
>10 10/0
Note
This remote control glows in the dark. However,
before glowing, the remote must be exposed to light
for awhile.
1 TV [/1 (on/standby)
2 Z (EJECT)
3 NAME
4 STEREO/MONO
5 MEMORY
6 CLEAR
7 PLAY MODE
8 AUDIO
9 ANGLE
q; SUBTITLE
qa VOL +/–
qs ./> PREV/NEXT, TV CH –/+,
PRESET –/+
qd H PLAY/SELECT
qf DVD TOP MENU
qg DVD DISPLAY
qh C/X/x/c/ENTER
qj DVD SETUP
qk 1 (standby)
ql DIMMER
w; TV/VIDEO
wa REPEAT
ws MUTING
wd TIME
wf FUNCTION
wg BAND
wh Number buttons
wj SOUND FIELD
wk DISPLAY
wl ENTER
e; COMMAND MODE DVD TV switch
ea m/M/ / SLOW, TUNING –/+
es x STOP
ed X PAUSE
ef DVD MENU
eg O RETURN
eh AMP MENU

• This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
SET
3-2. FRONT PANELSECTION,
SIDE PANEL (L)/(R)
(Page 10)
3-3. I/O BOARD
(Page 10)
3-4. SEL BOARD
(Page 11)
3-5. DVD BOARD
(Page 11)
3-6. MECHANISM DECK
SECTION (CDM72B-DVBU12)
(Page 12)
3-7. POWER SW BOARD,
DDCON BOARD
(Page 12)
SECTION 3
DISASSEMBLY
3-8. POWER BOARD
(Page 13)
3-10. OPTICAL PICK-UP BLOCK
(DVBU12)
(Page 14)
3-12. HOLDER (AT) ASSY.
RETAINER (CHASSIS) BLOCK
(Page 15)
3-13. BELT (L2)
(Page 15)
3-14. PULLEY (RTR) ASSY
(Page 16)
3-15. BELT (CK)
(Page 16)
3-9. AMP BOARD
(Page 13)
3-11. RELAY BOARD
(Page 14)
3-16. PULLEY (SPT) ASSY
(Page 17)
HCD-S550/S880
3-17. BELT (CK),
MOTOR (CK) ASSY (M751)
(Page 17)
9

HCD-S550/S880
Note: Follow the disassembly procedure in the numerical order given.
3-2. FRONT PANEL SECTION, SIDE PANEL (L)/(R)
3-3. I/O BOARD
10
qa side panel (L)
8 connector
(CN803)
7 connector
(CN802)
6 connector
(CN804)
0 two two screws screws
(BVTP3 (BVTP3 × 8) 8)
5 connector
(CN805)
2 two flexible flat cables
(CN202, 203)
5 I/O board
3
2 three screws
(BVTP3 × 8)
9 front panel section
4 connector (CN900)
1 three screws
(BVTP3 × 8)
1 flexible flat cable
(CN201)
2 connector (CN205)
4 seven screws
(BVTP3 × 8)
qs two screws
(BVTP3 × 8)
qd side panel (R)

3-4. SEL BOARD
3-5. DVD BOARD
8 power cord block
9 connector
(CN900)
9 two screws
(BVTP3 × 8)
0 retainer
3 screw
(DIA. 2.6 × 8)
4 retainer
1 flexible flat cable
(CN005)
5 flexible board
(CN401)
5 SEL board
2 claw
qa two screws (BVTP3 × 8)
2 flexible flat cable
(CN006)
qs DVD board
1 screw
(DIA. 2.6 × 8)
3 flexible flat cable
(CN001)
4 flexible flat cable
(CN004)
6 connector
(CN008)
HCD-S550/S880
11

HCD-S550/S880
3-6. MECHANISM DECK SECTION (CDM72B-DVBU12)
3-7. POWER SW BOARD, DDCON BOARD
12
5 power button section
8 flexible flat cable
(CN814)
9 connector
(CN807)
3 mechanism deck
(CDM72B-DVBU12)
1 flexible flat cable
(CN701)
2 four screws
(BVTP3 × 8)
6 four screws
(P2 × 6)
4 connector
(CN901)
qa DDCON board
0 two screws
(BVTP3 × 8)
7 power SW board
2 four screws
(BVTP3 × 8)
3
1 connector (CN902)

3-8. POWER BOARD
3-9. AMP BOARD
3 connector
(CN902)
4 four screws
(BVTP3 × 8)
6 power sheet
1 two wires (flat type)
(CN301, 305)
3 connector
(CN904)
2 connector
(CN302)
5
2 connector
(CN903)
1 connector
(CN904)
7 power board
4 four screws
(BVTP3 × 8)
6 AMP board
5 two screws
(BVTP3 × 8)
HCD-S550/S880
13

HCD-S550/S880
3-10. OPTICAL PICK-UP BLOCK (DVBU12)
3-11. RELAY BOARD
14
3 connector
(CN741)
S880
1 three screws
(BTP2.6 × 6)
1 screw
(PTPWHM2.6)
8 connecter
(CN706)
9 relay board
2 retainer
7 connector
(CN702)
2 optical pick-up block
(DVBU12)
5
4 two screws
(BTP2.6 × 6)
6 two connector
(CN703, 707)

3-12. HOLDER (AT) ASSY, RETAINER (CHASSIS) BLOCK
3-13. BELT (L2)
1 tension spring
(S5)
2 three screws
(BTP2.6 × 8)
1 two gears
(S1)
2 belt (L2)
3 pulley (LDG)
3 holder (AT) assy
4 four screws
(BTP2.6 × 6)
HCD-S550/S880
5 retainer (chassis) block
15

HCD-S550/S880
3-14. PULLEY (RTR) ASSY
3-15. BELT (CK)
16
shaft
(pulley (RTR) assy)
2 gear (L4)
3 torsion spring
(L)
front
– bottom view –
fig. 1
3 belt (CK)
5 pulley (LCG)
hole
A
1 two bushings
(CDM72)
1 Rotate the pulley (RTR) assy in the direction of arrow A
to disengage the shaft of the pulley (RTR) assy from
the hole of the chassis (refer to fig. 1), and remove it.
2 gear (L5)
4 pulley (L5)
pulley (RTR) assy
B
boss
claw
connector
Tilting the pulley (RTR) assy in the direction
of arrow B, move it over the claw and
the connector of the chassis.

3-16. PULLEY (SPT) ASSY
2 pulley (SPT) assy
3 gear (S2)
3-17. BELT (CK), MOTOR (CK) ASSY (M751)
2 belt (CK)
3 pulley (CKG)
1 busing (CDM72)
4 two solders
5 two screws
(BTP2.6 × 6)
4 torsion spring (S)
5 gear (SPT)
6 gear (KT)
hole
shaft
(pulley (SPT) assy
7 motor (CK) assy
(M751)
6 CK motor board
HCD-S550/S880
1 Rotate the pulley (SPT) assy to fit position
of the shaft to the hole of the chassis.
17

HCD-S550/C880
• This set can be assembled in the order shown below.
4-1. HOW TO INSTALL PULLEY (SPT) ASSY
18
gear (SPT)
gear (S2)
Note: installation of torsion spring (S)
gear (KT)
gear (SPT)
4-2. HOW TO INSTALL PULLEY (RTR) ASSY
pulley (RTR) assy
4 gear (S2)
SECTION 4
ASSEMBLY
torsion spring (S)
5 pulley (SPT) assy
3 torsion spring (S) (Note)
2 gear (SPT)
gear (S2)
1 gear (KT)
gear (S2)
pulley
(RTR) assy

4-3. HOW TO INSTALL ROTARY ENCODER (MODE) (S741)
linearly
cam (CDM72)
rotary encoder (mode)
(S741)
-bottom view-
4 screw
(PWH,2 × 6)
1 encoder board
2 screw
(BTP2.6 × 6)
3 rotary encoder (mode)
(S741)
HCD-S550/S880
19

HCD-S550/S880
Ver 1.4
[GENERAL DESCRIPTION]
The Test Mode allows you to make diagnosis and adjustment easily
using the remote commander and monitor TV. The instructions,
diagnostic results, etc. are given on the on-screen display (OSD).
[TEST DISC LIST]
Use the following test disc on test mode.
TDV-520CSO (DVD-SL): PART No. J-2501-236-A
LIV-P01 (CD): PART No. 4-999-032-01
TDV-540C (DVD-DL): PART No. J-2501-235-A
Note: Do not use exiting test disc for DVD.
[STARTING TEST MODE]
1. Press the [POWER] button to turn the power on, and set the
function to DVD.
2. While pressing the x and [DISPLAY] button, turn the
[VOLUME] knob clockwise to enter the test mode.
3. It displays “TEST MODE” on the fluorescent indicator tube,
and displays the Test Mode Menu on the monitor screen as
follows. (At the bottom of the menu screen, the model name
and revision number are displayed)
20
Test Mode Menu
0. Syscon Diagnosis
1. Drive Auto Adjustment
2. Drive Manual Operation
3. Mecha Aging
4. Emergency History
5. Mecha Error History
6. Version Information
7. Video Level Adjustment
Exit: POWER Key
Model :DAV-Sxxx
Revision :x.xx
4. To execute each function, select the desired menu and press its
number on the remote commander (RM-SS880J).
5. To release from test mode, press the [POWER] button and turn
the power off.
[OPERATING TEST MODE]
0. SYSCON DIAGNOSIS
The same contents as board detail check by serial interface can be
checked from the remote commander operation.
On the Test Mode Menu screen, press [10/0] key on the remote
commander, and the following Check Menu will be displayed.
0. Quit
1. All
2. Version
3. EEPROM
4. SPIO
5. SD Bus
6. Video
7. Audio
### Syscon Diagnosis ###
Check Menu
0-0. Quit
Quit the Syscon Diagnosis and return to the Test Mode Menu.
SECTION 5
TEST MODE
0-1. All (All items continuous check)
This menu checks all diagnostic items continuously. Normally, all
items are checked successively one after another automatically
unless an error is found, but at a certain item that requires judgment
through a visual check to the result, the following screen is displayed
for the key entry.
• Example display
### Syscon Diagnosis ###
Diag All Check
No.2 Version
2-3. ROM Check Sum
Check Sum = 2320
Press NEXT Key to Continue
Press PREV Key to Repeat
For the ROM Check, the check sum calculated by the Syscon is
output, and therefore you must compare it with the specified value
for confirmation.
Following the message, press the [NEXT > ] button to go to the
next item, or press the [ . PREV] button to repeat the same
operation again.
To quit the diagnosis and return to Check Menu screen, press the
[RETURN] key on the remote commander to display Check Menu.
• Error occurred
If an error occurred, the diagnosis is suspended and error is displayed.
Press the [RETURN] key on the remote commander to quit the
diagnosis, or press the [ . PREV] button to repeat the same check
where an error occurred, or press the [NEXT > ] button to continue
the check from the item next to faulty item.
General Description of Checking Method
Selecting 2 and subsequent items calls the submenu screen of each
item. And selecting 2 and subsequent items executes respective
menus and outputs the results.
For the contents of each submenu, see “Check Items List” as below.
Check Items List:
0-2. Version
0-2-1. All
0-2-2. Revision
0-2-3. ROM Check Sum
0-2-4. Model Type
0-2-5. Region
0-3. EEPROM Check
0-3-1. Sampling Check
0-3-2. Detail Check
0-4. GP I/O Check
0-5. SD Bus Check
0-6. Video Check
0-7. Audio Check
0-2. Version
0-2-2. Revision
The revision number of ROM (IC204) that the program for
the DVD system processor (IC206) is stored.
(4 digits hexadecimal number)

0-2-3. ROM Check Sum
The revision number of ROM (IC204) that the program for
the DVD system processor (IC206) is stored.
0-2-4. Model Type
Model name is displayed. (DAV-S550 or DAV-S880)
0-2-5. Region
Model destination code is displayed. (2 digits number)
0-3. EEPROM Check
0-3-1. Sampling Check
EEPROM check at every 64 words.
It compares read data with write data of each address. When
there are discrepancies between two data, it displays error.
0-3-2. Detail Check
EEPROM check at every 1 word.
It compares read data with write data of each address. When
there are discrepancies between two data, it displays error.
0-4. GP I/O Check
Pull up/down setting check of the DVD system processor (IC206)
pin 150, 151 and 154 (for clock setting port).
0-5. SD Bus Check
SD bus data check between DVD decoder (IC701) and D-RAM
(IC706).
0-6. Video Check
Output the color bars for video level adjustment.
0-7. Audio Check
Output the test signal (1kHz sine wave) for 5.1 CH test.
1. DRIVE AUTO ADJUSTMENT
On the Test Mode Menu screen, press the [1] key on the remote
commander, and the Adjustment Menu will be displayed.
## Drive Auto Adjustment ##
Adjustment Menu
0. ALL
1. DVD-SL
2. CD
3. DVD-DL
Exit: RETURN
Normally, [10/0] is selected to adjust DVD (single layer), CD and
DVD (dual layer) in this order. But, individual items can be adjusted
for the case where adjustment is suspended due to an error. In this
mode, the adjustment can be made easily through the operation
following the message displayed on the screen.
The disc used for adjustment must be the one specified for
adjustment.
1-0. ALL
Press the [10/0] key on the remote commander, and the servo set
data in EEPROM will be initialized. Then, 1. DVD-SL disc, 2. CD
disc and 3. DVD-DL disc are adjusted in this order.
Each time one disc was adjusted, it is ejected. Replace it with the
specified disc following the message. You can finish the adjustment
HCD-S550/S880
by pressing the [RETURN] button on the remote commander.
Note: During adjustment of each disc, the measurement for disc type judgment
is made. As automatic adjustment does not judge the disc
type unlike conventional models, take care not to insert wrong type
discs. Also, do not give a shock during adjustment.
1-1. DVD-SL (single layer)
Press the [1] key on the remote commander and insert a DVD single
layer disc following the message. Then the adjustment will be made
through the steps below, then adjusted values will be written to the
EEPROM.
DVD Single Layer Disc Adjustment Steps:
1. Sled tilt reset
2. Disc check memory SL
3. Wait 300 msec
4. Set disc type SL
5. LD on
6. Spindle start
7. Wait 1 sec
8. Focus servo on 0
9. Auto track offset adjust
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. Wait 1 sec
14. Sled on
15. Check CLV on
16. Auto LFO adjust
17. Auto focus offset adjust
18. Auto tilt position adjust
19. Auto focus gain adjust
20. Auto focus offset adjust
21. EQ boost adjust
22. Auto loop filter offset adjust
23. Auto track gain adjust
Search Check
24. 32 track jump forward
25. 32 track jump reverse
26. 500 track jump forward
27. 500 track jump reverse
28. All servo stop
29. EEP copy loop filter offset
1-2. CD
Press the [2] key on the remote commander and insert a CD disc
following the message. Then the adjustment will be made through
the steps below, then adjusted values will be written to the EEPROM.
CD Adjustment Steps
1. Sled tilt rest
2. Disc check memory CD
3. Wait 500 msec
4. Set disc type CD
5. LD on
6. Spindle start
7. Wait 500 msec
8. Focus servo on 0
9. Auto track offset adjust
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. (TC display start)
14. Wait 1 sec
15. Jitter display start
16. Sled ON
17. Check CLV on
21

HCD-S550/S880
22
18. Auto loop filter offset adjust
19. Auto focus offset adjust
20. Auto focus gain adjust
21. Auto focus offset adjust
22. EQ boost adjust
23. Auto LFO Adjust
24. Auto track gain adjust
Search Check
25. 32Tj forward
26. 32Tj reverse
27. 500Tj forward
28. 500Tj reverse
29. All servo stop
1-3. DVD-DL (dual layer)
Press the [3] key on the remote commander and insert a DVD dual
layer disc following the message. Then the adjustment will be made
through the steps below, then adjusted values will be written to the
EEPROM.
DVD Dual Layer Disc Adjustment Steps:
1. Sled tilt reset
2. Disc check memory DL
3. Wait 500 msec
4. Set disc type DL
5. LD on
6. Spindle start
7. Wait 1 sec
Layer 1 Adjust
8. Focus servo on 0
9. Auto track offset adjust
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. Wait 500 msec
14. Sled on
15. Check CLV lock
16. Auto loop filter offset adjust, Auto focus adjust
17. Auto focus gain adjust
18. Auto focus offset adjust
19. EQ boost adjust
20. Auto loop filter offset adjust
21. Auto Track Gain Adjust
Search Check
22. 32 track jump forward
23. 32 track jump reverse
24. 500 track jump forward
25. 500 track jump reverse
Layer 0 Adjust
26. Focus jump (L1 t L0)
27. Auto track offset adjust L0
28. CLVA on
29. Wait 500 msec
30. Tracking on
31. Wait 500 msec
32. Sled on
33. Check CLV lock
34. Auto focus filter offset adjust
35. Auto Focus Adjust
36. Auto focus gain adjust
37. Auto focus offset adjust
38. EQ boost adjust
39. Auto Loop Filter Offset
40. Auto track gain adjust
Search Check
41. 32 track jump forward
42. 32 track jump reverse
43. 500 track jump forward
44. 500 track jump reverse
Layer Jump Check
45. Layer jump (L0 ? L1)
46. Layer jump (L1 ? L0)
47. All servo stop
2. DRIVE MANUAL OPERATION
Note: This mode is used for design, and not used in service fundamentally.
On the Test Mode Menu screen, press the [2] key on the remote
commander, and the Operation Menu will be displayed. For the
manual operation, each servo on/off control and adjustment can be
executed manually.
## Drive Manual Operation ##
Operation Menu
1. Disc Type
2. Servo Control
3. Track/Layer Jump
4. Non EEPROM Write Adjust
5. EEPROM Write Adjust
6. Memory Check
7. Disc Check Memory
8. Error Rate Display
9. SACD Water Mark
Exit: RETURN
In using the manual operation menu, take care of the following
points. These commands do not provide protection, thus requiring
correct operation. The sector address or time code field is displayed
when a disc is loaded.
Note:
1. Set correctly the disc type to be used on the Disc Type screen.
2. In case of an alarm, immediately press the x button to stop the
servo operation, and press the [POWER] button to turn the power
off.
Basic operation:
(controllable from front panel or remote commander)
[POWER] :Power OFF (release the Test Mode)
x : Servo stop
A : Stop and eject/Loading
[RETURN] : Return to Operation Menu or Test
Mode Menu
[ .
PREV], [NEXT > ] :Transition between sub modes of menu
[1] to [9], [10/0] : Selection of menu items
Cursor o / O : Increase/Decrease in manually
adjusted value

2-1. Disc Type
Disc Type
Disc Type Select
1. Disc Type Auto Check
2. Set Disc Type DVD
3. Set Disc Type CD
4. Set Disc Type Hybrid
Exit: RETURN
2-1-1. Disc Type Auto Check
1) Press the [1] key on the remote commander to display the Disc
Type Auto Check screen.
2) Insert a disc and press the [ENTER] key on the remote
commander.
3) It judges the type of inserted disc automatically and displays
the disc type and so on as below.
Disc Type Auto Check
Disc Type xx
Layer xx
Mirr Time xx
Mirr Count xx
FZC Count xx
PI Reference xx
PI Peak xx
ENTER.Execute
Exit: RETURN
Disc Type : CD, DVD or Hybrid (SACD)
Layer : SINGLE, DUAL or HYBRID
Mirr Time : Mirror time of between disc surface and record
surface when disc type judgment. (hexadecimal
number)
Mirr Count : The number of times which mirror counts between
disc surface and record surface when disc type
judging.
FZC Count : The number of times which focus zero cross points
of each layer when lens down.
PI Reference : The average of PI reference voltage. (hexadecimal
number)
PI Peak : PI peak level voltage. It performs only when disc
type judgment is successful. (hexadecimal number)
2-1-2. Disc Type DVD
It sets up so that it may judge as a disc type of specification of the
disc with which the set was inserted.
[1]: DVD single layer disc (12 cm)
[2]: DVD dual layer disc (0 layer, 12 cm)
[3]: DVD dual layer disc (1 layer, 12 cm)
[4]: DVD-RW disc (12 cm)
[5]: DVD single layer disc (8 cm)
[6]: DVD dual layer disc (0 layer, 8 cm)
[7]: DVD dual layer disc (1 layer, 8 cm)
[8]: DVD-RW disc (8 cm)
HCD-S550/S880
2-1-3. Disc Type CD
It sets up so that it may judge as a disc type of specification of the
disc with which the set was inserted.
[1]: CD disc (normal speed, 12 cm)
[2]: CD disc (double speed, 12 cm)
[3]: CD disc (normal speed, 8 cm)
[4]: CD disc (double speed, 8 cm)
[5]: CD-RW disc (normal speed, 12 cm)
[6]: CD-RW disc (double speed, 12 cm)
[7]: CD-RW disc (normal speed, 8 cm)
[8]: CD-RW disc (double speed, 8 cm)
2-1-4. Disc Type Hybrid
It sets up so that it may judge as a disc type of specification of the
disc with which the set was inserted.
[1]: SACD Hybrid disc (SACD layer, 12 cm)
[2]: SACD Hybrid disc (CD layer, normal speed, 12 cm)
[3]: SACD Hybrid disc (CD layer, double speed, 12 cm)
[4]: SACD Hybrid disc (SACD layer, 8 cm)
[5]: SACD Hybrid disc (CD layer, normal speed, 8 cm)
[6]: SACD Hybrid disc (CD layer, double speed, 8 cm)
2-2. Servo Control
Note: Be sure to perform the disc type setup before performing this item.
Servo Control
1.LD off R.Sled FWD
2.Focus off L.Sled REV
3.SPDL off U.Sled Reset
4.CLVA off D.Sled Limit
5.Trk. off
6.Sled off
7.Fcs.Srch off
8.Fcs.OppL off
0.All Servo Off
Exit: RETURN
On this screen, the servo on/off control necessary for replay is
executed. Normally, turn on each servo from 1 sequentially and
when CLVA is turned on, the usual trace mode becomes active. In
the trace mode, DVD sector address or CD time code is displayed.
This is not displayed where the spindle is not locked.
The spindle could run overriding the control if the spindle system is
faulty or RF is not present. In such a case, do not operate CLVA.
[1] LD : Turn on/off the laser.
[2] Focus : Search the focus and turn on the focus.
[3] SPDL : Turn on/off the spindle.
[4] CLVA : Turn on/off normal servo of spindle servo.
[5] Trk. : Turn on/off the tracking servo.
[6] Sled : Turn on/off the sled servo.
[7] FCS. Srch : Turn on/off the focus search.
[8] FCS. OppL : Turn on/off the focus search to another
(opposite) layer of designated layer in Disc
Type setting. (dual layer disc only)
[10/0] : All servo off.
[R] Sled FWD (right cursor) : Move the sled forward.
[L] Sled REV (left cursor) : Move the sled reverse.
[U] Sled FWD (up cursor) : Reset the sled.
[D] Sled REV (down cursor): Limit in the sled.
23

HCD-S550/S880
2-3. Track/Layer Jump
24
Track/Layer Jump
1. 1Tj FWD R.Lj L0>L1
2. 1Tj REV L.Lj L1>L0
3.500Tj Fine FWD U.Fj L0>L1
4.500Tj Fine REV D.Fj L1>L0
5.10kTj Dirc FWD
6.10kTj Dirc REV
7.20kTj Dirc FWD
8.20kTj Dirc REV
0. All Servo Off
Exit: RETURN
On this screen, track jump, etc. can be performed. Only for the DVD
dual layer disc, the focus jump and layer jump are displayed in the
right field
[1] 1Tj FWD : 1 track jump forward.
[2] 1Tj REV : 1 track jump reverse.
[3] 500Tj FWD: 500 track jump (fine search)forward.
[4] 500Tj REV : 500 track jump (fine search) reverse.
[5] 10kTj FWD: 10k track jump (direct search) forward.
[6] 10kTj REV : 10k track jump (direct search) reverse.
[7] 20kTj FWD: 20k track jump (direct search) forward.
[8] 20kTj REV : 20k track jump (direct search) reverse.
[10/0] : All servo off.
2-4. Non EEPROM Write Adjust
Non EEPROM Write Adjust
1. Focus Offset
2. Focus Gain
3. Trk. Offset Coarse
4. Trk. Offset Fine
5. Trk. Gain
6. EQ Boost
0.All Servo Off
Exit: RETURN
On this screen, each item can be adjusted manually. Select the desired
number [1] to [10/0] from the remote commander, and current
setting for the selected item will be displayed, then increase or
decrease numeric value with the O key or o key. This value is
stored in the EEPROM. If CLV has been applied, the jitter is
displayed for reference for the adjustment.
[1] Focus Offset : Adjusts focus offset.
[2] Focus Gain : Adjusts focus gain.
[3] TRK. Offset : Adjusts tracking offset of the RF amp
(IC001) side.
[4] TRK. Offset : Adjusts tracking offset of the DSP (IC401)
side.
[5] TRK. Gain : Adjusts track gain.
[6] EQ Boost : Adjusts amount of boost of equalizer.
[10/0] : All servo off.
2-5. EEPROM Write Adjust
EEPROM Write Adjust
1. Focus Offset
2. Focus Gain
3. Trk. Offset Coarse
4. ——————
5. Trk. Gain
6. EQ Boost
0.All Servo Off
Exit: RETURN
On this screen, each item can be adjusted automatically. Select the
desired number [1] to [10/0] from the remote commander, and
selected item is adjusted automatically.
[1] Focus Offset : Adjusts focus offset.
[2] Focus Gain : Adjusts focus gain.
[3] TRK. Offset : Adjusts tracking offset of the RF amp
(IC001) side.
[5] TRK. Gain : Adjusts track gain.
[6] EQ Boost : Adjusts amount of boost of equalizer.
[10/0] : All servo off.
2-6. Memory Check
Display images are shown as follows, and all two screens are able
to switch by the O key (UP) or o key (DW).
EEPROM Data 1/2 CD SL L0 L1
Focus Gain xx xx xx xx
Trk. Gain xx xx xx xx
Focus Offset xx xx xx xx
Trk. Offset xx xx xx xx
EQ. Boost xx xx xx xx
PI Level xx xx -- --
Fcs. Balance -- xx -- --
Jitter xx xx xx xx
Mirror Time xx xx xx --
FE Level -- xx -- --
Traverse Lv1. -- xx -- --
Next:DW Default:CLR Exit:RET
EEPROM Data 2/2 CDRW DVDRW
Focus Gain xx xx
Trk. Gain xx xx
Focus Offset xx xx
Trk. Offset xx xx
EQ. Boost xx xx
Next:UP Default:CLR Exit:RET
On this screen, current servo adjusted data stored in the EEPROM
are displayed. The adjusted data are initialized by pressing the
[CLEAR] key, but be careful that they are not recoverable after
initialization.
Before clearing the adjusted data, make a note of the set data. This
screen will also appear if [0]-All is selected in the Drive Auto
Adjustment. In this case, default setting cannot be made.

2-7. Disc Check Memory
Disc Check Memory
1. SL Disc check
2. SL Disc check
3. SL Disc check
Exit: RETURN
On this screen, measure the mirror time of chucked disc, and write
to the EEPROM.
2-8. Error Rate Display
Error Rate Display
UC CR ADD
PI1 Err Now xx xxxx xxxxxxxx
Max xx xxxx xxxxxxxx
Avg xx xxxx xxxxxxxx
PI2 Err Now xx xxxx xxxxxxxx
Max xx xxxx xxxxxxxx
Avg xx xxxx xxxxxxxx
PO Err Now xx xxxx xxxxxxxx
Max xx xxxx xxxxxxxx
Avg xx xxxx xxxxxxxx
Exit: RETURN
On this screen, measure and display the error rate.
UC : Incorrect value
CR : Correct value
Add : Address
2-9. SACD Water Mark Check
SACD Water Mark Check
PSP AMP
PSN
Start: ENTER Exit: RETURN
On this screen, measure the PSP AMP value and PSN value of SACD
water mark.
HCD-S550/S880
3. MECHA AGING
On the Test Mode Menu screen, selecting [3] executes the aging of
the mechanism deck.
### Aging Test MENU ###
Operation Menu
1. Open/Close Test
Exit: RETURN
1) On the Aging Test MENU screen, press the [1] key on the
remote commander to display the Open/Close Test screen.
2) Insert discs and press the [ENTER] key on the remote
commander.
3) Is starts the aging.
During aging, the disc number, operating status and repeat cycle
are displayed. Aging can be aborted at any time by pressing
the x key. After the operation is stopped, press the x key or
[RETURN] key aging to return to the Aging Test MENU.
4. EMERGENCY HISTORY
On the Test Mode Menu screen, selecting [4] displays the
information such as servo emergency history.
The history information from last 1 up to 10 can be scrolled with
the O key or o key. Also, specific information can be displayed
by directly entering that number with ten keys.
### EMG. History ###
Laser Hours CD xxxxhxxm
DVD xxxxhxxm
a. bb xx xx xx xx xx xx xx
xx xx xx xx xx xx xx xx
a. bb xx xx xx xx xx xx xx
xx xx xx xx xx xx xx xx
Select:1-9 Scroll:UP/DOWN
(1.Latest EMG.) Exit: RETURN
xxxxhxxm : The laser on total hours. Data below minutes are
omitted.
a. : Error number.
bb : Error code.
xx : Not used.
• Clearing History Information
Clearing laser hours:
Press the [DVD DISPLAY] and [CLEAR] keys in this order.
Then both CD and DVD data are cleared.
Clearing emergency history:
Press the [DVD TOP MENU] and [CLEAR] keys in this order.
Initializing set up data:
Press [DVD MENU] and [CLEAR] keys in this order.
The data have been initialized when “Set Up Initialized”
message is displayed. The EMG. History screen will be restored
soon.
25

HCD-S550/S880
• Code list of Emergency History
10: Communication to RF AMP (IC001) failed.
11: Each servo for focus, tracking, and spindle is unlocked.
12: Check sum error of EEPROM (IC203).
14: Communication to servo DSP (IC401) failed, or servo DSP
decoder (IC801) is faulty.
15: Communication to DVD decoder (IC701) failed, or DVD
decoder (IC801) is faulty.
16: Communication to DSD decoder (IC801) failed, or DSD
decoder (IC801) is faulty.
20: Initialization of sled servo failed. It is not placed in the initial
position.
23: Sled servo operation error.
24: Made a request to move the sled servo to wrong position.
30: Tracking balance adjustment error.
31: Tracking gain adjustment error.
33: Focus bias adjustment error.
34: Focus gain adjustment error.
35: Equalizer adjustment error.
40: Focus servo does not operate.
41: With a DVD dual layer disc, focus jump failed.
50: CLV (spindle) servo does not operate.
51: Spindle does not stop.
60: Made a request to seek nonexistent address.
61: Seek error of retry more than regulated times.
70: Control data could not be read.
80: Disc reading failed.
5. MECHA ERROR HISTORY
On the Test Mode Menu screen, selecting [5] displays the information
of mechanism deck error history.
The history information from last 1 up to 8 can be scrolled with
the O key or o key. Also, specific information can be displayed
by directly entering that number with ten keys.
26
### Mecha Error History ###
1. aa bb cc xx xx xx xx xx
2. aa bb cc xx xx xx xx xx
3. aa bb cc xx xx xx xx xx
4. aa bb cc xx xx xx xx xx
5. aa bb cc xx xx xx xx xx
6. aa bb cc xx xx xx xx xx
7. aa bb cc xx xx xx xx xx
8. aa bb cc xx xx xx xx xx
Scroll:UP/DOWN
(1.Latest Err.) Exit: RETURN
aa: Initialization is completed or not.
FF : Complete.
other number : Not complete.
bb: Operating status of mechanism deck at an error occurred.
(lod sq jcp)
00 : Initializing.
10 to 15 : Open operating.
16 to 19 : Kicking cause open failed.
1A to 1F : Open operating.
20 to 27 : Complete the open operation.
28 : No disc and complete the open operation.
29 to 2F : Complete the open operation.
30 to 3F : Close requesting.
40 to 4F : Open requesting.
50 to 5F : Close operating.
60 to 6F : Complete the chucking operation.
80 to 8F : Complete the release operation.
(BU is home position)
90 to 9F : BU down operating.
A0 to AF : Opening/closing the shutter. Or stationary state in
open/close the shutter is enablement.
B0 to BF : BU up requesting.
C0 to CF : BU down requesting.
D0 to DF : BU upping.
E0 to EF : No disc checking in disc loading.
cc: Operating status of mechanism deck at an error occurred.
(lod oq jcp)
00 : Complete the operation.
10 to 1F : Open operating.
20 to 2F : Close operating.
30 to 3F : Release operating.
60 to 6F : Chucking operating.
70 to 7F : Kicking operating.
80 to 8F : Returning the BU to home position. (after kicking)

6. VERSION INFORMATION
On the Test Mode Menu screen, selecting [6] displays the ROM
version and region code.
The parenthesized hexadecimal number in version field is checksum
value of ROM.
## Version Information ##
IF con. Ver.x. xx
SYScon. Ver.x. xx (xxxx)
Model DAV-Sxxx
Region 0x
Front End Ver.x.xx
Exit: RETURN
IF con. : The version of system controller (IC901).
SYScon. : The version of DVD system processor (IC206).
Front End: The version of mechanism controller (IC301).
7. VIDEO LEVEL ADJUSTMENT
On the Test Mode Menu screen, selecting [7] displays color bars
for video level adjustment. During display of color bars, OSD
disappears but the menu screen will be restored if pressing the
[RETURN] key.
27
AUTO SERVO ADJUSTMENT
After parts related to the servo circuit (RF amplifier (IC001), DSP
(IC401), motor driver (IC501), EEPROM (IC302) so on) are
replaced, re-adjusting the servo circuit is necessary. Select “ALL”
at “1. DRIVE AUTO ADJUSTMENT” (Refer to page 21 in TEST
MODE) and adjust DVD-SL (single layer), CD and DVD-DL (dual
layer).
27
SECTION 6
ELECTRICAL ADJUSTMENT
HCD-S550/S880
Ver 1.4

HCD-S550/S880
SECTION 7
DIAGRAMS
7-1. BLOCK DIAGRAM – RF SERVO Section –
DETECTOR
OPTICAL PICK-UP
BLOCK
(TDP022W)
LASER
DIODE
(FOR CD)
LASER
DIODE
(FOR DVD)
2AXIS
DEVICE
FOCUS/
TRACKING
COIL
RF
A
B
C
D
F
E
CD LD
PD
DVD LD
INLIM
SW
FCS+
FCS–
TRK+
TRK–
M1
(SPINDLE)
D
C
B
A
B
A
D
C
B
A
D
C
AUTOMATIC POWER
CONTROL (FOR CD)
Q002
AUTOMATIC POWER
CONTROL (FOR DVD)
Q001
LASER DIODE
SELECT
Q301
M2
(SLED)
M
M
1 DVDRFP
63 RFSIN
3
4
5
6
A2
B2
C2
D2
18 CD E
17 CD F
12 A
11 B
10 C
9 D
16 CD A
15 CD B
14 CD C
13 CD D
22 CDLD
24 CDPD
23 DVDPD
21 DVDLD
36 V125
42
ATOP 62
ATON 61
59 AIP
60 AIN
36 FOCUS COIL 48
37 DRIVE
1
34 TRACKING COIL 3
35 DRIVE
4
32
31
27
28
47
46
• SIGNAL PATH
: CD PLAY
: DVD PLAY
: SACD PLAY
FOCUS/TRACKING COIL DRIVER,
SPINDLE, SLED MOTOR DRIVER
IC501
BUFFER
SLED MOTOR
DRIVE
30
29 SLED MOTOR
DRIVE
SPINDLE MOTOR
DRIVE
BUFFER
FNP 53
FNN 52
CD/DVD/SACD RF AMP,
FOCUS/TRACKING ERROR AMP
IC001
40
7
10
54 DIP
55 DIN
RFAC 57
47
46
48
39
40
POWER SAVE 39
97 DSAVE
MUTE12 19
60 MUTE 2D
MUTE34 20
MUTE5 21
63 SP ON
TSD-M 22
73 TSD
13
45
AVC
(1.65V)
FF
FR
TF
TR
: AUDIO
: VIDEO
SDATA
SCLK
SDEN
TE
FE
MNTR
MIRR
42
27
LDON 26
FF
FR
7
8
44
43
FCS JMP 1
FCS JMP 2
SLED B
SLED A
62 FG
76 28 31
LDSEL
LD ON
INLIM
DATA_RF
CLK_RF
SDEN
SLED 61
TE
FE
PI
MIRR
TE
FE
PI
DATA_RF
CLK_RF
SDEN
83 82 2
SDATA RF
SDCLK RF
SDEN
AMP
IC402 (1/2)
FF
FR
TF
TR
TE
FE
PI
65 67 66
TE
FE
PI
50 RFAC
41 TE
40 SE
39 FE
43 RFDC
33
34
31
32
29
30
DIGITAL SIGNAL PROCESSOR,
DIGITAL SERVO PROCESSOR
IC401
26 SSTP
38 VC
42 CE
MIRR
28
FFDR
FRDR
TFDR
TRDR
SFDR
SRDR
MECHANISM
CONTROLLER
IC301 (1/2)
28
DOUT
PCMD
SCOR
COUT
SCLK
FOK
MIRR
64
66
BCLK 67
LRCK 65
C2PO 14
WDCK 17
WFCK 10
SBSO 79
EXCK 80
XTAI
MDP
XRST
MD2
71
25
2
63
15
19
8
22
20
BCLK
LRCK
C2PO
GSCOR
WFCK
SBSO
EXCK
SCOR
CLOCK
GENERATOR
IC303
3
26 SCOR
27M
768FS
DOCTR/
ISBTEST
DATA 4
49 DATA CD
CLOK 6
50 CLOK CD
XLAT 5
27 LAT CD
SENS 7
9 SENS CD
SQSO 76
52 SQSO
SQCK 77
54 SQCK
XRD 85
17 XRD
XWR 84
18 XWR
LOCK
GFS
MUTE
24
13
3
75 LOCK CD
71 GFS CD
59 MUTE CD
XCS DVD
INT0 DVD
INT1 DVD
12
22
23
19 XCS
20 XINT0
21 XINT1
30 COUT CD
72 SCLK CD
74 FOK CD
29 MIRR
X302
27MHz
7 8
XTI
SO2
MO1
XTO
SO3
SO1
10 3 13 9
BUFFER
IC703 (2/2)
98
XDRST
GFS DVD 58
107 GFS
XRST DVD 25
164 XRST
JIT OFFSET
JIT
SACD/DVD
EEP RDY
D0 – D7
14-21
A0 – A7
89-96
45
64
77
6
EEP SI 5
EEP CLK 100
EEP CS 99
SDIN DSD 47
SDOUT DSD 46
SCK DSD 24
XMSLAT 51
READY DSD 48
MUTE DSD 53
BCLK
LRCK
C2PO
GSCOR
WFCK
SBSO
EXCK
SCOR
COMPARATOR
IC703 (1/2)
5 SDA
6 SCL
7 WP
117 RFIN
160 MDAT
158 BCK
163 LRCK
155 C2PO
146 GSCOR
151 WFCK
148 SBIN
147 EXCK
150 SCOR
167 XTA1
169 XTA2
170 XTAL
137 MDIN2
135 SPO
172-176, 1, 2, 4
5, 7, 9-14
MSDATO
MSDATI
MSCK
XMSLAT
SHRRDY
SHRMUT
D0 – D7
A0 – A7
EEPROM
IC302
DVD DECODER
IC701
AEP0
109
MNT1
92
HDB0 – HDB7
XDCK 48
XSAK 46
HDB8 26
XSHD 49
MNT2
MDB0 – MDB9,
MDBA – MDBF
XSRQ
53
44, 41, 39, 35,
32, 30, 27, 24
93
66-69, 71, 73-75, 96, 97,
99, 101, 102, 104-106
MA0 – MA9
79, 80, 82-87,
89, 91
WE 76
XMOE 94
XRAS 78
XCAS 95
AV DATA BUS
XDCK
XSAC
SDEF
XSHD
2-5, 7-10,
41-44, 46-49
21-24,
27-32
I/O0 – I/O15
A0 – A9
17 WE
33 OE
18 RAS
34 UCAS
35 LCAS
SACD/DVD
SELECT
IC814
16Mbit
D-RAM
IC706
WARFI A (Page 29)
CDDOUT
B (Page 29)
SD0 – SD7
(for AUDIO SYSTEM)
C (Page 29)
SD0 – SD7
(for VIDEO SYSTEM)
D (Page 31)
XDCK, XSAC, SDEF, XSHD
(for AUDIO SYSTEM)
E (Page 29)
XDCK, XSAC,, SDEFF
(for VIDEO SYSTEM)
F (Page 31)
XRST_DSD
WCK G (Page 29)
768FS
27M
MSDATO, MSDATI, MSCK,
XMSLAT, SHRRDY, SHRMUT
H (Page 29)
I (Page 31)
J (Page 29)
XSRQ K (Page 29)
XSRQ-ZIVA L (Page 31)
M (Page 29)

7-2. BLOCK DIAGRAM – AUDIO (DSP) Section –
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 31)
(Page 28)
(Page 31)
(Page 31)
(Page 30)
COAXIAL
FM
75Ω
AM
A
G
C
E
H
M
J
K
N
WARFI
WCK
B CDDOUT
O SPDIF
P
SD0 – SD7
SDEF, XSHD,
XDCK, XSAK
768FS
XRST_DSD
AV0 – AV2
S RSTAD
D5V
MSDATO, MSDATI, MSCK,
XMSLAT, SHRRDY, SHRMUT
XSRQ
TDOSA, TDISA,
TCK, TMS, TRST
J205 (1/4)
VIDEO 1
AUDIO IN
J206 (1/3)
VIDEO 2
AUDIO IN
FM/AM TUNER PACK
FM ANT
GND
AM ANT
GND
AV DATA BUS
L-CH
R-CH
DI
DO
CK
CE
TUNED
XDCK
XSAK
SDEF
XSHD
L
R
L
R
REFERENCE VOLTAGE
GENERATOR
IC402 (2/2)
R-CH
TUDI
TUDO
TUCLK
TCE
TUN
LEVEL SHIFT
IC812
LEVEL SHIFT
IC813
OPTICAL
DIGITAL IN
VIDEO 2
R-CH
R-CH
MSDATO
MSDATI
MSCK
XMSLAT
SHRRDY
SHRMUT
TDOSA
TDISA
TCK
TMS
TRST
AMP
Q221
Q205
127 WAVRB
126 WARFI
123 WCK
169 – 176
OPTICAL RECEIVER
IC204
SD0 – SD7
166 SDCK
167 XSAK
168 SDEF
165 XSHD
6 MSDATO
4 MSDATI
3 MSCK
2 XMSLAT
7 MSREADY
10 SMUTE
9 XRST
29 TDO
27 TDI
26 TCK
30 TMS
31 TRST
DSD DECODER
IC801
Q206
DSAL
DSAR
DSAC
DSALFE
DSALS
DSARS
X600
12.288MHz
64
DQ0 – DQ7
139-136,
134-131
A0 – A11
66
69
71
74
76
PHREFO 62
EXCKO1 13
162-159, 157-154,
152, 151, 149, 148
XWE 143
XRAS 145
XCAS 144
DCKE 142
DCLK 141
2, 3, 5, 6, 8,
9, 11, 12
19-24, 27-32
A0 – A11
DQ0 – DQ7
15 WE
17 RAS
16 CAS
34 CKE
35 CLK
16Mbit
SD-RAM
IC808
5 DIN2
DATA
4 DIN1
3 DIN0
CKOUT
BCK
LRCK
DIGITAL AUDIO
INTERFACE
IC606 DI
DO
22 XIN
CL
CE
21 XOUT XSTATE
20 XMCK
XMODE
ERROR
AUDIO
AUDIO INPUT
SELECTOR
IC202 A/D CONVERTER
IC602
2 Y2
1 Y0 Y 3
5 Y1
A B
10 9
AV2
11 MCKI
164 XSRQ
AV0
LOW-PASS
FILTER
IC603
1 LIN
5 RIN
DOUT 15
16 6
BCK 14
LRCK 13
FM-DET
DET AMP
Q201
4 MUX
RDATA 2
RCLK
16
RDSD
RDSC
X201
XI
13
XO
14
RDS DECODER
IC201
(AEP, UK, Russian) 4.332MHz
(AEP, UK, Russian)
R-CH
SYSCLK
RSTB
16
13
14
15
36
35
38
37
17
48
34
24
EXID2
BCK2
LRCK2
PLOCK
DIGDI
DO
DIGCLK
CSDIR
XST
RSTDIR
EXID1
EXIMCK
EXIBCK
EXILRCK
TUDI
TUDO
TUCLK
TCE
TUN
RDSD
RDSC
AV0
AV1
AV2
EXID1
EXIMCK
EXIBCK
EXILRCK
33 AD-RST
52 TUN-DI
54 TUN-DO
55 TUN-CLK
53 TUN-CE
51 TUNED
EXID2
BCK2
LRCK2
88 RDS-DATA
94 RDS-CLK
95 AV-SEL0
96 AV-SEL1
48 AV-SEL2
29
65 98
DFIL RST2
DF-SYNC
63 DSIFL
64 DSIFR
65 DSICT
66 DSISW
67 DSISL
68 DSISR
62 DSBCKF
52 MCK
58 EXID1
59 EXIMCK
55 EXIBCK
56 EXILRCK
57 EXID2
29 BCK2
28 LRCK2
79 INIT
78 SYNC
77 SELEXT
ENABLE
SWITCH
Q908 – 910
29
97
DF-SW
F2FLREX1
F2CSWEX2
DIGITAL AUDIO
PROCESSOR
IC612
F2SLR
DIGDI
DO
DIGCLK
CSDIR
RSTDIR
47
46
45
CKOUT 49
F2BCK 43
F2LRCK 44
7 25 8 20 24
DIG-DI
DI
DIG-CLK
DIR-CE
DIR-XMODE
DIGDI
DIGCLK
XST
PLOCK
22 18
DIR-XST
DIR-ZERO
X601
13.5MHz
LEVEL SHIFT
IC900
6 15 17
DSP-DO
DSP-HACN
DSP-GP9
SYSTEM CONTROLLER
IC901 (1/3)
19
DIR-ERR
18 SDI1
30 SDI2
114 SDI3
22 KFSIO
17 BCKI1
15 LRCKI1
9
33 HDIN
34 HCLK
35 HDOUT
32 HACN
68 GP9
DIGITAL AUDIO
SIGNAL PROCESSOR
IC607
MCLK1
12 MCLK2
EXLOCK
GP8
59 69
23
DIR-AD
SDO4
SDO1
SDO2
SDO3
SCKOUT 14
BCKO 20
LRCKO 19
GP10 67
D0 – D15
A0 – A15
26
23
24
25
108, 107, 105-102, 99
98, 80-77, 75-72
112, 110, 109,
97-92, 82-85, 66-64
CS0 44
WE0 45
PM 113
HCS 36
BST 56
XRST 2
Q903
D903
28
DAMP-MUTEN
D4
D1
D2
D3
SCK
BCKO
LRCKO
7-10, 13-16,
29-32, 35-38
5-1, 44-42,
27-24, 21-18
D0 – D15
A0 – A15
41 OE
17 WE
PM
HCS
BST
RSTDSP
D490
POWER ON
MUTING
Q490, 492
12V
S-RAM
IC604
PM
HCS
BST
RSTDSP
13 14 16 12
DSP-PM
DSP-CS
DSP-BST
DSP-RST
D1 – D4, SCK,
BCKO, LRCKO
DIGDI, DIGCLK
HCD-S550/S880
NSMUTE
Q
• R-ch is omitted due
to same as L-ch.
• SIGNAL PATH
: AUDIO
: CD PLAY
: DVD PLAY
: SACD PLAY
: AUX IN
: OPTICAL
DIGITAL IN
: TUNER
T
R
(Page 30)
(Page 30)
(Page 30)

HCD-S550/S880
7-3. BLOCK DIAGRAM – AUDIO OUT, PANEL Section –
(Page 29)
(Page 29)
(Page 29)
(Page 29)
(Page 32)
(Page 31)
(Page 31)
• SIGNAL PATH
: AUDIO
T
S
Q
R
X
W
V
DIGDI, DIGCLK
RSTAD
D1 – D4, SCK,
BCKO, LRCKO
NSMUTE
DISC IN
I2CDATA,
I2CCLK, I2HLP
ZIVARESET
FLUORESCENT
INDICATOR TUBE
FL801
D4
SCK
BCKO
LRCKO
DIGDI
DIGCLK
S801 – 806,
S821 – 825
5 – 39
S1 – S35
G1 – G12
40 – 51
DISC LOADING
DETECT
Q913
4 AD1
3 AD2
3 SDTI
1 MCLK
2 BICK
4 LRCK
8
7
FL DRIVER
IC802
D/A CONVERTER
IC608
CDTI
CCLK
REMOTE CONTROL
RECEIVER
IC801
DAT 63
CLK 62
CS 61
RST 60
OSC0 58
OSC1 59
VOLUME
S201
SCAN SELECT
INTERLACE
SELECTABLE
AOUTL+ 12
AOUTL– 11
AOUTR+ 10
AOUTR– 9
PDN
5
CSN
6
OSC
C818, R840
KEY0, KEY2
KEY INPUT
DETECT
IC903, 904
WAKE UP
DETECT
Q907
SIRCS DETECT
Q906
ROTARY
ENCODER
S800
I2CDATA
I2CCLK
I2HLP
LOW-PASS
FILTER
IC610
60 FL-DATA
57 FL-CLK
61 FL-CS
56 FL-MUTE
82 – 84
KEY0 – KEY2
93 WAKE
92 SIRCS
85 EN-A
86 EN-B
49 PROG SW
3 I2C-DATA
5 I2C-CLK
100 I2HLP
4 CQ-RST
MUTING
Q207, 208
SYSTEM CONTROLLER
IC901 (2/3)
L
R
MUTING CONTROL
Q900
HPSW 64
HP-MUTE 46
AU-MUTE 47
DAS-CS 32
X1
X2
DIP-RST
DIP-OCP
39
38
DAMP-DATA 1
DAMP-CLK 2
CS1 29
CS2 30
CS3 31
DAMP-RST 26
DAMP-MUTING 27
43
44
J205 (2/4)
VIDEO 1
AUDIO OUT
X901
20MHz
AU-MUTE
DAS-CS
HP-SW
HP-MUTE
AU-MUTE
DAS-CS
SCDT
SHIFT
LATCH1
LATCH2
LATCH3
INIT
PGMUTE
30
D1
SCK
BCKO
LRCKO
SCDT
SHIFT
LATCH1
INIT
PGMUTE
D2
SCK
BCKO
LRCKO
SCDT
SHIFT
LATCH2
INIT
PGMUTE
D3
SCK
BCKO
LRCKO
SCDT
SHIFT
LATCH3
INIT
PGMUTE
30
STREAM PROCESSOR
IC305
43 DATA
64 XFSIIN
44 BCK
45 LRCK
38 SCDT
37 SCSHIFT
36 SCLATCH
41 INIT
40 PGMUTE
39 NSPMUTE
OUTL1–
OUTL2–
OUTR1–
OUTR2–
OUTL1+
OUTL2+
OUTR1+
OUTR2+
XFSOIN
21
18
7
4
24
15
10
1
FSOCKO 73
FSOI 74
STREAM PROCESSOR
IC308
43 DATA
64 XFSIIN
44 BCK
45 LRCK
38 SCDT
37 SCSHIFT
36 SCLATCH
41 INIT
40 PGMUTE
39 NSPMUTE
OUTR1+
OUTR2+
OUTL1+
OUTL2+
FSOI
STREAM PROCESSOR
IC310
43 DATA
64 XFSIIN
44 BCK
45 LRCK
38 SCDT
37 SCSHIFT
36 SCLATCH
41 INIT
40 PGMUTE
39 NSPMUTE
XFSOIN
XFSOUT
XFSOUT
XFSOIN
OUTL1+
OUTL2+
OUTR1+
OUTR2+
FSOI
28
77
28
10
1
24
15
74
77
28
24
15
10
1
74
BUFFER
IC300
X300
49.152MHz
HADPHONE
AMP
IC401
HP-MUTE
6 INA
16 INB
6 INA
16 INB
6 INA
16 INB
6 INA
16 INB
6 INA
16 INB
6 INA
16 INB
MUTING
CONTROL
Q902
POWER AMP
IC301
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
POWER AMP
IC304
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
POWER AMP
IC307
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
POWER AMP
IC306
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
POWER AMP
IC309
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
POWER AMP
IC311
OUTA
OUTB
ENA
ENB
DIAGA
DIAGB
7 17 8 18
PROTECT DETECT
Q113, 114
9
19
D105
HP-SW
D181 POWER ON
MUTING
Q192
D192
9
19
9
19
9
19
9
19
9
19
MUTING
Q900, 901
D102
D103
D106
D104
D101
OVER LOAD
DETECT
Q109, 110
OVER LOAD
DETECT
Q103, 104
OVER LOAD
DETECT
Q105, 106
OVER LOAD
DETECT
Q111, 112
OVER LOAD
DETECT
Q107, 108
OVER LOAD
DETECT
Q101, 102
32V
J401
SPEAKER
(+)
(–)
(+)
(–)
J900
PHONES
FRONT
L
FRONT
R
(+)
CENTER
(–)
(+)
WOOFER
(–)
(+)
(–)
(+)
(–)
REAR
L
REAR
R
FAN Y (Page 32)

7-4. BLOCK DIAGRAM – VIDEO Section –
(Page 28)
(Page 28)
(Page 28)
(Page 28)
(Page 29)
(Page 30)
(Page 29)
(Page 30)
D
F
I
L
O
V
N
W
SD0 – SD7
XDCK, XSAK,
SDEF
27M
XSRQ_ZIAV
SPDIF
ZIVARESET
TDOSA, TDISA,
TCK, TMS, TRST
I2HLP,
I2CDATA, I2CCLK
AV DATA BUS
XDCK
XSAK
SDEF
TDOSA
TDISA
TCK
TNS
TRST
I2HLP
I2CDATA
I2CCLK
177-174, 171-168
SDDATA0 – SDDATA7
183 SDCLK
179 SDEN
182 SDERROR
139 XIN
178 SDREQ
156 IEC958
202 RESET
199 TDI
198 TDO
201 TCK
200 TMS
197 TRST
106 I2C_CTRL
I2C_DA
I2C_CL
161 160
78 79
I2C SIO
I2C-CLK
EXTAL
VDAC_0 131
VDAC_2 125
VDAC_1 128
VDAC_3 122
VDAC_4 119
DRVTX
DRVRX
DRVCLK
HIRQ1
186 187 185 184
34 33 35 36
SOZIVA
SIZIVA
SCKZIVA
DRVIRQ
XTAL
41 40
X301
20MHz
DRVRDY
188
FLIP-FLOP
IC803
37
DRVRDY
J205 (3/4)
VIDEO 1
VIDEO IN
J206 (2/3)
VIDEO 2
VIDEO IN
SWITCHING
IC802
6 DO
5 DI
4 SK
MECHANISM CONTROLLER
IC301 (2/2)
HIRQ2
WC_EEPROM
146 158
1 8
R/B
WC
EEPROM
IC203
3
CS
Q302
1 IN1
3 IN2
5 IN3
CS_EEPROM
157
32
CS ZIVA
VIDEO INPUT
SELECTOR
IC207
SW1
SW2
RST_SPC
191
38
RST
2 4
OUT
7
DVD SYSTEM PROCESSOR
IC206
HAD0 – HAD15
31
14 2B
9 3B
1 1B
VIDEO SELECTOR
IC209
CT2
CT3
CT1
12 7
2
DATA & ADDRESS BUS
31
OUT2
OUT3
OUT1
5
6
3
HAD0 – HAD15
DATA & ADDRESS BUS
75Ω DRIVER
IC206
HA1 – HA3
22, 19-14, 11-3 2, 207, 206
HAD0 – HAD15 HA1 – HA3
HAD0 – HAD15 HA1 – HA3
55, 54, 52, 51,
34, 33, 31
49-47, 45-40, 38-36
2D7 – 2D9
1D1 – 1D10, 2D1 – 2D6
HA1 –
HA3
1Q1 – 1Q10, 2Q1 – 2Q8
2, 3, 5, 6, 8-10, 12-17,
19-21, 23, 24
ADDRESS BUS
HA4 –HA21
15-22, 24-31 11-9 2-8, 34-44
DQ0 – DQ15 A0 – A2 A3 – A20
ALE
190
56 29
1LE
2LE
32Mbit PROGRAMMABLE ROM
IC204
BUS INTERFACE
IC215
CE
OE
WE
VIDEO AMP, 75Ω DRIVER
IC208
6 YIN
2 CIN
4 VIN
12 14 1
CE
OE
WE
12 CYIN
14 CBIN
16 CRIN
HCS0
HREAD
WEN.UDS
195 27 25
CE
WE
OE
MUTE1
MUTE2
3 15
YOUT 28
COUT 33
VOUT 31
CYOUT 25
CBOUT 22
CROUT 19
AV2
AV0
AV1
WIDE SWITCH
Q210, 214
107
VS/WIDE
MD0 – MD31
57-60, 64-71, 75-78,
81-84, 88-95, 99-102
2,4,5,7,8,10,11,13,74,76,77,79,82,83,85,31,
33,34,36,37,39,40,42,45,47,48,50,51,53,54,56
4
2
J205 (4/4)
VIDEO 1
VIDEO OUT
3
1
VIDEO
21, 24-27,
60-66
DQ0 – DQ31 A0 – A11
Y
PB/CB
PR/CR
HCD-S550/S880
• SIGNAL PATH
: VIDEO
: Y
: CHROMA
: COMPONENT VIDEO
J202
MONITOR OUT
J206 (3/3)
COMPONENT
VIDEO OUT
MCLK
MCS0
MWE
MRAS
MCAS
MDQM0
MDQM1
MDQM2
MDQM3
MA0 – MA12
42-33, 45, 46 48 47 56 49 53 51 52 62 73 86 97
128Mbit SD-RAM
IC202
S VIDEO
BA0
BA1
22 23
BS0
BS1
AV0 – AV2
68 20 17 19 18 16 71 28 59
CLK
CS
WE
RAS
CAS
DQM0
DQM1
DQM2
DQM3
P (Page 29)

HCD-S550/S880
7-5. BLOCK DIAGRAM – MECHANISM DECK, POWER SUPPLY Section –
(Page 30)
X
EJECT
INSERT
DISC IN
M711
(LOADING) M
M751
(ELECT)
S711
(DISC IN/OUT)
81
SEN2
M
OPT-SEN2 78
OPT-SEN 79
PARA-DO2 67
25 DO2
PARA-DATA 72
26 DI1
PARA-CLK 71
3 CLK
PARA-LT1 69
4 LAT
PARA-RST 68
2 RESET
TU-ON 50
SP RELAY 66
STOP 90
RESET 34
SYSTEM CONTROLLER
IC901 (3/3)
POWER-SW 91
DVD-POWER 89
P-PWM 11
ST-POWER 45
LOADING MOTOR DRIVE
IC711
4
2
OUT1 FIN
OUT2 RIN
7
9
EJECT MOTOR DRIVE
IC701
4
2
OUT1 FIN
OUT2 RIN
7
9
RESET SWITCH
Q901
D812
STANDBY
23 P1
24 P0
21 P3
22 P2
ROTARY
10
ENCODER
– 7
S741
(MODE)
LED DRIVE
Q701
DISC INSERT
DETECT SENSOR
IC731
CHUCKING
DETECT SENSOR
IC721
MECHANISM DECK
CONTROLLER
IC902
P10 – P13
5 P15
6 P14
20 P2
RESET SIGNAL
GENERATOR
IC907
AND GATE
IC905
LED DRIVE
Q911, 912
S901 (2/2)
POWER
VOLTAGE DETECT
IC904
U5V
S901 (1/2)
TO FLUORESCENT
INDICATOR TUBE
DSP +2.6V
A3.3V
FL
FL1
VFL
STREAM PROCESSOR
+3.3V
+2.6V
REGULATOR
IC605
32
DA03V
+3.3V
REGULATOR
IC001
A5V, RF+5V
D5V
D/A, A/D
+5V
10V
TU 10V
RECT
D806 – 809
+3.3V
REGULATOR
IC303
STREAM PROCESSOR
+5V
+3.3V
REGULATOR
IC005
+5V
REGULATOR
IC600
D203
DA05V,
VIDEO +5V
+5V
REGULATOR
IC002
+5V
REGULATOR
IC003
B+ SWITCH
Q222, 223
POWER ON/OFF
CONTROL
Q902, 906
SYSTEM
CONTROLLER
+5V
32
U5V
DC/DC
CONVERTER
T801
M12V
D900
D901
+2.5V
+1.8V
OSC
Q803, 804
+5V
REGULATOR
IC302
+5V
REGULATOR
IC004
B+ SWITCH
Q003, 004
+6.5V
(AMP +6.5V)
+10V
REGULATOR
IC601
B+ SWITCH
Q001, 002
12V
+5.6V
REGULATOR
IC905
D917
+2.5V
REGULATOR
IC702
+1.8V
REGULATOR
IC006
D3.3V
POWER ON/OFF
CONTROL
Q910, 911
D900
+6.5V
REGULATOR
IC903
+12V
REGULATOR
IC908
VOLTAGE
DETECT
Q992
B+ SWITCH
Q990, 991
+3.3V
REGULATOR
IC906
+32V
(AMP +32V)
FAN MOTOR
CONTROL
Q190, 191
RECT
D911
+6.8V
REGULATOR
Q904
POWER
TRANSFORMER
T901
VCC
BUFFER
IC909
M
M301
(FAN)
D906
TH901
OSC
Q912, 914
+20V
REGULATOR
Q905
RECT
D902
SWITCHING
IC902
POWER ON/OFF
CONTROL
Q901, 903
D919 D920
D933
D905, 907
D912
S901 (2/2)
LINE FILTER
LF901, 902
ISOLATOR
PC901
3
FAN
S901 (1/2)
POWER
D
4 VCC
1 OCP/SYNC
5 FB/OLP
Y (Page 30)
POWER CONTROL
IC901
(AC IN)

7-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
• f : internal component.
• : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side: Parts on the pattern face side seen from
(Conductor Side) the pattern face are indicated.
Parts face side: Parts on the parts face side seen from
(Component Side) the parts face are indicated.
• Indication of transistor.
C
B E
B
Q
Q
C E
These are omitted.
These are omitted.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1 /4 W or less unless otherwise
specified.
• f : internal component.
• 2 : nonflammable resistor.
• C : panel designation.
Note:
The components identified
by mark 0 or dotted
line with mark 0 are critical
for safety.
Replace only with part
number specified.
Note:
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro
spécifié.
• A : B+ Line.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : DVD PLAY
( ) : CD PLAY
[ ] : SACD PLAY
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
J : CD PLAY
c : DVD PLAY
I : SACD PLAY
f : AUX IN
i : OPTICAL DEITAL IN
d : TUNER
F : AUDIO
L : VIDEO
E : Y
a : CHROMA
r : COMPONENT VIDEO
• Abbreviation
AUS : Australian model
CH : Chinese model
CIS : Rissian model
EA : Saudi Arabia model
HK : Hong Kong model
KR : Korean model
MX : Mexican model
MY : Malaysia model
SP : Singapore model
TW : Taiwan model
33
• Circuit Boards Location
33
DDCON board
not supplied
(power LED board)
FL board
not supplied
(power SW board)
not supplied
(encoder board)
not supplied
(SW board)
DVD board
control board
not supplied
(CK motor board)
not supplied
(D sensor board)
vol board
I/O board
HP board
not supplied
(CK sensor board)
not supplied
(SEL board)
power board
relay board
HCD-S550/S880
tuner board
RF board
AMP board

HCD-S550/S880
7-7. PRINTED WIRING BOARDS – RF Section – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
1 2 3 4 5 6 7 8 9 10 11 12 13
A
DVD BOARD
CN401
(Page 38)
• Semiconductor
Location
Ref. No. Location
D001 C-11
D002 B-11
IC001 D-11
Q001 B-3
Q002 B-3
E
E
RF BOARD (COMPONENT SIDE)
RF BOARD (CONDUCTOR SIDE)
FLEXIBLE BOARD
1-684-822-
34
11
OPTICAL PICK-UP
BLOCK
(DVBU16)
34
IC001
(11) 1-684-822-
1
16
64 49
17 32
48
33
11
(11)

7-8. SCHEMATIC DIAGRAM – RF Section – • See page 67 for Waveforms. • See page 72 for IC Block Diagram.
FLEXIBLE
BOARD
D
C
RF
GND
VC
VCC
E
A
B
N.C
F
PD
VR
VCC
SW
LD GND
DVD LD
INLIM
CD LD
INLIM_3V
FCS+
FCS-
TRK+
TRK-
SLEDA+
SLEDB+
SLEDB-
SLEDA-
LED {LIMIT-SW(A)}
GND {LIMIT-SW(B)}
INLIM {LIMIT-SW(B)}
SPDL-
SPDL+
CN001
24P
CN003
9P
SLA+
SLB+
SLB-
SLA-
FD+
FD-
TD+
TD-
R001 100
D
C
RFP
C009
0.1
B
D001
1SS355TE
-17
IOP2
JL007
R003 R004
33 33
L001
47µH
C002
10
16V
JL005
35
R021
0
R005
47k
C001
100
6.3V
R006
470
R007
33
R008
33
R009
47k
IOP1
C010
1000p
R025
100
R023
820
R024
0
R022 C019
220 5600p
C017
2200p
C020 22p
C021 22p
C022 22p
C023 22p
C018 5600p
C016 2200p
C015 2200p
C014 2200p
C024
0.01
PD
C042
180p
JL003
R032
FD-
R014 0
CD/DVD/SACD RF AMP,
FOCUS/TRACKING ERROR AMP
100
FE
FD+
R013 0
IC001
TE
TD-
R012 0
CXD1881AR
PI/CE
TD+
R011 0
SLB-
DVD_LD
R018 0
SLB+
R017 0
C049
SLA-
CD_LD
R016 0
0.1
SLA+
JL002
R015 0
JL001
R041
1k
E
A
F
RFP
A
B
C
D
E
F
PD
CD_LD
DVD_LD
R035
0
R019 R020
0 0
Q001 Q002
2SB1132-T100-QR 2SB1132-T100-QR
AUTOMATIC POWER
CONTROL
(FOR DVD)
AUTOMATIC POWER
CONTROL
(FOR CD)
D002
1SS355TE
-17
L002
47µH
C004
10
16V
C008
0.1
47µH
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
35
JL004
C041
0.1
C025
0.1
C040
0.1
C026
0.1
C003
100
6.3V
R010
470
C011
1000p
C028 C027
0.1 0.1
LDON
MIRR
C030 0.01
C029
0.01
C039 0.033
C038 0.033
C037 330p
R026
C031
1000p
12k
R033
0
C036
0.47
R034
10M
C032
0.047
JL006
R027 0
R028 0
R029 0
C034
0.1
C006
22
10V
C033 C012
0.1 0.1
C013
0.1
C005
22
10V
C035
0.1
RFMON
SDEN
DATA_RF
CLK_RF
MIRR
PI/CE
TE
FE
SDEN
DATA_RF
CLK_RF
LDON
RFMON
Les composants identifiés par une marque 0 sont
critiques pour la sécurité. Ne les remplacer que
par une pièce portant le numéro spécifié.
CN002
29P
HCD-S550/S880
AGND
RFAC
AGND
AVC
AVC
MIRR
PI
TE
FE
A5V
A5V
SDEN
DATA_RF
CLK_RF
LDON
A3V
RFMON
INLIM
LDSEL
FD-
FD+
TD-
TD+
SLEDB-
SLEDB+
SLEDA-
SLEDA+
SPDL-
SPDL+
(Page 40)

HCD-S550/S880
7-9. PRINTED WIRING BOARDS – MECHANISM DECK Section – • See page 33 for Circuit Boards Location.
A
B
C
D
D SENSOR BOARD
3 1
CNP761
3 1
CNP721
1 2 3 4 5 6 7 8
IC721
IC731
IC731
E
C
DISC INSERT
DETECT SENSOR
CK SENSOR BOARD
• Semiconductor
Location
Ref. No. Location
D701 C-5
D711 C-4
IC701 C-5
IC711 C-4
Q701 C-3
C
E
1-684-999- 11
(11)
IC721
1-685-000-
CHUCKING
DETECT SENSOR
11
(11)
RELAY BOARD
CNP707
C712
3
1
JW14
5 1
CNP703
R707
CNP702
R706
CNP731
1 3
1 5
R714
JW9
R713
JW20
JW15
R711
C709
S731
R712
JW6
R708
C701
E
Q701
R709
R710
JW18
JW17
R703
JW16
D711
IC711
JW13
JW12
R704
JW11
JW8
36
B
CN701
JW4
JW5
JW10
DVD BOARD
CN006
JW3
R701
36
JW19
D701
JW7
R702
IC701
9 1 9
1
SWITCH BOARD
RED
1-685-122-
INSERT EJECT
11
(11)
BLK
S731
DISC IN/OUT
M
M711
(LOADING)
(Page 38)
5
CNP704
JW1
JW2
C713
ENCODER PC BOARD
4
3
G
2
1
1
2 1
CNP706
S741
ROTARY ENCODER
(MODE)
1-685-003-
CNP741
1-685-001-
5
1
11
(11)
CK MOTOR BOARD
M751
(EJECT)
CNP751
2 1
11
(11) 1-685-002-
M
11
(11)

7-10. SCHEMATIC DIAGRAM – MECHANISM DECK Section – • See page 72 for IC Block Diagrams.
IC721
RPR-220
DISC CHUCKING
DETECT SENSOR
M711
S731
(DISC IN/OUT)
EJECT
(LOADING)
INSERT
IC731
RPR-220
DISC INSERT
DETECT SENSOR
S741
ROTARY ENCODER
(MODE)
TP2
TP1
CN721
3P
CN731
5P
CN702
3P
CK SEN LED CK SEN LED
CK.SENSOR
CK.SENSOR
GND
SW(2)
GND
SW(1)
LO MTR 2
LO MTR 1
GND
CN761 CN707
3P 3P
D SEN LED D SEN LED
D.SENSOR
GND
CN741 CN704
5P 5P
E4
E3
GND
E2
E1
CN703
5P
SW(2)
GND
SW(1)
LO MTR 2
LO MTR 1
D.SENSOR
GND
E4
E3
GND
E2
E1
C709
0.1
R713 330
R714 330
A7
A1
A2
A8
A6
A5
A4
A3
LOADING
MOTOR DRIVE
IC711
BA6956AN
C712
0.01
IC701
BA6956AN
37
R704
100
D711
UDZSTE-175.1B
EJECT
MOTOR DRIVE
R702
100
D701
UDZSTE-173.6B
VREF
VREF
37
OUT2
OUT2
R711
330
RNF
RNF
R712 330
OUT1
OUT1
VM
R703
680
VM
R701
680
VCC
VCC
FIN
FIN
GND
GND
RIN
RIN
Q701
2SC2712
LED DRIVE
R709
100k
C713
0.01
R710
1k
C701
10
50V
R707
4.7k
R708
10k
R706
10k
A7
A8
A1
A2
A3
A4
A5
A6
CN706 CN751
2P 2P
CK MTR 1
CK MTR 1
CK MTR 2
CK MTR 2
CN701
18P
D+5V
M+12V
M+12V
MGND
MGND
CK.SENSOR
D.SENSOR
SW(2)
SW(1)
E1
E2
E3
E4
LO-MTR-R
LO-MTR-F
CK-MTR-R
CK-MTR-F
SENSE-LED
(Page 48)
M751
(EJECT)
HCD-S550/S880

HCD-S550/S880
7-11. PRINTED WIRING BOARD – DVD Board (Component Side) – • See page 33 for Circuit Boards Location.
• Semiconductor
Location
Ref. No. Location
D900 C-2
D901 C-6
IC206 G-9
IC301 E-4
IC401 G-4
IC402 G-3
IC605 E-14
IC606 E-13
IC607 C-13
IC612 C-11
IC701 G-6
IC801 C-9
IC813 D-7
IC901 C-4
IC902 C-6
A
B
C
D
E
F
G
H
I
G
DDCON
BOARD
CN814
(Page 58)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
NC
R909
NC
7
CN301
1
17
16
C301
CN005
2
1
CN900
DVD BOARD
R345
C302
R344
R329
IC402
C424
C410
R321 R320
R361
R318
25
X301
C413
C411
C320
R330
R413
R440
C408
R437 C409
R425 R421
R423
R426
R429
R441
R438
R430
C525 R435
C425
D900
C919
R967
R926
C913
C914
R971
R445
R443
R324
50
R332
R340
R333
C404
R418
R412
C407
C420
25
51
C419
R338
R411
R341
C309
C432 C426
R554
R449 C435
R553
C427
R455
R447
C528
(COMPONENT SIDE)
IC301
R402
R401
R403
R404
C428
C433
X901
R929
IC901
R409
R405
R406
R407
R408
IC401
R446 R452
R457
C421
R448
C436
1
75
C422
C423
C434
R931
100
76
C303
R410
R906
R306
R420
R417
R444 R453
R959 R952
C901
JW900
C809
R305
R424
17
18
R907
R436
R432
R431
R439
C922
R442
C417
C526
R742
45
R741
R074
C740
88
B
CN006
C793
44
89
RELAY BOARD
CN701
C912
IC902
R917
C723
1
2
R920
R918
D901
CN401
(Page 36)
R744 C811
IC701
A
R745
R746
C715
R930
IC813
C702
RB901
R799
FB902
1
132
R806
C706
C776
FL704
38
R804
C791
176
R752
133
C903
R830
R753
C849
C837
C804
C819
R756
R759
R754
R766
R765
R771
132
133
176
C729
C405
C316
38
R836
R843
R846
C871
R841
R842 R840
R838
C815 C865 R837
R835 R845
R834 R844
R833
R852
C867 C866
89
88
FB004
IC801
1 C818 44
R827
R212
FL706
C262
R354
C317
C313
C260
C252
C251
C247
C241
C240
52
R362
X302
C318
R266
R265
C230
R264
CN003
R263
C269
IC206
R262
C229
R826
R850 R686
R849
R848
R821
R822
R823
C856
R866
R865
R867
45 C838
C268
R684
R695
C675
C274
C267
C228
R688
R692
R232
R682
C797
C671
R699
C676
R960
C315
C201
R231
R961
R962
R972
R238
C261
C250
C246
C661
C795
R230
C266
1
R229
53 208
104
105
156
157
IC612
R233
R919
C356
R248
C314
R247
R226
R672
R673
R675 R676
R241
C265
CN201
C020
R674
R677
C668
C643
R956
R700
R671
C673
R663
C677
C651
I/O BOARD
CN002 F CN203
E
RF BOARD
(Page 34)
(Page 55)
C679
NC
C008
CN002
C001
C669
X600
IC607
C642
R680
C672 C670
C640
R634
C641
24
25
13
C609 R611
12
C616
C627
C636
R625 IC606
R615
C637
R614
C634
R628
R631 36
1
C626
37
C648
48
R639
R640
R642
C646 C652
C622
C623
C625
C618
C630
C628
C631
R025
I/O BOARD
CN202
C610
R027
(Page 55)
L600
R613
R618
C624
C654
R610
R612
R629
C614
R623
C655
R669
R609
R679
R616
FB001
R645
C644
R659
C653
R637
X601
C639 C638
3 1
IC605
C606
C602
C004
2
C006
C005
C003
R689
CN001
CN004
CN008
1-685-086- 12
C
AMP
BOARD
CN301
(Page 51)
D
AMP
BOARD
CN305
(Page 51)
H
POWER
BOARD
CN903
(Page 65)

7-12. PRINTED WIRING BOARD – DVD Board (Conductor Side) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
G
H
I
1 2 3 4 5 6 7 8 9 10 11 12 13 14
DVD BOARD
R037
R040
R042
R044
R045
R046
R048
R049
R050
R075
R051
R032
FB003
R028
R035
R038
R034
R031
R029
R059
C007
R060
R026
C014
(CONDUCTOR SIDE)
R664
R662
R666
R658
R655
R648
IC005
IC004
C601
2
1 3
C016 C017
2
1 3
C015
2
IC600
C600
C650
C647
R667
C635
IC608
R660
R998
R656
C657
C659
C612
R653
IC604
C604
C608
R600
R604
R607
R603
R602
R605
R608
R606
R624
R622
R621
R617
1 3
C607
8
C629
9
IC602
R021
R023
C605
R650
C621
R019 FB008
2
C663
R654 C615
R017
IC601
R665
R668
3
FB013 FB009
FL006 FL004
FL003
FB007
1 3
C678
C645 R635
C656
R652
R646
C552
2
1
FB014 FB010
FB011
E
Q001
FL005
R079
R011
R009
R696
R644
R626
FB012
E
Q003
R067
R066
R636
R649
C658
R657
R630
R627
R619
IC603
R033 R030
2
IC002
1 3
C011
C010
E B
Q002
C
C662
1
IC610
L602
E B
Q004
C
R651
R647
16
C633
C603
IC003
C660
C617
C611
C674
FL605
C613
R001
R020
R018
R016
R014
R054
FL603
R620
C632
C620
C619
C012
R992
FB901
Q910
FL604
IC203
C013
1
C264
C900 R901 R903 R905
C203 E
FL204
IC001
3
R008 R007
IC900
C667
FL606
Q302
C259
C255
R239
R252
R253
C243
R900
R902
R954
R904
C204
R249
R250
IC702
C796
C263
R851
C857
IC204
C855
C258
C861
C841
C235 R245
R213 R214
C225 C236
FB202
R206
C840
FL811 FL807
R258
C231
FL810
C848
C802
C854
C843
C803
C217
C232
C233
R260
R355
C319
IC215
C257
R256
R244
R215
R217
R220
8
R216
R218
R219
R221
1 C355 28R211
C271
R235
R223
2
E
Q908
R687
E
R006
R005
R004
R003
R002
R022
R024
C018
Q909
56 29
(AEP, UK, CIS)
E
2
FB201
3 1
IC006
2
3
1
R246
C019
FL203
R203
R236
FL812
R257
R207
R043 R041 R039 R036
R208
R222
R259
R209
R224
C270
R225
R227
R228
C219
C234
C239
C242
C245
C249
C237
R202
R015 R234
R013
R805
IC808
1
R261
R064
R210
R831
C839
C810
C807
IC303
IC703
R802
16
9
FL303
C253
IC202
C842
FL202
R727
R725 R728
R720 R721
R724
R726
C720 C721
R889
R888
R887
R886
R885
R884
R883
R882
C817
R800
R839
R828
R356
R357
R358
L301
R803
C870
R661
C226
R758
C728 C703
39
C254
C808
C771
C248 C774
R767 C775
R729
R757
C521
R829
R541
R538
R545
C523
R544
R770
R762
R763
R540
C812
C813
IC814
C769
C781
C764
R847
R750
C765
C238
R776
C766
R251 R755
C767
C768
C244
1
4
R777
C773
R764
R707
C709
FL701
8
5
R778
C406
C772
C780
FL703
C770
39
R415
R416
D903
R955 R957
R713 R714
R780 C727
R708
R709
R712 R748
R717
R747
R718
C717 C779
R711
C711
R719
R781
C716
C722
FL702
C718 C778
C752
C712
R710
C777
C708
20
1
C763
C713
C714
IC812
R715
IC706
R716
11
10
R428
C009
E
C762
Q903
R731
FL705
C730
C902
C744
+
R327
R328
R743
C745
R772
R706
R737
R705
R735
R704
R703
R702 C743
C742
R730
C741
C725
C724
R077
R974
C726
C760
C761
R732
IC803
FL402
R072
FL401
R533
R579
R451
C514 C512
R581
C519
R580
R583
R582
C416
R933
R985
D904
E
R916
C918 E
3
R987
R922
1 3 1
R935 (S880)
R322 R323
R326
C401
C402
Q913
IC903
Q906
R331
R364
IC802
C527
R427
R911
R912
R913
Q301
C925
R980
R010
R977
R979
E
R978
R921 R908
E
R945
Q901
ER948
JW903
R964
D902
E
4
5
R990
C909
4
IC905
3
E
1
3
Q912
E
R056
R057
R062
R061
R950 5 1
FB006
C926
R970
R047
C910
1
4
1
3
8
5
5
4
R307
R349
R535
R914
R915
R910
R335
Q907
4 5
E
FL304
R988
4 5
IC904
R738
R534
R532
R529
R530
R531
R528
C312
R986
C917
C311
R899
R989
R303
C310
R346
C308
R342
R304
R360
R319
C304
R309 R308
C307
R352
R351 R363 R339
R336
R527
C510
IC501
R932
R685
R991
Q902
Q900
R969
C921
C908
C905
C906
C907
R311
R313 R312
R314
R315
R316
R337
R525
R524
R965
R993
R951
R946
R949
R968
R937
R939
R941
R942
R943
R944
R963
C412
R359
R523
R521
R522
C509
C506 R517
R999
D907
IC907
R353
C529
R981
R350
R536
C508
C503
C504
R317
R520
R519
R419
R514
C418
R940
C927
R934 Q911
R938
R966
R512
R936
R516
R513
R069
R433
C414
R434
C415
R510
R511
R052
R070
R053
R055
R058
R063
R065
R068
R597 R450
FB005
IC302
FL301
1-685-086-
12
HCD-S550/S880
• Semiconductor
Location
Ref. No. Location
D902 C-13
D903 C-10
D904 C-12
D907 B-13
IC001 H-5
IC002 H-4
IC003 G-4
IC004 E-2
IC005 D-2
IC006 I-6
IC202 G-8
IC203 G-5
IC204 G-6
IC215 E-6
IC302 D-14
IC303 E-8
IC501 H-13
IC600 F-2
IC601 G-2
IC602 F-4
IC603 H-3
IC604 C-4
IC608 F-3
IC610 G-3
IC702 D-6
IC703 H-8
IC706 F-10
IC802 E-12
IC803 E-12
IC808 C-8
IC812 D-10
IC814 E-9
IC900 C-5
IC903 D-12
IC904 D-12
IC905 B-13
IC907 C-13
Q001 H-2
Q002 I-2
Q003 H-3
Q004 I-3
Q301 F-12
Q302 G-5
Q900 B-13
Q901 B-13
Q902 B-13
Q903 D-11
Q906 C-12
Q907 D-12
Q908 B-5
Q909 B-6
Q910 B-5
Q911 B-14
Q912 B-14
Q913 B-12

HCD-S550/S880
7-13. SCHEMATIC DIAGRAM – DVD Board (1/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagram.
(Page
35)
AGND
RFAC
AGND
AVC
AVC
MIRR
PI
TE
FE
A5V
A5V
SDEN
DATA_RF
CLK_RF
LDON
A3V
RFMON
INLIM
LDSEL
FD-
FD+
TD-
TD+
SLEDB-
SLEDB+
SLEDA-
SLEDA+
SPDL-
SPDL+
CN401
29P
JL544
JL537
JL536
C405
C406
10 16V
0.0022
JL535
JL531
JL530
JL529
JL527
JL526
JL525
JL524
JL523
JL522
JL501
JL502
JL500
JL511
JL512
JL509
JL510
JL503
JL504
JL505
JL506
JL507
JL508
(1/10)
RFAC
MIRR
PI
TE
FE
SDEN
DATA_RF
CLK_RF
LDON
RFMON
INLIM
LDSEL
FCS-
FCS+
TRK-
TRK+
SLEDB-
SLEDB+
SLEDA-
SLEDA+
SPDL-
SPDL+
C526
C527
22
0.1
16V
SPDL+
SPDL-
SLEDB-
SLEDB+
SLEDA-
SLEDA+
TRK+
TRK-
FCS+
FCS-
R428
1k
C528
C529
22
0.1
16V
(CH3456)
(CH12)
TSD-M
SP_ON
R415
0
MUTE_2D
R416
0
R514
10k
R510
150k
R511
150k
R597
0
R582 R583
10k 10k
R554 R553
C525
0 0
0.1
C504
33000p
R513
56k
R580
33k
C519
0.01
R512
56k
C503
33000p
C506
330p
R516
4.7k
R581
12k
FOCUS/TRACKING COIL DRIVER,
SPINDLE/SLED MOTOR DRIVER
IC501
FAN8035
R579
8.2k
C514 R533
R534
56k
0.01 33k
C512 R529
0.01 33k
R532
0
R535 0
R530 R531
56k 0
R528
0
C510 R527
R525
10k
1000p 2.2k TRDR
C509
330p
R522
4.7k
R520
10k
R524
10k
R523
10k
R517 C508
2.2k 1000p
TFDR
FRDR
FFDR
R536
200k
SPFG
40
SLEDA
SLEDB
DSAVE
SLED
C414
0.01
R433
47k
R418 C404 R419
10k 0.1 68k
GND
0.01
C415
R521
100k
R519
100k
R434
47k
40
VCC
IC402
NJM3404AV(TE2)
SLEDCTRL
AMP,
REFERENCE
WAVRB
FE
TE
PI
SPIN
VOLTAGE
GENERATOR
R437
47k
FJMP2
FJMP1
RFAC
SLEDCTRL
C410
10
16V
R440
47k
R443
47k
C411
0.1
TFDR
TRDR
FFDR
FRDR
FE
TE
PI
MDP
RFAC
R441
1k
R445
1k
R450
1k
LOCK
C409 0.0022
C412 0.0022
C413 0.0022
C419 0.047
C420 0.0022
FOK
R435 0
R438 0
C424
0.022
DFCT
R411
0
C407 10
C408 0.1
C425
0.0022
R412
10k
R413
10k
R421 1k
R423 1k
R425 1k
R426 1k
R429 1k
R430 1k
MIRR
COUT
C418
0.1
GSCOR
SCOR
C401 C402
0.1 10
R402 R403
0 0
33k
R449
C2PO
0
R401
R455
100k
GFS_CD
10k
R447
IC401
CXD3068Q
3300p
C428
C426 C427 C433
0.01 0.47 0.0015
WFCK
DIGITAL SIGNAL PROCESSOR,
DIGITAL SERVO PROCESSOR
100p
C432
SCLK
0
R404
SENS
0
R405
CLOK
0
R406
R446
10k
R448
1k
C421
0.1
R457
3.3k
XLAT
0
R407
DATA
0
R408
MUTE_CD
0
R409
XRST_CD
0
R410
R452
1M
R444
470k
C422 C423 R453
100p 0.1 1M
R424
0
R431
0
R427 0
R432 0 MDAT
R436 0 LRCK
R439 330 MD2
C434 C436 C435
10 0.1 0.1
AVC
D3.3V
D5V
DGND
A3.3V
A5V
FL401
EXCK
SBSO
R451 10k
R417 0 SQCK
R420 0 SQSO
768FS
BCLK
CDDOUT
FL402
C417 0.1 C416 10
R442
10k
(Page 43)
A5V
A3.3V
DGND
D5V
D3.3V
AVC
M12V
MGND
DSP_BUS
SPC970_BUS
ANALOG_BUS
(Page 49)
(Page
41)

HCD-S550/S880
41
41
7-14. SCHEMATIC DIAGRAM – DVD Board (2/10) – • See page 67 for Waveforms.
C703
R719
R720
R538
C776
C777
R767
C774
FL704
FL703
C772
R763
R771
R764 C773
R762
R758
R759
R757
R756
R766
C778
FL702
R750
R777
R799
R752
R541
R544
C521
R540
C729
C770
C779
C775
C769
C768
R778
C767
R765
R746
C763 C762
R745
R744
C761
C760
C764
C706
C702
C752
C709
R772
C718 C723
R724
R721 C720
R725
TP701
C715 R726
C721
R727
R728 C728
IC703(1/2)
C722
C717
R748
C716
R781 R718
R716
R717
R780
R713
C713
C714
R715
R710
R711
R712
C711
R747
R714
R707
FL706
R729
C523
R545
R730
R731
R732
R702
R703
R735
R704
R737
R705
C740
C741
C742
C743
C744
C730
R741
R706
R742
R743
C745
TP702
R755
R754
R753
IC703(2/2)
FL701
C766
C781
C780
R770
C765
C771
R776
C712
C708
R708
R709
IC701
0.1
1k
1k
100k
0.1
0.1
47k
0.0047
0.1
8.2k
2.2k
1M 0.47
22k
0
0
0
0
0
0.1
10k
0
0
0
100k
100k
1500p
10k
10
0.1
10
0.1
0.1
0.1
100k
0.1
22k
47k
0.1 0.1
47k
22
0.1
0.1
0.1
0.1
10
0.1
0.1
22
0.1 0.1
1k
33k 0.1
1.8k
1500p 100k
0.1
3.3k
10k 0.1
NJM3404AV(TE2)
0.1
0.01
33k
0.47
0 10k
100
100k
0
10k
0.1
0.1
10k
10k
2.2k
10k
0.01
33k
10k
100
8.2k
1500p
100k
22
22
10k
10k
10k
10k
10k
10k
10k
0.1
0.1
0.1
0.1
0.1
0.1
22
10k
22
22
0.1
0
0
0
NJM3404AV(TE2)
100p
10
10
0
0.1
0.047
0
100p
0.01
470k
150k
CXD1882R
D1
D2
D3
D4
D5
D6
D7
D8
E1
E2
E3
E4
E5
E6
E7
DSP_BUS
SPC970_BUS
ANALOG_BUS
BD0
BD1
BD2
BD3
BD4
BD5
BD6
BD7
WE
RAS
MA0
MA1
MA2
MA3
MA8
XMOE
BD8
BD9
BDA
BDB
BDC
BDD
BDE
BDF
LRCK
SD1
SD2
SD0
SD3
SD4
SD5
SDEF
SD7
MA4
MA5
MA6
MA7
D4
D3
D2
D1
D0
XHWR
XHRD
A7
A6
A5
A4
A3
A2
A1
A0
D7
D6
D5
RF_AC
JIT
SCOR
GSCOR
EXCK
SBSO
WFCK
C2PO
D3V
D5V
A3V
DGND
AGND
A5V
BCLK
MDAT
XCAS
XCS1882
MA9
SD6
XINIT1
XINIT0
AVC
MDP
MDIN
MDIN
GFS_DVD
JITOFF
SPIN
XSRQ
XSHD
XDCK
XSAK
2
3
4
1
8
7
6
5
(2/10)
BUFFER
DVD DECODER
(1/2)
(2/2)
COMPARATOR
(Page
40)
(Page 43)
(Page 42)

HCD-S550/S880
42
42
7-15. SCHEMATIC DIAGRAM – DVD Board (3/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagrams.
C855
C861
C857
R841
R843
R840
R838
R837
R836
R835
R834
R833
R846
R845
R844
SL811
SL813
R805
IC814
C813
C819
R830
C804
C837
C849
R800
C817
R827
C839
R828
R839
R889
R888
R887
R886
R885
R884
R883
R882
C842
C796
C797
C795
C843
C840
FL810
C807
IC702
R826
R850
R849
R848
R821
R822
R823
R867
R866
R865
C856
C811
C854
C841 C848
C803
C802
FL807
FL812
R847
C812
C724
C727 C725 C726
C870
SL812
R804
C871
FL705
FL811
C865 C866
C867
C815
R852
R851
C838
C818
C810
R831
R803
IC706
IC808
IC801
R842
IC813 IC812
R806
C808
R829
0.01
0.01
0.01
0
0
0
0
0
0
0
0
0
0
0
0
10k
TC7WH157FK
0.01
0.01
4.7k
0.01
0.01
0.01
4.7k
0.01
100
0.01
4.7k
4.7k
10k
10k
10k
10k
10k
10k
10k
10k
0.01
0.1
220
4V
100
6.3V
0.01
10
0.01
TA48M025F(TE16L)
22
22
22
22
22
22
22
0
0
0
0.01
0.01
0.01
10 0.01
0.01
10
22
0.01
0.1
10 0.1 0.1
33000p 0
0.01 0.01 0.01
0.01
0.01
0
0
0.01
0.01
0.01
33k
100
MSM51V18165F-
60TSKR1
MSM56V16160F-8TK
7R1
CXD2752R
10k
SN74LV245APWR SN74LV245APWR
0
100p
100
D1
D2
D3
D4
D5
D6
D7
D8
F1
F2
F3
F4
F6
F7
SDATALS
SDATARS
SDATAL
SDATAR
SDATAC
SDATALF
DSBC
DSMCK
CDDOUT
TRST
TMS
TDOSA
TCK
TDISA
SD7
SD6
SD5
SD4
SD3
SD2
SD1
SD0
SHRRDY
BD0
BD1
BD2
BD3
BD4
BD5
BD6
BD7
MA0
MA1
MA2
MA3
WE
RAS
XMSLAT
XRST_DSD
XSHD
SDCK
XSHD
XSAK
SDEF
D3V
D3V DGND
XDCK
SHRMUT
AV0
AV1
AV2
AV3
AV4
AV5
AV6
AV7
SDEF
XSAK
XSAK
SDEF
XSHD
AV0
AV1
AV2
AV3
AV4
AV5
AV6
AV7
XSRQ
D3V
SA0
SA1
SA2
SA3
SA4
SA5
SA6
SA7
SA8
SA9
SA10
SA11
SCAS
SRAS
SWE
DCLK
DCKE
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
SA4
SA5
SA6
SA7
SA8
SA9
DCLK
DCKE
AGND
MSCK
MSDATI
MSDATO
DGND
DSL
DSR
DSC
DSLF
DSLS
DSRS
SDCK
WAVRB
MA10
MA11
RF_AC
CDDOUT
768FS
WRF WPK
WRF
WPK
DQ6
DQ7
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
SWE
SCAS
SRAS
SA11
SA10
SA0
SA1
SA2
SA3
DQ0
BDD
BDC
BDB
BDA
BD9
BD8
XMOE
XCAS
MA8
MA7
MA6
MA5
MA4
BDF
BDE
MA9
DSLS
DSRS
DSL
DSR
DSC
DSLF
XMSLAT
MSCK
MSDATI
MSDATO
XMSDOE
XRST
SMUTE
MCKI
EXCKO1
EXCKO2
LRCK
F75HZ
MNT0
MNT1
MNT2
MNT3
MNT4
MNT5
MNT6
MNT7
TCK
TDI
TDO
TMS
TEST1
TEST2
TEST3
UBIT
XBIT
SUPDT0
SUPDT1
SUPDT2
SUPDT3
SUPDT4
SUPDT5
SUPDT6
SUPDT7
SUPEN
BCKASL
BCKAI
BCKAO
PHREFI
PHREFO
ZDFL
DSAL
ZDFR
DSAR
ZDFC
DSAC
ZDFLFE
DSALFE
ZDFLS
DSALS
ZDFRS
DSARS
IOUT0
IOUT1
IOUT2
IOUT3
IOUT4
IOUT5
IANCO
IFULL
IEMPTY
IFRM
IOUTE
IBCK
IERR
IPLAN
IHOLD
IVLD
IDIN0
IDIN1
IDIN2
IDIN3
IDIN4
IDIN5
IDIN6
IDIN7
WAD0
WAD1
WAD2
WAD3
TESTI
WAD4
WAD5
WAD6
WAD7
WRFD
WCK
WARFI
WAVRB
DCLK
DCKE
XWE
XCAS
XRAS
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
XSRQ
XSHD
SDCK
XSAK
SDEF
SD0
SD1
SD2
SD3
SD4
SD5
SD6
SD7
IANCI
DQ7
DQ5
DQ4
DQ6
DQ3
DQ2
DQ1
DQ0
VDD
VDD
VSS
VSS
DQ0
DQ1
VSSQ
DQ2
DQ3
VDDQ
DQ4
DQ5
VSSQ
DQ6
DQ7
VDDQ
LDQM
WE
CAS
RAS
CS
A10/AP
A0
A1
A2
A3 A4
A5
A6
A7
A8
A9
NC
CKE
CLK
UDQM
NC/RFU
DQ8
DQ9
VSSQ
DQ10
DQ11
VDDQ
DQ12
DQ13
VSSQ
DQ14
DQ15
A11-BA
VDDQ
NC
NC
NC
NC
TEST5
TEST4
NC
A
B
Y
GND
VCC
ST
SL
Y
IN
G
OUT
VDD
I/O0
I/O1
I/O2
I/O3
VDD
I/O4
I/O5
I/O6
I/O7
N.C.
N.C.
N.C.
WE
RAS
A0
A1
A2
A3
VDD
GND
I/O15
I/O14
I/O13
I/O12
GND
I/O11
I/O10
I/O9
I/O8
N.C.
N.C.
LCAS
UCAS
OE
A9
A8
A7
A6
A5
A4
GND
A10
A11
(3/10)
16Mbit D-RAM
16Mbit SD-RAM
LEVEL SHIFT LEVEL SHIFT
SACD/DVD
SELECT
DSD DECODER
REGULATOR
+2.5V
VDIOB0
VSCB1
VSIOB1
VSCB2
VDCB2
WAVDD0
WAVDD1
WAVSS1
WAVSS0
VSIOA2
VDCB1
VDIOB1
VDIOA2
VSIOA3
VDIOA3
VSCA3
VSIOA4
VDIOA4
VDCA3
VSCA0
VDCA0
VSIOA0
VDIOA0
VSCA1
VDCA1
VSIOA1
VDIOA1
VSCA2
VSDSD0
VDCA2
VDDSD0
VSDSD1
VDDSD1
VSCB0
VDCB0
VSIOB0
TRST
MSREADY
(Page
41)
(Page 43)
(Page 44)
(Page 46)

7-16. SCHEMATIC DIAGRAM – DVD Board (4/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagrams.
(Page 41)
(Page
40)
AVC
D3.3V
D5V
DGND
A3.3V
A5V
E7
E5
E6
E2
E1
E3
E4
FL301
EEPROM
IC302
BR24C02F-WE2
C793
220
4V
AVC
DGND
D3V
D5V
C791
100
6.3V
A3V
A5V
AGND
GND
SDA
(4/10)
A2
SCL
A1
WP
A0
VCC
C320
0.01
R312
10k
R361 10k R316 10k
R309
MD2
0
FJMP1
FJMP2
SENS
R311
22
XCS1882
D0
D1
D2
D3
D4
D5
D6
D7
XINIT0
XINIT1
MSCK
R738
22
R313 0
R314 0
R315 0
SDEN
C301
10
10V
R304
22
R303
22
C302
0.01
C303
0.01
100
R317
SCOR
XRST_DVD
XRST_CD
DSAVE
A7
A6
A5
A4
A3
A2
A1
A0
100
R318
XLAT
0
R319
LDON
MIRR
0
100
R320
COUT
R321
INLIM
0
R322
CS_SPC
DRVRX
DRVTX
100
R323
DRVCLK
DRVIRQ
MECHANISM
CONTROLLER
IC301
CXP973064-224R
0.01
C304
R324
0
R305
10k
XHRD
X301
20MHz
XHWR
DATA_RF
CLK_RF
R306 22
R307 22
R308 22
SLEDA
SLEDB
TXD
RXD
R326 100
R327 100
R328 100
JITOFF
MSDATI
MSDATO
SHRRDY
R329 100
R330 100
DATA
CLOK
LDSEL
LDSEL
Q301
DTC114EKA
-T146
LASER DIODE
SELECT
TSD-M
C307
0.01
43
R331
220
R332 10k
R333 10k
R364
4.7k
43
R352 0
LOCK
R351 0
FOK
TSD-M
R350 100
SCLK
R349 0
C312 10 10V
GFS_CD
C311 C309 C310
0.01 100p 100p
R346 1k FE
R345 0
R340 0
R339 0
R338 0
R363
10k
I2C_SCL
I2C_SIO
R360
10k
R344 1k TE
JIT
R342 0 SP_ON
C308 33000p
R341
0
R337 100
R336 0
F1
XRST_DSD
PI
SLED
MUTE_2D
MUTE_CD
GFS_DVD
SPFG
SQCK
SHRMUT
SQSO
R335 22 XMSLAT
RST_SPC
FL304
RFMON
RF_AC
27M
CL301
L301
10µH
FL303
DRVRDY
CS_SPC
R355
22
C318 9p
C317 X302 R362 R354
10p 27MHz 0 1M
C316
10 16V
C313
0.1
DRVCLK
(Page 42)
SWITCHING
IC802
TC7S32FU(TE85R)
VCC
GND
FLIP-FLOP
IC803
TC7W74FK(TE85L)
IC303
SM8707GV-G-E2
VDD1 NC
VSS1 NC
MO1 NC
NC SO3
VDD2 VDD3
VSS2 VSS3
XTI SO2
XTO SO1
F2
F3
F4
CLOCK
GENERATOR
R356
68
XSRQ_ZIVA
F6
F7
R357
68
R358
68
CL304
C809
0.01
CL303
CL302
TXD
RXD
JIG_MOD
R353 R359
10k 10k
HCD-S550/S880
JL301
JL302
JL303
JL304
JL305
JL306
JL307
RF
CN301
7P
RF_AC
GND
TXD
RXD
DGND
3V-D
ZIVA_BUS
(Page 44)
(FOR CHECK)

HCD-S550/S880
7-17. SCHEMATIC DIAGRAM – DVD Board (5/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagram.
(Page 48)
(Page 43)
(Page 57)
(Page 46)
(FOR CHECK)
(Page 42)
(Page 49)
SPDIF
ZIVARESET
I2C_SCL
I2C_SIO
I2C_CTRL
ZIVA_BUS
TDOSA
TRST
TDISA
TMS
TCK
A3.3V
DGND
D5V
D3.3V
+1.8V
CN003
14P
CN201
4P
RXD
TXD
GND
D5V
NC
I/P SW
CR
GND
CB
D5V
D5V
GND
VIDEOY
GND
VIDEOC
GND
VIDEOV
VS/WIDE
CL206
R235
0
TP077
TP076
TP023
TP024
TP025
TP026
TP027
TP028
TP029
TDOSA
TRST
TDISA
TMS
TCK
(5/10)
R064 0
R013 0
R015 0
FB004
R036 0
R039 0
R041 0
R043 0
R241
10k
CS_SPC
R239
47k
I/P-SW
CR/B
CB/R
Y
C
V
VS
SPDIF
I2C_CTRL
Q302
DTC114EKA
-T146
INVERTER
C255
0.01
DA05V
DGND
R226
4.7k
(Page 49)
R202
0
EEPROM
IC203
BR9040F
R/ B WC
VCC GND
CS DO
SK DI
C264 C243 C250 C259 C203
10 0.01 0.01 0.01 0.01
FL204 CL803
27M
C228
0.01
C246
0.01
C261
0.01
R253 R252
4.7k 4.7k
R247
4.7k
I2C_SCL
I2C_SIO
R233
10k
R248
4.7k
SD7
SD6
SD5
SD4
SD3
SD2
SD1
SD0
XSRQ_ZIVA
XSAK
SDEF
XDCK
DRVIRQ
DRVCLK
DRVTX
DRVRX
DRVRDY
ALE
JIG_MOD
RST_SPC
TRST
TDISA
TDOSA
TMS
TCK
HA3
HA2
SYS_RST
CL201
CL202
CL203
CL204
CL205
R229 33
R230 33
FB202
44
R238
100
SPDIF
R249 R250
4.7k 4.7k
33
R231
44
R245
4.7k
R246
4.7k
HA1
HAD15
HAD14
HAD13
HAD12
HAD11
HAD10
HAD9
HAD8
HAD7
HAD6
HAD5
FB201
R232
0
HAD4
C225
0.1
C235
0.01
HAD3
HAD2
HAD1
C201
220
4V
R203
180
C236
0.01
HAD0
R236
1k
R206
0
R257
R262 75
R207 75
R258
R263 75
R208 75
R259
R264 75
R209 75
C265 C266 C267 R256 R244
C271 C268 C269 C270
0.01 0.01 0.01 4.7k 4.7k
0.01 0.01 0.01 0.01
V
C229
0.01
IC206
ZIVA-5P-B0
C
DVD SYSTEM PROCESSOR
UDS
R/W
Y
C230
0.01
C231
0.01
R260
R265 75
R210 75
C232
0.01
R261
R266 75
R234 75
C233
0.01
R215 33
R216 33
R217 33
R218 33
R219 33
R220 33
R221 33
R222 33
R223 33
R224 33
MA9
CB/R
MA8
MA7
MA6
CR/B
MA5
MA4
MA3
MA2
MA1
MA0
C237
0.01
33
R225
MA10
MA11
BA1
BA0
I/P-SW
VS
MCSO
I2C_CTRL
R227 R228
33 33
MRAS
MCAS
MD31
MD30
MD29
MD28
MDQM3
MD27
MD26
MD25
MD24
MD23
MD22
MD21
MD20
MDQM2
MD19
MD18
MD17
MD16
MD15
MD14
MD13
MD12
MDQM1
MD11
MD10
MD9
MD8
MD7
MD6
MD5
MD4
MDQM0
MD3
MD2
MD1
MD0
MCLK
R212 22
MWE
C240
0.01
C241
0.01
C247
0.01
C251
0.01
C252
0.01
C260
0.01
C262
0.01
G1
G2
G3
G4
G5
G6
G7
(Page 45)

7-18. SCHEMATIC DIAGRAM – DVD Board (6/10) – • See page 72 for IC Block Diagram.
(Page 44)
G1
G2
G3
G4
G5
G6
G7
C217
0.01
C219
0.01
C234
0.01
C239
0.01
C242
0.01
C245
0.01
C249
0.01
MD16
MD0
MD1
MD2
MD3
MD4
MD5
MD6
MD17
MD18
MA10
MD19
MD20
MD21
MD22
IC202
MT48LC4M32B2-7
MD15
MD14
MD13
MD12
MD11
MD10
MD7 MD8
MDQM0 MDQM1
MWE
MCAS
MRAS
MCSO
MA11
BA0
BA1
(6/10)
128Mbit SD-RAM
MA0
MA5
MA1
MA4
MA2 MA3
MDQM2 MDQM3
MD23 MD24
MD9
MCLK
MA9
MA8
MA7
MA6
MD31
MD30
MD29
MD28
MD27
MD26
MD25
R251
10k
C226
0.01
C238
0.01
C244
0.01
C248
0.01
C253
0.01
C254
10
FL202
FL203
C319
33p
45
CL801
C257 C258
10 0.01
C274 C314 C315
0.01 0.01 0.01
ALE
HAD0
HA4
HAD1
HA5
HAD2
HA6
HAD3
HA7
HAD4
HA8
C356 C355
0.01 0.01
45
HA9
HA10
HA11
HA12
HA13
HA14
HA15
HA16
IC204
MR27V3202F
-8NTPZ020
UDS
HA21
WE N.C.
HA19 HA20
A18 A19
HA18
HA9
A17 A8
HA8
HA10
A7 A9
HA7
HA11
A6 A10
HA6
HA12
A5 A11
HA5
HA13
A4 A12
HA4
HA14
A3 A13
HA3
HA15
A2 A14
HA2
HA16
A1 A15
HA1
HA17
A0 A16
CE BYTE
VSS VSS
R/W
HAD15
OE DQ15
HAD0
HAD7
DQ0 DQ7
HAD8
HAD14
DQ8 DQ14
HAD1
HAD6
DQ1 DQ6
HAD9
HAD13
DQ9 DQ13
HAD2
HAD5
DQ2 DQ5
HAD10
HAD12
DQ10 DQ12
HAD3 HAD4
DQ3 DQ4
HAD11
DQ11 VCC
HAD5
HAD6
HAD7
HAD8
HAD9
HAD10
HAD11
32Mbit PROGRAMMABLE
HAD12
HAD13
HA17
HAD14
HA18
HAD15
HA19
HA1
HA20
HA2
HA21
HA3
ALE
C204
0.01
BUS INTERFACE
IC215
SN74ALVCH16841
DGGR
HCD-S550/S880

HCD-S550/S880
7-19. SCHEMATIC DIAGRAM – DVD Board (7/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagrams.
(Page 42)
CDDOUT
DSMCK
DSBC
SDATAL
SDATAR
SDATAC
SDATALF
SDATALS
SDATARS
ERR
DO
DIGDI
A1
R625
3.3k
R631
100
R686 10k
R688 10k
A2
C636
0.1
R628 100
FL606
0
2FS/EX
SYNC
INIT
L602
10µH
R699
100
(Page 47)
C675
0.01
(7/10)
R692 100
R695 100
R608
3.3k
R682 10k
R684 10k
C608 0.1
C671 C661
0.01 0.01
C603
22p
X600
12.288MHz
R602 1M
C604
56p
R661
100
DVDD
DGND
AUDIO-(O)
R603 100
R604 100
R605 100
R606 100
R607 100
R639 R642
100 100
CSDIR
Z4
Z1
DIGCLK
R640 100
EXD1
IC612
CXD9633Q
R919
10k
R672
100
R673 220
R674 220
R675 220
R676 220
R677 220
C676 C679
C677
0.01 0.01
0.01
R960
10k
R961
10k
R962
10k
Z2
Z3
IC606
LC89056W
R972
10k
C648
0.1
XST
Z1
Z2
Z3
Z4
EMPHA(O)
XIN(I)
XOUT(O)
XMCK(O)
DVDD
DGND
XSTATE(O)
DATA(O)
LRCK(O)
BCK(O)
CKOUT(O)
CSFLAG(O)
F0(O)
F1(O)
F2(O)
VF(O)
LOCK(O)
BPSYNC(O)
ERROR(O)
DO(O)
DI(I)
CE(I)
CL(I)
XSEL(I)
MODE0(I)
DIGITAL AUDIO
INTERFACE
MODE1(I)
DGND
DVDD
DOSEL0(I)
DOSEL1(I)
C646 0.01
DIGITAL AUDIO
PROCESSOR
CKSEL0(I)
256FS
CKSEL1(I)
RSTDIR
XMODE(I)
R600
100
PLOCK
R687
1k
LR
AGND
AVDD
LPF(O)
VIN(I)
R(I)
DVDD
DGND
DIN2(I)
DIN1(I)
DIN0(I)
SPDIF(O)
DISEL(I)
CW
SLR
LRCK
BCK
C626 R614 C616 C627
0.01 33k 0.1 0.01
C668
0.01
C637
0.01
C634
0.1
C612
10
C609
0.1
R615
4.7k
R616
5.6k
R611
100
R623 100 DIN
R629 100 DOUT
C652
220
4V
SPDIF
R956 R700
10k 10k
C667 C673
10 0.01
RSTDSP
SCK
LRCK
BCK
LR
LRCKO
BCKO
256FS
D1
D2
D3
D4
LRCKI
BCKI
CW
46
R637
100
X601
13.5MHz R645
10k
R648
100
R655 100
R658 100
R659 33
R662 100
R664 100
R666 100
R667 100
C647 C644
0.01 0.01
C653
0.01
C650
0.01
R689
10k
46
S-RAM
IC604
IS61LV6416-15-
EL10(ISSI)
R679 100
C641
0.01
HACN
DIGDI
DIGCLK
V1
V2
V3
V4
V34
DSPDO
V33
SLR
R634
1k
V32
R998
10k
C611 0.01 C635 0.01
C640
0.01
IC607
CXD9617R
C617
0.1
R680 C670
C672
100 0.01
0.01
HCS
V31
PM
V30
V30
V5
V6
V7
V8
V29
V31
V28
V32
V27
V29
V26
V28
V4
V21
V27
V9
V25
V26
V10
V24
V25
V11
V23
V24
V12
V22
V21
V13
V14
V15
V16
A5
A6
A7
OE
BHE
BLE
D15
D14
D13
D12
VSS
VDD
D11
D10
D9
D8
NC
A8
A9
A10
A11
NC
A4
A3
A2
A1
A0
CS
D0
D1
D2
D3
VDD
VSS
D4
D5
D6
D7
WE
A15
A14
A13
A12
NC
DIGITAL AUDIO
SIGNAL PROCESSOR
V20
C613
10
C642
0.01
V23
V19
V22
V18
V17
V33
V34
V1
V2
V3
V13
BST
ERR
FL605
C669 C660
0.01 0.01
C639
0.1
G
O I
IC605
NJM2391DL1
-26(TE1)
+2.6V REGULATOR
R671
100
V15
V16
V17
V14
V12
V11
V10
V9
V8
V7
V6
V5
R663
100
V18
V19
V20
GP9
SPDIF
DIN
DOUT
C638
0.1
FL604 FL603
C643
220
4V
C674
10
C651
0.01
DIN
DOUT
DGND
SPDIF
(Page 48)
DGND
DA03V
B1
B2
B3
B4
(Page 44)
(Page 49)
(Page 48)

7-20. SCHEMATIC DIAGRAM – DVD Board (8/10) – • See page 67 for Waveform.
(NC)
(Page 48)
(Page 49)
(Page 59)
(Page 48)
(Page 48)
I/P-SEL
DGND
6.5V
STANBY-SW
ST-LED
5V
L-SEN
D-SEN
SEN2S
CN900
8P
IN
OUT
CLK
2PIN
RESET
VPP
VDD
GND
CN005
17P
6.5V
DGND
ENB
ENA
KEY1
KEY0
KEY2
FDATA
FCS
SIRCS
FCLK
DGND
DIMM
DGND
5V
STBY-LED
POWER-SW
(8/10)
TP050
TP051
TP052
TP053
TP054
TP055
TP056
TP057
TP058
TP059
TP060
TP061
TP062
FB005
R069 0
R068 0
R065 0
R063 0
R058 0
R055 0
R053 0
R070 0
R052 0
R047 0
FB006
R057 0
R056 0
R980
47k
R979
47k
C922
0.1
Y1
Y2
Y3
Y4
EB
EA
K1
K0
K2
FDATA
FCS
SIRCS
FCLK
DIMM
JW903
0
R948
10k
R993
1k
R946
10k
A1
DRST
OCP
X901
20MHz
Q902
DTA114EKA
-T146
Q913
2SA1037AK
A2
AV2
FM
AUMUTE STPOW
DISC
LOADING
DETECT
CS3
LT
RSTAD
MUTING
CONTROL
R929 15k
R932 10k
R685 1k
R899 2.2k
Q900
DTA114EKA
-T146
FMUTE
(Page 46)
MUTING
CONTROL
SIRCS
R991
10k
Q903
2SC2712-GL
-TE85L
R985
470k
INVERTER
R908
10k
CS2
TUN
R957 R955 D903
10k 10k 1SS355
R959
R986
47k
Q906
2SC2712-GL
-TE85L
SIRCS
DETECT
CS1
TUDI
MUTEN
1k
TCE
MUTEG
TUDO
R951
10k
AMPRST
TUCLK
R965 C913 C914
10k 0.01 0.01
D904
1SS355
C917
0.1
DO
DIMM
47
RSTDIR
100
R967
FCLK
R978
1k
R977
22k
DXST
10k
R909
100
R968
FDATA
CSDIR
FCS
DERR
0
R061
R062 0
R987
47k
47
DPLOCK
DGP9
HPSW
R970
10k
BST
100
R911
R926
Q907
2SC2712-GL
-TE85L
R936
R912 100
R913 100
IC901
µPD70F3033BYGF
-M10-3BA
100
INIT
DHACN
SYSTEM CONTROLLER
WAKE UP
DETECT
1k
RELAY
HCS
PARA-DO2
PM
IORST
RSTDSP
IOLAT1
P-PWM
IOCLK
C901 0.01
R914 100
R915 100
IODATAI
DIGCLK
DIGDI
DDSPDO
I2CCLK
TP902
CQRST
100
R916
MY,TW,
EXCEPT HK,SP,
I2CDATA
TP901
AMPCLK
100
JW900
R910 100
R963 ∗
KR,AUS
AMPDATA
R981
∗
Y4
R906
3.3k
R907 R918
3.3k 820
R917 820
R922 10k
R937 10k
R939 10k
R941 10k
R942 3.3k
R943 3.3k
R944 10k
R971 10k
C918 R989
100p 0
Y3
R935
4.7k
(EXCEPT AEP,UK)
∗R963
150 (CIS)
330 (CH)
1k (E,MX)
4.7k (EA,AUS)
10k (HK,SP,MY,TW,KR)
∗R981
1k (EA)
4.7k (CIS,E,MX,CH)
10k (AEP,UK)
(S880)
Y2
Y1
D5V
R933
10k
C921 100p EA
C908 100p K2
C905 330p K1
C906 330p
C907 0.001
K0
0
R988
K0
R969
150 (S880)
10k (S550)
(Page 49)
I2H
SYNC
2FS/EX
AV1
AV0
RDSC
SIRCS
PSW
DVDPW
RDSD
IN
EB
NC
GND
GND
OUT
KEY INPUT
DETECT
IC903
PST9126NL
K2
HCD-S550/S880
IC904
PST9140NL
IN
NC
GND
GND
KEY INPUT DETECT
OUT
C1
C2
C3
C4
C5
C6
C7
(Page 48)

HCD-S550/S880
7-21. SCHEMATIC DIAGRAM – DVD Board (9/10) – • See page 67 for Waveforms. • See page 72 for IC Block Diagrams.
(Page 47)
(Page 47)
(Page 49)
(Page 37)
L-SEN
D-SEN
SEN2S
DGND
C1
C2
C3
C4
C5
C6
C7
MGND
M12V
D+5V
M+12V
M+12V
MGND
MGND
CK.SENSOR
D.SENSOR
SW(2)
SW(1)
E1
E2
E3
E4
LO-MTR-R
LO-MTR-F
CK-MTR-R
CK-MTR-F
SENSE-LED
C009
0.01
CN006
18P
(9/10)
L600
C621
470p
C629
470p
C615
0.1
R621 100
R622 100
R624 100
C630 C631
10 0.1
IC600
NJM78M05DL1A
-TE1
C602
C605 C600 C601
100
0.1
16V
0.1 0.1
IC602 PCM1800
IC601
µPC2910T-E1
O I
G
R949
10k
C620
0.1
R920 100
C618
10
16V
R617 R656
0 0
R077
0
TP078
TP078
TP079
TP080
TP081
TP082
TP083
TP084
TP085
TP086
TP087
TP088
TP089
TP090
TP091
TP092
TP093
B3
EXD1
BCKI
LRCKI
B4
R072
0
R010 0
10µH
C606
100
6.3V
C610
47
6.3V
R074 0 SEN1
R073 0 SEN2
SEN3
SEN4
SEN5
SEN6
MA1
MA2
MB1
MB2
MC1
+5V REGULATOR
C607
0.1
O I
G
R945
10k
A/D CONVERTER
IORST
IOCLK
IOLAT1
+10V REGULATOR
RB901
10k
Q901
2SD1819A-QRS
-TX
RESET SWITCH
SEN1
SEN2
SEN3
SEN4
SEN5
SEN6
C909
0.22
R950
47k
R964
47k
D902
1SS355
C614 10 16V
C619
0.1
C622
10
16V
SCK
C625
BCKO
10
16V C623
D4
10p
LRCKO
R620
100
RSTAD
LT
DIGCLK
C632
0.01
DIGDI
MECHANISM DECK CONTROLLER
IC902
PT8300
RESET SIGNAL
GENERATOR
IC907
PST9140NL
B2
R990
15k
NC IN
GND
GND RESET
MA1
MA2
MB1
MB2
MC1
C926
0.1
(Page 46) (Page 49)
R974
0
D/A CONVERTER
IC608
AK4382AVT-E2
R999
1.5k
R921
100
R952
100
D907
1SS355
C903
100
6.3V
C902
0.1
R930
10k
5V
IODATAI
PARA-DO2
C655
C657 100
0.1 6.3V
AND GATE
IC905
TC7S08F
GND
VCC
48
R636 R647 R635 C645
4.7k
C658
470p
220 10k 220p
R649 R696
4.7k 220
R644 R646
10k 4.7k
100 16V
C654
C927
0.1
R651
C656
R652
R660 C662
220 220p
R650
4.7k
C663
470p
R654 220
R653
4.7k
10k
0.1
C912
47
6.3V
4.7k
220p
C678
R665
10k
48
0.1
C552
GND
D901 1SR154
D900
1SR154
VCC
R668
1k
C659
220p
FB902
C910 C911
0.22F 47
5.5V 6.3V
LOW-PASS
FILTER
IC610
NJM2904V(TE2)
XST
DXST
ERR
DERR
PLOCK
Q908
DTC124EKA
-T146
Q909
DTC124EKA
-T146
DPLOCK
(Page 47)
R954
10k
R900 100
R902 100
R904 100
R940
100
Q912
2SC2712-GL
-TE85L
B1
R657
1k
ST-LED
R626 R609
R610
1k 470
2.2k
VCC
Q910
DTC124EKA
-T146
Q911
DTC124EK
GND
Q908-910
ENABLE SWITCH
R630 470
LEVEL SHIFT
R992
10k
IC900
TC74HCT7007AF
Q911,912
LED DRIVE
LOW-PASS
FILTER
IC603
NJM2904V(TE2)
STPOW
R627 2.2k
R938
10k
R669
1k
FB901
C925 R931
0.1 1k
R905
100
PSW
DA05V
C900
0.1
R613 4.7k
C624 0.1
R612 47k
C628 10 16V
C633
R618 R619
4.7k 47k
R901 100 DGP9
R903 100 DHACN
R934 R966
10k 220
STANBY-SW
P-PWM
ERR
2FS/EX
GP9
HACN
DSPDO
DDSPDO
E5.6V
0.1
(Page 48)
12V
(Page 49)
SCK
LRCKO
BCKO
D3
D2
D1
RDSD
RDSC
TUDO
TUDI
TUN
TCE
TUCLK
AV0
AV1
AV2
FM
R026 0
R028 0
R029 0
R031 0
R032 0
R034 0
FB003
AUMUTE
AMPRST
MUTEG
MUTEN
AMPCLK
CS1
CS2
CS3
DRST
OCP
HPSW
RELAY
R025 0
R027 0
R030 0
R033 0
FB001
AMPDATA
FMUTE
STPOW
DVDPW
I2CDATA
CQRST
I2CCLK
I2H
TP030
TP031
TP032
TP033
TP034
TP035
TP036
(AEP,UK,CIS)
R054 0
R014 0
R016 0
R018 0
R020 0
R001 0
R035 0
R037 0
R038 0
R040 0
R042 0
R044 0
R045 0
R046 0
R048 0
R049 0
R050 0
R075 0
R024 0
R022 0
R002 0
R003 0
R004 0
R005 0
R006 0
R008 0
DGND
SCK
DGND
BCKO
D3
D2
D1
DGND
DGND
6.5V
6.5V
TP049
LRCKO
CN001
12P
TP001
TP002
TP003
TP004
TP005
TP006
TP007
TP008
TP009
R007 0
TP010
TP011
TP012
TP013
TP014
TP015
TP016
TP017
TP018
TP019
TP020
TP021
TP022
TP037
TP038
TP039
TP040
TP041
TP042
TP043
TP044
TP045
TP046
TP047
6.5V
I/P-SEL
DGND
DOUT
DIN
CN002 29P
RDATA
RCLK
TUNDO
TUNDIN
TUNSTE
TUNCE
TUNCLK
D.GND
D.IN
D.DND
D.OUT
D.GND
I/P-SEL
NC
AV0
AV1
AV2
AUMUTE
TU-ON
DGND
L
A.GND
R
A.GND
R.IN
A.GND
L.IN
10V
10V
CN004 17P
INIT
PGMUTE
NSMUTE
DGND
SCDT
SHIFT
DGND
LAT1
LAT2
LAT3
DGND
EN
DIAG
HPSW
DGND
RELAY
HPMUTE
RESET
RELAY
STPOW
DVDPW
POWER-AD
AGND
I2C_SIO
ZIVARESET
I2C_SCL
I2C_CTRL
(Page 52)
(Page 49)
(Page 47)
(Page 46)
(Page 56)
(Page 52)
(Page 49)
(Page 44)

7-22. SCHEMATIC DIAGRAM – DVD Board (10/10) –
(Page 48)
(Page 47)
(Page 48)
(Page 44)
(Page 46)
(Page 47)
(Page 44)
(Page 48)
(Page 48)
(Page 40)
(Page 48)
6.5V
DGND
DA05V
DA05V
DGND
DA03V
DGND
D5V
+1.8V
D5V
D3.3V
DGND
A3.3V
6.5V
E5.6V
12V
M12V
D3.3V
A5V
A3.3V
MGND
DGND
DGND
MGND
M12V
IC001
µPC2933T-E2
C012
0.1
+3.3V REGULATOR
O I
G
(10/10)
+3.3V REGULATOR
IC005
µPC2933T-E2
O I
G
C017 C016 C015
0.1 0.1 0.1
+5V REGULATOR
IC003
µPC2905T-E1
O I
G
+5V REGULATOR
IC002
µPC2905T-E1
O I
G
C001
C008 C010
C011
100
0.1
6.3V
0.1
0.1
C013
0.1
+5V REGULATOR
IC004
µPC2905T-E1
O I
G
Q004
2SB906(TE16L)
R067
470
Q003,004
B+ SWITCH
Q003
DTC124EKA
-T146
C014 C018
0.1 0.1
R066
1k
R011
1k
Q001
DTC124EKA
-T146
49
C020
220
4V
IC006
µPC2918T-E1
Q002
2SB906(TE16L)
R079
1k
+1.8V REGULATOR
O I
G
R009
1k
Q001,002
B+ SWITCH
C003
100
6.3V
49
C019
0.1
FB010
C005
220
4V
FB012
FB014
FL006
FB013
C004
47
16V
FL004
FL005
FB008
FB009
C006
47
16V
FB011
FL003
DVDPW
FB007
RESET
STPOW
POWER-AD
(Page 48)
AGND
RELAY
R017 0
R019 2.2k
R021 0
R023 0
R060 C007
0 10p
R059 0
R051 0
TP063
TP064
TP065
TP066
TP067
TP068
TP069
TP070
TP071
TP072
TP073
TP048
12V
6.5V
DVD3.3V
E5.6V
RESET
P.CONT1
P.CONT2
A/D
MGND
DGND
DGND
AGND
P.CONT3
HCD-S550/S880
CN008
13P
(Page 66)

HCD-S550/S880
• Semiconductor
Location
Ref. No. Location
D101 K-6
D102 K-6
D103 J-6
D104 J-6
D105 J-6
D106 J-6
D181 D-2
D190 H-9
D191 H-9
D192 E-2
D331 E-10
D332 E-8
D333 E-7
D334 E-6
D335 E-4
D336 E-3
D341 G-10
D342 H-8
D343 H-7
D344 H-5
D345 H-4
D346 H-3
D361 F-9
D362 F-7
D363 F-6
D364 F-5
D365 F-4
D366 F-2
IC300 C-9
IC303 B-9
IC305 C-8
IC308 C-5
IC310 C-3
Q101 K-8
Q102 K-8
Q103 K-8
Q104 K-7
Q105 K-7
Q106 K-7
Q107 J-8
Q108 J-7
Q109 J-7
Q110 J-7
Q111 J-7
Q112 J-7
Q113 K-8
Q114 K-6
Q191 B-6
Q192 E-2
7-23. PRINTED WIRING BOARD – AMP Section (1/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
G
H
I
J
K
(CHASSIS)
1 2 3 4 5 6 7 8 9 10
AMP BOARD (COMPONENT SIDE)
D181
R193
C415
C416
Q192
D192
R192
R191
(CHASSIS)
C194
50
D366
C192
R350
C409
C410
C408
D336
D346
C473
R475
R349
IC310
R490
50
R348
R312
R491
C399
R311
R485
C483
R310
C394
D365
R343
R309
R308
C387
C391
FB314
D345
FB315
C388
D335
C390
R335
C378
D364
C372
C373
R333
D344
FL300
FB305
IC308
R330
D334
C368
Q114
R398
Q191
C355
D363
D106
D105
R113
R399
D104
D103
R321
D102
C352
D101
FB308
D343
FB307
C348
C349
Q112
C359
D333
Q110
Q106
C358
C106
Q111
Q109
Q105
R320
C351
D362
Q108
Q104
R112
C103
C344
C337
Q107
D342
R111
Q103
R307
R190
IC305
C105
R305
Q102
D332
R110
R104
Q113
C331
R109
R108
C104
R106
C102
Q101
IC303
1
C190
R102 R103
C328
2
C327
R105
R101
D361
R107
R304
D190
3
C101
FB304
IC300
D191
C306
FB301
C191
3 1
4 5
C307
R302
C308
R370
C432
L302
D331
FB300
L300
X300
D341
1-685-079-
12
(12)

7-24. PRINTED WIRING BOARDS – AMP Section (2/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
G
H
I
J
K
L
FRONT
R
CENTER
REAR
R
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
J401
SPEAKER
(FRONT VIEW)
9 10
– +
5 6
– +
1 2
– +
11 12
– +
7 8
– +
3 4
– +
FRONT
L
WOOFER
REAR
L
IMPEDANCE
USE
WOOFER 3Ω
EXCEPT
WOOFER 4Ω
C161
C141
L401
C182
J401
C181
C452
C168
C148
C170
C150
C149
C169
C146
C166
C145
C165
C172
C143
C163
D311
AMP BOARD (CONDUCTOR SIDE)
C301
C302
C303
IC301
C451
C162
C142
C152
C325
C167
C147
C164
C144
C326
D351
C151
C171
C312
2
C324
C111
1
20 19
R301
C311
C316
C131
D321
C121
C454
C334
C319
C318
C313
C317
IC304
FB303
C400
C401
C304
L402
C323
C197
C189
D312
C320
D352
2
C453
C310
C112
1
20 19
C122
D322
GP301
M
CN302
2
IC302
1 3
C132
C356
C343
C341
C345
C407
C333
L403
C455
M301
(FAN)
C309
C329
R325
C332
C342
IC306
C336
C350
C456
Q190
C457
L404
C376
51
C397
C362 C381
C353
C364
C417
C354
IC307
C458
L405
C374
C383
C423
C375
CN301
IC309
C459 C460
51
C392
C389
L406
C461
C413
C405
C395
C403
C425
C396
IC311
C133
C134
C135
C136
FB309 FB312 FB313 FB318 FB320
C406 C414
C418
C424
C426
(CHASSIS)
D313
D353
2
C330
C113
1
20 19
R313
C123
D323
E
C363
C365
R397
R396
R395
D314
D354
2
R315
C114
1
20 19
R316
C124
C382
D324
R317
C
C384
R318
D315
(Page 38)
DVD BOARD
CN001
R319
R322
D355
2
C481
R334
C115
C402
D325
C404
C462
CN305
C493
C490
C492
D326
C484
C422
C411
C420
C427
C412
C300
CN300
C474
R483 R484
R470
R482
C393
1
20 19
R480
R336
C125
R337
C482
R481
R338
R339
IC401
C491
R340
D
D316
R341
D356
C116
2
(Page 38)
DVD BOARD
CN004
R342
1
20 19
C472
R474
R344
C419
R471
R346
C126
C139
FB311
R473
R347
R300
C421
C471
FB306
FB310
R472
CN309
D197
1-685-079-
POWER BOARD
CN904
12
(12)
M
(Page 65)
HP BOARD
HP BOARD
FB805
CN900
5
1
L903 C991
R991
R902
FB804
Q900
(COMPONENT SIDE)
(CONDUCTOR SIDE)
R992
L902
FB803
J900
PHONES
E
Q901
R900
L900
R903
C904
C902
L901
C903
C992
R901
1-685-083-
E
J900
1-685-083-
HCD-S550/S880
11
(11)
11
(11)
• Semiconductor
Location
Ref. No. Location
D197 C-12
D311 F-4
D312 H-6
D313 H-7
D314 H-8
D315 H-9
D316 H-11
D321 H-5
D322 H-6
D323 H-7
D324 H-9
D325 H-10
D326 H-11
D351 E-4
D352 E-6
D353 E-7
D354 E-8
D355 E-10
D356 E-11
IC301 E-4
IC302 B-6
IC304 F-6
IC306 F-7
IC307 F-8
IC309 F-10
IC311 F-11
IC401 K-11
Q190 B-7
Q900 J-15
Q901 I-15

HCD-S550/S880
7-25. SCHEMATIC DIAGRAM – AMP Section (1/2) – • See page 67 for Waveforms. • See page 72 for IC Block Diagrams.
J900
PHONES
(Page 66)
M301
(FAN)
(Page 48)
(Page 48)
(CHASSIS)
C903
0.01
L901
33µH
C904 C902
0.01 0.1
CN300
5P
CN302
2P
CN301
12P
CN305
17P
Q900
DTC343TK
R900
4.7k
Q901
DTC343TK
L900
33µH
32V
32V
PGND
PGND
12V
PGND
12V
INIT
PGMUTE
NSMUTE
DGND
SCDT
SHIFT
DGND
LAT1
LAT2
LAT3
DGND
6.5V
6.5V
DGND
DGND
D1
D2
D3
BCKO
LRCKO
DGND
SCK
DGND
EN
DIAG
HPSW
DGND
RELAY
HPMUTE
MUTING
R903
4.7k
MUTING
R902
68
C992
0.047
C991
0.047
R901
68
C300
2200
35V
R397
180
R139
0
R315 100
R316 100
R317 100
R318 100
R319 100
R322 47
R346 0
R347 0
D197
MA111-TX
C194
0
R991
0
FB803
FB805
FB804
R992
0
(1/2)
180
R396
FB305
10UH
FL300
R339 470
R340 470
R341 470
R342 470
R344 470
R395
180
C329
220
10V
C330
0.01
D1
D2
D3
BCKO
LRCKO
SCK
R334 470 INIT
R336 470 PGMUTE
R338 0 NSMUTE
L903
L902
SCDT
SHIFT
LAT1
LAT2
LAT3
EN
DIAG
C309
0.1
CN900
5P
HP.L-CH
GND
HP.R-CH
HP-MUTE
HP-SW
+5V REGULATOR
IC302
BA05FP-E2
I O
G
D2
BCKO
LRCKO
SCK
IC303
BA033FP-E2
C320
C310 C323 C324
0.01
100
0.01 0.01
10V
(CHASSIS)
FB307
R308
1.0k
C336
100 C352
10V 0.01
C373
0.01
CN309
5P
HP-SW
HP-MUTE
HP.R-CH
GND
HP.L-CH
INIT
D181
MA111-TX
+3.3V REGULATOR
I O
G
FB311 0
C192
0
C493
47
35V
C492
0.1
FB310
0
FB306
0
PGMUTE
Q190
2SB1013
R309 1k
R310 2.2k
R311 1k
R312 1k
R313 1k
NSMUTE
SCDT
SHIFT
52
C325
100
10V
C490
R491
100
10k
16V
LAT2
R490 R485
10k 24k
R481
22k
R398 R399
47k 4.7k
C348
0.01
IC308
CXD9634Q
C390
0.01
C491 R475 C473
0.1 24k 100p
C483
100p
R480 R482
22k 22k
Q191
DTC124EKA
Q190,191
FAN MOTOR CONTROL
STREAM PROCESSOR
C481 R483
120p 22k
R471 C471
22k 120p
52
C391
0.01
Q192
DTC124EKA
POWER ON
MUTING
C349
0.01
HEADPHONE AMP
IC401
NJM4580E(TE2)
FB308
R192
22k
C474
470
16V
R473
22k
GND
C350
100
10V
R321
100
C355
0.1
C368
0.1
R330
100
R333
100
C372
0.1
C378
0.1
R335
100
R191
2.2k
D192
UDZSTE-
1713B
R193
0
R470
22k
R472
22k
C472
100p
R474
33k
VCC
R484
33k
C482
100p
C484
470
16V
FB304
C326
47
6.3V
C409
0.01
C327
0.01
C344
0.01
C358
0.01
FB315
C392
100
10V
C393
0.01
INIT
BCKO
LRCKO
INIT
D3
SCK
D1
BCKO
LRCKO
SCK
PGMUTE
PGMUTE
NSMUTE
NSMUTE
SCDT
SCDT
SHIFT
SHIFT
LAT1 LAT3
C306
0.01
R325
22
C387
0.01
R301
1.0k
STREAM PROCESSOR
IC305
CXD9634Q
R337
1.0k
STREAM PROCESSOR
IC310
CXD9634Q
C415 C416
0.01
0.01
C388
0.01
C311
0.01
FB301
C312
100
10V
R304
100
C328
0.1
C331
0.1
R305
100
R307
100
C337
0.1
C351
0.1
R320
100
C359
0.01
FB314
C389
100
10V
R343
100
C394
0.1
R348
100
C399
0.1
R349
100
C408
0.1
R350
100
C410
0.1
A19
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
(Page 53)

7-26. SCHEMATIC DIAGRAM – AMP Section (2/2) – • See page 67 for Waveform. • See page 72 for IC Block Diagrams.
(Page
52)
A1
A2
A3
A4
A5
A6
A7
A8
A9
A19
A10
A11
A12
A13
A14
A15
A16
A17
A18
FB300 L300
0
R190
100k
C302
0.01
C191
1
50V
C301
22
6.3V
IC300
MC74VHC1G04
X300 R370
49.152MHz 680
C307
5p
(2/2)
R302
1M
D190 C190
MA111-TX 2.2
D191
MA111-TX
BUFFER
VCC
GND
R300 10k
C308
0.001
L302 C432
10.0p
EN
DIAG
FB303
C318 C319
100
10V
0.1
FB309
C345
C343
100
0.1
10V
FB312
C362
C365
100
0.1
10V
FB313
FB318
C405
100
C404
0.1
10V
FB320
D351 C303
SFPL 0.022
C317
100
50V
D352
SFPL
C342
100
50V
C401
C316 C313
100
0.01 0.1
10V
C334
0.022
D361
SFPL
D362
SFPL
D353 C356
D363
SFPL 0.022
SFPL
C363 C353 C417
C364
C414
100
100
0.01 0.1
0.1
50V
10V
D354
SFPL
D355
SFPL
C403
100
C402 C395
0.01 0.1
50V
D356
SFPL
C376 D364
0.022 SFPL
C397 D365
0.022 SFPL
C413
0.022
C425
100
10V
C422 C420
C427
C421
C419 C411
100
100
100
10V
0.1
50V
0.01 0.1
10V
D366
SFPL
C304
0.022
C333
0.022
C354
0.022
C375
0.022
C396
0.022
C412
0.022
D311
LI116
D321
LI116
C400 C111 C121 C131
0.1 0.01 0.1 0.1
C407
C341 C332
C406 C112 C122
0.01 0.1
100
0.1 0.01 0.1
10V
C113 C123
0.01 0.1
C381
C383
C423
C384 C382 C374 C418 C114 C124
100
0.1
100
0.01 0.1
100
0.1 0.01 0.1
10V
50V
10V
C424 C115 C125
0.1 0.01 0.1
C426 C116 C126
0.1 0.01 0.1
D312
LI116
D331
P6SMB39AT3
D341
P6SMB39AT3
D332
P6SMB39AT3
D322 D342
LI116 P6SMB39AT3
C132
0.1
D313
LI116
D323
LI116
C133
0.1
D314
LI116
D324
LI116
C134
0.1
D315
LI116
D325
LI116
C135
0.1
D316
LI116
D326
LI116
C136
0.1
POWER AMP
IC301
CXD9702L
POWER AMP
IC304
CXD9702L
POWER AMP
IC306
CXD9702L
D333
P6SMB39AT3
D343
P6SMB39AT3
POWER AMP
IC307
CXD9702L
D334
P6SMB39AT3
D344
P6SMB39AT3
POWER AMP
IC309
CXD9702L
D335
P6SMB39AT3
D345
P6SMB39AT3
POWER AMP
IC311
CXD9702L
D336
P6SMB39AT3
D346
P6SMB39AT3
L401
10µH
L402
10µH
L403
10µH
L404
10µH
L405
10µH
L406
10µH
C452
1
C451
1
C453
1
C454
1
C455
1
C456
1
C457
1
C458
1
C460
1
C459
1
C461
1
C462
1
53
C162
0.1
C161
0.1
C164
0.1
C163
0.1
C168
0.1
C167
0.1
C166
0.1
C165
0.1
C170
0.1
C169
0.1
C172
0.1
C171
0.1
C142
0.01
C141
0.01
C144
0.01
C143
0.01
C148
0.01
C147
0.01
C146
0.01
C145
0.01
C150
0.01
C149
0.01
C152
0.01
C151
0.01
53
R111
100k
C106
1
R112
100k
R106
100k
C103
1
R105
100k
R107
100k
C104
1
R108
100k
R101
100k
C101
1
R102
100k
Q112
2SC2412
Q111
2SC2412
Q106
2SC2412
Q105
2SC2412
Q107
2SC2412
Q108
2SC2412
Q102
2SC2412
Q101
2SC2412
Q103,104
OVER LOAD
DETECT
R103 C102 R104 R110 C105
100k 1 100k 100k 1
Q111,112
Q113
DTC124EKA
D102
MA111-TX
D106
MA111-TX
D103
MA111-TX
D104
MA111-TX
D101
MA111-TX
R113
100k
C197
0.1
C189
1000p
C181
3300p
C182
3300p
Q114
DTA114EK
R109
100k
Q103 Q104 Q110 Q109
2SC2412 2SC2412 2SC2412 2SC2412
OVER LOAD
DETECT
Q105,106
OVER LOAD
DETECT
Q107,108
OVER LOAD
DETECT
Q101,102
OVER LOAD
DETECT
Q113,114
PROTECT
DETECT
Q109,110
OVER LOAD
D105
DETECT
MA111-TX
GP301
(CHASSIS)
J401
SPEAKER
FRONT L
FRONT R
WOOFER
CENTER
REAR L
REAR R
HCD-S550/S880

HCD-S550/S880
7-27. PRINTED WIRING BOARD – I/O Section (1/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
1 2 3 4 5 6
I/O BOARD
(COMPONENT SIDE)
54
54
1-685-078-
11
(11)

7-28. PRINTED WIRING BOARDS – I/O Section (2/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
VIDEO
C292
C288
R269
R278
C285
1 2 3 4 5 6 7 8
I/O BOARD
J202
MONITOR
OUT
E
S VIDEO
(DVD ONLY)
Q210
C284
R286
4 3
2 1
R267
C244
C294
C293
E
C276
Q214
R270
C279
(CONDUCTOR SIDE)
C295
IC208
C296
IC204
C248
C277 C280
C283
C286
C274
C290
IC209
C249
C291
IC204
OPTICAL
DIGITAL IN
L202
C299
C282
C287
C301
L209
R255
3 1
C297
C275
C281
C300
C268
C278
VIDEO IN
R254
C289
C298
C330
C269
R259
R268
C302
R273
3
4
IC206
PR/CR PB/CB Y
1
6
IC207
C265
C231 C240
R253
R249
R246
C242
R302
C245
C202
C272
J206
L AUDIO IN R
C243
C267
R243
L207
C218
R223
R301
R300
E
R256
CN203
Q206
Q205
R218
E
F
55
C241
C222
C235
R236
C239 R247
R252
C226
R242
R233
R238
C228 R226 C224
R224
R219
VIDEO 2
COMPONENT
VIDEO OUT
C225
C227
DVD BOARD
CN003
(Page 38)
IC202
R222
R303
VIDEO
OUT
R231
R266
R217
C220
55
C221
L206
R251 C234
C229
Q208 R227
Q207
R244
R250
R225
VIDEO
IN
E
R265
C237
C223
R221
C609
R230
R204
R214
R215
C211
C233
R220
C230
C608
C238
R237
R205
J205
VIDEO 1
AUDIO
OUT
L R
E
R201
R202
R241
C201
Q201
C210
Q220
C209
CN202
R290
R228
R294
C216
R293
Q221
C232
R229
R207
R206
R292
R295
R232
X201
C207
R213 D203
R216
Q223
Q222
R291
L205
E
E
D204
(AEP, UK, CIS)
E
E
E
C214
D201
R203
C203
C208
AUDIO
IN
L R
C213 C215
E
D202
C206
C236
C217
R211
R235
16 9
1
DVD BOARD
CN002
(Page 38)
AEP, UK, CIS
KR, CH
8
CN201
R210
IC201
C205
R212
R208
C204
R209
1-685-078-
CN205
11
(11)
AM
COAXIAL
FM
75Ω
FM/AM TUNER
PACK
SUPPLIED WITH
THE ASSEMBLED
BLOCK
SEL BOARD
CNP205
1
2
S801
SCAN SELECT
INTERLACE SELECTABLE
HCD-S550/S880
• Semiconductor
Location
Ref. No. Location
1-685-085-
D201 C-6
D203 D-6
IC201 C-6
IC202 C-4
IC204 B-2
IC206 C-3
IC207 D-3
IC208 C-2
IC209 D-2
Q201 C-5
Q205 C-4
Q206 C-4
Q207 B-5
Q208 B-5
Q210 D-1
Q214 D-1
Q220 C-5
Q221 C-5
Q222 D-6
Q223 D-5
11
(11)

HCD-S550/S880
7-29. SCHEMATIC DIAGRAM – I/O Section (1/2) – • See page 67 for Waveform. • See page 72 for IC Block Diagrams.
VIDEO 2
VIDEO 1
AUDIO OUT R
AUDIO IN R
AUDIO OUT L
AUDIO IN L
VIDEO OUT
VIDEO IN
AUDIO IN R
COMPONENT
VIDEO OUT
Y
AUDIO IN L
COMPONENT
VIDEO OUT
PB/CB
VIDEO IN
COMPONENT
VIDEO OUT
PR/CR
J205
6P
(CHASSIS)
J206
6P
C1
R300 0
R303 0
R231
75
R251
75
C229 2200p
C231 2200p
C244 2200p
C2
C3
Z1
R254
75
C233
1000p
C245 10 50V
C243 10 6.3V
R235 C236 R229 C234
47k 220p 100k 1000p
R237
6.8k
R243
6.8k
R249
6.8k
C237
22
25V
C239
22
25V
R246 C240
47k 220p
C241
22
25V
R253 C242
47k 220p
R238
10k
R247
R244
10k
R250
10k
R252 10k
R236
10k
R232 C238 R241 C235 R242 R233
6.8k 220p 47k 22 10k 10k
R230
100k
25V
Z2
Z3
Z4
(1/2)
10k
22 16V
C221
0.1
C223
C226
0.1
(AEP,UK,CIS)
VDD
X2
X1
X
X0
X3
A
B
Y0
Y2
Y
Y3
Y1
INH
VEE
VSS
R203 R204 R202 R205 C203
68k 47k 1k 100k 0.1
C228 0.1
C207
4.7
50V
C204
560p
C201
330p
AUDIO INPUT
SELECTOR
IC202
MC14052 BDR2
C225
0.1
Q208
DTC343TK-T-146
MUTING
Q201
2SC2492K-T
-146-QR
BUFFER
IC201
BU1924F-E2
CMP T2
VSS3 T1
VSS1 VSS2
VDD1 VDD2
MUX XI
VREF XO
RDATA NC
QUAL RCLK
RDS DECODER
R219 100
R224 100
C209
47
16V
R223
10k
Q206
DTC124EK
INVERTER
(Page 57)
56
D201
R201
4.7k
UDZ-TE17
-4.3B
X201
4.332MHz
Q207
DTC343TK-T-146
MUTING
R218 R217 R225
10k 33k 33k
56
R206
470k
R207
270
C220
22
25V
R292
1k
C210
R294
22
330
25V
R214
6.8k
R222 R226
33k 33k
Q205
DTC124EK
INVERTER
C205
0.01
C206
51p
C208
56p
C215
1
R290
470k
C216
1
C214
0.01
Q220 Q221
2SC2412K 2SC2412K
AMP
AMP
C224 22 25V
C222 22 16V
R291
470k
R295
330
C213
0.01
C217
220
16V
L205
R293
1k
C211
22
25V
R215
6.8k
C230
10
R227
50V
1k
R228 C232
1k 10
50V
D204
0
R220 100k
C608 6800p
C609 6800p
R221 100k
C227 22 16V
D203 D202
MA111-TX 0
Q222
2SA1037AK
B+ SWITCH
R216
4.7k
Q223
DTC124EKA
B+ SWITCH
R266
10k
R256
10k
L206
10µH
Z5
Z7
R213
47k
Z8
Z9
TD
CK
DO
CE
DI
R212 220
R208 220
R209 220
R211 220
R210 220
Z10
DO
DI
TD
CE
CK
L-CH
CN201
11P
TUNED
R-CH
10V
A.GND
FM-DET
A.GND
CK
DO
CE
DI
CN205
2P
CN202
29P
RDATA
RCLK
TUNDO
TUNDIN
TUNSTE
TUNCE
TUNCLK
D.GND
D.IN
D.DND
D.OUT
D.GND
I/P-SEL
NC
AV0
AV1
AV2
AUMUTE
TU-ON
DGND
L
A.GND
R
A.GND
R.IN
A.GND
L.IN
10V
10V
CNP205
2P
FM/AM TUNER
PACK
SUPPLIED WITH
THE ASSEMBLED
BLOCK
(Page 48)
S801
SCAN SELECT
SELECTABLE
INTERLACE
COAXIAL
FM
75Ω
AM

7-30. SCHEMATIC DIAGRAM – I/O Section (2/2) – • See page 72 for IC Block Diagrams.
MONITOR
OUT
VIDEO
S VIDEO
OPTICAL
DIGITAL IN
VIDEO 2
J202
2P
R
VCC
GND
OUT
OPTICAL
RECEIVER
IC204
TORX179L
C1
C2
C3
R269 C288
75 0.1
R267
75
R270
75
R259
75
R268
75
R273
75
C292 220 10V
C293 100 10V
(2/2)
C295 470 10V
C296 100 16V
C297 220 10V
C298 100 10V
C299 100 16V
C300 22 25V
C301 100 16V
C302 22 25V
Z1
C249
0.1
C248
22
25V
R255
100
IC208
MM1568
R301 0
R302 0
VIDEO AMP, 75Ω DRIVER
VCC2
VCC1
COUT
CIN
GND2
MUTE1
VOUTB
VIN
VOUTA
YC MIX
GND2
YIN
YOUTB
BIAS
YOUTA
GND1
GND2
TRAP
CYOUTB
GND1
CYOUTA
NC
GND2
CYIN
CBOUTB
CLP
CBOUTA
CBIN
GND2
MUTE2
CROUTB
CRIN
CROUTA
GND2
C279
0.01
C286
0.1
C283
1 50V
C280
1 50V
L202
10µH
C277
22
25V
D4
D2
D1
Z2
57
L209
10µH
R278
10k
C218
47
10V
C202
220
10V
C276
10
50V
C294
0.1
Q210
DTA114EKA
R286
10k
C285
0.1
C281
0.1
C275
0.1
D5
57
C284 100 16V
C269 0.1
C268 100 16V
C278
10
6.3V
Q210,214
WIDE SWITCH
GND
(Page 56)
VDD
GND
IC206
MM1510
SAG
OUT
VCC
C291
10
50V
PS
GND
IN
75Ω DRIVER
C287
0.1
C282
0.1
GND
D4
C274
10
6.3V
C290
0.1
Q214
DTC144EKA
VIDEO
SELECTOR
IC209
NJM2285V
C289
10
50V
C330 100p
Z3
Z4
VIDEO INPUT
SELECTOR
GND
IN1
OUT
SW1
VDD
IN2
D3
IN3
SW2
C265
10
6.3V
IC207
NJM2235V
C267
100
6.3V
Z5
L207
10µH
C272
0.1
Z7
Z8
Z9
Z10
R265
10k
D1
D2
D4
D5
D3
NC
CR
CB
HCD-S550/S880
I/P SW
GND
D5V
D5V
GND
VIDEOY
GND
VIDEOC
GND
VIDEOV
VS/WIDE
CN203
14P
(Page 44)

HCD-S550/S880
7-31. PRINTED WIRING BOARDS – DC-DC CONVERTER Section – • See page 33 for Circuit Boards Location.
A
B
C
D
I
POWER SW
BOARD
CNP911
(Page 65)
1 2 3 4 5 6 7 8 9
DDCON BOARD
CN807
FB802
R838
CN814
(COMPONENT SIDE)
DDCON BOARD (CONDUCTOR SIDE)
• Semiconductor
Location
Ref. No. Location
D806 C-6
D807 C-5
D808 C-6
D809 C-5
D810 C-6
D812 D-3
Q803 C-4
Q804 C-5
FB800 R841
T801
FB801 R850
R855 C822
CN803 CN802
R843 R842
C823
CN804
R874 D810
Q804
2 2
G
DVD BOARD
CN005
(Page 38)
J
FL BOARD
CNP801
(Page 62)
POWER LED BOARD
1 2
CNP809
R804
D812
1-685-077-
D812
(STANDBY)
11
(11)
C821
L801
E
Q803
E
C826
58
DC-DC CONVERTER
58
D809
D807
D806
D808
C820
1-685-076-
11
(11)
L
1-685-076-
CONTROL BOARD
CNP808
CN805
11
(11)
(Page 60)
K
FL BOARD
CN806
(Page 62)

7-32. SCHEMATIC DIAGRAM – DC-DC CONVERTER Section –
(Page 47)
(Page 66)
(Page 61)
CN814
17P
CN807
2P
CN804
6P
GND
6.5V
GND
ENB
ENA
KEY1
KEY0
KEY2
FDATA
FCS
SIRCS
FCLK
DGND
DIMM
DGND
5V
STBY-LED
STBY-SW
R804
470
D812
SLR325VR-T31
STANDBY
FB802
CNP809 CN802
2P 2P
C1
C2
C3
C4
C5
B1
B2
B3
B4
B5
B6
B7
B7
B5
B3
B4
B1
B2
B6
FB801
C821
10
10V
R850
3.9k
L801
47µH
Q803
2SD1624
-T-TD
OSC
Q804
2SD1624
-T-TD
OSC
0.01
C826
C3
C1
C4
C2
C5
59
T801
DC/DC
CONVERTER
FB800
59
R838
47
R841 100
R842 100
R843 100
D806
MA111-TX
D807
MA111-TX
D808
MA111-TX
D809
MA111-TX
C820
0.01
D810
UDZS-TE17
-6.2B
C822
0.1
C823
R874 R855
10
35V
33k 100
CN803
6P
CN805
4P
(Page 63)
(Page 63)
HCD-S550/S880

HCD-S550/S880
7-33. PRINTED WIRING BOARDS – CONTROL Section – • See page 33 for Circuit Boards Location.
VOL BOARD
C800
S800
ROTARY ENCODER
3
VOLUME
CN820
C801
1
1-685-084-
11
(11)
CONTROL BOARD
CONTROL BOARD
+
NEXT
3
1
S803
R860
S805
PRESET −
CNP813
(COMPONENT SIDE)
R849 R864
PREV
(CONDUCTOR SIDE)
S821
S822
S823 S824 S825
FIELD, +
R837
SOUND, −
R844 DISPLAY BAND FUNCTION
R873
60
60
R800
R809
S804 S802
S801
R802
R801
R803
1-685-074-
11
(11)
1-685-074-
S806
CN808
1
6
11
(11)
L
DDCON BOARD
CN804
(Page 58)

7-34. SCHEMATIC DIAGRAM – CONTROL Section –
S800
ROTARY
ENCODER
VOLUME
ENB
GND
ENA
C800
0.01
C801
0.01
(Page 59)
CN820
3P
CNP808
6P
GND
CNP813
3P
R873
220
R809
220
R864
4.7k
R837
330
R844
470
R849
680
S821 S822 S823 S805 S803
SOUND
-
S806
FIELD
+
61
R860
1k
DISPLAY PREV NEXT
R800 R801 R802 R803
330 470 680 1k
S804 S802 S824
BAND
S801
+ PRESET -
S825
FUNCTION
61
HCD-S550/S880

HCD-S550/S880
7-35. PRINTED WIRING BOARD – FL Board – • See page 33 for Circuit Boards Location.
K
DDCON
BOARD
CN805
(Page 58)
FL BOARD (COMPONENT SIDE)
4
1
CNP806
FL BOARD (CONDUCTOR SIDE)
FL801
FLUORESCENT INDICATOR TUBE
62
62
IC802
C819
R840
C817
C818
R839
C816
R815
C815
1-685-082-
1 3
IC801
C814
C808
C813
11
(11)
1-685-082-
CNP801
1
6
11
(11)
J
DDCON
BOARD
CNP803
(Page 58)

7-36. SCHEMATIC DIAGRAM – FL Board – • See page 67 for Waveform. • See page 72 for IC Block Diagram.
(Page 59)
(Page 59)
CNP801
6P
CNP806
4P
P1
P2
P3
P4
P5
IC801
NJL62H400A-1
R839
10k
P6
REMOTE
CONTROL
RECEIVER
P7
P8
R815
47
P9
C813
0.1
P10
C814
0.001
P11
P12
C808
0.01
P13
P14
C815 C816
100p 0.001
P15
P16
P17
P37
P18
P36
P19
C817
0.001
P1
P20
P2
P21
R840
3.3k
C818
47p
P3
P22
C819
0.01
P4
FL801
FLUORESCENT INDICATOR TUBE
P23
P5
P24
63
P6
P25
P7
P26
P8
P27
P9
P28
P10
1G
63
P29
P11
2G
P30
P12
3G
P31
P13
4G
P32
P14
5G
P33
P15
6G
P34
P16
7G
P35
P17
8G
P36
P18
9G
P37
P19
10G
P20
11G
12G
P21
12G
11G
P22
P35
10G
P23
P34
9G
P24
P33
8G
P25
P32
7G
P26
P31
6G
P27
P30
5G
P28
P29
4G
3G
2G
1G
FL DRIVER
IC802
MSM9202-05
HCD-S550/S880

HCD-S550/S880
64
7-37. PRINTED WIRING BOARD – POWER Section (1/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
64
1 2 3 4 5
POWER BOARD (COMPONENT SIDE)
1-685-080-
21
(21)

7-38. PRINTED WIRING BOARDS – POWER Section (2/2) – • See page 33 for Circuit Boards Location.
A
B
C
D
E
F
H
DVD BOARD
CN008
(Page 38)
(CHASSIS)
M
AMP BOARD
CN300
(Page 51)
1 2 3 4 5 6 7 8 9
POWER BOARD (CONDUCTOR SIDE)
CN904
CN903
C943
EB903
R933
D912
IC902
Q902
Q906
C937
C915
E
E
C941
C924
D904 Q911
R918
R931
R932
R927
R926
C922
L904
Q910
L905
L906
L907
L908
L911
Q912
L910
L901
C931
R928
Q901
3 1
E
E
E
E
E
Q914
R910
R914
A
K
E
R906
Q904
IC909
Q905
C933
R916
R917
C926
R920
R919
(MX, TW)
Q903
PC901
R902
E
R925
IC903
L903
C921
D932
R903
D906
R907
D907
R911
D933
R904
C936
1 5 1 5
1 3
E
C
R936
L902
C934
D916
R913
C919
R924
R929
C914
D905
IC908
D921
D914
IC906
C901
D931
C930
1 5
C918
C923
T901
POWER
TRANSFORMER
C904
R901
R915
L909
D917
D990
R939
R942
C935
R937
C916
IC901
C905
R935
R912
Q990
R940
Q991
R923
C932
1 5
E E
IC904
C938
Q992
D911
C920
D908
R938
C927
R941
R943
R921
R922
A K A
D913
IC905
C925
C928
D915
C929
R909
R934
(EXCEPT MX, TW)
C913
(EXCEPT MX, TW)
C910
R905
R908
D919
TH901
C946
C911
C909
D920
EB901
(EXCEPT MX, TW)
C902
LF901
LF902
(MX, TW)
C912
C939
CN902
1 2
C903
D902
R930
65
F901
(CHASSIS)
1-685-080-
EB902
(CHASSIS)
21
(21)
65
POWER SW BOARD
(COMPONENT SIDE)
21
1-685-081- (21)
POWER SW BOARD
(CONDUCTOR SIDE)
S901
POWER
CN900
1 2
2
CN901
1
CNP911
1-685-081-
(AC IN)
21
(21)
HCD-S550/S880
I
DDCON
BOARD
CN807
(Page 58)
• Semiconductor
Location
Ref. No. Location
D902 D-5
D904 E-1
D905 F-3
D906 E-2
D907 F-2
D908 F-4
D911 C-3
D912 D-2
D913 B-4
D914 B-3
D915 A-4
D916 B-2
D917 A-3
D919 D-4
D920 D-5
D921 B-3
D931 E-3
D932 E-2
D933 F-2
D990 A-3
IC901 F-3
IC902 D-2
IC903 A-2
IC904 B-3
IC905 A-4
IC906 C-3
IC908 A-3
IC909 F-1
PC901 E-2
Q901 D-2
Q902 D-1
Q903 D-2
Q904 E-2
Q905 F-2
Q906 E-1
Q910 D-2
Q911 E-2
Q912 E-2
Q914 E-2
Q990 A-3
Q991 B-3
Q992 B-4

HCD-S550/S880
7-39. SCHEMATIC DIAGRAM – POWER Section – • See page 72 for IC Block Diagrams.
(AC IN)
CNP911
2P
S901
POWER
C900
CN900 0.1
CN901
2P 275V
2P
(CHASSIS)
(CHASSIS)
(CHASSIS)
(Page 59)
CN902
2P
EB902
EB901
EB903
∗ F901
5A/125V (MX,TW)
T3.15AL/250V (EXCEPT MX,TW)
F901
∗
IC901
C946
0.1
C943
0.1
(EXCEPT MX,TW)
POWER CONTROL
R901
220
C904
220p
C903
0.1
LF901 LF902 250V
C902
C909
0.1
2200p
250V
250V
R930
C910 2200p 250V
3.3M
∗ D902
RBV-604 (MX,TW)
RBV-606 (EXCEPT MX,TW)
C911
2200p ∗ C912
250V
1000 200V (MX,TW)
390 450V (EXCEPT MX,TW)
STR-F6238 (MX,TW)
STR-F6267 (EXCEPT MX,TW)
(MX,TW)
C937
0.047
C905
0.0047
R936
150k
C901
4.7
50V
C914
47
35V
D905
1SS133T-77
R902 R903 R904
0.15
1W
C939
1000p
250V
∗ R905
33k 3W (MX,TW)
68k 3W (EXCEPT MX,TW)
0.15
1W
0.22
1W
D933
11EQS10
D907
1SS133T-77
R911
3.9k
C919
∗
R912
1.5k
Q914 Q912
2SC2412 2SC2412
R927
1.0k
D902
∗
RECT
Q912,914
OSC
D919
10E6N
TH901
D920
10E6N
D932
MTZJ-T-77-22B
Q905
2SD1616
+20V
REGULATOR
C938
0.001
R905
∗
R918 R931
2.7k 2.7k
C912
∗
R907
4.7k
C915
0.1
R934
100k
R908
68k
3W
R909
47k
2W
D906
11EQS10
∗ C916
C916
2200p 1.5kV (MX,TW)
470p 2kV (EXCEPT MX,TW)
∗
D931
MTZJ-T-77-20B
C913
3300p
630V
∗ C919
470p (MX,TW)
1000p (EXCEPT MX,TW)
VCC
(EXCEPT MX,TW)
GND
R926
100k
C922
0.001
D908
SARS03
(EXCEPT MX,TW)
R913
2.2
R910
4.7k
BUFFER
IC909
BA10358F
C941
47
16V
T901
POWER
TRANSFORMER
ISOLATOR
PC901
IC TLP421
Q904
2SC2412K
+6.8V
REGULATOR
66
D911
FML-22S
RECT
C921 2200 35V
C923 2200 35V
C918 0.1
R906
10k
D904
MTZJ-T-77
-6.8B
C920
4700p
630V
R919 R920
15k 4.7k
R917 C926
2.7k 100p
R914
2.7k
D990
MA111-TX
R941
10k
Q992
2SC2412
VOLTAGE
DETECT
R943
1.8k
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
66
IC902
SE-B2
R916
SWITCHING
L901
10µH
REF
C
GND
1.2k (MX,TW)
1k (EXCEPT MX,TW)
D912
MTZJ-T-77
-6.2B
Q901
DTC114EKA
Q901,903
POWER
ON/OFF
CONTROL
R938
4.7k
R940 R939
15k 1k
Q991
2SC2412
R928
22k
Q990
2SB1640
R942
1k
C924
2200
35V
VIN
SW OUT
Q990,991
B+ SWITCH
C936
0.1
Q903
DTC114EKA
GND
VOS
ON/OFF
R924
560
Q902
DTC114EKA
D917 11ES2
C928
C927
2200
0.1
35V
VIN
SW OUT
C934
0.1
+6.5V REGULATOR
IC903
SI-8050S
+5.6V REGULATOR
IC905 BA05T
I O
G
R925 180
L902 100µH
IC908
SI-8120JF
D921
11EQS04-TA
1B
IC906
SI-8033JF
R915
180
L909
100µH
C933
D914 C930
D916
1000
FMB-G16L
10V
0.1
FMB-G16L
D915
11ES2
GND
VOS
ON/OFF
Q902,906
POWER
ON/OFF
CONTROL
D913
MA111-TX
R921
22k
C929 C925
100 1
10V 50V
+12V REGULATOR
+3.3V
REGULATOR
R933 R932
22k 22k
Q906
DTC114EKA
VCC
IN
GND
NC
RESET
R922
6.2k
VIN
SW OUT
R937 1k
C935
1000
16V
Q910
DTC114EKA
IC904
M51945BL
R923
10k
R935 C932
100k 0.1
L907 L908 L911
10µH 10µH 10µH
Q910,911
POWER
ON/OFF
CONTROL
VOLTAGE
DETECT
R929
10
L903 C931
100µH
1000
10V
Les composants identifiés par une marque 0 sont
critiques pour la sécurité. Ne les remplacer que
par une pièce portant le numéro spécifié.
GND
VOS
ON/OFF
Q911
DTC114EKA
L904 10µH
L905 10µH
L906 10µH
L910 10µH
CN904
5P
32V
32V
PGND
PGND
12V
CN903
14P
12V
NC
6.5V
DVD3.3V
E5.6V
RESET
P.CONT1
P.CONT2
A/D
MGND
DGND
DGND
AGND
P.CONT3
(Page 52)
(Page 49)

• Waveforms
– RF Board –
1 IC001 1 (DVDRFP)
2 IC001 el (TE)
Approx.
400 mVp-p
Approx.
100 mVp-p
Approx.
50 mVp-p
Approx.
1.2 Vp-p
154 ns
qj IC401 ua (XTAI)
29.5 ns
3 IC001 r; (FE) qd IC401 ra (TE)
qk IC701

HCD-S550/S880
wa IC701

eh IC206

HCD-S550/S880
ta IC602 qd (LRCK)
ts IC602 qf (BCK)
70
325 ns
20.8 µs
6.3 Vp-p
5.9 Vp-p
– AMP Board –
ia IC305, 308, 310 rf (BCK)
325 ns
is IC305, 308, 310 rg (LRCK)
20.8 µs
id IC305, 308, 310 yf (XFSIIN)
81 ns
if IC305 ud (FSOCKO)
20.8 µs
ig IC305 uj (XFSOOUT)
20 ns
3.6 Vp-p
3.7 Vp-p
3.4 Vp-p
3.7 Vp-p
3.5 Vp-p
ih IC300 4
20 ns
3.3 Vp-p

– I/O Board –
ya IC201 qf (X0)
ys IC208 qk, ql (CrOUT)
(NTSC Color Bars Play)
H
yd IC208 wa, ws (CbOUT)
(NTSC Color Bars Play)
H
231 ns
H
3.4 Vp-p
1.4 Vp-p
1.4 Vp-p
yf IC208 wf, wg (CYOUT), wj, wk (YOUT)
(NTSC Color Bars Play)
2.1 Vp-p
yg IC208 e;, ea (VOUT)
(NTSC Color Bars Play)
H
yh IC208 ed(COUT)
(NTSC Color Bars Play)
H
2.5 Vp-p
1.7 Vp-p
– DDCON Board –
ua Q803, 804 (Collector)
– FL Board –
504 ns
9.1 µs
oa IC802 tk (OSCO)
HCD-S550/S880
18.6 Vp-p
2.2 Vp-p
71

HCD-S550/S880
• IC Block Diagrams
– RF Board –
IC001 CXD1881AR
DVDRFP
DVDRFN
72
A2
B2
C2
D2
CP
CN
D
1
2
3
4
5
6
7
8
9
C 10
B 11
A 12
CD D 13
CD C 14
CD B 15
CD A 16
RFDC
RFSIN
64 63 62 61 60 59 58 57 56
55 54 53 52 51 50 49
INPUT
SEL ATT
4
MUX ATT
2
INPUT
IMPEDANCE
SEL
BUFFER
3
FROM
S-PORT
17
GCA
MUX
CD/DVD
D
C
B
A
EQ
3
FROM
S-PORT
GCA
VC
3
FROM
S-PORT
COMPARATOR
GCA
3
FROM
S-PORT
GCA
W/LPF
3
FROM
S-PORT
GCA
4
FROM
S-PORT
VCI FOR SERVO INPUT
VC = VPB/2
DUAL APC
LD H/L
FROM S-PORT
A+D
+
+
+
+
B+C
B+D
+
+
INPUT
BIAS
2
INPUT
IMPEDANCE
SEL
+
–
2
SIGDET
PHASE
DETECTOR
PHASE
DETECTOR
+
–
SUM
AMP
+
+
A+C
+
+
AGC
CLAMP &
ENVELOPE
LEVEL
DAC
–
+
+
+
–
–
GCA
4
FROM
S-PORT
APC SEL
DVD/CD
PROGRAMMABLE
EQUALIZER
FILTER
DIFFERENTIATOR
AGCO
TOPHOLD
TOPHOLD
MUX GCA GCA LPF
+
–
CD/DVD CP/CN
LOW
IMPEDANCE
GCA LPF
HYSTERESISTER
& OFFSET
FROM S-PORT
INTERNAL
FDGHG
OUTPUT
INHIBIT
FROM S-PORT
+
–
FULL WAVE
RECTIFER
OFFSET
CANSEL
4
FROM
S-PORT
OFFSET
CANSEL
5
FROM
S-PORT
OFFSET
CANSEL
6
FROM
S-PORT
GCA
AGC CHARGE
PUMP
SERIAL
PORT
REGISTER
MNTR
CONTROL
18 19 20 21 22 23 24 25 26 27 28 29 30
31 32
CD F
CD E
VPB
VC
DVDLD
CDLD
ATOP
ATON
AIN
AIP
DVDPD
CDPD
VNB
LDON
VPA
MIRR
RFAC
BYP
GCA LPF
GCA SUB
CEFDB
OFFSET
CANSEL
5
FROM
S-PORT
BCA
DET
MIRR
COMPARATOR
PEAK/BOTTOM
HOLD
MP
MB
TOP
HOLD
FROM
S-PORT
2
DAC
CE ATT
CEPOL
HOLDEN
48 SDEN
47 SDATA
46 SCLK
45 V33
41 CE
GCA 40 FE
GCA
3
FROM
S-PORT
COMPA-
RATOR
+
–
INPUT GAIN
FROM S-PORT INPUT
2 IMPEDANCE
FROM S-PORT
2
MLPF
DIN
DIP
FNP
FNN
INPUT
BUFFER
FAST ATTACK
CONTROL
SIGNALS
TO EACH
BLOCK
MIN
3
VNA
LPF ATT
POL SEL
BUFFER
SEL
TE
RST
V33 FOR
OUTPUT
BUFFER
PI
FE
TE
CE
V25
V125
V25/3
MEV
FOR SERVO
OUTPUT
V25/2
LINKEN
AGCO
SINK CURRENT
FROM S-PORT
GCA SEL
2
AGC
HOLD
PH
BOTTOM
ENVELOPE
MUX
MEVO
RX
PH
44 LCP
43 LCN
42 MNTR
39 TE
38 PI
37 V25
36 V125
35 TPH
34 DFT
33 LINK

– RELAY Board –
IC701, 711 BA6956AN
TSD
CONTROL LOGIC
1 2 3 4 5 6 7 8 9
VREF
OUT2
RNF
– DVD Board –
OUT1
IC203 BR9040F-D-E2
WC
VM
GND
8 7 6 5
VCC
1 2 3 4
R/B
8bit
4096bit
EEPROM ARRAY
ADDRESS
DECODER
8bit
ADDRESS
BUFFER
16bit
R/W
AMP
16bit
DATA
REGISTER
VCC
FIN
HIGH VOLTAGE
GENERATOR
GND
DO
RIN
WRITE
DISABLE
POWER
SUPPLY
VOLTAGE
DETECTOR
CS
DI
COMMAND
REGISTER
COMMAND DECODE
CONTROL CLOCK
GENERATION
SK
HCD-S550/S880
IC215 SN74ALVCH16841DGGR
1OE 1 OE LE 56 1LE
1D1
1D2
GND
1D3
1D4
VCC
1D5
1D6
GND
1D7
1D8
1D9
1D10
2D1
2D2
2D3
GND
2D4
2D5
2D6
VCC
2D7
2D8
GND
2D9
2D10
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
LATCH
LATCH
55
54
1Q1
1Q2
GND
1Q3
1Q4
VCC
1Q5
1Q6
GND
1Q7
1Q8
1Q9
1Q10
2Q1
2Q2
2Q3
GND
2Q4
2Q5
2Q6
VCC
2Q7
2Q8
GND
2Q9
2Q10
2OE 28 OE LE 29 2LE
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
73

HCD-S550/S880
IC302 BR24C08F-E2
A0
A1
A2
GND
74
1
2
3
4
8bit
ADDRESS
DECODER
HIGH–VOLTAGE
GENERATOR
IC401 CXD3068Q
DVDD2
ASYE
MD2
DOUT
LRCK
PCMD
BCK
EMPH
XTSL
DVSS2
XTAI
XTAO
SOUT
SOCK
XOLT
SQSO
SQCK
SCSY
SBSO
EXCK
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
DVDD0
DIGITAL
OUT
XRST
D/A DIGITAL
INTERFACE
MUTE
8bit
2048bit EEPROM ARRAY
SLAVE/ WORD
ADDRESS REGISTER
START
STOP
CONTROL CIRCUIT
DATA
POWER SUPPLY
VOLTAGE DETECTOR
CPU
INTERFACE
XLAT
VPCO
60
CLOCK
GENERATOR
32K
RAM
SERVO
AUTO
SEQUENCER
CLOK
OSC
8bit
DATA
REGISTER
ACK
ERROR
CORRECTOR
SUBCODE
PROCESSOR
SERVO INTERFACE
SENS
V16M
VCTL
BIAS
AVDD1
PCO
FILI
FILO
CLTV
8
7
6
5
EFM
DEMODULATOR
Vcc
TEST
SCL
SDA
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2PO
SCOR
C4M
WDCK
DVSS0
COUT
MIRR
AVSS1
RFAC
ASYI
ASYO
AVDD0
IGEN
AVSS0
ADIO
RFDC
CE
TE
59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
DIGITAL
PLL
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
ASYMMETRY
CORRECTOR
FOCUS
SERVO
DSP
TRACKING
SERVO
DSP
SLED
SERVO
DSP
A/D
CONVERTER
OPERATIONAL
AMPLIFIER &
ANALOG SWITCH
FOCUS
PWM
GENERATOR
TRACKING
PWM
GENERATOR
SLED
PWM
GENERATOR
DIGITAL
CLV
PROCESSOR
MIRR, DFCT,
FOK
DETECTOR
40
39
38
37
36
35
34
28
27
26
25
24
23
22
21
SE
TE
VC
TES1
TEST1
DVSS1
FRDR
33 FFDR
32 TRDR
31 TFDR
30 SRDR
29 SFDR
DVDD1
FSTO
SSTP
MDP
LOCK
PWMI
FOK
DFCT

IC602 PCM1800E/2K
SINGLE-END
DEFERENTIAL
CONVERTER
LIN
REFERENCE
V REF 1
REFCOM
V REF 2
DIGITAL ∑
MODULATOR
SINGLE-END
DEFERENTIAL
CONVERTER
IC604 IDT71V016S15PH-AUTL
A4
A3
A2
A1
A0
CS
1
2
3
4
5
6
I/O 0 7
I/O 1 8
I/O 2 9
I/O 3 10
VDD 11
VSS 12
I/O 4 13
I/O 5 14
I/O 6 15
I/O 7 16
WE 17
A15 18
A14 19
A13 20
A12 21
NC 22
AGND
VCC
C PR
C NR
C PR
C NR
DIGITAL ∑
MODULATOR 1/64
DECIMATION
FILTER
&
RIN
VDD
LOW-CUT
FILTER
CLOCK/
TIMING CONTROL RESET/
POWER CONTROL
RSTB
SERIAL I/O
INTERFACE
&
MODE/FORMAT
CONTROL
1 2 3 4 5 6 7 8 9 10 11 12
DGND
SYSCLK
BYPASS
FMT0
FMT1
DOUT
BCK
LRCK
24 23 22 21 20 19 18 17 16 15 14 13
CHIP ENABLE
BUFFER
WRITE ENABLE
BUFFER
LOW
BYTE
I/O
BUFFER
ROW/COLUMN
DECODER
64K x 16
MEMORY
ARRAY
SENSE AMP
&
WRITE
PRIVER
HIGH
BYTE
I/O
BUFFER
OUTPUT ENABLE
BUFFER
BYTE ENABLE
BUFFER
MODE0
MODE1
FSYNC
44 A5
43 A6
42 A7
41 OE
40 BHE
39 BLE
38 I/O 15
37 I/O 14
36 I/O 13
35 I/O 12
34 VSS
33 VDD
32 I/O 11
31 I/O 10
30 I/O 9
29 I/O 8
28 NC
27 A8
26 A9
25 A10
24 A11
23 NC
HCD-S550/S880
75

76
HCD-S550/S880
IC606 LC89056W-E
IC608 AK4382AVT-E2
38
37
36
23
24
1 2 3 4 5
44
8 9 10
46
17
22
21
20
30
35 25
26
27
28
29
32
33
34
16
45
13
14
15
47
40
41
48
CL
39
XSEL
CE
DI
EMPHA
AUDIO
DISEL
DOUT
DINO
DINI
DIN2
6
DGND
7
DVDD
11
AVDD
12
AGND
DOSEL0
R
VIN
LPF
CKSEL0
XSTATE
18 DGND
19 DVDD
XIN
XOUT
XMCK
XSEL
31
DGND
DO
CSFLAG
F0
F1
F2
VF
ERR9P
BPSYNC
ERROR
DATAO
DOSEL1
CKOUT
BCK
LRCK
CKSEL1
MODE0
MODE1
42
DGND
43
DVDD
XMODE
TIMING
MICROCOMPUTER
INTERFACE
SAMPLING
FREQUENCY
C BIT
DETECT
PA/PB
DETECT
LOCK
DETECT
INPUT
CIRCUIT
DATA
DEMODULATOR
PLL
X’ TAL
PDN
CSN
CCLK
CDTI
MCLK 1
BICK
SDTI
LRCK
2
3
4
5
6
7
8
VSS
VDD
DZFR
DZFL
13
14
15
16
AOUTL–
AOUTL+
11
12
SCF
∆∑
MODULATOR
8x
INTERPOLATOR
AOUTR–
AOUTR+
9
10
SCF
∆∑
MODULATOR
8x
INTERPOLATOR
AUDIO
DATA
INTERFACE
CLOCK
DIVIDER
DE–EMPHASIS
CONTROL
µP
INTERFACE

IC612 CXD9633Q
VDD6
DSBCKF
DSIFL 63
DSIFR 64
DSICT 65
DSISW 66
DSISL 67
DSISR 68
DIRDSCK1 69
DIRDSCK2 70
SELRAM
XMTPCM
XMTDSD
75
SEL8FS 76
SELEXT 77
SYNC 78
INIT 79
VSS7
61
62
71
SELFIR1 72
SELFIR2 73
74
80
FL
FR
CT
SW
SL
SR
1
VDD1
INTERNAL
CONTROL
2
3
MSHIFT
MLATCH
MDATA
VSS6
4
60
CPU I/F
CONTROL
EXIMCK
5
DSGAIN
EXID1
EXID2
EXILRCK
EXIBCK
59 58 57 56 55
CLOCK
GENERATOR
&
TIMING
CONTROL
CK
CKB
WCK
RAM
29bit x 240
FIR FILTER
&
DOWN
SAMPLING
UNIT
6
7
SELSBSW
SELSBR
BCK
TEST3
54
SR
SL
SW
CT
FR
FL
COEF. SELECT
8
SELMCU
9
MONTOR
TEST2
53
TEST/MONITOR
CONTROL
ROM
24bit x 720
10
VSS1
MCK
52
INTERNAL
CLOCK
FL
FR
CT
PCM
SW MUTE
SL
SR
CKB
11
DSBCKB
VDD5
VSS5
51 50
2FS
EXT.
CLOCK
SELECT
SR
SL
CKOUT
49
TEST1
48
8FS
SW/SB
SELECT
SW
DSD MUTE
DSD
SW/SB
SELECT
F2FLREX1
F2CSWEX2
47 46
2FS I/F
2FS
EXT.
DATA
SELECT
CT
FR
FL
12 13 14 15 16 17 18 19
DSOSR
DSOSL
DSOBR
DSOBL
DSOSW
DSOCT
DSOFR
DSOFL
F2SLR
45
20
VSS2
F2LRCK
F2BCK
44 43
8FS
I/F
FMT2FS
42
VDD4
41
HCD-S550/S880
38 SELDH1
37 SELDH2
36 F8FL
35 F8FR
34 F8CT
33 F8SW
32 F8BL
31 VDD3
30 VSS3
29 F8BR
28 F8SL
27 F8SR
WCK
26 F8WCK
BCK
25 F8BCK
CK
40 VSS4
39 DIR2CK
24 FMT8WCK
23 FMT8FS
22 DIR8CK
21 VDD2
77

HCD-S550/S880
IC706 MSM51V18165F-60TSKR1
VSS
VCC
IC808 MSM56V16160F-8TK7R1
78
VCC
DQ16
DQ15
DQ14
DQ13
1 2 3 4 5 6 7 8 9 10
DQ1
DQ2
DQ3
DQ4
VSS
VCC
DQ12
DQ11
DQ10
DQ9
50 49 48 47 46 45 44 43 42 41
NC
40 – 36 35 34 33
VSS
VCC
OUTPUT
BUFFER
OUTPUT
BUFFER
DQ16
DQ15
DQ1
DQ2
VSSQ
VSSQ
INPUT
BUFFER
INPUT
BUFFER
DQ5
DQ6
DQ7
DQ8
I/O
CONTROLLER
I/O
CONTROLLER
NC
I/O
SELECTOR
LCAS
UCAS
WE
RAS
OE
SENSE
AMPLIFIER
MEMORY
CELLS
ON CHIP
VBB GENERATOR
COLUMN
ADDRESS
BUFFERS
COLUMN
DECODERS
WORD
DRIVERS
NC
NC
A9
A8
A7
A6
A5
A4
A0
A1
A2
A3
VSS
32 31 30 29 28 27 26
ROW
DECODERS
ON CHIP
VCC VCC
VCC
IVCC GENERATOR
DQ14
DQ13
DQ3
DQ4
VCCQ
VCCQ
DQ12
DQ11
DQ5
DQ6
VSSQ
VSSQ
DQ10
DQ9
DQ7
DQ8
11 – 16
VCCQ
1 2 3 4 5 6 7 8 9 10 11 12 13
VCCQ
17 18
TIMING
GENERATOR
50 49 48 47 46 45 44 43 42 41 40 39 38
37 36 35 34
OUTPUT
BUFFERS
READ
DATA
REGISTER
INPUT
DATA
REGISTER
INPUT
BUFFERS
PROGRAMING
REGISTER
LATENCY
&
BURST
CONTROLLER
I/O
CONTROLLER
TIMING
REGISTER
NC
BANK
CONTROLLER
UDQM
CLK
CKE
14 15 16 17 18
LDQM
WE
CAS
RAS
CS
REFRESH
CONTROL
CLOCK
NC
33
SENSE
AMPLIFIER
MEMORY
CELLS
INTERNAL
ADDRESS
COUNTER
VCC
ROW
ADDRESS
BUFFERS
19 20 21 22 23 24 25
INTERNAL
COLUMN
ADDRESS
COUNTOR
WORD
DRIVERS
COLUMN
ADDRESS
BUFFERS
COLUMN
DECODERS
ROW
DECODERS
VCC
ROW
ADDRESS
BUFFERS
A9
A8
A7
A6
A5
A4
VSS
32 31 30 29 28 27 26
INTERNAL
ROW
ADDRESS
COUNTOR
19 20 21 22 23 24 25
A11
A10
A0
A1
A2
A3
VCC

IC814 TC7WH157FK (TE85R)
A 1
B 2
Y
3
GND 4
EN G
A Y
B
Y
8
117
116
5
VCC
ST
SELECT
Y
– AMP Board –
IC301, 304, 306, 307, 309, 311 CXD9702L
VBBA
VBOOTA
VDRVA
VDDA
GNDA
INA
ENA
DIAGA
OUTA
1
2
3
4
5
6
7
8
9
SA 10
VBBB 11
VBOOTB 12
VDRVB 13
VDDB 14
GNDB 15
INB 16
ENB 17
DIAGB 18
OUTB 19
SB 20
VBBA
VDRVA
LOW SIDE
LEVEL SHIFT
PRE
DRIVER
VBBB
VDRVB
LOW SIDE
LEVEL SHIFT
PRE
DRIVER
CROSS OVER
DELAY
CROSS OVER
DELAY
HIGH SIDE
LEVEL SHIFT
PRE
DRIVER
HIGH SIDE
LEVEL SHIFT
PRE
DRIVER
UNDER
VOLTAGE
LOCK–OUT
VBBA
VBBB
UNDER
VOLTAGE
LOCK–OUT
HCD-S550/S880
VDRVA
VDRVB
THERMAL
SHUT DOWN
PROTECTOR
CIRCUIT
FILTER
−
−
+
THERMAL
SHUT DOWN
PROTECTOR
CIRCUIT
FILTER
−
−
+
+
+
VBBA
VBBB
79

HCD-S550/S880
IC305, 308, 310 CXD9634Q
OUTR2+
VDDR2+
VDDR2–
OUTR2–
VSSR2–
VSSR1–
OUTR1–
VDDR1–
VDDR1+
OUTR1+
VSSR1+
VWELR
VWELL
VSSL2+
OUTL2+
VDDL2+
VDDL2–
OUTL2–
VSSL2–
VSSL1–
OUTL1–
VDDL1–
VDDL1+
OUTL1+
80
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
VSSR2+
80
25
VSSL1+
PWM
/THROUGH
26
XSUBCL
27
XVDD
28
XFSOIN
29
XVSS
VSUBCR
79
30
VSUBX
XOVSS
78
∆∑
31
DVSS
XFSOUT
XOVDD
DVDD
FSOI
FSOCKO
SFLAG
OFLFLAG
OUTSEL
CLOCK
GENERATOR
(SECONDARY)
LINER
INTERPOLATOR
(2 TIMES)
DVSS
BFVSS
77 76 75 74 73 72 71 70 69 68 67 66 65
MCKSEL
CKCTL2
CKCTL1
GAIN
CONTROL
CKO3
CKO2
CKO1
32
MCKSEL
SYNC
XFSIIN
FSII
CLOCK
GENERATOR
(PRIMARY)
33
DVDD
RATE
CONVERTER
34 35
MODE1
MODE2
MCKSEL
SERIAL
CONTROL
36 37 38
SCLATCH
SCSHIFT
SCDT
XFSIIN
S g P
CKCTL2
CKCTL1
DOWN
SAMPLING
FILTER
FSII
SYNC
S g P
INIT/
MUTE
39
NSPMUTE
40
PGMUTE
64 XFSIIN
63 CXWCK
62 EXBCK
61 EXDATAR
60 EXDATAL
59 EXIOSEL
58 BFVDD
57 CKCTL2
56 CKCTL1
55 TEST2
54 TEST1
53 DSDCKIO
52 DSDCKSEL2
51 DSDCKSEL1
50 DSDL
49 DSDR
48 DSD64FS
47 DSD128FS
46 FSII
45 LRCK
44 BCK
43 DATA
42 SYNC
41 INIT

– I/O Board –
IC201 BU1924F-E2 (AEP, UK, Russian)
QUAL
RCLK
RDAT
VREF
NC
16 15
14
13 12 11 10 9
PLL
1187.5Hz
BIPHASE
DECODER
DEFFERENTIAL
DECODER
PLL 57kHz
RDS/ARI
COMPARATOR
8th SWITCHED
CAPACITOR
FILTER
ANTI-ALIASING
FILTER
1 2 3 4
5 6 7 8
IC206 MM1510
SAG
OUT
1
2
DRIVER
6 PS
5 GND
VCC 3
CLAMP
BIAS
4 IN
IC207 NJM2235V (TE2)
VIN 1
SW 1
VIN 2
SW 2
1
2
3
4
BIAS
MUX
BUFFER
ANALOG
VDD1
XO
CLOCK
8
7
6
5
VSS1
GND
V OUT
V+
VIN 3
VSS3
XI
CMP
VDD2
DIGITAL
VSS2
T1
T2
TEST
IC208 MM1568
4dB
4dB
IC202 MC14052 BDR2
2X0
2X2
2XCOM
2X3
2X1
INH
VEE
VSS
1
2
3
4
5
6
7
8
HCD-S550/S880
16
15
14
13
12
11
10
9
VDD
X2
X1
XCOM
VCC1 1
BIAS
34 VCC2
CIN 2
4dB LPF
2dB
75Ω
DRIVER
33 COUT
MUTE1 3
VIN 4
YC MIX 5
YIN 6
BIAS 7
GND1 8
NC 9
GND1 10
NC 11
CYIN 12
CLP 13
CbIN 14
MUTE2 15
CrIN 16
GND2 17
CLAMP
CLAMP
BIAS
CLAMP
BIAS
BIAS
BIAS
4dB
4dB
4dB
LPF
LPF
+
LPF
LPF
LPF
2dB
2dB
2dB
2dB
2dB
75Ω
DRIVER
75Ω
DRIVER
75Ω
DRIVER
75Ω
DRIVER
75Ω
DRIVER
X0
X3
A
B
32 GND2
31 VOUT
30 VSAG
29 GND2
28 YOUT
27 YSAG
26 GND2
25 CYOUT
24 CYSAG
23 GND2
22 CbOUT
21 CbSAG
20 GND2
19 CrOUT
18 CrSAG
81

82
HCD-S550/S880
– FL Board –
IC802 MSM9202-05GS-KDR1
58
56
57
59
61
60
63
64
62
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
6
5
7
8
9
10
11
12
13
14
15
16
17
18
19
20
COMMAND
DECODER
CONTROL
CIRCUIT
GRID
DRIVER
TIMING
GENERATOR1
TIMING
GENERATOR2
8bit
SHIFT
REGISTER
WRITE
ADDRESS
COUNTER
OSCILLATOR
DUTY
CONTROL
DIGIT
CONTROL
ADDRESS
SELECTOR
ADRAM
2bit x 16
DCRAM
8bit x 16
CGROM
35bit x 248
CGRAM
35bit x 8
AD
DRIVER
SEGMENT
DRIVER
OSC0
VFL
GND
OSC1
CS
RESET
DA
VDD
CP
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
4
3
AD2
AD1
2
1
P1
P2
39
38
PORT
DRIVER
COM15
COM16
COM13
COM14
COM11
COM12
COM9
COM10
COM7
COM8
COM5
COM6
COM3
COM4
COM1
COM2
READ
ADDRESS
COUNTER
53
54
55
51
52
49
50
47
48
45
46
43
44
41
42
40

– POWER Board –
IC901 STR-F6238 (Mexican, Taiwan), STR-F6267D (Except Mexican, Taiwan)
1
O.C.P
OVER
CURRENT
PROTECTOR
FEED BACK
INH1
INH2
2
GND
DRIVE
LATCH
3
D
OSC
OVER
VOLTAGE
PROTECTOR
THERMAL
SHUT DOWN
OVER LOAD
PROTECTOR
DRIVE
REGULATOR
START
REGULATOR
CURRENT
MIRROR
IC903 SI-8050S-LF1101 IC904 M51945BL
1
VIN
REGULATOR
OSC
+
–
+
–
OVER
CURRENT
PROTECTOR
RESET
COMPARATOR
ERROR AMP
OVER HEAT
PROTECTOR
VREF
2
SW OUT
3
GND
LATCH
&
DRIVER
IC906 SI-8033JF IC908 SI-8120JF
1
VIN
REGULATOR
ON/OFF
SOFT
START
OSC
RESET
OVER
CURRENT
PROTECTOR
COMPARATOR
+
–
ERROR AMP
+
–
OVER HEAT
PROTECTOR
VREF
2
SW OUT
3
GND
4
VOS
LATCH
&
DRIVER
4
VOS
5
S.S
5
ON/OFF
1
VIN
4
VIN
5
F.B
+
–
1 2 3 4
SUPPLY
VOLTAGE
REGULATOR
ON/OFF
SOFT
START
INPUT
OSC
1.25V
GND
RESET
NC
OVER
CURRENT
PROTECTOR
COMPARATOR
+
–
ERROR AMP
+
–
5
OUTPUT
HCD-S550/S880
OVER HEAT
PROTECTOR
VREF
2
SW OUT
3
GND
LATCH
&
DRIVER
4
VOS
5
ON/OFF
83

HCD-S550/S880
7-40. IC PIN FUNCTION DESCRIPTION
• DVD BOARD IC301 CXP973064-224R (MACHANISM CONTROLLER)
84
Pin No. Pin Name I/O Description
1 EEP SO O Not used
2 SDEN O Serial data enable signal output to DVD/CD RF amplifier
3
DOCTRL/
ISBTEST
O
Digital out on/off control signal output to the digital signal processor
“L”: digital out off, “H”: digital out on
4 EEP WC O Not used
5 EEP SI I/O Two-way data bus with the EEPROM
6 EEP RDY I EEPROM ready signal input from the DVD decoder
7 FCS JMP 1 O Focus jump 1 signal output to the motor/coil driver
8 FCS JMP 2 O Focus jump 2 signal output to the motor/coil driver
9 SENS CD I Internal status (SENSE) signal input from the digital signal processor
10 LOAD+ O Loading motor drive signal (loading in direction) output terminal Not used
11 LOAD– O Loading motor drive signal (loading out direction) output terminal Not used
12 XCS DVD O Chip select signal output to the DVD decoder
13 VSS — Ground terminal (digital system)
14 to 21 D0 to D7 I/O Two-way data bus with the DVD decoder
22 INIT0 DVD I Interrupt signal input from the DVD decoder
23 INIT1 DVD I Interrupt signal input from the DVD decoder
24 SCK DSD O Serial data transfer clock signal output to the DSD decoder
25 XRST DVD O Reset signal output to the DVD decoder “L”: reset
26 SCOR I Subcode sync (S0+S1) detection signal input from the digital signal processor
27 LAT CD O Serial data latch pulse signal output to the digital signal processor
28 LD ON O
Laser diode on/off control signal output to the DVD/CD RF amplifier
“L”: laser diode off, “H”: laser diode on
29 MIRR I Mirror signal input from the digital signal processor
30 COUT CD I Numbers of track counted signal input from the digital signal processor
31 INLIM I Detection signal input from limit in switch The optical pick-up is inner position when “H”
32 CS ZIVA O Chip select signal output to the DVD system processor
33 SI ZIVA I Serial data input from the DVD system processor
34 SO ZIVA O Serial data output to the DVD system processor
35 SCK ZIVA O Serial data transfer clock signal output to the DVD system processor
36 DRVIRQ O Interrupt request signal output to the DVD system processor
37 DRVRDY O Ready signal output to the DVD system processor
38 RST I System reset signal input from the DVD system processor “L”: reset
39 VSS — Ground terminal (digital system)
40 XTAL I System clock input terminal (20 MHz)
41 EXTAL O System clock output terminal (20 MHz)
42 VDD — Power supply terminal (+3.3V) (digital system)
43, 44 SLED A, SLED B O Sled motor drive signal output
45 JIT OFFSET O Output terminal for offset adjustment of APEO (

Pin No. Pin Name I/O Description
53 MUTE DSD O Muting on/off control signal output to the DSD decoder “H”: muting on
54 SQCK O Subcode Q data reading clock signal output to the digital signal processor
55 VSS — Ground terminal (digital system)
56 TRAY IN I Disc tray in detection signal input terminal Not used
57 TRAY OUT I Disc tray out detection signal input terminal Not used
58 GFS DVD I Guard frame sync signal input from the DVD decoder
59 MUTE CD O Muting on/off control signal output to the digital signal processor “H”: muting on
60 MUTE 2D O Muting on/off control signal output to the motor/coil driver “H”: muting on
61 SLED I Sled motor servo drive PWM signal input terminal
62 FG I Spindle motor control signal input
63 SP ON O Muting on/off control signal output to the motor/coil driver “H”: muting on
64 JIT I Jitter signal input
65 TE I Tracking error signal input from the DVD/CD RF amplifier
66 PI I Pull in signal input from the DVD/CD RF amplifier
67 FE I Focus error signal input from the DVD/CD RF amplifier
68 AVSS — Ground terminal (for A/D converter)
69 AVREF I Reference voltage input terminal (for A/D converter)
70 AVDD — Power supply terminal (+3.3V) (for A/D converter)
71 GFS CD I Guard frame sync signal input from the digital signal processor
72 SCLK CD O SENSE serial data reading clock signal output to the digital signal processor
73 TSD O Thermal shut down signal output to the motor/coil driver
74 FOK CD I Focus OK signal input from the digital signal processor
75 LOCK CD I GFS is sampled by 460 Hz “H” input when GFS is “H”
76 LDSEL O Laser diode selection signal output
77 SACD/DVD O SACD/DVD selection signal output “L”: DVD, “H”: SACD
78 I2C SIO I/O Communication data bus with the DVD system processor and system controller
79 I2C SCL I/O
HCD-S550/S880
Communication data reading clock signal input or transfer clock signal output with the DVD
system processor and system controller
80 RXD I Serial data input from the RS-232C (for check)
81 TXD O Serial data output to the RS-232C (for check)
82 SDCLK RF O Serial data transfer clock signal output to the DVD/CD RF amplifier
83 SDATA RF I/O Two-way data bus with the DVD/CD RF amplifier
84 XWR O Write strobe signal output to the DVD decoder
85 XRD O Read strobe signal output to the DVD decoder
86 (PWE) — Not used
87 VDD — Power supply terminal (+3.3V) (digital system)
88 VSS — Ground terminal (digital system)
89 to 96 A0 to A7 O Address signal output to the DVD decoder
97 DSAVE O Motor/coil driver power save control signal output terminal Not used
98 XDRST O Reset signal output to the digital signal processor and DSD decoder “L”: reset
99 EEP WP O Write protect signal output to the EEPROM
100 EEP CLK O Clock signal output to the EEPROM
85

HCD-S550/S880
• DVD BOARD IC401 CXD3068Q (DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR)
86
Pin No. Pin Name I/O Description
1 DVDD0 — Power supply terminal (+3.3V) (digital system)
2 XRST I Reset signal input from the mechanism controller “L”: reset
3 MUTE I Muting on/off control signal input from the mechanism controller “H”: muting on
4 DATA I Serial data input from the mechanism controller
5 XLAT I Serial data latch pulse signal input from the mechanism controller
6 CLOK I Serial data transfer clock signal input from the mechanism controller
7 SENS O Internal status (SENSE) signal output to the mechanism controller
8 SCLK I SENSE serial data reading clock signal input from the mechanism controller
9 ATSK I/O Input/output terminal for anti-shock Not used
10 WFCK O Write frame clock signal output to the DVD decoder
11 RFCK O RFCK signal output terminal Not used
12 XPCK O XPCK signal output terminal Not used
13 GFS O Guard frame sync signal output to the mechanism controller
14 C2PO O C2 pointer signal output to the DVD decoder
15 SCOR O Subcode sync (S0+S1) detection signal output to the DVD decoder and mechanism controller
16 C4M O 4.2336 MHz clock signal output terminal Not used
17 WDCK O Guard subcode sync (S0+S1) detection signal output to the DVD decoder
18 DVSS0 — Ground terminal (digital system)
19 COUT O Numbers of track counted signal output to the mechanism controller
20 MIRR O Mirror signal output to the mechanism controller
21 DFCT I/O Defect signal input/output terminal Not used
22 FOK O Focus OK signal output to the mechanism controller
23 PWMI I Spindle motor external control signal input terminal Not used
24 LOCK O GFS is sampled by 460 Hz “H” output when GFS is “H”
25 MDP O Spindle motor servo drive signal output to the DVD decoder
26 SSTP I Detection signal input from limit in switch The optical pick-up is inner position when “H”
27 FSTO O 2/3 divider output terminal Not used
28 DVDD1 — Power supply terminal (+3.3V) (digital system)
29 SFDR O Sled servo drive PWM signal (+) output
30 SRDR O Sled servo drive PWM signal (–) output
31 TFDR O Tracking servo drive PWM signal (+) output
32 TRDR O Tracking servo drive PWM signal (–) output
33 FFDR O Focus servo drive PWM signal (+) output
34 FRDR O Focus servo drive PWM signal (–) output
35 DVSS1 — Ground terminal (digital system)
36 TEST I Input terminal for the test
37 TES1 I Input terminal for the test
38 VC I Middle point voltage (+1.65V) input terminal
39 FE I Focus error signal input from the DVD/CD RF amplifier
40 SE I Sled error signal input from the DVD/CD RF amplifier
41 TE I Tracking error signal input from the DVD/CD RF amplifier
42 CE I Middle point servo analog signal input
43 RFDC I RF signal input from the DVD/CD RF amplifier
44 ADIO O Output terminal for the test Not used
45 AVSS0 — Ground terminal (analog system)
46 IGEN I Stabilized current input for operational amplifiers

Pin No. Pin Name I/O Description
47 AVDD0 — Power supply terminal (+3.3V) (analog system)
48 ASYO O EFM full-swing output terminal
49 ASYI I Asymmetry comparator voltage input terminal
50 RFAC I EFM signal input from the DVD/CD RF amplifier
51 AVSS1 — Ground terminal (analog system)
52 CLTV I Internal VCO control voltage input terminal
53 FILO O Filter output for master PLL
54 FILI I Filter input for master PLL
55 PCO O Charge pump output for master PLL
56 AVDD1 — Power supply terminal (+3.3V) (analog system)
57 BIAS I Asymmetry circuit constant current input terminal
58 VCTL I VCO control voltage input terminal for the wideband EFM PLL Not used
59 V16M O VCO oscillation output terminal for the wideband EFM PLL Not used
60 VPCO O Charge pump output terminal for the wideband EFM PLL Not used
61 DVDD2 — Power supply terminal (+3.3V) (digital system)
HCD-S550/S880
62 ASYE I Asymmetry circuit on/off control signal input terminal “L”: off, “H”: on Not used
63 MD2 I
Digital out on/off control signal input from the mechanism controller
“L”: digital out off, “H”: digital out on
64 DOUT O Digital audio signal output to the digital audio interface IC
65 LRCK O L/R sampling clock signal (44.1 kHz) output to the DVD decoder
66 PCMD O Serial data output to the DVD decoder
67 BCK O Bit clock signal (2.8224 MHz) output to the DVD decoder
68 EMPH O
“L” is output when playback disc is emphasis off
“H” is output when playback disc is emphasis on Not used
69 XTSL I
Input terminal for the system clock frequency setting
“L”: 16.9344 MHz, “H”: 33.8688MHz Fixed at “H” in this set
70 DVSS2 — Ground terminal (digital system)
71 XTAI I System clock input terminal (33.8688 MHz)
72 XTAO O System clock output terminal (33.8688 MHz) Not used
73 SOUT O Serial data output terminal Not used
74 SOCK O Serial data reading clock signal output terminal Not used
75 XOLT O Serial data latch pulse signal output terminal Not used
76 SQSO O Subcode Q data output to the mechanism controller
77 SQCK I Subcode Q data reading clock signal input from the mechanism controller
78 SCSY I Input terminal for resynchronism of guard subcode sync (S0+S1) Not used
79 SBSO O Subcode serial data output to the DVD decoder
80 EXCK I Subcode serial data reading clock signal input to the DVD decoder
87

HCD-S550/S880
• DVD BOARD IC607 CXD9617R (DIGITAL AUDIO SIGNAL PROCESSOR)
88
Pin No. Pin Name I/O Description
1 VSS — Ground terminal
2 XRST I Reset signal input from the system controller “L”: reset
3 EXTIN I Master clock signal input terminal Not used
4 FS2 I Sampling frequency selection signal input terminal Not used
5 VDDI — Power supply terminal (+2.6V)
6 FS1 I Sampling frequency selection signal input terminal Not used
7 PLOCK O Internal PLL lock signal output terminal Not used
8 VSS — Ground terminal
9 MCLK1 I System clock signal input terminal (13.5 MHz)
10 VDDI — Power supply terminal (+2.6V)
11 VSS — Ground terminal
12 MCLK2 O System clock signal output terminal (13.5 MHz)
13 MS I Master/slave selection signal input terminal “L”: slave, “H”: master (fixed at “L” in this set)
14 SCKOUT O Internal system clock signal output to the D/A converter and stream processor
15 LRCKI1 I L/R sampling clock signal (44.1 kHz) input from the digital audio processor
16 VDDE — Power supply terminal (+3.3V)
17 BCKI1 I Bit clock signal (2.8224 MHz) input from the digital audio processor
18 SDI1 I Front L-ch and R-ch audio serial data input from the digital audio processor
19 LRCKO O L/R sampling clock signal (44.1 kHz) output to the D/A converter and stream processor
20 BCKO O Bit clock signal (2.8224 MHz) output to the D/A converter and stream processor
21 VSS — Ground terminal
22 KFSIO I Audio clock signal (11.2896 MHz) input from the digital audio processor
23 SDO1 O Front L-ch and R-ch audio serial data output to the stream processor
24 SDO2 O Center and woofer audio serial data output to the stream processor
25 SDO3 O Rear L-ch and R-ch audio serial data output to the stream processor
26 SDO4 O Audio serial data output to the D/A converter
27 SPDIF O S/PDIF signal output terminal Not used
28 LRCKI2 I L/R sampling clock signal (44.1 kHz) input from the A/D converter
29 BCKI2 I Bit clock signal (2.8224 MHz) input from the A/D converter
30 SDI2 I Center and woofer audio serial data input from the digital audio processor
31 VSS — Ground terminal
32 HACN O Acknowledge signal output to the system controller
33 HDIN I Write data input from the system controller
34 HCLK I Clock signal input from the system controller
35 HDOUT O Read data output to the system controller
36 HCS I Chip select signal input from the system controller
37 SDCLK O Clock signal output terminal Not used
38 CLKEN O Clock enable signal output terminal Not used
39 RAS O Row address strobe signal output terminal Not used
40 VDDI — Power supply terminal (+2.6V)
41 VSS — Ground terminal
42 CAS O Column address strobe signal output terminal Not used
43 DQM O Output terminal of data input/output mask Not used
44 CS0 O Chip select signal output to the S-RAM
45 WE0 O Write enable signal output to the S-RAM

Pin No. Pin Name I/O Description
46 VDDE — Power supply terminal (+3.3V)
47 WMD1 I S-RAM wait mode setting terminal Fixed at “H” in this set
48 VSS — Ground terminal
49 WMD0 I S-RAM wait mode setting terminal Fixed at “L” in this set
50 PAGE2 O Page selection signal output terminal Not used
51 VSS — Ground terminal
52, 53 PAGE1, PAGE0 O Page selection signal output terminal Not used
54 BOOT I Boot mode control signal input terminal Not used
55 BTACT O Boot mode state display signal output terminal Not used
56 BST I Boot trap signal input from the system controller
HCD-S550/S880
57 MOD1 I
PLL input frequency selection signal input terminal
“L”: 384fs, “H”: 256fs (fixed at “H” in this set)
58 MOD0 I Mode setting terminal “L”: single chip mode, “H”: use prohibition (fixed at “L” in this set)
59 EXLOCK I PLL lock error and data error flag input from the digital audio interface IC
60 VDDI — Power supply terminal (+2.6V)
61 VSS — Ground terminal
62, 63 A17, A16 O Address signal output terminal Not used
64 to 66 A15 to A13 O Address signal output to the S-RAM
67 GP10 O L/R sampling clock signal (44.1 kHz) output to the D/A converter and stream processor
68 GP9 O Decode signal output to the system controller
69 GP8 I Bit 1 input terminal of channel status from the digital audio interface IC
70 VDDI — Power supply terminal (+2.6V)
71 VSS — Ground terminal
72 to 75 D15 to D12 I/O Two-way data bus with the S-RAM
76 VDDE — Power supply terminal (+3.3V)
77 to 80 D11 to D8 I/O Two-way data bus with the S-RAM
81 VSS — Ground terminal
82 to 85 A9, A12 to A10 O Address signal output to the S-RAM
86 TDO O Simple emulation data output terminal Not used
87 TMS I Simple emulation data input start/end detection signal input terminal Not used
88 XTRST I Simple emulation asychronous break input terminal Not used
89 TCK I Simple emulation clock signal input terminal Not used
90 TDI I Simple emulation data input terminal Not used
91 VSS — Ground terminal
92 to 97 A8 to A3 O Address signal output to the S-RAM
98, 99 D7, D6 I/O Two-way data bus with the S-RAM
100 VDDI — Power supply terminal (+2.6V)
101 VSS — Ground terminal
102 to 105 D5 to D2 I/O Two-way data bus with the S-RAM
106 VDDE — Power supply terminal (+3.3V)
107, 108 D1, D0 I/O Two-way data bus with the S-RAM
109, 110 A2, A1 O Address signal output to the S-RAM
111 VSS — Ground terminal
112 A0 O Address signal output to the S-RAM
113 PM I PLL reset signal input from the system controller “L”: reset
114 SDI3 I Rear L-ch and R-ch audio serial data input from the digital audio processor
89

HCD-S550/S880
90
Pin No. Pin Name I/O Description
115 SDI4 I Audio serial data input terminal Not used
116 SYNC I
Synchronous/asychronous selection signal input terminal
“L”: Synchronous, “H”: asynchronous (fixed at “H” in this set)
117 to 119 VSS — Ground terminal
120 VDDI — Power supply terminal (+2.6V)

• DVD BOARD IC701 CXD1882R (DVD DECODER)
Pin No. Pin Name I/O Description
1, 2 D5, D6 I/O Two-way data bus with the mechanism controller
3 VSS — Ground terminal (digital system)
4 D7 I/O Two-way data bus with the mechanism controller
5 A0 I Address signal input from the mechanism controller
6 VDD — Power supply terminal (+3.3V) (digital system)
7 A1 I Address signal input from the mechanism controller
8 VDD5V — Power supply terminal (+5V)
9 to 14 A2 to A7 I Address signal input from the mechanism controller
15 VSS — Ground terminal (digital system)
16 XWAIT O Wait signal output terminal Not used
17 XRD I Read strobe signal input from the mechanism controller
18 XWR I Write strobe signal input from the mechanism controller
19 XCS I Chip select signal input from the mechanism controller
20, 21 XINT0, XINT1 O Interrupt signal output to the mechanism controller
22 VDD — Power supply terminal (+3.3V) (digital system)
23 XHRS I Not used
24 HDB7 O Stream data signal output to the DSD decoder and DVD system processor
25 VSS — Ground terminal (digital system)
26 HDB8 O Error flag signal output to the DSD decoder and DVD system processor
27 HDB6 O Stream data signal output to the DSD decoder and DVD system processor
28 VDDS — Power supply terminal (+5V) (digital system)
29 HDB9 O Not used
30 HDB5 O Stream data signal output to the DSD decoder and DVD system processor
31 HDBA O Not used
32 HDB4 O Stream data signal output to the DSD decoder and DVD system processor
33 VSS — Ground terminal (digital system)
34 HDBB O Not used
35 HDB3 O Stream data signal output to the DSD decoder and DVD system processor
36 VDD — Power supply terminal (+3.3V) (digital system)
37 HDBC O Not used
38 VDDS — Power supply terminal (+5V) (digital system)
39 HDB2 O Stream data signal output to the DSD decoder and DVD system processor
40 HDBD O Not used
41 HDB1 O Stream data signal output to the DSD decoder and DVD system processor
42 VSS — Ground terminal (digital system)
43 HDBE O Not used
44 HDB0 O Stream data signal output to the DSD decoder and DVD system processor
45 HDBF O Not used
46 XSAK O Serial data effect flag signal output to the DSD decoder and DVD system processor
47 VDDS — Power supply terminal (+5V) (digital system)
HCD-S550/S880
48 XDCK O Serial data transfer clock signal output to the DSD decoder and DVD system processor
49 XSHD O Header flag signal output to the DSD decoder
50 VDD — Power supply terminal (+3.3V) (digital system)
51 REDY O Not used
52 VSS — Ground terminal (digital system)
91

HCD-S550/S880
92
Pin No. Pin Name I/O Description
53 XSRQ I
DVD mode: Serial data request signal input from the DVD system processor
SACD mode: Serial data request signal input from the DSD decoder
54 HINT O Not used
55 XS16 O Not used
56 HA1 I Not used
57 XPDI I/O Not used
58 VDDS — Power supply terminal (+5V) (digital system)
59, 60 HA0, HA2 I Not used
61 VSS — Ground terminal (digital system)
62, 63 HCS0, HCS1 I Not used
64 VDD — Power supply terminal (+3.3V) (digital system)
65 DASP I/O Not used
66 to 69 MDB0 to MDB3 I/O Two-way data bus with the D-RAM
70 VSS — Ground terminal (digital system)
71 MDB4 I/O Two-way data bus with the D-RAM
72 VDD5V — Power supply terminal (+5V)
73 to 75 MDB5 to MDB7 I/O Two-way data bus with the D-RAM
76 XMWR O Write enable signal output to the D-RAM
77 VDD — Power supply terminal (+3.3V) (digital system)
78 XRAS O Row address strobe signal output to the D-RAM
79, 80 MA0, MA1 O Address signal output to the D-RAM
81 VSS — Ground terminal (digital system)
82 to 87 MA2 to MA7 O Address signal output to the D-RAM
88 VDD — Power supply terminal (+3.3V) (digital system)
89 MA8 O Address signal output to the D-RAM
90 VSS — Ground terminal (digital system)
91 MA9 O Address signal output to the D-RAM
92 MNT1 O EEPROM ready signal output to the mechanism controller
93 MNT2 O Operation clock signal output for PSP physical disc mark detection to DSD decoder
94 XMOE O Output enable signal output to the D-RAM
95 XCAS O Column address strobe signal output to the D-RAM
96, 97 MDB8, MDB9 I/O Two-way data bus with the D-RAM
98 VSS — Ground terminal (digital system)
99 MDBA I/O Two-way data bus with the D-RAM
100 VDD — Power supply terminal (+3.3V) (digital system)
101, 102 MDBB, MDBC I/O Two-way data bus with the D-RAM
103 VDD5V — Power supply terminal (+5V)
104 to 106 MDBD to MDBF I/O Two-way data bus with the D-RAM
107 GFS O Guard frame sync signal output to the mechanism controller
108 VSS — Ground terminal (digital system)
109 APEO O Absolute phase error signal output
110 VDD — Power supply terminal (+3.3V) (digital system)
111 DASYO O RF binary signal output
112 GNDA5 — Ground terminal (analog system)
113, 114 ASF1, AFS2 — Filter connected terminal for selection the constant asymmetry compensation
115 DASYI I Analog signal input after integrated from the RF binary signal

Pin No. Pin Name I/O Description
116 RFDCC I Input terminal for adjusting DC cut high-pass filter for RF signal Not used
117 RFIN I RF signal input from the DVD/CD RF amplifier
118, 119 VCCA5, VCCA4 — Power supply terminal (+3.3V) (analog system)
120 VCOR1 — VCO oscillating range setting resistor connected terminal
121 VCOIN I VCO input terminal
122, 123 GNDA4, GNDA3 — Ground terminal (analog system)
124 LPF5 O Signal output from the operation amplifier from PLL loop filter
125 VC1 I Middle point voltage (+1.65V) input terminal
126, 127 LPF2, LPF1 I Inverted signal input to the operation amplifier from PLL loop filter
128, 129 VCCA3, VCCA2 — Power supply terminal (+3.3V) (analog system)
130 PD0 O Signal output from the charge pump for phase comparator
131 PDHVCC I Middle point voltage input terminal for RF PLL
132 FDO O Signal output from the charge pump for frequency comparator
133, 134 GNDA2, GNDA1 — Ground terminal (analog system)
135 SPO O Spindle motor control signal output
136 VC2 I Middle point voltage (+1.65V) input terminal
137 MDIN2 I Spindle motor servo drive signal input
138 MDIN1 I MDP input terminal
139 VCCA1 — Power supply terminal (+3.3V) (analog system)
140 CLVS O Control signal output for selection the spindle control filter constant at CLVS
141 VSS — Ground terminal (digital system)
142 MDSOUT O Frequency error output terminal of internal CLV circuit
143 VDD — Power supply terminal (+3.3V) (digital system)
144 MDPOUT O Phase error output terminal of internal CLV circuit
145 DEFECT I Defect signal input terminal Not used
HCD-S550/S880
146 GSCOR I Guard subcode sync (S0+S1) detection signal input from the digital signal processor
147 EXCK O Subcode serial data reading clock signal output to the digital signal processor
148 SBIN I Subcode serial data input from the digital signal processor
149 VSS — Ground terminal (digital system)
150 SCOR I Subcode sync (S0+S1) detection signal input from the digital signal processor
151 WFCK I Write frame clock signal input from the digital signal processor
152 VDD5V — Power supply terminal (+5V)
153 XRCI I RAM overflow signal input terminal Not used
154 VDDS — Power supply terminal (+5V) (digital system)
155 C2PO I C2 pointer signal input from the digital signal processor
156 VDD — Power supply terminal (+3.3V) (digital system)
157 DBCK O Bit clock signal (2.8224 MHz) output terminal Not used
158 BCLK I Bit clock signal (2.8224 MHz) input from the digital signal processor
159 DDAT O PCM data output terminal Not used
160 MDAT I Serial data input from the digital signal processor
161 VSS — Ground terminal (digital system)
162 DLRC O L/R sampling clock signal (44.1 kHz) output terminal Not used
163 LRCK I L/R sampling clock signal (44.1 kHz) input from the digital signal processor
164 XRST I Reset signal input from the mechanism controller “L”: reset
165 IFS0 I Interface selection signal input terminal Fixed at “L” in this set
166 IFS1 I Interface selection signal input terminal Fixed at “H” in this set
93

HCD-S550/S880
94
Pin No. Pin Name I/O Description
167 XTAL I 33.8688 MHz clock signal input terminal
168 VSS — Ground terminal (digital system)
169 XTL2 O System clock output terminal (33.8688 MHz)
170 XTL1 I System clock input terminal (33.8688 MHz)
171 VDD — Power supply terminal (+3.3V) (digital system)
172 to 176 D0 to D4 I/O Two-way data bus with the mechanism controller

• DVD BOARD IC801 CXD2752R (DSD DECODER)
Pin No. Pin Name I/O Description
1 VSCA0 — Ground terminal (for core)
2 XMSLAT I Serial data latch pulse signal input from the mechanism controller
3 MSCK I Serial data transfer clock signal input from the mechanism controller
4 MSDATI I Serial data input from the mechanism controller
5 VDCA0 — Power supply terminal (+2.5V) (for core)
6 MSDATO O Serial data output to the mechanism controller
7 MSREADY O Ready signal output to the mechanism controller “L”: ready
8 XMSDOE O Serial data output enable signal output terminal Not used
9 XRST I Reset signal input from the mechanism controller “L”: reset
HCD-S550/S880
10 SMUTE I Soft muting on/off control signal input from the mechanism controller “H”: muting on
11 MCKI I Master clock signal (33.8688 MHz) input
12 VSIOA0 — Ground terminal (for I/O)
13 EXCKO1 O Master clock signal (33.8688 MHz) output to the digital audio processor
14 EXCKO2 O External clock 2 signal output terminal Not used
15 LRCK O L/R sampling clock signal (44.1kHz) output terminal Not used
16 F75HZ O Not used
17 VDIOA0 — Power supply terminal (+3.3V) (for I/O)
18 to 25 MNT0 to MNT7 O Monitor signal output terminal Not used
26 TCK I Clock signal input from the DVD system processor
27 TDI I Serial data input from the DVD system processor
28 VSCA1 — Ground terminal (for core)
29 TDO O Serial data output to the DVD system processor
30 TMS I MS signal input from the DVD system processor
31 TRST I Reset signal input from the DVD system processor “L”: reset
32 to 34 TEST1 to TEST3 I Input terminal for the test (normally: fixed at “L”)
35 VDCA1 — Power supply terminal (+2.5V) (for core)
36 UBIT O Not used
37 XBIT O Not used
38 to 41
SUPDT0 to
SUPDT3
O Supplementary data output terminal Not used
42 VSIOA1 — Ground terminal (for I/O)
43, 44 SUPDT4, SUPDT5 O Supplementary data output terminal Not used
45 VDIOA1 — Power supply terminal (+3.3V) (for I/O)
46, 47 SUPDT6, SUPDT7 O Supplementary data output terminal Not used
48 SUPEN O Supplementary data enable signal output terminal Not used
49 VSCA2 — Ground terminal (for core)
50 NC O Not used
51, 52 TEST4, TEST5 I Input terminal for the test (normally: fixed at “L”)
53 NC O Not used
54 VDCA2 — Power supply terminal (+2.5V) (for core)
55, 56 NC O Not used
57 BCKASL I
Input/output selection signal input terminal of bit clock signal (2.8224 MHz) for DSD data output
“L”: input (slave), “H”: output (master) Fixed at “H” in this set
58 VSDSD0 — Ground terminal (for DSD data output)
59 BCKAI I Bit clock signal (2.8224 MHz) input terminal for DSD data output Not used
60 BCKAO O Bit clock signal (2.8224 MHz) output terminal for DSD data output Not used
95

HCD-S550/S880
96
Pin No. Pin Name I/O Description
61 PHREFI I Bit clock signal (2.8224 MHz) input terminal for DSD data output Not used
62 PHREFO O Bit clock signal (2.8224 MHz) output to the digital audio processor
63 ZDFL O Front L-ch Zero data flag detection signal output terminal Not used
64 DSAL O Front L-ch DSD data output to the digital audio processor
65 ZDFR O Front R-ch Zero data flag detection signal output terminal Not used
66 DSAR O Front R-ch DSD data output to the digital audio processor
67 VDDSD0 — Power supply terminal (+3.3V) (for DSD data output)
68 ZDFC O Center zero data flag detection signal output terminal Not used
69 DSAC O Center DSD data output to the digital audio processor
70 ZDFLFE O Woofer zero data flag detection signal output terminal Not used
71 DSALFE O Woofer DSD data output to the digital audio processor
72 VSDSD1 — Ground terminal (for DSD data output)
73 ZDFLS O Rear L-ch zero data flag detection signal output terminal Not used
74 DSALS O Rear L-ch DSD data output to the digital audio processor
75 ZDFRS O Rear R-ch zero data flag detection signal output terminal Not used
76 DSARS O Rear R-ch DSD data output to the digital audio processor
77 VDDSD1 — Power supply terminal (+3.3V) (For DSD data output)
78, 79 IOUT0, IOUT1 O Data output terminal for IEEE 1394 link chip interface Not used
80 VSCB0 — Ground terminal (for core)
81, 82 IOUT2, IOUT3 O Data output terminal for IEEE 1394 link chip interface Not used
83 VDCB0 — Power supply terminal (+2.5V) (for core)
84, 85 IOUT4, IOUT5 O Data output terminal for IEEE 1394 link chip interface Not used
86 VSIOB0 — Ground terminal (for I/O)
87 IANCO O Transmission information data output terminal for IEEE 1394 link chip interface Not used
88 IFULL I Data transmission hold request signal input terminal for IEEE 1394 link chip interface Not used
89 IEMPTY I
High speed transmission request signal input terminal for IEEE 1394 link chip interface
Not used
90 VDIOB0 — Power supply terminal (+3.3V) (for I/O)
91 IFRM O Frame reference signal output terminal for IEEE 1394 link chip interface Not used
92 IOUTE O Enable signal output terminal for IEEE 1394 link chip interface Not used
93 IBCK O Data transmission clock signal output terminal for IEEE 1394 link chip interface Not used
94 VSCB1 — Ground terminal (for core)
95 IERR I Not used
96 IANCI I Not used
97 IPLAN I Not used
98 IHOLD O Not used
99 VDCB1 — Power supply terminal (+2.5V) (for core)
100 IVLD I Not used
101 to 105 IDIN0 to IDIN4 I Not used
106 VSIOB1 — Ground terminal (for I/O)
107 to 109 IDIN5 to IDIN7 I Not used
110 VDIOB1 — Power supply terminal (+3.3V) (for I/O)
111 to 114 WAD0 to WAD3 I External A/D data input terminal for PSP physical disc mark detection Not used
115 TESTI I Input terminal for the test (normally: fixed at “L”)
116 VSCB2 — Ground terminal (for core)
117 to 120 WAD4 to WAD7 I External A/D data input terminal for PSP physical disc mark detection Not used
121 VDCB2 — Power supply terminal (+2.5V) (for core)

Pin No. Pin Name I/O Description
122 WRFD I Not used
HCD-S550/S880
123 WCK I Operation clock signal input for PSP physical disc mark detection from the DVD decoder
124, 125
WAVDD0,
WAVDD1
— A/D power supply terminal (+2.5V) (for PSP physical disc mark detection)
126 WARFI I Analog RF signal input for PSP physical disc mark detection from the DVD/CD RF amplifier
127 WAVRB I A/D bottom reference terminal for PSP physical disc mark detection
128, 129 WAVSS1, WAVSS0 — A/D ground terminal (for PSP physical disc mark detection)
130 VSIOA2 — Ground terminal (for I/O)
131 to 134 DQ7 to DQ4 I/O Two-way data bus with the SD-RAM
135 VDIOA2 — Power supply terminal (+3.3V) (for I/O)
136 to 139 DQ3 to DQ0 I/O Two-way data bus with the SD-RAM
140 VSIOA3 — Ground terminal (for I/O)
141 DCLK O Clock signal output to the SD-RAM
142 DCKE O Clock enable signal output to the SD-RAM
143 XWE O Write enable signal output to the SD-RAM
144 XCAS O Column address strobe signal output to the SD-RAM
145 XRAS O Row address strobe signal output to the SD-RAM
146 VDIOA3 — Power supply terminal (+3.3V) (for I/O)
147 NC O Not used
148, 149 A11, A10 O Address signal output to the SD-RAM
150 VSCA3 — Ground terminal (for core)
151, 152 A9, A8 O Address signal output to the SD-RAM
153 VDCA3 — Power supply terminal (+2.5V) (for core)
154 to 157 A7 to A4 O Address signal output to the SD-RAM
158 VSIOA4 — Ground terminal (for I/O)
159 to 162 A3 to A0 O Address signal output to the SD-RAM
163 VDIOA4 — Power supply terminal (+3.3V) (for I/O)
164 XSRQ O Serial data request signal output to the DVD decoder
165 XSHD I Header flag signal input from the DVD decoder
166 SDCK I Serial data transfer clock signal input from the DVD decoder
167 XSAK I Serial data effect flag signal input from the DVD decoder
168 SDEF I Error flag signal input from the DVD decoder
169 to 176 SD0 to SD7 I Stream data signal input from the DVD decoder
97

HCD-S550/S880
• DVD BOARD IC901 µPD70F3033BYGF-M10-3BA (SYSTEM CONTROLLER)
98
Pin No. Pin Name I/O Description
1 DAMP-DATA O Serial data output to the stream processors
2 DAMP-CLK O Serial data transfer clock signal output to the stream processors
3 I2C-DATA I/O Communication data bus with the DVD system processor and mechanism controller
4 CQ-RST O Reset signal output to the DVD system processor “L”: reset
5 I2C-CLK I/O
Communication data reading clock signal input or transfer clock signal output with the DVD
system processor and mechanism controller
6 DSP-DO I Write data input from the digital audio signal processor
7 DIG-DI O
Read data output to the digital audio interface IC, digital audio signal processor and D/A
converter
8 DIG-CLK O
Clock signal output to the digital audio interface IC, digital audio signal processor and D/A
converter
9 EVDD — Power supply terminal (+5V)
10 EVSS — Ground terminal
11 P-PWM O PWM voltage control signal output
12 DSP-RST O Reset signal output to the digital audio signal processor “L”: reset
13 DSP-PM O PLL reset signal output to the digital audio signal processor “L”: reset
14 DSP-CS O Chip select signal output to the digital audio signal processor
15 DSP-HACN I Acknowledge signal input from to the digital audio signal processor
16 DSP-BST O Boot trap signal output to the digital audio signal processor
17 DSP-GP9 I Decode signal input from to the digital audio signal processor
18 DIR-ZERO I Audio serial data input from the digital audio interface IC
19 DIR-ERR I PLL lock error and data error flag input from the digital audio interface IC
20 DIR-CE O Chip enable signal output to the digital audio interface IC
21 VPP — Power supply terminal (for programming) Not used
22 DIR-XST I Source clock switching monitor input from the digital audio interface IC
23 DIR-AD O Not used
24 DIR-XMODE I System reset signal input from the digital audio interface IC “L”: reset
25 DIRDO I Write data input from the digital audio interface IC
26 DAMP-RST O Reset signal output to the stream processors “L”: reset
27 DAMP-MUTEG O Muting on/off control signal output to the stream processors “H”: muting on
28 DAMP-MUTEN O Muting on/off control signal output to the stream processors “H”: muting on
29 CS1 O Chip select signal output to the stream processor (for front L-ch and R-ch)
30 CS2 O Chip select signal output to the stream processor (for center and woofer)
31 CS3 O Chip select signal output to the stream processor (for rear L-ch and R-ch)
32 DAC-CS O Chip select signal output to the D/A converter
33 AD-RST O Reset signal output to the A/D converter and D/A converter “L”: reset
34 RESET I
System reset signal input “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
35 XT1 I Sub system clock input terminal Not used
36 XT2 O Sub system clock output terminal Not used
37 REG0 — Not used
38 X2 O Main system clock output terminal (20 MHz)
39 X1 I Main system clock input terminal (20 MHz)
40 VSS — Ground terminal
41 VDD — Power supply terminal (+5V)
42 CLKOUT O Clock signal output terminal Not used

Pin No. Pin Name I/O Description
43 DIP-RST O Reset signal output to the power amplifier “L”: reset
44 DIP-OCP I Protect signal input from the power amplifier
45 ST-POWER O System power on/off control signal output “H”: power on
46 HP-MUTE O Headphone muting on/off control signal output “L”: muting on
47 AU-MUTE O Audio line muting on/off control signal output “L”: muting on
48 AV-SEL2 O Audio/video selection signal output
49 PROG SW I SCAN SELECT switch input terminal “L”: SELECTABLE, “H”: INTERLACE
50 TU-ON O Tuner power on/off control signal output “H”: power on
51 TUNED I Tuning detection signal input from the tuner unit “L”: tuned
52 TUN-DI I Serial data input from the tuner unit
53 TUN-CE O Chip enable signal output to the tuner unit
54 TUN-DO O Serial data output to the tuner unit
55 TUN-CLK O Serial data transfer clock signal output to the tuner unit
56 FL-MUTE O Reset signal output to the fluorescent indicator tube driver “L”: reset
HCD-S550/S880
57 FL-CLK O Serial data transfer clock signal output to the LED driver and fluorescent indicator tube driver
58 BVDD — Power supply terminal (+5V) (for bus interface)
59 BVSS — Ground terminal (for bus interface)
60 FL-DATA O Serial data output to the LED driver and fluorescent indicator tube driver
61 FL-CS O Chip select signal output to the fluorescent indicator tube driver “L” active
62 LED-CS O Standby signal output to the LED driver “L”: standby
63 LED-CLR O Reset signal output to the LED driver “L”: reset
64 HPSW I
Connection detection signal input of the headphone jack
“L”: no connected, “H”: headphone connected
65 DFIL RST2 O Reset signal output to the digital audio processor “L”: reset
66 SP RELAY O Relay drive signal output terminal for the speaker protect Not used
67 PARA-DO2 I Serial data input from the mechanism deck controller
68 PARA-RST O Reset signal output to the mechanism deck controller “L”: reset
69 PARA-LT1 O Serial data latch pulse signal output to the mechanism deck controller
70 PARA-LT2 O Serial data latch pulse signal output terminal Not used
71 PARA-CLK O Serial data transfer clock signal output to the mechanism deck controller
72 PARA-DATA O Serial data output to the mechanism deck controller
73 PARA-DO1 I Serial data input terminal Not used
74 AVDD — Power supply terminal (+5V) (analog system)
75 AVSS — Ground terminal (analog system)
76 AVREF I Reference voltage (+5V) input terminal (analog system)
77 NO USE — Not used
78 OPT-SEN2 I Disc insert detection signal input from the photo sensor
79 OPT-SEN I Chucking detection signal input from the photo sensor
80 AREA1 I Destination setting terminal
81 SEN2 I Disc in/out switch input terminal “L”: when a disc is inserted
82 to 84 KEY0 to KEY2 I Key input terminal (A/D input)
85 EN-A I Jog dial pulse input from the rotary encoder (A phase input)
86 EN-B I Jog dial pulse input from the rotary encoder (B phase input)
87 MODEL I Model setting terminal
88 RDS-DATA I RDS serial data input from the RDS decoder (AEP, UK and Russian models only)
89 DVD-POWER O DVD power on/off control signal output “H”: power on
90 STOP I System stop signal input
91 POWER-SW I System power on/off control signal input “H”: power on
99

HCD-S550/S880
Pin No. Pin Name I/O Description
100
92 SIRCS I Remote control signal input
93 WAKE I
System wake up signal input by pressing any key on the front panel or remote commander or disc
insert detect switch
94 RDS-CLK I
RDS serial data transfer clock signal input from the RDS decoder
(AEP, UK and Russian models only)
95 AV-SEL0 O Audio/video selection signal output
96 AV-SEL1 O Audio/video selection signal output
97 DF-SW O selection signal output to the digital audio processor
98 DF-SYNC O Sync signal output to the digital audio processor
99 DF-RST O Reset signal output for the digital audio processor “L”: reset Not used
100 I2HLP I/O Busy signal input/output for the I2C bus

• DVD BOARD IC902 PT3000 (MECHANISM DECK CONTROLLER)
Pin No. Pin Name I/O Description
1 VSS — Ground terminal
2 RESET I Reset signal input from the system controller “L”: reset
3 CLK I Serial data transfer clock signal input from the system controller
4 LAT I Serial data latch pulse signal input from the system controller
5 P15 I Disc in/out switch input terminal “L”: when a disc is ejected
6 P14 I Disc in/out switch input terminal “L”: when a disc is inserted
7 to 10 P13 to P10 I Mode detect rotary encoder input terminal
11, 12 P9, P8 I Not used
13 LATCHO O Serial data latch pulse signal output terminal Not used
14 CLKO O Serial data transfer clock signal output terminal Not used
15 DO1 O Serial data output terminal Not used
16 DI2 I Serial data input terminal Not used
17 to 19 P7 to P5 O Not used
20 P4 O LED drive control signal output of the disc insert detect sensor “H”: LED on
21, 22 P3, P2 O Eject motor drive control signal output
23, 24 P1, P0 O Loading motor drive control signal output
25 DO2 O Serial data output to the system controller
26 DI1 I Serial data input from the system controller
27 PULLUP — Connected to power supply (+5V)
28 VCC — Power supply terminal (+5V)
HCD-S550/S880
101

HCD-S550/S880
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑ ↑
Parts Color Cabinet's Color
8-1. GENERAL SECTION
102
1
front panel section-1
chassis section-1
SECTION 8
EXPLODED VIEWS
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• Abbreviation
AUS : Australian model
CH : Chinese model
CIS : Russian model
EA : Soudi Arabia model
HK : Hong Kong model
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 4-240-394-01 SIDE PANEL (L)
2 4-240-395-01 SIDE PANEL (R)
3 A-4676-939-A I/O BOARD, COMPLETE (S550: AEP, UK, CIS)
3 A-4729-045-A I/O BOARD, COMPLETE (S880: AEP, UK, CIS)
3 A-4729-906-A I/O BOARD, COMPLETE
(E32, AUS, EA, HK, MX, SP, MY, TW)
#1
#1
3
#1
KR : Korean model
MX : Mexican model
MY : Malaysia model
SP : Singapore model
TW : Taiwan model
4
not supplied
(SEL board)
4
not supplied
3 A-4730-166-A I/O BOARD, COMPLETE (KR)
3 A-4731-092-A I/O BOARD, COMPLETE (CH)
4 4-931-757-31 SCREW (DIA.2.6X8) (IT3B), TAPPING
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
2
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
#1
#1

8-2. FRONT PANEL SECTION-1
not supplied
#9
51
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
51 4-240-404-02 CD BUTTON
52 4-240-405-01 BAND BUTTON
53 1-685-074-11 CONTROL BOARD
55 1-685-084-11 VOL BOARD
56 2-626-294-01 SCREW (+ PTPWH) (2.6X7) (EXCEPT KR)
#1
56 3-229-336-01 SCREW, +BVWH TAPPING (KR)
#1
52
#1
#1
53
58
front panel section-2
#1
not supplied
supplied with S800
57
55
56
57 1-685-083-11 HP BOARD
58 4-240-024-01 KNOB VOLUME (S550)
58 X-4952-564-1 KNOB (VOL) ASSY (S880)
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
#9 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
103

HCD-S550/S880
Ver 1.6
8-3. FRONT PANEL SECTION-2
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
101 X-4954-740-5 WINDOW SUB ASSY (KR)
101 X-4955-250-1 WINDOW SUB ASSY (EXCEPT KR)
102 X-4954-741-3 CD LID SUB ASSY
103 4-240-402-02 FL HOLDER
105 1-685-082-11 FL BOARD
106 X-4954-738-2 POWER SUB ASSY
107 4-240-393-02 PANEL (AL), FRONT
(S550: KR, MX, EA, SP, AUS, E, HK, TW, CH)
104
101
107
106
#1
#1
FL801
103
102
108
not
supplied
(power LED board)
105
108
107 4-240-393-12 PANEL (AL), FRONT (S550: AEP, UK, CIS)
107 4-241-535-02 PANEL (AL), FRONT
(S880: KR, TW, MX, SP, EA, HK, E, AUS, CH)
107 4-241-535-12 PANEL (AL), FRONT (S880: AEP, UK, CIS)
108 4-931-757-31 SCREW (DIA.2.6X8) (IT3B), TAPPING
FL801 1-518-824-11 INDICATOR TUBE, FLOURESCENT
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S

8-4. CHASSIS SECTION-1
mechanism deck
section-1
158
157
156
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
151 A-4433-609-A DVD BOARD, COMPLETE (S550: CH)
151 A-4676-925-A DVD BOARD, COMPLETE (S550: AEP, UK)
151 A-4729-034-A DVD BOARD, COMPLETE (S880: AEP, UK)
151 A-4730-160-A DVD BOARD, COMPLETE (S550: KR)
151 A-4730-201-A DVD BOARD, COMPLETE (S880: KR)
151 A-4730-605-A DVD BOARD, COMPLETE (S550: E, MX)
151 A-4730-612-A DVD BOARD, COMPLETE (S550: EA)
151 A-4730-616-A DVD BOARD, COMPLETE
(S550: HK, SP, MY, TW)
151 A-4730-618-A DVD BOARD, COMPLETE (S550: CIS)
151 A-4730-620-A DVD BOARD, COMPLETE (S550: AUS)
151 A-4730-650-A DVD BOARD, COMPLETE (S880: AUS)
151 A-4730-652-A DVD BOARD, COMPLETE (S880: CIS)
#1
#1
not
supplied
151
not supplied
152
153
#1
154
chassis section-2
155
151 A-4730-654-A DVD BOARD, COMPLETE (S880: EA)
151 A-4730-669-A DVD BOARD, COMPLETE
(S880: HK, SP, MY, TW)
151 A-4730-674-A DVD BOARD, COMPLETE (S880: E, MX)
151 A-4733-713-A DVD BOARD, COMPLETE (S880: CH)
152 1-824-477-11 FLEXIBLE FLAT CABLE (17 CORE)
153 1-824-475-11 FLEXIBLE FLAT CABLE (18 CORE)
154 1-824-476-11 FLEXIBLE FLAT CABLE (12 CORE)
155 1-824-624-11 FLEXIBLE FLAT CABLE (17 CORE)
156 1-824-474-11 FLEXIBLE FLAT CABLE (29 CORE)
157 1-824-473-11 FLEXIBLE FLAT CABLE (14 CORE)
158 1-687-072-11 PWB, FLEXIBLE
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
Ver 1.6
105

HCD-S550/S880
8-5. CHASSIS SECTION-2
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
201 X-4954-745-1 FOOT SUB ASSY
202 A-4676-937-A DDCON BOARD, COMPLETE (EXCEPT KR)
202 A-4730-153-A DDCON BOARD, COMPLETE (KR)
106
204
not supplied
not supplied
(power SW board)
202
not supplied
chassis section-3
#2
#1
201
#1
#1
not supplied
not supplied
204 4-240-397-01 POWER BUTTON
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
#2 7-685-645-79 SCREW +P 3X6 TYPE2 NON-SLIT

8-6. CHASSIS SECTION-3
F901
not
supplied
chassis section-4
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
251 A-4676-932-A POWER BOARD, COMPLETE
(AEP, UK, CIS, HK, SP, MY, AUS, CH)
251 A-4730-164-A POWER BOARD, COMPLETE (KR)
251 A-4730-608-A POWER BOARD, COMPLETE (MX, TW)
251 A-4730-615-A POWER BOARD, COMPLETE (EA)
251 A-4730-623-A POWER BOARD, COMPLETE (E)
#1
251
252
252 A-4676-942-A AMP BOARD, COMPLETE (EXCEPT MX, KR)
252 A-4730-168-A AMP BOARD, COMPLETE (KR)
252 A-4730-610-A AMP BOARD, COMPLETE (MX)
0F901 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (5A/125V)
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
#1
#1
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
107

HCD-S550/S880
8-7. CHASSIS SECTION-4
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
301 3-703-244-00 BUSHING (2104), CORD (KR)
301 4-217-350-11 STOPPER, CORD (EXCEPT KR)
0 302 1-696-169-12 CORD, POWER
(AEP, UK, E, HK, EA, CIS, SP, MY, TW)
0 302 1-696-848-42 CORD, POWER (AUS)
0 302 1-769-079-22 CORD, POWER (KR)
0 302 1-775-789-91 CORD, POWER (MX)
0 302 1-782-464-22 CORD, POWER (CH)
303 4-931-757-31 SCREW (DIA.2.6X8) (IT3B), TAPPING
108
not supplied
306
not supplied
not supplied
301
302
not
supplied
305
not supplied
M301
303
#3
305 1-824-486-11 FLEXIBLE FLAT CABLE (11 CORE)
306 A-4730-139-A TUNER BOARD, COMPLETE (DTP-001)
(EXCEPT E, EA, HK, MX, SP, MY)
306 A-4730-143-A TUNER BOARD, COMPLETE (DTP-001)
(E, EA, HK, MX, SP, MY)
M301 1-763-861-11 FAN, DC
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
#1
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
#3 7-685-659-14 SCREW +BVTP 4X8 TYPE2 N-S

8-8. MECHANISM DECK SECTION-1
(CDM72B-DVBU12)
354
351
353
352
not supplied
not supplied
355
mechanism deck section-2
(CDM72A-DVBU12)
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
351 4-240-856-01 SCREW (+PWH.2X6), STEP TAPPING
352 4-241-159-01 SPRING (SL), TENSION
353 4-241-160-01 SPRING (S5), TENSION
354 4-992-069-01 SCREW (+PTPWH) (M2) (DIA. 7)
355 4-243-128-01 SCREW (+PWH.2X3), STEP TAPPING
109

HCD-S550/S880
Ver 1.5
8-9. MECHANISM DECK SECTION-2
(CDM72A-DVBU12)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
401 4-240-212-01 COVER (AT-DV)
402 4-240-211-01 PULLEY (AT-DV)
403 X-4954-988-1 HOLDER (AT) ASSY
404 A-4676-588-A RELAY BOARD, COMPLETE
110
not supplied
#5
#4
406
mechanism deck section-3
#4
401
#5
403
optical pick-up section
#4
402
405
not supplied
404
405 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING
406 4-238-194-01 SHEET (PULLEY DV)
#4 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
#5 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
#4

8-10. MECHANISM DECK SECTION-3
(CDM72A-DVBU12)
not supplied
(SW board)
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
451 4-239-618-01 SCREW (+PWH,2X6), STEP TAPPING
452 4-240-200-01 GEAR (L1)
* 453 3-344-749-01 RETAINER (B)
M711 A-4746-746-A MOTOR (LD) ASSY (LOADING)
#4
not supplied
(encoder board)
S880
not supplied
451
#4
#4
452
#8
#6
#7
not supplied
M711
453
mechanism deck section-4
#4
not supplied
(D sensor board)
#4 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
#6 7-623-921-01 RING, RETAINING, CAPSTAN
#7 7-627-853-28 SCREW, PRECISION +P 2X3 TYPE3
#8 7-685-102-19 SCREW +P 2X4 NON-SLIT TYPE 2
111

HCD-S550/S880
8-11. MECHANISM DECK SECTION-4
(CDM72A-DVBU12)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
501 X-4954-711-1 PULLEY (RTR) ASSY
502 4-240-205-01 GEAR (S1)
503 4-241-020-01 BELT (L2)
112
501
502
mechanism deck section-5
504
503
505
504 4-240-202-01 PULLEY (LDG)
505 X-4954-712-1 PULLEY (RTL) ASSY

8-12. MECHANISM DECK SECTION-5
(CDM72A-DVBU12)
551
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
551 4-240-203-01 GEAR (L4)
552 4-238-552-01 REFLECTOR (CDM71)
553 4-240-206-01 GEAR (S2)
554 X-4954-710-1 PULLEY (SPT) ASSY
553
mechanism deck
section-6
552
554
#4
555
556
557
not
supplied
555 4-237-430-01 SPRING (S), TORSION
556 4-240-236-01 GEAR (SPT)
557 4-240-209-01 GEAR (KT)
#4 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
113

HCD-S550/S880
8-13. MECHANISM DECK SECTION-6
(CDM72A-DVBU12)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
601 4-240-213-01 CAM (CDM72)
602 X-4954-987-1 LEVER (ST) ASSY
603 4-240-208-01 GEAR (C2)
604 4-240-207-01 GEAR (C1)
114
601
603
602
604 605
not supplied
(CK motor board)
not supplied
#4
606
M751
mechanism deck
section-7
#4
not supplied
(CK sensor board)
605 4-241-021-01 BELT (CK)
606 4-240-210-01 PULLEY (CKG)
M751 A-4746-747-A MOTOR (CK) ASSY (EJECT)
#4 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S

8-14. MECHANISM DECK SECTION-7
(CDM72A-DVBU12)
653
652
not supplied
651
HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
651 4-240-830-01 PULLEY (L5)
652 4-240-202-01 PULLEY (LDG)
653 4-241-021-01 BELT (CK)
654
not supplied
655
656
not supplied
654 4-240-231-01 GEAR (L5)
655 4-240-219-01 SPRING (L), TORSION
656 4-240-204-01 GEAR (CNT)
115

HCD-S550/S880
8-15. OPTICAL PICK-UP SECTION
(DVBU12)
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
701 4-981-923-01 SCREW (M), STEP
702 3-053-847-31 INSULATOR
0703 1-477-263-11 PICKUP UNIT (TDP022W)
704 A-4728-690-A RF BOARD, COMPLETE
116
701
702
701
702
704
#9
703
706
701
702
705
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
705 1-685-250-11 FLEXIBLE BOARD
706 X-4954-899-1 HOLDER (BU) ASSY
#9 7-685-533-14 SCREW +BTP 2.6X6 TYPE2 N-S

NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified
in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Abbreviation
AUS : Australian model
CH : Chinese model
CIS : Rissian model
EA : Saudi Arabia model
HK : Hong Kong model
KR : Korean model
MX : Mexican model
MY : Malaysia model
SP : Singapore model
TW : Taiwan model
SECTION 9
ELECTRICAL PARTS LIST
HCD-S550/S880
AMP
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
A-4676-942-A AMP BOARD, COMPLETE (EXCEPT MX, KR)
A-4730-168-A AMP BOARD, COMPLETE (KR)
A-4730-610-A AMP BOARD, COMPLETE (MX)
*********************
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR/SHORT >
C101 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C102 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C103 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C104 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C105 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C106 1-127-573-11 CERAMIC CHIP 1uF 10% 16V
C111 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C112 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C113 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C114 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C115 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C116 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C121 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C122 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C123 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C124 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C125 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C126 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C131 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C132 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C133 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C134 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C135 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C136 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C139 1-216-864-11 SHORT
C141 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C142 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C143 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C144 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C145 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C146 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C147 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C148 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C149 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C150 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering
these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. . uPA. . : µPA. .
uPB. . : µPB. . uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
C151 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C152 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C161 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C162 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C163 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C164 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C165 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C166 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C167 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C168 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C169 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C170 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C171 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C172 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C181 1-162-968-11 CERAMIC CHIP 10% 50V
C182 1-164-245-11 CERAMIC CHIP 10% 25V
C189 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C190 1-164-505-11 CERAMIC CHIP 2.2uF 16V
C191 1-126-193-21 ELECT 1uF 20% 50V
C192 1-216-295-11 SHORT
C194 1-216-295-11 SHORT
C197 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C199 1-216-295-11 SHORT
C300 1-115-819-11 ELECT 2200uF 20% 35V
C301 1-126-153-11 ELECT 22uF 20% 6.3V
C302 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C303 1-136-157-00 FILM 0.022uF 5% 50V
C304 1-136-157-00 FILM 0.022uF 5% 50V
C306 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C307 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V
C308 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C309 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C310 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C311 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C312 1-124-584-00 ELECT 100uF 20% 10V
C313 1-136-165-00 FILM 0.1uF 5% 50V
C316 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C317 1-126-948-11 ELECT 100uF 20% 35V
C318 1-104-665-11 ELECT 100uF 20% 10V
C319 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C320 1-124-584-00 ELECT 100uF 20% 10V
117

HCD-S550/S880
AMP
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C323 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C401 1-104-665-11 ELECT 100uF 20% 10V
C324 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C325 1-124-584-00 ELECT 100uF 20% 10V C402 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C326 1-124-589-11 ELECT 47uF 20% 16V C403 1-126-948-11 ELECT 100uF 20% 35V
C404 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C405 1-104-665-11 ELECT 100uF 20% 10V
C406 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C327 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C328 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C329 1-126-176-11 ELECT 220uF 20% 10V
C330 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C331 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C332 1-136-165-00 FILM 0.1uF 5% 50V
C333 1-136-157-00 FILM 0.022uF 5% 50V
C334 1-136-157-00 FILM 0.022uF 5% 50V
C336 1-124-584-00 ELECT 100uF 20% 10V
C337 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C341 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C342 1-126-948-11 ELECT 100uF 20% 35V
C343 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C344 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C345 1-104-665-11 ELECT 100uF 20% 10V
C348 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C349 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C350 1-124-584-00 ELECT 100uF 20% 10V
C351 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C352 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C353 1-136-165-00 FILM 0.1uF 5% 50V
C354 1-136-157-00 FILM 0.022uF 5% 50V
C355 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C356 1-136-157-00 FILM 0.022uF 5% 50V
C358 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C359 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C362 1-104-665-11 ELECT 100uF 20% 10V
C363 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C364 1-126-948-11 ELECT 100uF 20% 35V
C365 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C368 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C372 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C373 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C374 1-136-165-00 FILM 0.1uF 5% 50V
C375 1-136-157-00 FILM 0.022uF 5% 50V
C376 1-136-157-00 FILM 0.022uF 5% 50V
C378 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C381 1-104-665-11 ELECT 100uF 20% 10V
C382 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C383 1-126-948-11 ELECT 100uF 20% 35V
C384 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C387 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C388 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C389 1-124-584-00 ELECT 100uF 20% 10V
C390 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C391 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C392 1-124-584-00 ELECT 100uF 20% 10V
C393 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C394 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C395 1-136-165-00 FILM 0.1uF 5% 50V
C396 1-136-157-00 FILM 0.022uF 5% 50V
C397 1-136-157-00 FILM 0.022uF 5% 50V
C399 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C400 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
118
C407 1-104-665-11 ELECT 100uF 20% 10V
C408 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C409 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C410 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C411 1-136-165-00 FILM 0.1uF 5% 50V
C412 1-136-157-00 FILM 0.022uF 5% 50V
C413 1-136-157-00 FILM 0.022uF 5% 50V
C414 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C415 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C416 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C417 1-104-665-11 ELECT 100uF 20% 10V
C418 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C419 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V
C420 1-126-948-11 ELECT 100uF 20% 35V
C421 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C422 1-104-665-11 ELECT 100uF 20% 10V
C423 1-104-665-11 ELECT 100uF 20% 10V
C424 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C425 1-104-665-11 ELECT 100uF 20% 10V
C426 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C427 1-104-665-11 ELECT 100uF 20% 10V
C432 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V
C451 1-131-704-11 FILM 1uF 5% 50V
C452 1-131-704-11 FILM 1uF 5% 50V
C453 1-131-704-11 FILM 1uF 5% 50V
C454 1-131-704-11 FILM 1uF 5% 50V
C455 1-131-704-11 FILM 1uF 5% 50V
C456 1-131-704-11 FILM 1uF 5% 50V
C457 1-131-704-11 FILM 1uF 5% 50V
C458 1-131-704-11 FILM 1uF 5% 50V
C459 1-131-704-11 FILM 1uF 5% 50V
C460 1-131-704-11 FILM 1uF 5% 50V
C461 1-131-704-11 FILM 1uF 5% 50V
C462 1-131-704-11 FILM 1uF 5% 50V
C471 1-162-928-11 CERAMIC CHIP 120PF 5% 50V
C472 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C473 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C474 1-126-935-11 ELECT 470uF 20% 16V
C481 1-162-928-11 CERAMIC CHIP 120PF 5% 50V
C482 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C483 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C484 1-126-935-11 ELECT 470uF 20% 16V
C490 1-126-933-11 ELECT 100uF 20% 16V
C491 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C492 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C493 1-126-947-11 ELECT 47uF 20% 35V
< CONNECTOR >
CN300 1-565-731-11 PLUG, CONNECTOR (2.5mm) 5P
CN301 1-779-280-11 CONNECTOR, FFC (LIF (NON-ZIF)) 12P
* CN302 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
CN305 1-779-285-11 CONNECTOR, FFC/FPC (ZIF) 17P
* CN309 1-506-987-11 PIN, CONNECTOR (PC BOARD) 5P
< DIODE >
D101 8-719-404-50 DIODE MA111-TX
D102 8-719-404-50 DIODE MA111-TX
D103 8-719-404-50 DIODE MA111-TX
D104 8-719-404-50 DIODE MA111-TX
D105 8-719-404-50 DIODE MA111-TX
D106 8-719-404-50 DIODE MA111-TX
D181 8-719-404-50 DIODE MA111-TX
D190 8-719-404-50 DIODE MA111-TX
D191 8-719-404-50 DIODE MA111-TX
D192 8-719-083-63 DIODE UDZSTE-1713B
D197 8-719-404-50 DIODE MA111-TX
D311 6-500-131-01 DIODE LI116
D312 6-500-131-01 DIODE LI116
D313 6-500-131-01 DIODE LI116
D314 6-500-131-01 DIODE LI116
D315 6-500-131-01 DIODE LI116
D316 6-500-131-01 DIODE LI116
D321 6-500-131-01 DIODE LI116
D322 6-500-131-01 DIODE LI116
D323 6-500-131-01 DIODE LI116
D324 6-500-131-01 DIODE LI116
D325 6-500-131-01 DIODE LI116
D326 6-500-131-01 DIODE LI116
D331 6-500-260-01 DIODE P6SMB39AT3
D332 6-500-260-01 DIODE P6SMB39AT3
D333 6-500-260-01 DIODE P6SMB39AT3
D334 6-500-260-01 DIODE P6SMB39AT3
D335 6-500-260-01 DIODE P6SMB39AT3
D336 6-500-260-01 DIODE P6SMB39AT3
D341 6-500-260-01 DIODE P6SMB39AT3
D342 6-500-260-01 DIODE P6SMB39AT3
D343 6-500-260-01 DIODE P6SMB39AT3
D344 6-500-260-01 DIODE P6SMB39AT3
D345 6-500-260-01 DIODE P6SMB39AT3
D346 6-500-260-01 DIODE P6SMB39AT3
D351 6-500-248-01 DIODE SFPL-62V
D352 6-500-248-01 DIODE SFPL-62V
D353 6-500-248-01 DIODE SFPL-62V
D354 6-500-248-01 DIODE SFPL-62V
D355 6-500-248-01 DIODE SFPL-62V
D356 6-500-248-01 DIODE SFPL-62V
D361 6-500-248-01 DIODE SFPL-62V
D362 6-500-248-01 DIODE SFPL-62V
D363 6-500-248-01 DIODE SFPL-62V
D364 6-500-248-01 DIODE SFPL-62V
D365 6-500-248-01 DIODE SFPL-62V
D366 6-500-248-01 DIODE SFPL-62V
< FERRITE BEAD >
FB300 1-469-760-21 FERRITE BEAD
FB301 1-469-760-21 FERRITE BEAD
FB303 1-400-160-51 FERRITE BEAD
FB304 1-469-760-21 FERRITE BEAD
FB305 1-414-398-11 INDUCTOR (SMD)10uH
FB306 1-216-295-11 SHORT
FB307 1-469-760-21 FERRITE BEAD
FB308 1-469-760-21 FERRITE BEAD
FB309 1-400-160-51 FERRITE BEAD
FB310 1-216-295-11 SHORT
FB311 1-216-295-11 SHORT
FB312 1-400-160-51 FERRITE BEAD
FB313 1-400-160-51 FERRITE BEAD
FB314 1-469-760-21 FERRITE BEAD
FB315 1-469-760-21 FERRITE BEAD
FB318 1-400-160-51 FERRITE BEAD
FB320 1-400-160-51 FERRITE BEAD
< FILTER >
FL300 1-234-177-21 FILTER, CHIP EMI
< GROUND TERMINAL >
GP301 1-537-770-21 TERMINAL BOARD GROUND
< IC >
IC300 6-701-189-01 IC MC74VHC1GU04DFT1
IC301 6-701-845-01 IC CXD9702L
IC302 8-759-533-85 IC BA05FP-E2
IC303 8-759-460-72 IC BA033FP-E2
IC304 6-701-845-01 IC CXD9702L
IC305 6-700-279-01 IC CXD9634Q
IC306 6-701-845-01 IC CXD9702L
IC307 6-701-845-01 IC CXD9702L
IC308 6-700-279-01 IC CXD9634Q
IC309 6-701-845-01 IC CXD9702L
IC310 6-700-279-01 IC CXD9634Q
IC311 6-701-845-01 IC CXD9702L
IC401 8-759-385-17 IC NJM4580E (TE2)
< TERMINAL BOARD >
HCD-S550/S880
J401 1-694-919-11 TERMINAL BOARD (SPEAKER FRONT L/R,
CENTER, WOOFER, REAR L/R)
< COIL/SHORT >
L300 1-216-295-11 SHORT CHIP 0
L302 1-412-939-11 INDUCTOR 1uH
L401 1-456-035-11 INDUCTOR 10uH
L402 1-456-035-11 INDUCTOR 10uH
L403 1-456-035-11 INDUCTOR 10uH
L404 1-456-035-11 INDUCTOR 10uH
L405 1-456-035-11 INDUCTOR 10uH
L406 1-456-035-11 INDUCTOR 10uH
< TRANSISTOR >
Q101 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q102 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q103 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q104 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q105 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q106 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q107 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
AMP
119

HCD-S550/S880
AMP CK MOTOR CK SENSOR CONTROL
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
Q108 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q109 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q110 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q111 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q112 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q113 8-729-901-00 TRANSISTOR DTC124EK-T146
Q114 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q190 8-729-801-84 TRANSISTOR 2SB1013-4
Q191 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q192 8-729-901-00 TRANSISTOR DTC124EKA-T146
120
< RESISTOR >
R101 1-216-845-11 METAL CHIP 100K 5% 1/10W
R102 1-216-845-11 METAL CHIP 100K 5% 1/10W
R103 1-216-845-11 METAL CHIP 100K 5% 1/10W
R104 1-216-845-11 METAL CHIP 100K 5% 1/10W
R105 1-216-845-11 METAL CHIP 100K 5% 1/10W
R106 1-216-845-11 METAL CHIP 100K 5% 1/10W
R107 1-216-845-11 METAL CHIP 100K 5% 1/10W
R108 1-216-845-11 METAL CHIP 100K 5% 1/10W
R109 1-216-845-11 METAL CHIP 100K 5% 1/10W
R110 1-216-845-11 METAL CHIP 100K 5% 1/10W
R111 1-216-845-11 METAL CHIP 100K 5% 1/10W
R112 1-216-845-11 METAL CHIP 100K 5% 1/10W
R113 1-216-845-11 METAL CHIP 100K 5% 1/10W
R190 1-216-845-11 METAL CHIP 100K 5% 1/10W
R191 1-216-837-00 METAL CHIP 22K 5% 1/10W
R192 1-216-837-00 METAL CHIP 22K 5% 1/10W
R193 1-216-864-11 METAL CHIP 0 5% 1/10W
R300 1-216-833-11 METAL CHIP 10K 5% 1/10W
R301 1-216-821-11 METAL CHIP 1K 5% 1/10W
R302 1-216-857-11 METAL CHIP 1M 5% 1/10W
R304 1-216-809-11 METAL CHIP 100 5% 1/10W
R305 1-216-809-11 METAL CHIP 100 5% 1/10W
R307 1-216-809-11 METAL CHIP 100 5% 1/10W
R308 1-216-821-11 METAL CHIP 1K 5% 1/10W
R309 1-216-821-11 METAL CHIP 1K 5% 1/10W
R310 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R311 1-216-821-11 METAL CHIP 1K 5% 1/10W
R312 1-216-821-11 METAL CHIP 1K 5% 1/10W
R313 1-216-821-11 METAL CHIP 1K 5% 1/10W
R315 1-216-809-11 METAL CHIP 100 5% 1/10W
R316 1-216-809-11 METAL CHIP 100 5% 1/10W
R317 1-216-809-11 METAL CHIP 100 5% 1/10W
R318 1-216-809-11 METAL CHIP 100 5% 1/10W
R319 1-216-809-11 METAL CHIP 100 5% 1/10W
R320 1-216-809-11 METAL CHIP 100 5% 1/10W
R321 1-216-809-11 METAL CHIP 100 5% 1/10W
R322 1-216-805-11 METAL CHIP 47 5% 1/10W
R325 1-216-801-11 METAL CHIP 22 5% 1/10W
R330 1-216-809-11 METAL CHIP 100 5% 1/10W
R333 1-216-809-11 METAL CHIP 100 5% 1/10W
R334 1-216-817-11 METAL CHIP 470 5% 1/10W
R335 1-216-809-11 METAL CHIP 100 5% 1/10W
R336 1-216-817-11 METAL CHIP 470 5% 1/10W
R337 1-216-821-11 METAL CHIP 1K 5% 1/10W
R338 1-216-864-11 METAL CHIP 0 5% 1/10W
R339 1-216-817-11 METAL CHIP 470 5% 1/10W
R340 1-216-817-11 METAL CHIP 470 5% 1/10W
R341 1-216-817-11 METAL CHIP 470 5% 1/10W
R342 1-216-817-11 METAL CHIP 470 5% 1/10W
R343 1-216-809-11 METAL CHIP 100 5% 1/10W
R344 1-216-817-11 METAL CHIP 470 5% 1/10W
R346 1-216-864-11 METAL CHIP 0 5% 1/10W
R347 1-216-864-11 METAL CHIP 0 5% 1/10W
R348 1-216-809-11 METAL CHIP 100 5% 1/10W
R349 1-216-809-11 METAL CHIP 100 5% 1/10W
R350 1-216-809-11 METAL CHIP 100 5% 1/10W
R370 1-216-819-11 METAL CHIP 680 5% 1/10W
R395 1-216-031-00 METAL CHIP 180 5% 1/10W
R396 1-216-031-00 METAL CHIP 180 5% 1/10W
R397 1-216-031-00 METAL CHIP 180 5% 1/10W
R398 1-216-841-11 METAL CHIP 47K 5% 1/10W
R399 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R470 1-216-837-11 METAL CHIP 22K 5% 1/10W
R471 1-216-837-11 METAL CHIP 22K 5% 1/10W
R472 1-216-837-11 METAL CHIP 22K 5% 1/10W
R473 1-216-837-11 METAL CHIP 22K 5% 1/10W
R474 1-216-839-11 METAL CHIP 33K 5% 1/10W
R475 1-218-725-11 RES-CHIP 24K 5% 1/10W
R480 1-216-837-11 METAL CHIP 22K 5% 1/10W
R481 1-216-837-11 METAL CHIP 22K 5% 1/10W
R482 1-216-837-11 METAL CHIP 22K 5% 1/10W
R483 1-216-837-11 METAL CHIP 22K 5% 1/10W
R484 1-216-839-11 METAL CHIP 33K 5% 1/10W
R485 1-218-725-11 RES-CHIP 24K 5% 1/10W
R490 1-216-833-11 METAL CHIP 10K 5% 1/10W
R491 1-216-833-11 METAL CHIP 10K 5% 1/10W
< VIBRATOR >
X300 1-795-286-21 VIBRATOR, CRYSTAL (44.152MHz)
**************************************************************
CK MOTOR BOARD
****************
**************************************************************
CK SENSOR BOARD
*****************
< PHOTO SENSOR >
IC721 8-749-017-45 SENSOR, PHOTO RPR-220C1N
**************************************************************
1-685-074-11 CONTROL BOARD
**************
< RESISTOR >
R800 1-216-815-11 METAL CHIP 330 5% 1/10W
R801 1-216-817-11 METAL CHIP 470 5% 1/10W
R802 1-216-819-11 METAL CHIP 680 5% 1/10W
R803 1-216-821-11 METAL CHIP 1K 5% 1/10W
R809 1-216-813-11 METAL CHIP 220 5% 1/10W
R837 1-216-815-11 METAL CHIP 330 5% 1/10W
R844 1-216-817-11 METAL CHIP 470 5% 1/10W

HCD-S550/S880
CONTROL DDCON DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R849 1-216-819-11 METAL CHIP 680 5% 1/10W
< RESISTOR >
R860 1-216-821-11 METAL CHIP 1K 5% 1/10W
R864 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R838 1-216-805-11 METAL CHIP 47 5% 1/10W
R841 1-216-809-11 METAL CHIP 100 5% 1/10W
R873 1-216-813-11 METAL CHIP 220 5% 1/10W R842 1-216-809-11 METAL CHIP 100 5% 1/10W
R843 1-216-809-11 METAL CHIP 100 5% 1/10W
< SWITCH >
R850 1-216-828-11 METAL CHIP 3.9K 5% 1/10W
S801 1-786-220-11 SWITCH, KEYBOARD (H)
S802 1-786-220-11 SWITCH, KEYBOARD (X)
S803 1-786-220-11 SWITCH, KEYBOARD (PRESET+, > NEXT)
S804 1-786-220-11 SWITCH, KEYBOARD (x)
S805 1-786-220-11 SWITCH, KEYBOARD (PRESE–, . PREV)
S806 1-786-220-11 SWITCH, KEYBOARD (A)
S821 1-786-220-11 SWITCH, KEYBOARD (FIELD, +)
S822 1-786-220-11 SWITCH, KEYBOARD (SOUND, –)
S823 1-786-220-11 SWITCH, KEYBOARD (DISPLAY)
S824 1-786-220-11 SWITCH, KEYBOARD (BAND)
S825 1-786-220-11 SWITCH, KEYBOARD (FUNCTION)
**************************************************************
A-4676-937-A DDCON BOARD, COMPLETE (EXCEPT KR)
A-4730-153-A DDCON BOARD, COMPLETE (KR)
***********************
< CAPACITOR >
C820 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C821 1-124-261-00 ELECT 10uF 20% 50V
C822 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C823 1-124-247-61 ELECT 10uF 20% 35V
C826 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
< CONNECTOR >
CN802 1-506-481-11 PIN, CONNECTOR 2P
* CN803 1-568-944-11 PIN, CONNECTOR 6P
CN804 1-568-955-11 PIN, CONNECTOR 6P
CN805 1-506-469-11 PIN, CONNECTOR 4P
CN807 1-568-940-21 PIN, CONNECTOR 2P
CN814 1-779-554-21 CONNECTOR, FFC (LIF (NON-ZIF)) 17P
< DIODE >
D806 8-719-404-50 DIODE MA111-TX
D807 8-719-404-50 DIODE MA111-TX
D808 8-719-404-50 DIODE MA111-TX
D809 8-719-404-50 DIODE MA111-TX
D810 8-719-069-56 DIODE UDZSTE-176.2B
< FERRITE BEAD >
FB800 1-414-813-11 FERRITE 0uH
FB801 1-414-813-11 FERRITE 0uH
FB802 1-414-813-11 FERRITE 0uH
< COIL >
L801 1-412-959-11 INDUCTOR 47uH
< TRANSISTOR >
Q803 8-729-808-42 TRANSISTOR 2SD1624-T-TD
Q804 8-729-808-42 TRANSISTOR 2SD1624-T-TD
R855 1-216-809-11 METAL CHIP 100 5% 1/10W
R874 1-216-839-11 METAL CHIP 33K 5% 1/10W
< TRANSFORMER >
T801 1-437-416-11 TRANSFORMER, DC-DC CONVERTER
**************************************************************
A-4433-609-A DVD BOARD, COMPLETE (S550: CH)
A-4676-925-A DVD BOARD, COMPLETE (S550: AEP, UK)
A-4729-034-A DVD BOARD, COMPLETE (S880: AEP, UK)
A-4730-160-A DVD BOARD, COMPLETE (S550: KR)
A-4730-201-A DVD BOARD, COMPLETE (S880: KR)
A-4730-605-A DVD BOARD, COMPLETE (S550: E, MX)
A-4730-612-A DVD BOARD, COMPLETE (S550: EA)
A-4730-616-A DVD BOARD, COMPLETE
(S550: HK, SP, MY, TW)
A-4730-618-A DVD BOARD, COMPLETE (S550: CIS)
A-4730-620-A DVD BOARD, COMPLETE (S550: AUS)
A-4730-650-A DVD BOARD, COMPLETE (S880: AUS)
A-4730-652-A DVD BOARD, COMPLETE (S880: CIS)
A-4730-654-A DVD BOARD, COMPLETE (S880: EA)
A-4730-669-A DVD BOARD, COMPLETE
(S880: HK, SP, MY, TW)
A-4730-674-A DVD BOARD, COMPLETE (S880: E, MX)
A-4733-713-A DVD BOARD, COMPLETE (S880: CH)
*********************
< CAPACITOR >
Ver 1.6
C001 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C003 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C004 1-126-204-11 ELECT CHIP 47uF 20% 16V
C005 1-126-246-11 ELECT CHIP 220uF 20% 4V
C006 1-126-204-11 ELECT CHIP 47uF 20% 16V
C007 1-164-850-11 CERAMIC CHIP 10PF 0.5PF 50V
C008 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C009 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C010 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C011 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C012 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C013 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C014 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C015 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C016 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C017 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C018 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C019 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C020 1-126-246-11 ELECT CHIP 220uF 20% 4V
C201 1-126-246-11 ELECT CHIP 220uF 20% 4V
C203 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C204 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C217 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C219 1-164-947-11 CERAMIC CHIP 0.01uF 50V
121

HCD-S550/S880
DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C225 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C226 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C228 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C229 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C230 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C231 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C232 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C233 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C234 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C235 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C236 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C237 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C238 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C239 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C240 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C241 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C242 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C243 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C244 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C245 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C246 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C247 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C248 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C249 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C250 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C251 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C252 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C253 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C254 1-117-370-11 CERAMIC CHIP 10uF 10V
C255 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C257 1-117-370-11 CERAMIC CHIP 10uF 10V
C258 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C259 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C260 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C261 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C262 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C263 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C264 1-117-370-11 CERAMIC CHIP 10uF 10V
C265 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C266 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C267 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C268 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C269 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C270 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C271 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C274 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C301 1-117-370-11 CERAMIC CHIP 10uF 10V
C302 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C303 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C304 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C307 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C308 1-127-772-11 CERAMIC CHIP 33000PF 10% 10V
C309 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C310 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C311 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C312 1-117-370-11 CERAMIC CHIP 10uF 10V
C313 1-107-820-11 CERAMIC CHIP 0.1uF 16V
122
C314 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C315 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C316 1-124-779-00 ELECT CHIP 10uF 20% 16V
C317 1-164-850-11 CERAMIC CHIP 10PF 0.5PF 50V
C318 1-164-849-11 CERAMIC CHIP 9PF 0.5PF 50V
C319 1-164-862-11 CERAMIC CHIP 33PF 5% 50V
C320 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C355 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C356 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C401 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C402 1-117-370-11 CERAMIC CHIP 10uF 10V
C404 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C405 1-124-779-00 ELECT CHIP 10uF 20% 16V
C406 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C407 1-117-370-11 CERAMIC CHIP 10uF 10V
C408 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C409 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C410 1-124-779-00 ELECT CHIP 10uF 20% 16V
C411 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C412 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C413 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C414 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C415 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C416 1-117-370-11 CERAMIC CHIP 10uF 10V
C417 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C418 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C419 1-119-923-11 CERAMIC CHIP 0.047uF 10% 10V
C420 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C421 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C422 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C423 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C424 1-107-819-11 CERAMIC CHIP 0.022uF 10% 16V
C425 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V
C426 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C427 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V
C428 1-164-940-11 CERAMIC CHIP 0.0033uF 10% 16V
C432 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C433 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V
C434 1-117-370-11 CERAMIC CHIP 10uF 10V
C435 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C436 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C503 1-127-772-11 CERAMIC CHIP 33000PF 10% 10V
C504 1-127-772-11 CERAMIC CHIP 33000PF 10% 10V
C506 1-164-934-11 CERAMIC CHIP 330PF 10% 50V
C508 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50V
C509 1-164-934-11 CERAMIC CHIP 330PF 10% 50V
C510 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50V
C512 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C514 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C519 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C521 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V
C523 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V
C525 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C526 1-126-395-11 ELECT 22uF 20% 16V
C527 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C528 1-126-395-11 ELECT 22uF 20% 16V
C529 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C552 1-107-820-11 CERAMIC CHIP 0.1uF 16V

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C600 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C601 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C602 1-117-681-11 ELECT CHIP 100uF 20% 16V
C603 1-164-858-11 CERAMIC CHIP 22PF 5% 50V
C604 1-164-868-11 CERAMIC CHIP 56PF 5% 50V
C605 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C606 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C607 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C608 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C609 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C610 1-126-205-11 ELECT CHIP 47uF 20% 6.3V
C611 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C612 1-117-370-11 CERAMIC CHIP 10uF 10V
C613 1-117-370-11 CERAMIC CHIP 10uF 10V
C614 1-124-779-00 ELECT CHIP 10uF 20% 16V
C615 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C616 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C617 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C618 1-124-779-00 ELECT CHIP 10uF 20% 16V
C619 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C620 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C621 1-164-935-11 CERAMIC CHIP 470PF 10% 50V
C622 1-124-779-00 ELECT CHIP 10uF 20% 16V
C623 1-164-850-11 CERAMIC CHIP 10PF 0.5PF 50V
C624 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C625 1-124-779-00 ELECT CHIP 10uF 20% 16V
C626 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C627 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C628 1-124-779-00 ELECT CHIP 10uF 20% 16V
C629 1-164-935-11 CERAMIC CHIP 470PF 10% 50V
C630 1-117-370-11 CERAMIC CHIP 10uF 10V
C631 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C632 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C633 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C634 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C635 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C636 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C637 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C638 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C639 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C640 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C641 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C642 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C643 1-126-246-11 ELECT CHIP 220uF 20% 4V
C644 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C645 1-164-882-11 CERAMIC CHIP 220PF 5% 16V
C646 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C647 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C648 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C650 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C651 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C652 1-126-246-11 ELECT CHIP 220uF 20% 4V
C653 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C654 1-117-681-11 ELECT CHIP 100uF 20% 16V
C655 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C656 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C657 1-107-820-11 CERAMIC CHIP 0.1uF 16V
HCD-S550/S880
DVD
C658 1-164-935-11 CERAMIC CHIP 470PF 10% 50V
C659 1-164-882-11 CERAMIC CHIP 220PF 5% 16V
C660 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C661 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C662 1-164-882-11 CERAMIC CHIP 220PF 5% 16V
C663 1-164-935-11 CERAMIC CHIP 470PF 10% 50V
C667 1-117-370-11 CERAMIC CHIP 10uF 10V
C668 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C669 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C670 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C671 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C672 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C673 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C674 1-117-370-11 CERAMIC CHIP 10uF 10V
C675 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C676 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C677 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C678 1-164-882-11 CERAMIC CHIP 220PF 5% 16V
C679 1-164-947-11 CERAMIC CHIP 0.01uF 50V
C702 1-117-370-11 CERAMIC CHIP 10uF 10V
C703 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C706 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C708 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C709 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C711 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C712 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C713 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C714 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C715 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V
C716 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V
C717 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C718 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C720 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C721 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C722 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C723 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C724 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C725 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C726 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C727 1-117-370-11 CERAMIC CHIP 10uF 10V
C728 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V
C729 1-117-370-11 CERAMIC CHIP 10uF 10V
C730 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C740 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C741 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C742 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C743 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C744 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C745 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C752 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C760 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C761 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C762 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C763 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C764 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C765 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C766 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C767 1-107-820-11 CERAMIC CHIP 0.1uF 16V
123

HCD-S550/S880
DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C768 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C769 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C770 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C771 1-119-923-11 CERAMIC CHIP 0.047uF 10% 10V
C772 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C773 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V
C774 1-164-941-11 CERAMIC CHIP 0.0047uF 10% 16V
C775 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C776 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C777 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C778 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C779 1-117-370-11 CERAMIC CHIP 10uF 10V
C780 1-117-370-11 CERAMIC CHIP 10uF 10V
C781 1-117-370-11 CERAMIC CHIP 10uF 10V
C791 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C793 1-126-246-11 ELECT CHIP 220uF 20% 4V
C795 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C796 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C797 1-126-246-11 ELECT CHIP 220uF 20% 4V
C802 1-117-370-11 CERAMIC CHIP 10uF 10V
C803 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C804 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C807 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C808 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C809 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C810 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C811 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C812 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C813 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C815 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C817 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C818 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C819 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C837 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C838 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C839 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C840 1-117-370-11 CERAMIC CHIP 10uF 10V
C841 1-117-370-11 CERAMIC CHIP 10uF 10V
C842 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C843 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C848 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C849 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C854 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C855 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C856 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C857 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C861 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C865 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C866 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C867 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C870 1-127-772-11 CERAMIC CHIP 33000PF 10% 10V
C871 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C900 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C901 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C902 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C903 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C905 1-164-934-11 CERAMIC CHIP 330PF 10% 50V
124
C906 1-164-934-11 CERAMIC CHIP 330PF 10% 50V
C907 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50V
C908 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C909 1-164-222-91 CERAMIC CHIP 0.22uF 25V
C910 1-104-905-11 DOUBLE LAYER 0.22F 5.5V
C911 1-126-205-11 ELECT CHIP 47uF 20% 6.3V
C912 1-126-205-11 ELECT CHIP 47uF 20% 6.3V
C913 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C914 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V
C917 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C918 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C921 1-164-874-11 CERAMIC CHIP 100PF 5% 50V
C922 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C925 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C926 1-107-820-11 CERAMIC CHIP 0.1uF 16V
C927 1-107-820-11 CERAMIC CHIP 0.1uF 16V
< CONNECTOR >
CN001 1-784-371-31 CONNECTOR, FFC/FPC 12P
CN002 1-778-957-11 CONNECTOR, FFC/FPC 29P
CN003 1-784-373-31 CONNECTOR, FFC/FPC 14P
CN004 1-784-376-31 CONNECTOR, FFC/FPC 17P
CN005 1-784-376-31 CONNECTOR, FFC/FPC 17P
CN006 1-784-377-31 CONNECTOR, FFC/FPC 18P
CN008 1-815-954-21 PIN, CONNECTOR (PC BOARD) 13P
CN201 1-784-364-31 CONNECTOR, FFC/FPC 4P
* CN301 1-580-756-21 PIN, CONNECTOR (SMD) 7P
CN401 1-778-957-11 CONNECTOR, FFC/FPC 29P
CN900 1-784-367-31 CONNECTOR, FFC/FPC 8P
< DIODE >
D900 8-719-053-18 DIODE 1SR154-400TE-25
D901 8-719-053-18 DIODE 1SR154-400TE-25
D902 8-719-988-61 DIODE 1SS355TE-17
D903 8-719-988-61 DIODE 1SS355TE-17
D904 8-719-988-61 DIODE 1SS355TE-17
D907 8-719-988-61 DIODE 1SS355TE-17
< FERRITE BEAD >
FB001 1-469-324-21 FERRITE 0uH
FB003 1-469-324-21 FERRITE 0uH
FB004 1-469-324-21 FERRITE 0uH
FB005 1-469-324-21 FERRITE 0uH
FB006 1-469-324-21 FERRITE 0uH
FB007 1-469-324-21 FERRITE 0uH
FB008 1-469-324-21 FERRITE 0uH
FB009 1-469-324-21 FERRITE 0uH
FB010 1-469-324-21 FERRITE 0uH
FB011 1-469-324-21 FERRITE 0uH
FB012 1-469-324-21 FERRITE 0uH
FB013 1-469-324-21 FERRITE 0uH
FB014 1-469-324-21 FERRITE 0uH
FB201 1-469-324-21 FERRITE 0uH
FB202 1-469-324-21 FERRITE 0uH
FB901 1-469-324-21 FERRITE 0uH
FB902 1-469-324-21 FERRITE 0uH

HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
< FILTER/FERRITE BEAD >
IC701 8-752-412-43 IC CXD1882R
IC702 8-759-637-50 IC TA48M025F (TE16L)
FL003 1-234-177-21 FERRITE 0uH
FL004 1-234-177-21 FERRITE 0uH
FL005 1-233-893-21 FILTER, CHIP EMI
FL006 1-234-177-21 FERRITE 0uH
FL202 1-233-893-21 FILTER, CHIP EMI
FL203 1-233-893-21 FILTER, CHIP EMI
FL204 1-233-893-21 FILTER, CHIP EMI
FL301 1-233-893-21 FILTER, CHIP EMI
FL303 1-233-893-21 FILTER, CHIP EMI
FL304 1-233-893-21 FILTER, CHIP EMI
FL401 1-233-893-21 FILTER, CHIP EMI
FL402 1-233-893-21 FILTER, CHIP EMI
FL603 1-234-177-21 FERRITE 0uH
FL604 1-234-177-21 FERRITE 0uH
FL605 1-234-177-21 FERRITE 0uH
FL606 1-234-177-21 FERRITE 0uH
FL701 1-233-893-21 FILTER, CHIP EMI
FL702 1-233-893-21 FILTER, CHIP EMI
FL703 1-233-893-21 FILTER, CHIP EMI
FL704 1-233-893-21 FILTER, CHIP EMI
FL705 1-233-893-21 FILTER, CHIP EMI
FL706 1-233-893-21 FILTER, CHIP EMI
FL807 1-233-893-21 FILTER, CHIP EMI
FL810 1-233-893-21 FILTER, CHIP EMI
FL811 1-233-893-21 FILTER, CHIP EMI
FL812 1-233-893-21 FILTER, CHIP EMI
< IC >
IC001 8-759-583-47 IC uPC2933T-E2
IC002 8-759-473-95 IC uPC2905T-E1
IC003 8-759-473-95 IC uPC2905T-E1
IC004 8-759-473-95 IC uPC2905T-E1
IC005 8-759-583-47 IC uPC2933T-E2
IC006 6-700-398-01 IC uPC2918T-E1
IC202 6-702-368-01 IC MT48LC4M32B2-7
IC203 8-759-668-01 IC BR9040F-D-E2
IC204 6-802-149-01 IC MR27V3202F-8NTPZ020
IC206 6-700-404-01 IC ZIVA-5P-B0
IC215 6-700-437-01 IC SN74ALVCH16841DGGR
IC301 8-752-933-58 IC CXP973064-224R
IC302 8-759-640-41 IC BR24C08F-E2
IC303 6-700-407-01 IC SM8707GV-G-E2
IC401 8-752-408-73 IC CXD3068Q
IC402 8-759-058-43 IC NJM3404AV (TE2)
IC501 6-702-157-01 IC FAN8035L
IC600 8-759-052-52 IC NJM78M05DL1A-TE1
IC601 6-701-011-01 IC uPC2910T-E1
IC602 8-759-560-56 IC PCM1800E/2K
IC603 8-759-337-40 IC NJM2904V (TE2)
IC604 8-759-538-16 IC IDT71V016S15PH-AUTL
IC605 8-759-835-63 IC NJM2391DL1-26 (TE1)
IC606 8-759-825-15 IC LC89056W-E
IC607 8-759-698-76 IC CXD9617R
IC608 6-701-111-01 IC AK4382AVT-E2
IC610 8-759-337-40 IC NJM2904V (TE2)
IC612 6-700-278-01 IC CXD9633Q
IC703 8-759-058-43 IC NJM3404AV (TE2)
IC706 8-759-564-30 IC MSM51V18165F-60TSKR1
IC801 8-752-407-50 IC CXD2752R
IC802 8-759-058-64 IC TC7S32FU (TE85R)
IC803 6-702-563-01 IC TC7W74FK-TE85L
IC808 6-702-336-01 IC MSM56V16160F-8TK7R1
IC812 8-759-549-15 IC SN74LV245APWR
IC813 8-759-549-15 IC SN74LV245APWR
IC814 8-759-680-48 IC TC7WH157FK (TE85R)
IC900 8-759-238-47 IC TC74HCT7007AF (EL)
IC901 6-802-479-01 IC uPD70F3033BYGF-M10-3BA
IC902 8-759-828-32 IC PT8300
IC903 8-759-427-92 IC PST9126NL
IC904 8-759-326-78 IC PST9140NL
IC905 8-759-234-20 IC TC7S08F-TE85L
IC907 8-759-326-78 IC PST9140NL
< RESISTOR >
JW900 1-218-941-81 RES-CHIP 100 5% 1/16W
JW903 1-218-990-11 SHORT CHIP 0
< COIL >
L301 1-414-754-11 INDUCTOR 10uH
L600 1-414-754-11 INDUCTOR 10uH
L602 1-414-754-11 INDUCTOR 10uH
< TRANSISTOR >
Q001 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q002 6-550-220-01 TRANSISTOR 2SB906 (TE16L)
Q003 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q004 6-550-220-01 TRANSISTOR 2SB906 (TE16L)
Q301 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q302 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q900 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q901 8-729-230-63 TRANSISTOR 2SD1819A-QRS-TX
Q902 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q903 8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L
Q906 8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L
Q907 8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L
Q908 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q909 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q910 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q911 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q912 8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L
Q913 8-729-026-49 TRANSISTOR 2SA1037AK-T146-QR
< RESISTOR/FERRITE BEAD >
R001 1-218-990-11 SHORT CHIP 0
R002 1-218-990-11 SHORT CHIP 0
R003 1-218-990-11 SHORT CHIP 0
R004 1-218-990-11 SHORT CHIP 0
R005 1-218-990-11 SHORT CHIP 0
R006 1-218-990-11 SHORT CHIP 0
R007 1-218-990-11 SHORT CHIP 0
R008 1-218-990-11 SHORT CHIP 0
DVD
125

HCD-S550/S880
DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R009 1-218-953-11 RES-CHIP 1K 5% 1/16W
R010 1-218-990-11 SHORT CHIP 0
R011 1-216-198-00 RES-CHIP 1K 5% 1/8W
R013 1-218-990-11 SHORT CHIP 0
R014 1-218-990-11 SHORT CHIP 0
R015 1-218-990-11 SHORT CHIP 0
R016 1-218-990-11 SHORT CHIP 0
R017 1-218-990-11 SHORT CHIP 0
R018 1-218-990-11 SHORT CHIP 0
R019 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R020 1-218-990-11 SHORT CHIP 0
R021 1-218-990-11 SHORT CHIP 0
R022 1-218-990-11 SHORT CHIP 0 (AEP, UK, CIS)
R023 1-218-990-11 SHORT CHIP 0
R024 1-218-990-11 SHORT CHIP 0 (AEP, UK, CIS)
R025 1-218-990-11 SHORT CHIP 0
R026 1-218-990-11 SHORT CHIP 0
R027 1-218-990-11 SHORT CHIP 0
R028 1-218-990-11 SHORT CHIP 0
R029 1-218-990-11 SHORT CHIP 0
R030 1-218-990-11 SHORT CHIP 0
R031 1-218-990-11 SHORT CHIP 0
R032 1-218-990-11 SHORT CHIP 0
R033 1-218-990-11 SHORT CHIP 0
R034 1-218-990-11 SHORT CHIP 0
R035 1-218-990-11 SHORT CHIP 0
R036 1-218-990-11 SHORT CHIP 0
R037 1-218-990-11 SHORT CHIP 0
R038 1-218-990-11 SHORT CHIP 0
R039 1-218-990-11 SHORT CHIP 0
R040 1-218-990-11 SHORT CHIP 0
R041 1-218-990-11 SHORT CHIP 0
R042 1-218-990-11 SHORT CHIP 0
R043 1-218-990-11 SHORT CHIP 0
R044 1-218-990-11 SHORT CHIP 0
R045 1-218-990-11 SHORT CHIP 0
R046 1-218-990-11 SHORT CHIP 0
R047 1-218-990-11 SHORT CHIP 0
R048 1-218-990-11 SHORT CHIP 0
R049 1-218-990-11 SHORT CHIP 0
R050 1-218-990-11 SHORT CHIP 0
R051 1-218-990-11 SHORT CHIP 0
R052 1-218-990-11 SHORT CHIP 0
R053 1-218-990-11 SHORT CHIP 0
R054 1-218-990-11 SHORT CHIP 0
R055 1-218-990-11 SHORT CHIP 0
R056 1-218-990-11 SHORT CHIP 0
R057 1-218-990-11 SHORT CHIP 0
R058 1-218-990-11 SHORT CHIP 0
R059 1-218-990-11 SHORT CHIP 0
R060 1-218-990-11 SHORT CHIP 0
R061 1-218-990-11 SHORT CHIP 0
R062 1-218-990-11 SHORT CHIP 0
R063 1-218-990-11 SHORT CHIP 0
R064 1-218-990-11 SHORT CHIP 0
R065 1-218-990-11 SHORT CHIP 0
R066 1-218-953-11 RES-CHIP 1K 5% 1/16W
126
R067 1-216-817-11 RES-CHIP 470 5% 1/10W
R068 1-218-990-11 SHORT CHIP 0
R069 1-218-990-11 SHORT CHIP 0
R070 1-218-990-11 SHORT CHIP 0
R072 1-218-990-11 SHORT CHIP 0
R074 1-218-990-11 SHORT CHIP 0
R075 1-218-990-11 SHORT CHIP 0
R077 1-218-990-11 SHORT CHIP 0
R079 1-216-198-00 RES-CHIP 1K 5% 1/8W
R202 1-218-990-11 SHORT CHIP 0
R203 1-208-869-11 METAL CHIP 180 0.5% 1/16W
R206 1-218-990-11 SHORT CHIP 0
R207 1-218-285-11 RES-CHIP 75 5% 1/10W
R208 1-218-285-11 RES-CHIP 75 5% 1/10W
R209 1-218-285-11 RES-CHIP 75 5% 1/10W
R210 1-218-285-11 RES-CHIP 75 5% 1/10W
R211 1-218-990-11 SHORT CHIP 0
R212 1-208-643-11 RES-CHIP 22 5% 1/16W
R213 1-218-990-11 SHORT CHIP 0
R214 1-218-990-11 SHORT CHIP 0
R215 1-218-935-11 RES-CHIP 33 5% 1/16W
R216 1-218-935-11 RES-CHIP 33 5% 1/16W
R217 1-218-935-11 RES-CHIP 33 5% 1/16W
R218 1-218-935-11 RES-CHIP 33 5% 1/16W
R219 1-218-935-11 RES-CHIP 33 5% 1/16W
R220 1-218-935-11 RES-CHIP 33 5% 1/16W
R221 1-218-935-11 RES-CHIP 33 5% 1/16W
R222 1-218-935-11 RES-CHIP 33 5% 1/16W
R223 1-218-935-11 RES-CHIP 33 5% 1/16W
R224 1-218-935-11 RES-CHIP 33 5% 1/16W
R225 1-218-935-11 RES-CHIP 33 5% 1/16W
R226 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R227 1-218-935-11 RES-CHIP 33 5% 1/16W
R228 1-218-935-11 RES-CHIP 33 5% 1/16W
R229 1-218-935-11 RES-CHIP 33 5% 1/16W
R230 1-218-935-11 RES-CHIP 33 5% 1/16W
R231 1-218-935-11 RES-CHIP 33 5% 1/16W
R232 1-218-990-11 SHORT CHIP 0
R233 1-218-965-11 RES-CHIP 10K 5% 1/16W
R234 1-218-285-11 METAL CHIP 75 5% 1/10W
R235 1-218-990-11 SHORT CHIP 0
R236 1-208-683-11 METAL CHIP 1K 0.5% 1/16W
R238 1-218-941-81 RES-CHIP 100 5% 1/16W
R239 1-218-973-11 RES-CHIP 47K 5% 1/16W
R241 1-218-965-11 RES-CHIP 10K 5% 1/16W
R244 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R245 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R246 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R247 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R248 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R249 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R250 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R251 1-218-965-11 RES-CHIP 10K 5% 1/16W
R252 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R253 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R256 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R257 1-469-681-21 FERRITE, EMI (SMD)
R258 1-469-681-21 FERRITE, EMI (SMD)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R259 1-469-681-21 FERRITE, EMI (SMD)
R260 1-469-681-21 FERRITE, EMI (SMD)
R261 1-469-681-21 FERRITE, EMI (SMD)
R262 1-218-285-11 METAL CHIP 75 5% 1/10W
R263 1-218-285-11 METAL CHIP 75 5% 1/10W
R264 1-218-285-11 METAL CHIP 75 5% 1/10W
R265 1-218-285-11 METAL CHIP 75 5% 1/10W
R266 1-218-285-11 METAL CHIP 75 5% 1/10W
R303 1-208-643-11 RES-CHIP 22 5% 1/16W
R304 1-208-643-11 RES-CHIP 22 5% 1/16W
R305 1-218-965-11 RES-CHIP 10K 5% 1/16W
R306 1-208-643-11 RES-CHIP 22 5% 1/16W
R307 1-208-643-11 RES-CHIP 22 5% 1/16W
R308 1-208-643-11 RES-CHIP 22 5% 1/16W
R309 1-218-990-11 SHORT CHIP 0
R311 1-208-643-11 RES-CHIP 22 5% 1/16W
R312 1-218-965-11 RES-CHIP 10K 5% 1/16W
R313 1-218-990-11 SHORT CHIP 0
R314 1-218-990-11 SHORT CHIP 0
R315 1-218-990-11 SHORT CHIP 0
R316 1-218-965-11 RES-CHIP 10K 5% 1/16W
R317 1-218-941-81 RES-CHIP 100 5% 1/16W
R318 1-218-941-81 RES-CHIP 100 5% 1/16W
R319 1-218-990-11 SHORT CHIP 0
R320 1-218-990-11 SHORT CHIP 0
R321 1-218-941-81 RES-CHIP 100 5% 1/16W
R322 1-218-990-11 SHORT CHIP 0
R323 1-218-941-81 RES-CHIP 100 5% 1/16W
R324 1-218-990-11 SHORT CHIP 0
R326 1-218-941-81 RES-CHIP 100 5% 1/16W
R327 1-218-941-81 RES-CHIP 100 5% 1/16W
R328 1-218-941-81 RES-CHIP 100 5% 1/16W
R329 1-218-941-81 RES-CHIP 100 5% 1/16W
R330 1-218-941-81 RES-CHIP 100 5% 1/16W
R331 1-218-945-11 RES-CHIP 220 5% 1/16W
R332 1-218-965-11 RES-CHIP 10K 5% 1/16W
R333 1-218-965-11 RES-CHIP 10K 5% 1/16W
R335 1-208-643-11 RES-CHIP 22 5% 1/16W
R336 1-218-990-11 SHORT CHIP 0
R337 1-218-941-81 RES-CHIP 100 5% 1/16W
R338 1-218-990-11 SHORT CHIP 0
R339 1-218-990-11 SHORT CHIP 0
R340 1-218-990-11 SHORT CHIP 0
R341 1-218-990-11 SHORT CHIP 0
R342 1-218-990-11 SHORT CHIP 0
R344 1-218-953-11 RES-CHIP 1K 5% 1/16W
R345 1-218-990-11 SHORT CHIP 0
R346 1-218-953-11 RES-CHIP 1K 5% 1/16W
R349 1-218-990-11 SHORT CHIP 0
R350 1-218-941-81 RES-CHIP 100 5% 1/16W
R351 1-218-990-11 SHORT CHIP 0
R352 1-218-990-11 SHORT CHIP 0
R353 1-218-965-11 RES-CHIP 10K 5% 1/16W
R354 1-218-989-11 RES-CHIP 1M 5% 1/16W
R355 1-208-643-11 RES-CHIP 22 5% 1/16W
R356 1-218-939-11 RES-CHIP 68 5% 1/16W
R357 1-218-939-11 RES-CHIP 68 5% 1/16W
HCD-S550/S880
R358 1-218-939-11 RES-CHIP 68 5% 1/16W
R359 1-218-965-11 RES-CHIP 10K 5% 1/16W
R360 1-218-965-11 RES-CHIP 10K 5% 1/16W
R361 1-218-965-11 RES-CHIP 10K 5% 1/16W
R362 1-218-990-11 RES-CHIP 0 5% 1/16W
R363 1-218-965-11 RES-CHIP 10K 5% 1/16W
R364 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R401 1-218-990-11 SHORT CHIP 0
R402 1-218-990-11 SHORT CHIP 0
R403 1-218-990-11 SHORT CHIP 0
R404 1-218-990-11 SHORT CHIP 0
R405 1-218-990-11 SHORT CHIP 0
R406 1-218-990-11 SHORT CHIP 0
R407 1-218-990-11 SHORT CHIP 0
R408 1-218-990-11 SHORT CHIP 0
DVD
R409 1-218-990-11 SHORT CHIP 0
R410 1-218-990-11 SHORT CHIP 0
R411 1-218-990-11 SHORT CHIP 0
R412 1-218-965-11 RES-CHIP 10K 5% 1/16W
R413 1-218-965-11 RES-CHIP 10K 5% 1/16W
R415 1-218-990-11 SHORT CHIP 0
R416 1-218-990-11 SHORT CHIP 0
R417 1-218-990-11 SHORT CHIP 0
R418 1-218-965-11 RES-CHIP 10K 5% 1/16W
R419 1-218-975-11 RES-CHIP 68K 5% 1/16W
R420 1-218-990-11 SHORT CHIP 0
R421 1-218-953-11 RES-CHIP 1K 5% 1/16W
R423 1-218-953-11 RES-CHIP 1K 5% 1/16W
R424 1-218-990-11 SHORT CHIP 0
R425 1-218-953-11 RES-CHIP 1K 5% 1/16W
R426 1-218-953-11 RES-CHIP 1K 5% 1/16W
R427 1-218-990-11 SHORT CHIP 0
R428 1-218-953-11 RES-CHIP 1K 5% 1/16W
R429 1-218-953-11 RES-CHIP 1K 5% 1/16W
R430 1-218-953-11 RES-CHIP 1K 5% 1/16W
R431 1-218-990-11 SHORT CHIP 0
R432 1-218-990-11 SHORT CHIP 0
R433 1-218-973-11 RES-CHIP 47K 5% 1/16W
R434 1-218-973-11 RES-CHIP 47K 5% 1/16W
R435 1-218-990-11 SHORT CHIP 0
R436 1-218-990-11 SHORT CHIP 0
R437 1-218-973-11 RES-CHIP 47K 5% 1/16W
R438 1-218-990-11 SHORT CHIP 0
R439 1-218-947-11 RES-CHIP 330 5% 1/16W
R440 1-218-973-11 RES-CHIP 47K 5% 1/16W
R441 1-218-953-11 RES-CHIP 1K 5% 1/16W
R442 1-218-965-11 RES-CHIP 10K 5% 1/16W
R443 1-218-973-11 RES-CHIP 47K 5% 1/16W
R444 1-218-985-11 RES-CHIP 470K 5% 1/16W
R445 1-218-953-11 RES-CHIP 1K 5% 1/16W
R446 1-218-965-11 RES-CHIP 10K 5% 1/16W
R447 1-218-965-11 RES-CHIP 10K 5% 1/16W
R448 1-218-953-11 RES-CHIP 1K 5% 1/16W
R449 1-218-971-11 RES-CHIP 33K 5% 1/16W
R450 1-218-953-11 RES-CHIP 1K 5% 1/16W
R451 1-218-965-11 RES-CHIP 10K 5% 1/16W
R452 1-218-989-11 RES-CHIP 1M 5% 1/16W
R453 1-218-989-11 RES-CHIP 1M 5% 1/16W
127

HCD-S550/S880
DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R455 1-218-977-11 RES-CHIP 100K 5% 1/16W
R457 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R510 1-208-939-11 METAL CHIP 150K 0.5% 1/16W
R511 1-208-939-11 METAL CHIP 150K 0.5% 1/16W
R512 1-218-974-11 METAL CHIP 56K 0.5% 1/16W
R513 1-218-974-11 METAL CHIP 56K 0.5% 1/16W
R514 1-218-965-11 RES-CHIP 10K 5% 1/16W
R516 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R517 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R519 1-218-977-11 RES-CHIP 100K 5% 1/16W
R520 1-218-965-11 RES-CHIP 10K 5% 1/16W
R521 1-218-977-11 RES-CHIP 100K 5% 1/16W
R522 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R523 1-218-965-11 RES-CHIP 10K 5% 1/16W
R524 1-218-965-11 RES-CHIP 10K 5% 1/16W
R525 1-218-965-11 RES-CHIP 10K 5% 1/16W
R527 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R528 1-218-990-11 SHORT CHIP 0
R529 1-218-971-11 RES-CHIP 33K 5% 1/16W
R530 1-218-974-11 RES-CHIP 56K 5% 1/16W
R531 1-218-990-11 SHORT CHIP 0
R532 1-218-990-11 SHORT CHIP 0
R533 1-218-971-11 RES-CHIP 33K 5% 1/16W
R534 1-218-974-11 RES-CHIP 56K 5% 1/16W
R535 1-218-990-11 SHORT CHIP 0
R536 1-220-210-11 RES-CHIP 200K 5% 1/16W
R538 1-218-977-11 RES-CHIP 100K 5% 1/16W
R540 1-218-965-11 RES-CHIP 10K 5% 1/16W
R541 1-218-977-11 RES-CHIP 100K 5% 1/16W
R544 1-218-977-11 RES-CHIP 100K 5% 1/16W
R545 1-218-977-11 RES-CHIP 100K 5% 1/16W
R553 1-218-990-11 SHORT CHIP 0
R554 1-218-990-11 SHORT CHIP 0
R579 1-218-964-11 RES-CHIP 8.2K 5% 1/16W
R580 1-218-971-11 RES-CHIP 33K 5% 1/16W
R581 1-218-966-81 RES-CHIP 12K 5% 1/16W
R582 1-218-965-11 RES-CHIP 10K 5% 1/16W
R583 1-218-965-11 RES-CHIP 10K 5% 1/16W
R597 1-218-990-11 SHORT CHIP 0
R600 1-218-941-81 RES-CHIP 100 5% 1/16W
R602 1-218-989-11 RES-CHIP 1M 5% 1/16W
R603 1-218-941-81 RES-CHIP 100 5% 1/16W
R604 1-218-941-81 RES-CHIP 100 5% 1/16W
R605 1-218-941-81 RES-CHIP 100 5% 1/16W
R606 1-218-941-81 RES-CHIP 100 5% 1/16W
R607 1-218-941-81 RES-CHIP 100 5% 1/16W
R608 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R609 1-218-949-11 RES-CHIP 470 5% 1/16W
R610 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R611 1-218-941-81 RES-CHIP 100 5% 1/16W
R612 1-218-973-11 RES-CHIP 47K 5% 1/16W
R613 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R614 1-218-971-11 RES-CHIP 33K 5% 1/16W
R615 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R616 1-218-962-11 RES-CHIP 5.6K 5% 1/16W
R617 1-218-990-11 SHORT CHIP 0
R618 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
128
R619 1-218-973-11 RES-CHIP 47K 5% 1/16W
R620 1-218-941-81 RES-CHIP 100 5% 1/16W
R621 1-218-941-81 RES-CHIP 100 5% 1/16W
R622 1-218-941-81 RES-CHIP 100 5% 1/16W
R623 1-218-941-81 RES-CHIP 100 5% 1/16W
R624 1-218-941-81 RES-CHIP 100 5% 1/16W
R625 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R626 1-218-953-11 RES-CHIP 1K 5% 1/16W
R627 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R628 1-218-941-81 RES-CHIP 100 5% 1/16W
R629 1-218-941-81 RES-CHIP 100 5% 1/16W
R630 1-218-949-11 RES-CHIP 470 5% 1/16W
R631 1-218-941-81 RES-CHIP 100 5% 1/16W
R634 1-218-953-11 RES-CHIP 1K 5% 1/16W
R635 1-218-965-11 RES-CHIP 10K 5% 1/16W
R636 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R637 1-218-941-81 RES-CHIP 100 5% 1/16W
R639 1-218-941-81 RES-CHIP 100 5% 1/16W
R640 1-218-941-81 RES-CHIP 100 5% 1/16W
R642 1-218-941-81 RES-CHIP 100 5% 1/16W
R644 1-218-965-11 RES-CHIP 10K 5% 1/16W
R645 1-218-965-11 RES-CHIP 10K 5% 1/16W
R646 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R647 1-218-945-11 RES-CHIP 220 5% 1/16W
R648 1-218-941-81 RES-CHIP 100 5% 1/16W
R649 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R650 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R651 1-218-965-11 RES-CHIP 10K 5% 1/16W
R652 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R653 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R654 1-218-945-11 RES-CHIP 220 5% 1/16W
R655 1-218-941-81 RES-CHIP 100 5% 1/16W
R656 1-218-990-11 SHORT CHIP 0
R657 1-218-953-11 RES-CHIP 1K 5% 1/16W
R658 1-218-941-81 RES-CHIP 100 5% 1/16W
R659 1-218-935-11 RES-CHIP 33 5% 1/16W
R660 1-218-945-11 RES-CHIP 220 5% 1/16W
R661 1-218-941-81 RES-CHIP 100 5% 1/16W
R662 1-218-941-81 RES-CHIP 100 5% 1/16W
R663 1-218-941-81 RES-CHIP 100 5% 1/16W
R664 1-218-941-81 RES-CHIP 100 5% 1/16W
R665 1-218-965-11 RES-CHIP 10K 5% 1/16W
R666 1-218-941-81 RES-CHIP 100 5% 1/16W
R667 1-218-941-81 RES-CHIP 100 5% 1/16W
R668 1-218-953-11 RES-CHIP 1K 5% 1/16W
R669 1-218-953-11 RES-CHIP 1K 5% 1/16W
R671 1-218-941-81 RES-CHIP 100 5% 1/16W
R672 1-218-941-81 RES-CHIP 100 5% 1/16W
R673 1-218-945-11 RES-CHIP 220 5% 1/16W
R674 1-218-945-11 RES-CHIP 220 5% 1/16W
R675 1-218-945-11 RES-CHIP 220 5% 1/16W
R676 1-218-945-11 RES-CHIP 220 5% 1/16W
R677 1-218-945-11 RES-CHIP 220 5% 1/16W
R679 1-218-941-81 RES-CHIP 100 5% 1/16W
R680 1-218-941-81 RES-CHIP 100 5% 1/16W
R682 1-218-965-11 RES-CHIP 10K 5% 1/16W
R684 1-218-965-11 RES-CHIP 10K 5% 1/16W
R685 1-218-953-11 RES-CHIP 1K 5% 1/16W

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R686 1-218-965-11 RES-CHIP 10K 5% 1/16W
R687 1-218-953-11 RES-CHIP 1K 5% 1/16W
R688 1-218-965-11 RES-CHIP 10K 5% 1/16W
R689 1-218-965-11 RES-CHIP 10K 5% 1/16W
R692 1-218-941-81 RES-CHIP 100 5% 1/16W
R695 1-218-941-81 RES-CHIP 100 5% 1/16W
R696 1-218-945-11 RES-CHIP 220 5% 1/16W
R699 1-218-941-81 RES-CHIP 100 5% 1/16W
R700 1-218-965-11 RES-CHIP 10K 5% 1/16W
R702 1-218-965-11 RES-CHIP 10K 5% 1/16W
R703 1-218-965-11 RES-CHIP 10K 5% 1/16W
R704 1-218-965-11 RES-CHIP 10K 5% 1/16W
R705 1-218-965-11 RES-CHIP 10K 5% 1/16W
R706 1-218-965-11 RES-CHIP 10K 5% 1/16W
R707 1-218-941-81 RES-CHIP 100 5% 1/16W
R708 1-218-985-11 RES-CHIP 470K 5% 1/16W
R709 1-218-979-11 RES-CHIP 150K 5% 1/16W
R710 1-218-965-11 RES-CHIP 10K 5% 1/16W
R711 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R712 1-218-965-11 RES-CHIP 10K 5% 1/16W
R713 1-218-965-11 RES-CHIP 10K 5% 1/16W
R714 1-218-965-11 RES-CHIP 10K 5% 1/16W
R715 1-218-965-11 RES-CHIP 10K 5% 1/16W
R716 1-218-941-81 RES-CHIP 100 5% 1/16W
R717 1-218-977-11 RES-CHIP 100K 5% 1/16W
R718 1-218-965-11 RES-CHIP 10K 5% 1/16W
R719 1-218-953-11 RES-CHIP 1K 5% 1/16W
R720 1-218-953-11 RES-CHIP 1K 5% 1/16W
R721 1-208-719-11 METAL CHIP 33K 0.5% 1/16W
R724 1-208-683-11 METAL CHIP 1K 0.5% 1/16W
R725 1-208-689-11 METAL CHIP 1.8K 0.5% 1/16W
R726 1-208-935-11 METAL CHIP 100K 0.5% 1/16W
R727 1-208-695-11 METAL CHIP 3.3K 0.5% 1/16W
R728 1-208-707-11 METAL CHIP 10K 0.5% 1/16W
R729 1-218-964-11 RES-CHIP 8.2K 5% 1/16W
R730 1-208-643-11 RES-CHIP 22 5% 1/16W
R731 1-208-643-11 RES-CHIP 22 5% 1/16W
R732 1-218-965-11 RES-CHIP 10K 5% 1/16W
R735 1-218-965-11 RES-CHIP 10K 5% 1/16W
R737 1-218-965-11 RES-CHIP 10K 5% 1/16W
R738 1-208-643-11 RES-CHIP 22 5% 1/16W
R741 1-208-643-11 RES-CHIP 22 5% 1/16W
R742 1-208-643-11 RES-CHIP 22 5% 1/16W
R743 1-208-643-11 RES-CHIP 22 5% 1/16W
R744 1-208-643-11 RES-CHIP 22 5% 1/16W
R745 1-218-973-11 RES-CHIP 47K 5% 1/16W
R746 1-218-973-11 RES-CHIP 47K 5% 1/16W
R747 1-218-971-11 RES-CHIP 33K 5% 1/16W
R748 1-218-971-11 RES-CHIP 33K 5% 1/16W
R750 1-218-965-11 RES-CHIP 10K 5% 1/16W
R752 1-218-990-11 SHORT CHIP 0
R753 1-218-990-11 SHORT CHIP 0
R754 1-218-990-11 SHORT CHIP 0
R755 1-218-990-11 SHORT CHIP 0
R756 1-218-990-11 SHORT CHIP 0
R757 1-218-990-11 SHORT CHIP 0
R758 1-218-990-11 SHORT CHIP 0
HCD-S550/S880
R759 1-218-990-11 SHORT CHIP 0
R762 1-218-969-11 RES-CHIP 22K 5% 1/16W
R763 1-218-964-11 RES-CHIP 8.2K 5% 1/16W
R764 1-218-989-11 RES-CHIP 1M 5% 1/16W
R765 1-218-969-11 RES-CHIP 22K 5% 1/16W
R766 1-218-990-11 SHORT CHIP 0
R767 1-218-973-11 RES-CHIP 47K 5% 1/16W
R770 1-218-990-11 SHORT CHIP 0
R771 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R772 1-208-643-11 RES-CHIP 22 5% 1/16W
R776 1-218-990-11 SHORT CHIP 0
R777 1-218-990-11 SHORT CHIP 0
R778 1-218-977-11 RES-CHIP 100K 5% 1/16W
R780 1-218-990-11 SHORT CHIP 0
R781 1-218-990-11 SHORT CHIP 0
R799 1-218-990-11 SHORT CHIP 0
R800 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R803 1-218-941-81 RES-CHIP 100 5% 1/16W
R804 1-218-990-11 SHORT CHIP 0
R805 1-218-965-11 RES-CHIP 10K 5% 1/16W
R806 1-218-990-11 SHORT CHIP 0
R821 1-208-643-11 RES-CHIP 22 5% 1/16W
R822 1-208-643-11 RES-CHIP 22 5% 1/16W
R823 1-208-643-11 RES-CHIP 22 5% 1/16W
R826 1-208-643-11 RES-CHIP 22 5% 1/16W
R827 1-218-941-81 RES-CHIP 100 5% 1/16W
R828 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R829 1-218-941-81 RES-CHIP 100 5% 1/16W
R830 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R831 1-218-971-11 RES-CHIP 33K 5% 1/16W
R833 1-218-990-11 SHORT CHIP 0
R834 1-218-990-11 SHORT CHIP 0
R835 1-218-990-11 SHORT CHIP 0
R836 1-218-990-11 SHORT CHIP 0
R837 1-218-990-11 SHORT CHIP 0
DVD
R838 1-218-990-11 SHORT CHIP 0
R839 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
R840 1-218-990-11 SHORT CHIP 0
R841 1-218-990-11 SHORT CHIP 0
R842 1-218-965-11 RES-CHIP 10K 5% 1/16W
R843 1-218-990-11 SHORT CHIP 0
R844 1-218-990-11 SHORT CHIP 0
R845 1-218-990-11 SHORT CHIP 0
R846 1-218-990-11 SHORT CHIP 0
R847 1-208-643-11 RES-CHIP 22 5% 1/16W
R848 1-208-643-11 RES-CHIP 22 5% 1/16W
R849 1-208-643-11 RES-CHIP 22 5% 1/16W
R850 1-208-643-11 RES-CHIP 22 5% 1/16W
R851 1-218-990-11 SHORT CHIP 0
R852 1-218-990-11 SHORT CHIP 0
R865 1-218-990-11 SHORT CHIP 0
R866 1-218-990-11 SHORT CHIP 0
R867 1-218-990-11 SHORT CHIP 0
R882 1-218-965-11 RES-CHIP 10K 5% 1/16W
R883 1-218-965-11 RES-CHIP 10K 5% 1/16W
R884 1-218-965-11 RES-CHIP 10K 5% 1/16W
R885 1-218-965-11 RES-CHIP 10K 5% 1/16W
R886 1-218-965-11 RES-CHIP 10K 5% 1/16W
129

HCD-S550/S880
DVD
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R887 1-218-965-11 RES-CHIP 10K 5% 1/16W
R888 1-218-965-11 RES-CHIP 10K 5% 1/16W
R889 1-218-965-11 RES-CHIP 10K 5% 1/16W
R899 1-218-957-11 RES-CHIP 2.2K 5% 1/16W
R900 1-218-941-81 RES-CHIP 100 5% 1/16W
R901 1-218-941-81 RES-CHIP 100 5% 1/16W
R902 1-218-941-81 RES-CHIP 100 5% 1/16W
R903 1-218-941-81 RES-CHIP 100 5% 1/16W
R904 1-218-941-81 RES-CHIP 100 5% 1/16W
R905 1-218-941-81 RES-CHIP 100 5% 1/16W
R906 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R907 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R908 1-218-965-11 RES-CHIP 10K 5% 1/16W
R909 1-218-965-11 RES-CHIP 10K 5% 1/16W
R910 1-218-941-81 RES-CHIP 100 5% 1/16W
R911 1-218-941-81 RES-CHIP 100 5% 1/16W
R912 1-218-941-81 RES-CHIP 100 5% 1/16W
R913 1-218-941-81 RES-CHIP 100 5% 1/16W
R914 1-218-941-81 RES-CHIP 100 5% 1/16W
R915 1-218-941-81 RES-CHIP 100 5% 1/16W
R916 1-218-941-81 RES-CHIP 100 5% 1/16W
R917 1-218-952-11 RES-CHIP 820 5% 1/16W
R918 1-218-952-11 RES-CHIP 820 5% 1/16W
R919 1-218-965-11 RES-CHIP 10K 5% 1/16W
R920 1-218-941-81 RES-CHIP 100 5% 1/16W
R921 1-218-941-81 RES-CHIP 100 5% 1/16W
R922 1-218-965-11 RES-CHIP 10K 5% 1/16W
R926 1-218-941-81 RES-CHIP 100 5% 1/16W
R929 1-218-967-11 RES-CHIP 15K 5% 1/16W
R930 1-218-965-11 RES-CHIP 10K 5% 1/16W
R931 1-218-953-11 RES-CHIP 1K 5% 1/16W
R932 1-218-965-11 RES-CHIP 10K 5% 1/16W
R933 1-218-965-11 RES-CHIP 10K 5% 1/16W
R934 1-218-965-11 RES-CHIP 10K 5% 1/16W
R935 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
(S880)
R936 1-218-953-11 RES-CHIP 1K 5% 1/16W
R937 1-218-965-11 RES-CHIP 10K 5% 1/16W
R938 1-218-965-11 RES-CHIP 10K 5% 1/16W
R939 1-218-965-11 RES-CHIP 10K 5% 1/16W
R940 1-218-941-81 RES-CHIP 100 5% 1/16W
R941 1-218-965-11 RES-CHIP 10K 5% 1/16W
R942 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R943 1-218-959-11 RES-CHIP 3.3K 5% 1/16W
R944 1-218-965-11 RES-CHIP 10K 5% 1/16W
R945 1-218-965-11 RES-CHIP 10K 5% 1/16W
R946 1-218-965-11 RES-CHIP 10K 5% 1/16W
R948 1-218-965-11 RES-CHIP 10K 5% 1/16W
R949 1-218-965-11 RES-CHIP 10K 5% 1/16W
R950 1-218-973-11 RES-CHIP 47K 5% 1/16W
R951 1-218-965-11 RES-CHIP 10K 5% 1/16W
R952 1-218-941-81 RES-CHIP 100 5% 1/16W
R954 1-218-965-11 RES-CHIP 10K 5% 1/16W
R955 1-218-965-11 RES-CHIP 10K 5% 1/16W
R956 1-218-965-11 RES-CHIP 10K 5% 1/16W
R957 1-218-965-11 RES-CHIP 10K 5% 1/16W
R959 1-218-953-11 RES-CHIP 1K 5% 1/16W
R960 1-218-965-11 RES-CHIP 10K 5% 1/16W
130
R961 1-218-965-11 RES-CHIP 10K 5% 1/16W
R962 1-218-965-11 RES-CHIP 10K 5% 1/16W
R963 1-218-943-11 RES-CHIP 150 5% 1/16W
(CIS)
R963 1-218-947-11 RES-CHIP 330 5% 1/16W
(CH)
R963 1-218-953-11 RES-CHIP 1K 5% 1/16W
(E, MX)
R963 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
(EA, AUS)
R963 1-218-965-11 RES-CHIP 10K 5% 1/16W
(HK, SP, MY, TW, KR)
R964 1-218-973-11 RES-CHIP 47K 5% 1/16W
R965 1-218-965-11 RES-CHIP 10K 5% 1/16W
R966 1-218-945-11 RES-CHIP 220 5% 1/16W
R967 1-218-941-81 RES-CHIP 100 5% 1/16W
R968 1-218-941-81 RES-CHIP 100 5% 1/16W
R969 1-218-943-11 RES-CHIP 150 5% 1/16W
(S880)
R969 1-218-965-11 RES-CHIP 10K 5% 1/16W
(S550)
R970 1-218-965-11 RES-CHIP 10K 5% 1/16W
R971 1-218-965-11 RES-CHIP 10K 5% 1/16W
R972 1-218-965-11 RES-CHIP 10K 5% 1/16W
R974 1-218-990-11 SHORT CHIP 0
R977 1-218-969-11 RES-CHIP 22K 5% 1/16W
R978 1-218-953-11 RES-CHIP 1K 5% 1/16W
R979 1-218-973-11 RES-CHIP 47K 5% 1/16W
R980 1-218-973-11 RES-CHIP 47K 5% 1/16W
R981 1-218-953-11 RES-CHIP 1K 5% 1/16W
(EA)
R981 1-218-955-11 RES-CHIP 1.5K 5% 1/16W
(AUS)
R981 1-218-961-11 RES-CHIP 4.7K 5% 1/16W
(CIS, E, MX, CH)
R981 1-218-965-11 RES-CHIP 10K 5% 1/16W
(AEP, UK)
R985 1-218-985-11 RES-CHIP 470K 5% 1/16W
R986 1-218-973-11 RES-CHIP 47K 5% 1/16W
R987 1-218-973-11 RES-CHIP 47K 5% 1/16W
R988 1-218-990-11 SHORT CHIP 0
R989 1-218-990-11 SHORT CHIP 0
R990 1-218-967-11 RES-CHIP 15K 5% 1/16W
R991 1-218-965-11 RES-CHIP 10K 5% 1/16W
R992 1-218-965-11 RES-CHIP 10K 5% 1/16W
R993 1-218-953-11 RES-CHIP 1K 5% 1/16W
R998 1-218-965-11 RES-CHIP 10K 5% 1/16W
R999 1-218-955-11 RES-CHIP 1.5K 5% 1/16W
< COMPOSITION CIRCUIT BLOCK >
* RB901 1-233-270-11 NETWORK, RES (8 GANG) 10K
< VIBRATOR >
X301 1-781-945-21 VIBRATOR, CERAMIC (20MHz)
X302 1-795-630-11 VIBRATOR, CRYSTAL (27MHz)
X600 1-781-465-21 VIBRATOR, CRYSTAL (12.288MHz)
X601 1-795-363-21 VIBRATOR, CERAMIC (13.5MHz)
X901 1-781-945-21 VIBRATOR, CERAMIC (20MHz)
**************************************************************

HCD-S550/S880
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
FB805 1-469-144-21 FERRITE 0uH
D SENSOR BOARD
****************
< JACK >
< PHOTO SENSOR >
IC731 8-749-017-45 SENSOR, PHOTO RPR-220C1N
**************************************************************
ENCODER BOARD
***************
< SWITCH >
S741 1-477-161-11 ENCODER (MODE)
**************************************************************
1-685-082-11 FL BOARD
*********
4-240-402-01 FL HOLDER
< CAPACITOR >
C808 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C813 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C814 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C815 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C816 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C817 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C818 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C819 1-162-974-11 CERAMIC CHIP 0.01uF 50V
< FLUORESCENT INDICATOR TUBE >
FL801 1-518-824-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC801 8-759-827-68 IC NJL62H400A-1
IC802 6-700-112-01 IC MSM9202-05GS-KDR1
< RESISTOR >
R815 1-216-805-11 METAL CHIP 47 5% 1/10W
R839 1-216-833-11 METAL CHIP 10K 5% 1/10W
R840 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
**************************************************************
1-685-083-11 HP BOARD
*********
< CAPACITOR >
C902 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C903 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C904 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C991 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C992 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
< CONNECTOR >
* CN900 1-506-987-11 PIN, CONNECTOR (PC BOARD) 5P
< FERRITE BEAD >
FB803 1-469-144-21 FERRITE 0uH
FB804 1-469-144-21 FERRITE 0uH
D SENSOR ENCODER FL HP I/O
J900 1-566-891-21 JACK (PHONES)
< COIL >
L900 1-410-387-11 INDUCTOR CHIP 33uH
L901 1-410-387-11 INDUCTOR CHIP 33uH
L902 1-469-144-21 FERRITE 0uH
L903 1-469-144-21 FERRITE 0uH
< TRANSISTOR >
Q900 8-729-920-31 TRANSISTOR DTC343TK-T-146
Q901 8-729-920-31 TRANSISTOR DTC343TK-T-146
< RESISTOR >
R900 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R901 1-216-807-11 METAL CHIP 68 5% 1/10W
R902 1-216-807-11 METAL CHIP 68 5% 1/10W
R903 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R991 1-218-990-11 SHORT, CHIP 0
R992 1-218-990-11 SHORT, CHIP 0
**************************************************************
A-4676-939-A I/O BOARD, COMPLETE (S550: AEP, UK, CIS)
A-4729-045-A I/O BOARD, COMPLETE (S880: AEP, UK, CIS)
A-4729-906-A I/O BOARD, COMPLETE
(E, AUS, HK, EA, MX, SP, MY, TW)
A-4730-166-A I/O BOARD, COMPLETE (KR)
A-4731-092-A I/O BOARD, COMPLETE (CH)
*******************
< CAPACITOR >
C201 1-162-959-11 CERAMIC CHIP 330PF 5% 50V
(AEP, UK, CIS)
C202 1-126-934-11 ELECT 220uF 20% 16V
C203 1-164-156-11 CERAMIC CHIP 0.1uF 25V
(AEP, UK, CIS)
C204 1-164-739-11 CERAMIC CHIP 560PF 5% 50V
(AEP, UK, CIS)
C205 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
(AEP, UK, KR, CH, CIS)
C206 1-164-380-11 CERAMIC CHIP 51PF 5% 50V
(AEP, UK, CIS)
C207 1-126-963-11 ELECT 4.7uF 20% 50V
(AEP, UK, CIS)
C208 1-162-924-11 CERAMIC CHIP 56PF 5% 50V
(AEP, UK, CIS)
C209 1-126-947-11 ELECT 47uF 20% 16V
(AEP, UK, CIS)
C210 1-128-551-11 ELECT 22uF 20% 25V
C211 1-128-551-11 ELECT 22uF 20% 25V
C213 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C214 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C215 1-115-156-11 CERAMIC CHIP 1uF 10V
C216 1-115-156-11 CERAMIC CHIP 1uF 10V
C217 1-126-934-11 ELECT 220uF 20% 16V
C218 1-126-947-11 ELECT 47uF 20% 35V
C220 1-128-551-11 ELECT 22uF 20% 25V
C221 1-124-234-00 ELECT 22uF 20% 16V
131

HCD-S550/S880
I/O
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C222 1-124-234-00 ELECT 22uF 20% 16V
C223 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C224 1-128-551-11 ELECT 22uF 20% 25V
C225 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C226 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C227 1-124-234-00 ELECT 22uF 20% 16V
C228 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C229 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C230 1-126-964-11 ELECT 10uF 20% 50V
C231 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C232 1-126-964-11 ELECT 10uF 20% 50V
C233 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C234 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C235 1-128-551-11 ELECT 22uF 20% 25V
C236 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C237 1-128-551-11 ELECT 22uF 20% 25V
C238 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C239 1-128-551-11 ELECT 22uF 20% 25V
C240 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C241 1-128-551-11 ELECT 22uF 20% 25V
C242 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C243 1-126-157-11 ELECT 10uF 20% 16V
C244 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C245 1-126-964-11 ELECT 10uF 20% 50V
C248 1-128-551-11 ELECT 22uF 20% 25V
C249 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C265 1-126-157-11 ELECT 10uF 20% 16V
C267 1-124-584-00 ELECT 100uF 20% 10V
C268 1-126-933-11 ELECT 100uF 20% 16V
C269 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C272 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C274 1-126-157-11 ELECT 10uF 20% 16V
C275 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C276 1-126-964-11 ELECT 10uF 20% 50V
C277 1-128-551-11 ELECT 22uF 20% 25V
C278 1-126-157-11 ELECT 10uF 20% 16V
C279 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C280 1-126-960-11 ELECT 1uF 20% 50V
C281 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C282 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C283 1-126-960-11 ELECT 1uF 20% 50V
C284 1-126-933-11 ELECT 100uF 20% 16V
C285 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C286 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C287 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C288 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C289 1-126-964-11 ELECT 10uF 20% 50V
C290 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C291 1-126-964-11 ELECT 10uF 20% 50V
C292 1-126-934-11 ELECT 220uF 20% 16V
C293 1-126-933-11 ELECT 100uF 20% 16V
C294 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C295 1-126-935-11 ELECT 470uF 20% 10V
C296 1-126-933-11 ELECT 100uF 20% 16V
C297 1-126-934-11 ELECT 220uF 20% 16V
C298 1-126-933-11 ELECT 100uF 20% 16V
C299 1-126-933-11 ELECT 100uF 20% 16V
132
C300 1-128-551-11 ELECT 22uF 20% 25V
C301 1-126-933-11 ELECT 100uF 20% 16V
C302 1-128-551-11 ELECT 22uF 20% 25V
C330 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C608 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
C609 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
< CONNECTOR >
CN201 1-784-733-11 CONNECTOR, FFC 11P
CN202 1-779-566-21 CONNECTOR, FFC (LIF (NON-ZIF)) 29P
CN203 1-779-551-21 CONNECTOR, FFC (LIF (NON-ZIF)) 14P
CN205 1-506-481-11 PIN, CONNECTOR 2P
< DIODE/SHORT >
D201 8-719-056-78 DIODE UDZ-TE-17-4.3B (AEP, UK, CIS)
D202 1-216-295-11 SHORT
D203 8-719-404-50 DIODE MA111-TX
D204 1-216-864-11 SHORT
< IC >
IC201 8-759-557-36 IC BU1924F-E2 (AEP, UK, CIS)
IC202 8-759-385-76 IC MC14052 BDR2
IC204 6-600-013-01 IC TORX179L (OPTICAL DIGITAL IN VIDEO2)
IC206 6-702-334-01 IC MM1510
IC207 8-759-696-10 IC NJM2235V (TE2)
IC208 6-702-335-01 IC MM1568
IC209 8-759-284-49 IC NJM2285V-TE2
< JACK >
J202 1-694-920-11 TERMINAL BOARD (S TERMINAL+1P)
(MONITOR OUT)
J205 1-816-604-11 JACK, PIN 6P
(VIDEO 2/COMPONENT VIDEO OUT)
J206 1-816-605-11 JACK, PIN 6P (VIDEO 1)
< COIL >
L202 1-469-525-11 INDUCTOR 10uH
L205 1-469-525-11 INDUCTOR 10uH
L206 1-469-525-11 INDUCTOR 10uH
L207 1-469-525-11 INDUCTOR 10uH
L209 1-469-525-11 INDUCTOR 10uH
< TRANSISTOR >
Q201 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
(AEP, UK, CIS)
Q205 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q206 8-729-901-00 TRANSISTOR DTC124EKA-T146
Q207 8-729-920-31 TRANSISTOR DTC343TK-T-146
Q208 8-729-920-31 TRANSISTOR DTC343TK-T-146
Q210 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q214 1-801-806-11 TRANSISTOR DTC144EKA-T146
Q220 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q221 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
Q222 8-729-026-50 TRANSISTOR 2SA1037AK-T146
Q223 8-729-901-00 TRANSISTOR DTC124EKA-T146

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
< RESISTOR >
R201 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
(AEP, UK, CIS)
R202 1-216-821-11 METAL CHIP 1K 5% 1/10W
(AEP, UK, CIS)
R203 1-216-843-11 METAL CHIP 68K 5% 1/10W
(AEP, UK, CIS)
R204 1-216-841-11 METAL CHIP 47K 5% 1/10W
(AEP, UK, CIS)
R205 1-216-845-11 METAL CHIP 100K 5% 1/10W
(AEP, UK, CIS)
R206 1-216-853-11 METAL CHIP 470K 5% 1/10W
(AEP, UK, CIS)
R207 1-216-814-11 METAL CHIP 270 5% 1/10W
(AEP, UK, CIS)
R208 1-216-813-11 METAL CHIP 220 5% 1/10W
R209 1-216-813-11 METAL CHIP 220 5% 1/10W
R210 1-216-813-11 METAL CHIP 220 5% 1/10W
R211 1-216-813-11 METAL CHIP 220 5% 1/10W
R212 1-216-813-11 METAL CHIP 220 5% 1/10W
R213 1-216-841-11 METAL CHIP 47K 5% 1/10W
R214 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R215 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R216 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R217 1-216-839-11 METAL CHIP 33K 5% 1/10W
R218 1-216-833-11 METAL CHIP 10K 5% 1/10W
R219 1-216-809-11 METAL CHIP 100 5% 1/10W
R220 1-216-845-11 METAL CHIP 100K 5% 1/10W
R221 1-216-845-11 METAL CHIP 100K 5% 1/10W
R222 1-216-839-11 METAL CHIP 33K 5% 1/10W
R223 1-216-833-11 METAL CHIP 10K 5% 1/10W
R224 1-216-809-11 METAL CHIP 100 5% 1/10W
R225 1-216-839-11 METAL CHIP 33K 5% 1/10W
R226 1-216-839-11 METAL CHIP 33K 5% 1/10W
R227 1-216-821-11 METAL CHIP 1K 5% 1/10W
R228 1-216-821-11 METAL CHIP 1K 5% 1/10W
R229 1-216-845-11 METAL CHIP 100K 5% 1/10W
R230 1-216-845-11 METAL CHIP 100K 5% 1/10W
R231 1-218-285-11 METAL CHIP 75 5% 1/10W
R232 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R233 1-216-833-11 METAL CHIP 10K 5% 1/10W
R235 1-216-841-11 METAL CHIP 47K 5% 1/10W
R236 1-216-833-11 METAL CHIP 10K 5% 1/10W
R237 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R238 1-216-833-11 METAL CHIP 10K 5% 1/10W
R241 1-216-841-11 METAL CHIP 47K 5% 1/10W
R242 1-216-833-11 METAL CHIP 10K 5% 1/10W
R243 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R244 1-216-833-11 METAL CHIP 10K 5% 1/10W
R246 1-216-841-11 METAL CHIP 47K 5% 1/10W
R247 1-216-833-11 METAL CHIP 10K 5% 1/10W
R249 1-218-867-11 METAL CHIP 6.8K 5% 1/10W
R250 1-216-833-11 METAL CHIP 10K 5% 1/10W
R251 1-218-285-11 METAL CHIP 75 5% 1/10W
R252 1-216-833-11 METAL CHIP 10K 5% 1/10W
R253 1-216-841-11 METAL CHIP 47K 5% 1/10W
R254 1-218-285-11 METAL CHIP 75 5% 1/10W
R255 1-216-809-11 METAL CHIP 100 5% 1/10W
The components identified by
mark 0 or dotted line with
mark 0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
HCD-S550/S880
R256 1-216-833-11 METAL CHIP 10K 5% 1/10W
R259 1-218-285-11 METAL CHIP 75 5% 1/10W
R265 1-216-833-11 METAL CHIP 10K 5% 1/10W
R266 1-216-833-11 METAL CHIP 10K 5% 1/10W
R267 1-218-285-11 METAL CHIP 75 5% 1/10W
R268 1-218-285-11 METAL CHIP 75 5% 1/10W
R269 1-218-285-11 METAL CHIP 75 5% 1/10W
R270 1-218-285-11 METAL CHIP 75 5% 1/10W
R273 1-218-285-11 METAL CHIP 75 5% 1/10W
R278 1-216-833-11 METAL CHIP 10K 5% 1/10W
R286 1-216-833-11 METAL CHIP 10K 5% 1/10W
R290 1-216-853-11 METAL CHIP 470K 5% 1/10W
R291 1-216-853-11 METAL CHIP 470K 5% 1/10W
R292 1-216-821-11 METAL CHIP 1K 5% 1/10W
R293 1-216-821-11 METAL CHIP 1K 5% 1/10W
R294 1-216-815-11 METAL CHIP 330 5% 1/10W
R295 1-216-815-11 METAL CHIP 330 5% 1/10W
R300 1-216-864-11 SHORT
R301 1-216-864-11 SHORT
R302 1-216-864-11 SHORT
R303 1-216-864-11 SHORT
< VIBRATOR >
X201 1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz)
(AEP, UK, CIS)
**************************************************************
A-4676-932-A POWER BOARD, COMPLETE
(AEP, UK, CIS, HK, SP, MY, AUS, CH)
A-4730-623-A POWER BOARD, COMPLETE (E)
A-4730-615-A POWER BOARD, COMPLETE (EA)
A-4730-164-A POWER BOARD, COMPLETE (KR)
A-4730-608-A POWER BOARD, COMPLETE (MX, TW)
***********************
7-685-548-14 SCREW +BTP 3X12 TYPE2 N-S
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
I/O POWER
0C901 1-126-163-11 ELECT 4.7uF 20% 50V
0C902 1-104-705-11 MYLAR 0.1uF 20% 250V
0C903 1-104-705-11 MYLAR 0.1uF 20% 250V
0C904 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
0C905 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
0C909 1-113-920-11 CERAMIC 2200PF 20% 250V
0C910 1-113-920-11 CERAMIC 2200PF 20% 250V
0C911 1-113-920-11 CERAMIC 2200PF 20% 250V
0C912 1-100-192-11 ELECT 1000uF 20% 200V
(MX, TW)
0C912 1-165-911-21 ELECT 390uF 20% 450V
(EXCEPT MX, TW)
0C913 1-117-452-11 FILM 3300PF 5% 630V
0C914 1-119-772-11 ELECT 47uF 20% 35V
C915 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
0C916 1-117-824-11 FILM 2200PF 3% 1.5KV
(MX, TW)
0C916 1-104-332-11 FILM 470PF 10% 2KV
(EXCEPT MX, TW)
C918 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
133

HCD-S550/S880
POWER
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
0 C919 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
(MX, TW)
< GROUND TERMINAL >
0 C919 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V EB901 1-537-770-21 TERMINAL BOARD, GROUND
(EXCEPT MX, TW) EB902 1-537-770-21 TERMINAL BOARD, GROUND
C920 1-117-454-11 FILM 4700PF 5% 630V EB903 1-537-770-21 TERMINAL BOARD, GROUND
C921 1-115-819-11 ELECT 2200uF 20% 35V
< IC >
C922 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C923 1-115-819-11 ELECT 2200uF 20% 35V 0 IC901 6-702-338-01 IC STR-F6238 (MX, TW)
C924 1-126-953-11 ELECT 2200uF 20% 35V 0 IC901 6-703-098-01 IC STR-F6267D (EXCEPT MX, TW)
C925 1-126-160-11 ELECT 1uF 20% 50V IC902 6-700-388-01 IC SE-B2
C926 1-162-927-11 CERAMIC CHIP 100PF 5% 50V IC903 8-759-474-09 IC SI-8050S-LF1101
IC904 8-759-332-29 IC M51945BL
C927 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C928 1-126-953-11 ELECT 2200uF 20% 35V IC905 8-759-450-47 IC BA05T
C929 1-124-584-00 ELECT 100uF 20% 10V IC906 6-700-813-01 IC SI-8033JF
C930 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V IC908 6-701-021-01 IC SI-8120JF
C931 1-165-723-21 ELECT 1000uF
IC909 8-759-970-89 IC BA10358F-T1
C932 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C933 1-165-723-21 ELECT 1000uF
C934 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C935 1-128-950-21 ELECT 1000uF 16V
C936 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C937 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
0 C938 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
0 C939 1-117-699-11 CERAMIC 0.001uF 250V
C941 1-126-947-11 ELECT 47uF 20% 16V
C943 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
C946 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V
134
< CONNECTOR >
CN902 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
* CN903 1-506-996-11 PIN, CONNECTOR (PC BOARD) 14P
CN904 1-565-731-11 PLUG, CONNECTOR (2.5mm) 5P
< DIODE >
0 D902 8-719-022-92 DIODE RBV-604 (MX, TW)
0 D902 8-719-312-05 DIODE RBV-606 (EXCEPT MX, TW)
D904 8-719-109-97 DIODE MTZJ-T-77-6.8B
0 D905 8-719-991-33 DIODE 1SS133T-77
0 D906 8-719-200-91 DIODE 11EQS10-TA1
0 D907 8-719-991-33 DIODE 1SS133T-77
0 D908 6-500-241-01 DIODE SARS03
D911 8-719-313-14 DIODE FML-22S
D912 8-719-109-93 DIODE RD6.2ESB2
D913 8-719-404-50 DIODE MA111-TX
D914 8-719-312-08 DIODE FMB-G16L
D915 8-719-200-82 DIODE 11ES2
D916 8-719-312-08 DIODE FMB-G16L
D917 8-719-200-82 DIODE 11ES2-NTA1B
0 D919 8-719-084-21 DIODE 10E6N-TA1B2
0 D920 8-719-084-21 DIODE 10E6N-TA1B2
D921 8-719-210-21 DIODE 11EQS04-TA1B
0 D931 8-719-110-53 DIODE MTZJ-T-77-20B
0 D932 8-719-924-13 DIODE MTZJ-T-77-22B
0 D933 8-719-200-91 DIODE 11EQS10-TA1
D990 8-719-404-50 DIODE MA111-TX
The components identified by
mark 0 or dotted line with
mark 0 are critical for safety.
Replace only with part number
specified.
< COIL >
L901 1-424-860-11 INDUCTOR 10uH
L902 1-456-183-11 COIL, CHOKE 150uH
L903 1-456-182-11 COIL, CHOKE 100uH
L904 1-414-398-11 INDUCTOR 10uH
L905 1-414-398-11 INDUCTOR 10uH
L906 1-414-398-11 INDUCTOR 10uH
L907 1-414-398-11 INDUCTOR 10uH
L908 1-414-398-11 INDUCTOR 10uH
L909 1-456-213-11 COIL, CHOKE 100uH
L910 1-414-398-11 INDUCTOR 10uH
L911 1-414-398-11 INDUCTOR 10uH
< LINE FILTER >
0 LF901 1-456-081-11 FILTER, LINE (EXCEPT MX, TW)
0 LF901 1-456-082-11 FILTER, LINE (MX, TW)
0 LF902 1-456-081-11 FILTER, LINE (EXCEPT MX, TW)
0 LF902 1-456-082-11 FILTER, LINE (MX, TW)
< IC >
0 PC901 8-749-019-04 IC TLP421
< TRANSISTOR >
Q901 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q902 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q903 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q904 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R
0 Q905 8-729-111-29 TRANSISTOR 2SD1616A-TP-LK
Q906 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q910 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q911 8-729-900-53 TRANSISTOR DTC114EKA-T146
Q912 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R
Q914 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R
Q990 8-729-026-67 TRANSISTOR 2SB1640 (TP)
Q991 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R
Q992 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R
< RESISTOR >
0 R901 1-216-813-11 METAL CHIP 220 5% 1/10W
0 R902 1-245-392-51 METAL OXIDE 0.15 5% 1W
(MX, TW)
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
0 R903 1-245-392-51 METAL OXIDE 0.15 5% 1W
0 R904 1-216-341-11 METAL OXIDE 0.22 5% 1W
0 R905 1-215-926-00 METAL OXIDE 33K 5% 3W
(MX, TW)
0 R905 1-215-928-11 METAL OXIDE 68K 5% 3W
(EXCEPT MX, TW)
R906 1-216-833-11 METAL CHIP 10K 5% 1/10W
0 R907 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
0 R908 1-215-928-11 METAL OXIDE 68K 5% 3W
(EXCEPT MX, TW)
0 R909 1-215-902-11 METAL OXIDE 47K 5% 2W
R910 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
0 R911 1-216-828-11 METAL CHIP 3.9K 5% 1/10W
0 R912 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
0 R913 1-249-385-11 CARBON 2.2 5% 1/6W
R914 1-216-826-11 METAL CHIP 2.7K 5% 1/10W
R915 1-216-812-11 METAL CHIP 180 5% 1/10W
R916 1-216-821-11 METAL CHIP 1K 5% 1/10W
(EXCEPT MX, TW)
R916 1-216-822-11 METAL CHIP 1.2K 5% 1/10W
(MX, TW)
R917 1-216-826-11 METAL CHIP 2.7K 5% 1/10W
R918 1-216-826-11 METAL CHIP 2.7K 5% 1/10W
R919 1-216-833-11 METAL CHIP 10K 5% 1/10W
R920 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R921 1-216-837-11 METAL CHIP 22K 5% 1/10W
R922 1-218-866-11 METAL CHIP 6.2K 0.5% 1/10W
R923 1-216-833-11 METAL CHIP 10K 5% 1/10W
R924 1-216-818-11 METAL CHIP 560 5% 1/10W
R925 1-216-812-11 METAL CHIP 180 5% 1/10W
R926 1-216-845-11 METAL CHIP 100K 5% 1/10W
R927 1-216-821-11 METAL CHIP 1K 5% 1/10W
R928 1-216-837-11 METAL CHIP 22K 5% 1/10W
R929 1-216-797-11 METAL CHIP 10 5% 1/10W
0 R930 1-219-237-11 SOLID 3.3M 20% 1/2W
(EXCEPT MX, TW)
R931 1-216-826-11 METAL CHIP 2.7K 5% 1/10W
R932 1-216-837-11 METAL CHIP 22K 5% 1/10W
R933 1-216-837-11 METAL CHIP 22K 5% 1/10W
0 R934 1-215-904-11 METAL OXIDE 100K 5% 2W
(EXCEPT MX, TW)
R935 1-216-845-11 METAL CHIP 100K 5% 1/10W
R936 1-216-847-11 METAL CHIP 150K 5% 1/10W
R937 1-216-821-11 METAL CHIP 1K 5% 1/10W
R938 1-216-065-00 METAL CHIP 4.7K 5% 1/10W
R939 1-216-049-11 METAL CHIP 1K 5% 1/10W
R940 1-216-077-00 METAL CHIP 15K 5% 1/10W
R941 1-216-833-11 METAL CHIP 10K 5% 1/10W
R942 1-216-049-11 METAL CHIP 1K 5% 1/10W
R943 1-216-824-11 METAL CHIP 1.8K 5% 1/10W
< TRANSFORMER >
0 T901 1-437-865-11 TRANSFORMER, POWER (MX, TW)
0 T901 1-437-866-11 TRANSFORMER, POWER (EXCEPT MX, TW)
< THERMISTOR >
0 TH901 1-803-916-11 THERMISTOR, NTC
**************************************************************
The components identified by
mark 0 or dotted line with
mark 0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
POWER LED BOARD
*****************
< LED >
HCD-S550/S880
POWER POWER LED POWER S/W RELAY
D812 8-719-074-42 LED SLR325VR-T31 (STANDBY)
< RESISTOR >
R804 1-216-817-11 METAL CHIP 470 5% 1/10W
**************************************************************
POWER SW BOARD
****************
< CONNECTOR >
* CN900 1-568-226-11 PIN, CONNECTOR (3.96mm PITCH) 2P
* CN901 1-568-226-11 PIN, CONNECTOR (3.96mm PITCH) 2P
< SWITCH >
0S901 1-786-377-11 SWITCH, POWER (POWER)
**************************************************************
A-4676-588-A RELAY BOARD, COMPLETE
**********************
< CAPACITOR >
C701 1-126-795-11 ELECT 10uF 20.00% 50V
C709 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C712 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C713 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
< CONNECTOR >
CN701 1-785-732-21 CONNECTOR, FFC/FPC 18P
< DIODE >
D701 8-719-083-57 DIODE UDZSTE-173.6B
D711 8-719-069-54 DIODE UDZSTE-175.1B
< IC >
IC701 8-759-598-69 IC BA6956AN
IC711 8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q701 8-729-230-49 TRANSISTOR 2SC2712-YG-TE85L
< RESISTOR >
R701 1-216-819-11 METAL CHIP 680 5% 1/10W
R702 1-216-809-11 METAL CHIP 100 5% 1/10W
R703 1-216-819-11 METAL CHIP 680 5% 1/10W
R704 1-216-809-11 METAL CHIP 100 5% 1/10W
R706 1-216-833-11 METAL CHIP 10K 5% 1/10W
R707 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R708 1-216-833-11 METAL CHIP 10K 5% 1/10W
R709 1-216-845-11 METAL CHIP 100K 5% 1/10W
R710 1-216-821-11 METAL CHIP 1K 5% 1/10W
R711 1-216-815-11 METAL CHIP 330 5% 1/10W
R712 1-216-815-11 METAL CHIP 330 5% 1/10W
R713 1-216-815-11 METAL CHIP 330 5% 1/10W
135

HCD-S550/S880
RELAY RF SEL
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R714 1-216-815-11 METAL CHIP 330 5% 1/10W
**************************************************************
136
A-4728-690-A RF BOARD, COMPLETE
*******************
< CAPACITOR >
C001 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C002 1-124-779-00 ELECT CHIP 10uF 20% 16V
C003 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C004 1-124-779-00 ELECT CHIP 10uF 20% 16V
C005 1-128-993-21 ELECT CHIP 22uF 20% 10V
C006 1-128-993-21 ELECT CHIP 22uF 20% 10V
C008 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C009 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C010 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V
C011 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V
C012 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C013 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C014 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C015 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C016 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C017 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C018 1-164-172-11 CERAMIC CHIP 0.0056uF 10% 25V
C019 1-164-172-11 CERAMIC CHIP 0.0056uF 10% 25V
C020 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C021 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C022 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C023 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C024 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C025 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C026 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C027 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C028 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C029 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C030 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C031 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V
C032 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C033 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C034 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C035 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C036 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V
C037 1-162-959-11 CERAMIC CHIP 330PF 5% 50V
C038 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V
C039 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V
C040 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C041 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C042 1-164-218-11 CERAMIC CHIP 180PF 0.25PF 50V
C049 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
< CONNECTOR >
CN001 1-815-031-11 CONNECTOR, FFC/FPC (ZIF) 24P
CN002 1-784-836-21 CONNECTOR, FFC (LIF (NON-ZIF)) 29P
CN003 1-784-861-21 CONNECTOR, FFC (LIF (NON-ZIF)) 9P
< DIODE >
D001 8-719-988-61 DIODE 1SS355TE-17
D002 8-719-988-61 DIODE 1SS355TE-17
< IC >
IC001 8-752-417-53 IC CXD1881AR
< COIL >
L001 1-412-031-11 INDUCTOR CHIP 47uH
L002 1-412-031-11 INDUCTOR CHIP 47uH
< TRANSISTOR >
Q001 8-729-903-46 TRANSISTOR 2SB1132-T100-QR
Q002 8-729-903-46 TRANSISTOR 2SB1132-T100-QR
< RESISTOR >
R001 1-218-668-11 METAL CHIP 100 0.5% 1/16W
R003 1-216-803-11 METAL CHIP 33 5% 1/10W
R004 1-216-803-11 METAL CHIP 33 5% 1/10W
R005 1-216-841-11 METAL CHIP 47K 5% 1/10W
R006 1-216-817-11 METAL CHIP 470 5% 1/10W
R007 1-216-803-11 METAL CHIP 33 5% 1/10W
R008 1-216-803-11 METAL CHIP 33 5% 1/10W
R009 1-216-841-11 METAL CHIP 47K 5% 1/10W
R010 1-216-817-11 METAL CHIP 470 5% 1/10W
R011 1-216-864-11 METAL CHIP 0 5% 1/10W
R012 1-216-864-11 METAL CHIP 0 5% 1/10W
R013 1-216-864-11 METAL CHIP 0 5% 1/10W
R014 1-216-864-11 METAL CHIP 0 5% 1/10W
R015 1-216-864-11 METAL CHIP 0 5% 1/10W
R016 1-216-864-11 METAL CHIP 0 5% 1/10W
R017 1-216-864-11 METAL CHIP 0 5% 1/10W
R018 1-216-864-11 METAL CHIP 0 5% 1/10W
R019 1-216-864-11 METAL CHIP 0 5% 1/10W
R020 1-216-864-11 METAL CHIP 0 5% 1/10W
R021 1-216-864-11 METAL CHIP 0 5% 1/10W
R022 1-216-813-11 METAL CHIP 220 5% 1/10W
R023 1-216-820-11 METAL CHIP 820 5% 1/10W
R024 1-216-864-11 METAL CHIP 0 5% 1/10W
R025 1-216-809-11 METAL CHIP 100 5% 1/10W
R026 1-218-718-11 METAL CHIP 12K 0.5% 1/16W
R027 1-216-864-11 METAL CHIP 0 5% 1/10W
R028 1-216-864-11 METAL CHIP 0 5% 1/10W
R029 1-216-864-11 METAL CHIP 0 5% 1/10W
R032 1-216-809-11 METAL CHIP 100 5% 1/10W
R033 1-216-864-11 METAL CHIP 0 5% 1/10W
R034 1-219-570-11 RES-CHIP 10M 5% 1/10W
R035 1-216-864-11 METAL CHIP 0 5% 1/10W
R041 1-216-821-11 METAL CHIP 1K 5% 1/10W
**************************************************************
SEL BOARD
**********
< SWITCH >
S801 1-771-692-11 SWITCH, SLIDE (SCAN SELECT)
**************************************************************

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
SWITCH BOARD
**************
< SWITCH >
S731 1-786-289-21 SWITCH, DETECTION (DISC SIZE)
**************************************************************
1-685-084-11 VOL BOARD
**********
< CAPACITOR >
C800 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C801 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
< CONNECTOR >
* CN820 1-568-941-11 PIN, CONNECTOR 3P
< SWITCH >
S800 1-418-632-11 ENCODER, ROTARY (VOLUME)
**************************************************************
MISCELLANEOUS
**************
152 1-824-477-11 FLEXIBLE FLAT CABLE (17 CORE)
153 1-824-475-11 FLEXIBLE FLAT CABLE (18 CORE)
154 1-824-476-11 FLEXIBLE FLAT CABLE (12 CORE)
155 1-824-624-11 FLEXIBLE FLAT CABLE (17 CORE)
156 1-824-474-11 FLEXIBLE FLAT CABLE (29 CORE)
157 1-824-473-11 FLEXIBLE FLAT CABLE (14 CORE)
158 1-687-072-11 PWB, FLEXIBLE
0 302 1-696-169-12 CORD, POWER
(AEP, UK, E, HK, EA, CIS, SP, MY, TW)
0 302 1-696-848-42 CORD, POWER (AUS)
0 302 1-769-079-22 CORD, POWER (KR)
0 302 1-775-789-91 CORD, POWER (MX)
0 302 1-782-464-22 CORD, POWER (CH)
305 1-824-486-11 FLEXIBLE FLAT CABLE (11 CORE)
0 703 1-477-263-11 PICKUP UNIT (TDP022W)
705 1-685-250-11 FLEXIBLE BOARD
0 F901 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (5A/125V)
M301 1-763-861-11 FAN, DC
M711 A-4746-746-A MOTOR (LD) ASSY (LOADING)
M751 A-4746-747-A MOTOR (CK) ASSY (EJECT)
The components identified by
mark 0 or dotted line with
mark 0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
HCD-S550/S880
Ver 1.3
SWITCH VOL
137

HCD-S550/S880
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver. Date Description of Revision
1.0 2002.08 New
1.1 2002.10 Addition of “RELEASING THE DISC SLOT LOCK” to the SERVIC
ING NOTES (SPM-02096)
1.2 2002.12 Correction of Part No. for EXTENSION CABLE (DVD board – AMP
board)
Addition of EXTENSION CABLE (WITH RELAY board) (RELAY
board – DVD board) (SPM-02112)
1.3 2003.01 Addition of “CHECKING OF OPERATIONS WITH REMOTE COM
MANDERS OF DIFFERENT MODELS” to the SERVICING NOTES
Addition of Ref. No. 156, 157, 158 (SPM-02118/03001)
1.4 2003.03 Addition of “TEST DISC LIST” to the TEST MODE
Addition of “AUTO SERVO ADJUSTMENT” to the ELECTRICAL
ADJUSTMENT (SPM-03008)
1.5 2004.02 Addition of Ref. No. 406 to EXPLODED VIEWS (SPM-04006)
1.6 2004.03 Addition of Chinese model to HCD-S880
Addition of “NOTE OF REPLACING THE DVD BOARD” to the
SERVICING NOTES