Little General Store Propane Explosion - US Chemical Safety and ...

More documents

Recommendations

Info

Little General Store September 2008 1.0 Introduction 1.1 Summary At 10:53 am on January 30, 2007, a propane explosion leveled the Flat Top Little General Store (Little General) in Ghent, Raleigh County, West Virginia (Figure 1). The explosion killed four and injured six. The dead included two emergency responders (a fire department captain and an emergency medical technician, both from the Ghent Volunteer Fire Department) and two Appalachian Heating propane service technicians. The injured included the four Little General employees who remained inside the store, and two other Ghent Volunteer Fire Department emergency responders. Figure 1. Aerial photograph of Little General store and surrounding plot. 4
Little General Store September 2008 The morning of the explosion, a junior propane service technician 1 (junior technician) from Appalachian Heating was preparing to transfer liquid propane from an existing tank owned by Ferrellgas to a newly installed tank 2 owned by Thompson Gas and Electric Services (Thompson). The Ferrellgas propane tank was installed in 1994 directly against the store’s exterior back wall (Figure 2). At about 10:25 am, the junior technician, working alone, removed a threaded plug from the liquid withdrawal valve 3 on the Ferrellgas tank and liquid propane began flowing uncontrollably. Liquid propane sprayed upward, against the roof overhang, and dense propane gas accumulated at ground level around the tank and the foundation of the building. Over the next 25 minutes, the escaping propane entered the Little General store through openings in the roof overhang. Shortly after the release began, the junior technician called the lead technician to report the release and seek guidance. At 10:40 am, the junior technician called 911 to report the emergency and summon help. A captain and two emergency medical technicians from the Ghent Volunteer Fire Department were the first to arrive, followed by the lead technician and two other emergency responders. Shortly after their arrival, the propane in the store ignited, leveling it and killing two emergency responders (the fire captain and one of the emergency medical technicians) and the two Appalachian Heating propane service technicians. 1 The report discusses the activities of two propane service technicians: a junior technician, who had been performing propane duties for one and a half months, and a lead technician, who had been performing propane duties for one and a half years. “Junior” and “lead” are used in this report to differentiate the technicians’ relative experience in propane service. 2 While commonly referred to as tanks, both of these were 500-gallon pressure vessels. The American Society of Mechanical Engineers (ASME) publishes the Boiler and Pressure Vessel code; generally, stationary propane tanks are considered unfired pressure vessels and manufactured in accordance with Section VIII of the code. 3 The liquid withdrawal valve was a RegO Chek-Lok valve model number 7572FC, which is no longer manufactured. Although the RegO name is still used on propane equipment, the company that manufactured this valve is no longer in business. 5
Page 1 and 2: U.S. CHEMICAL SAFETY AND HAZARD INV
Page 3 and 4: Little General Store September 2008
Page 9: Little General Store September 2008
Page 61 and 62:
Little General Store September 2008
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
show all

Little General Store Propane Explosion - US Chemical Safety and ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?