Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
VOLKSWAGEN Model: ~upo PololClassiclEstate GolfNentolBoralCabrio Beetle Passat (08190+) Corrado Sharan TransporterlCaravelle i Transmission VAG type 00270 00281 00283 00285 00287 00290 00293 00296 00297 EOBD type - - - 00299 1 - I Transmission mode selection switch I Wiring, transmission mode selection switch 00300 1 - 00347 - - - - - - I - Fault location Solenoid valve 7 00348 I - I Solenoid valve 9 00349 00350 00351 00518 00526 - - - - - Vehicle speed sensor (VSS) ABS control module, LH front wheel speed signal - rangelperformance problem ABS control module, RH front wheel speed signal - rangelperformance problem ABS control module, RH rear wheel speed signal - rangelperformance problem ABS control module, LH rear wheel speed signal - rangelperformance problem Transmission range (TR) switch Transmission kick-down switch Output shaft speed (OSS) sensor - no signal Transmission fluid temperature (TFT) sensor I Solenoid valve 8 Probable cause 00529 I - I Engine RPM input - no signal I Wiring, ECM 00532 - Wiring, poor connection, transmission internal wiring, solenoid valve Wiring, speedometer, insecure rotor, VSS Wiring, ABS trouble code@) stored, incorrect ABS control module Wiring, ABS trouble code@) stored, incorrect ABS control module Wiring, ABS trouble code(s) stored, incorrect ABS control module Wiring, ABS trouble code@) stored, incorrect ABS control module Wiring, poor connection, TR switch Wiring, accelerator cable adjustment, transmission kick-down switch, TP sensor Wiring, transmission speed sensor, multi-plugs for VSS and transmission speed sensor interchanged Wiring, poor connection, TFT sensor Wiring, poor connection, transmission internal wiring, solenoid valve Wiring, poor connection, transmission internal wiring, solenoid valve Alternator, battery, wiring 1 ECM Wiring, ECM,TCM 00543 I - I Maximum engine RPM exceeded Incorrect gear shift, CKPlRPM sensor, valve body, 00545 I - 1 1 - 00549 - 00596 00597 - - Solenoid valve 10- Earth return wire, modulation valve Transmission intermediate shaft speed sensor - no signal Throttle position (TP) sensor Stop lamp switch Transmission contrd module (TCM) - supply voltage ECMffCMelectricalconnection-torque reduction signal Transmission control module (TCM), fault memory - supply voltage, from battery ECMffCM electrical connection - fuel consumption signal Solenoid vahres - short circuit ABS control module, wheel speed signals - speed difference too great I Wiring, poor connection, transmission internal wiring, solenoid valve Wiring open circuit, TCM Wiring open circuit, transmission intermediate shaft speed sensor Wiring, signal from TP sensor or ECM, TP sensor Wiring, stop lamp switch Fuse, supply voltage wiring, earth wiring Wiring, ECM, TCM Poor connection, transmission internal wiring Wiring, ABS trouble code(s) stored, incorrect ABS control module
Model: Lupo PololClassiclEstate GolfNentolBoralCabrio Beetle VOLKSWAGEN - 2~ ~ J J Passat (08/90+) Corrado Sharan TransporterICaravelle Transmission VAG type 00638 00638 00641 00652 00660 00668 00753 00777 EOBD type 00789 1 - I Reverse gear position switch I Wiring, reverse gear position switch, TR switch 01 044 01 045 01166 01 192 01 196 01236 01312 01314 01316 16955 16987 16989 17086 17087 17090 17094 17095 17096 - - - - - - - - I - I - - - - - - - - - - - - - - - - - Fault location Enginelgearbox electrical connection - TP sensor signal Transmission control module (TChA) - supply voltage Transmission fluid temperature (TFT) sensor - high input Gear monitoring - implausible signal Transmission kick-down switchlthrottle position (TP) sensor - implausible signal Transmission control module (TCM) - supply voltage, fmm battery ABS control module, wheel speed signals - implausible CAN data bus, APP sensor - incorrect si~nal Transmission control module (TChA) - Tiptronic gear selection switch - incorrect signal Engine toque signal Torque converter clutch (TCC) solenoid - mechanical fault CAN data bus, ECMrrCM Selector lever lock solenoid CAN data bus - defective CAN data bus, ECM CAN data bus, ABS Stop lamp switch - rangelperformance problem Transmission control module (TCM)- KAM error Transmission control module (TCM)- ROM emr Transmission control module UCM) - defective Stop lamp switch - circuit malfunction Transmission range (TR) switch - range1 performance problem Transmission fluid temperature (TFT) sensor - circuit malfunction Transmission Ruid temperature VFT) sensor - rangelperformance problem Transmission fluid temperature (TFT) sensor - low input Probable cause Wiring, ECM, TCM Battery, alternator, wiring, TCM ATF level incorrect, towing weight limit exceeded, transmission internal wiring, TFT sensor Wiring, hydraulic fault, clutchlvalve body Wiring, accelerator cable adjustment, kick-down switch, TP sensor Wiring, fuse Wiring, ABS trouble code@) stored, incorrect ABS control module Wiring, APP sensor signal from ECM, ECM trouble code(s) stored Incorrectly coded Wiring, tiptronic gear selection switch Trouble codes 01312101314 stored, ECM incorrectly coded, faulty enginelcomponent(s), ECM ATF level, clutch slipping, TCC solenoid, valve body defective Ignition switched ON with TCM disconnected, wiring, ECM, TCM Wiring, selector lever lock solenoid Trouble code@) stored in other system@), wiring Wiring, ECM trouble code(s) stored, ECM incorrectly coded, wiring ABS control module trouble code(s) stored, wiring - Wiring, stop lamp switch TCM TCM TCM Wiring, stop lamp switch, ECM, TCM Wiring, TR sensor Wiring, TFT sensor Wiring, TFT sensor Wiring, TFT sensor --
- Page 730 and 731: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 732 and 733: Model: ~upo polo 1,3 PololClassiclE
- Page 734 and 735: VOLKSWAGEN Model Lupo Polo 1,3 Polo
- Page 736 and 737: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 738 and 739: Engine management Model. Lupo Polo
- Page 740 and 741: I VOLKSWAGEN Model: Lupo Polo 1,3 P
- Page 742 and 743: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 744 and 745: 1 744 I,.,,,,,,,, /AUfodata I Engin
- Page 746 and 747: Engine management Model: Lupo Polo
- Page 748 and 749: Engine management Model: Lupo Polo
- Page 750 and 751: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 752 and 753: Engine management Model: Lupo Polo
- Page 754 and 755: I Model: Lupo Polo 1,3 PololClassic
- Page 756 and 757: 1 756 I,,,.,,,.,,, /Autodata VOLKSW
- Page 758 and 759: 1 I,,,,,,,,,, 758 /Autodata F e man
- Page 760 and 761: I Engine management Erasing Method
- Page 762 and 763: 1 762 I,,,,,,,,,,,, /Autodata - J V
- Page 764 and 765: 1 VOLKSWAGEN Model: Polo 1 ,O5/l,3
- Page 766 and 767: VOLKSWAGEN Model: GolfNento 1,4 (-0
- Page 768 and 769: VOLKSWAGEN Model: GolfNento 1,4 (+0
- Page 770 and 771: Erasing Ensure ignition switched OF
- Page 772 and 773: Engine management Engine code: Syst
- Page 775 and 776: I Year: 03\95-96 I Engine code: 1E
- Page 777 and 778: 4 Model: Lupo PololClassiclEstate G
- Page 779: Trouble code identification VAG typ
- Page 783 and 784: Model: Lupo PololClassiclEstate Gol
- Page 785 and 786: General information Refer to the fr
- Page 787 and 788: :-$yp"' 00545 00596 00638 00641 006
- Page 789 and 790: Beetle Passat Corrado (10194-95) Sh
- Page 791 and 792: CaddyIPickup TransporterICaravelle
- Page 793 and 794: Mel: 440/460/ VOLVO Engine manageme
- Page 795 and 796: Trouble code identification Scanner
- Page 797 and 798: EFI-355 EFI-411 EFI-414 EFI-415 EFI
- Page 799 and 800: Model: SN40 1,6/1,8/1,9/2,0 SN40 1,
- Page 801 and 802: V70 2,4ITurbo C70 2,O Turbo C70 2,3
- Page 803 and 804: Model: S60 2,012,3 Turbo S60 2,4lTu
- Page 805 and 806: I I Model: S60 2,012,3 Turbo S60 2,
- Page 807 and 808: Model: 240 2,012,3 740 2,012,3 7401
- Page 809 and 810: 940 2,OITurbo 9401960 2,0/2,3ITurbo
- Page 811 and 812: I Engine management Erasing Ensure
- Page 813 and 814: Model: 850 2,O 850 2,3/2,5 850 2,5
- Page 815 and 816: Model: 850 2,O 850 2,312,5 850 2,5
- Page 817 and 818: Model: 850 2,O 850 2,3/2,5 850 2,5
- Page 819 and 820: Flash type Fault location Probable
- Page 821 and 822: Engine management I Ignition system
- Page 823 and 824: Model: 850 2,012,5 9401960 2,0/2,3/
- Page 825 and 826: 1 Transmission Erasing Ensure ignit
- Page 827 and 828: I Year: 'i Transmission - 850 - nea
- Page 829 and 830: Model: 850 SNIC7O 960 Scanner ty Pe
Model: Lupo PololClassiclEstate GolfNentolBoralCabrio Beetle<br />
VOLKSWAGEN - 2~<br />
~ J J<br />
Passat (08/90+) Corrado Sharan TransporterICaravelle<br />
Transmission<br />
VAG type<br />
00638<br />
00638<br />
00641<br />
00652<br />
00660<br />
00668<br />
00753<br />
00777<br />
EOBD type<br />
00789 1 - I Reverse gear position switch I Wiring, reverse gear position switch, TR switch<br />
01 044<br />
01 045<br />
01166<br />
01 192<br />
01 196<br />
01236<br />
01312<br />
01314<br />
01316<br />
16955<br />
16987<br />
16989<br />
17086<br />
17087<br />
17090<br />
17094<br />
17095<br />
17096<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
I -<br />
I -<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
-<br />
<strong>Fault</strong> location<br />
Enginelgearbox electrical connection -<br />
TP sensor signal<br />
Transmission control module (TChA) -<br />
supply voltage<br />
Transmission fluid temperature (TFT)<br />
sensor - high input<br />
Gear monitoring - implausible signal<br />
Transmission kick-down switchlthrottle<br />
position (TP) sensor - implausible signal<br />
Transmission control module (TCM) -<br />
supply voltage, fmm battery<br />
ABS control module, wheel speed<br />
signals - implausible<br />
CAN data bus, APP sensor - incorrect<br />
si~nal<br />
Transmission control module (TChA) -<br />
Tiptronic gear selection switch -<br />
incorrect signal<br />
Engine toque signal<br />
Torque converter clutch (TCC) solenoid -<br />
mechanical fault<br />
CAN data bus, ECMrrCM<br />
Selector lever lock solenoid<br />
CAN data bus - defective<br />
CAN data bus, ECM<br />
CAN data bus, ABS<br />
Stop lamp switch - rangelperformance<br />
problem<br />
Transmission control module (TCM)-<br />
KAM error<br />
Transmission control module (TCM)-<br />
ROM emr<br />
Transmission control module UCM) -<br />
defective<br />
Stop lamp switch - circuit malfunction<br />
Transmission range (TR) switch - range1<br />
performance problem<br />
Transmission fluid temperature (TFT)<br />
sensor - circuit malfunction<br />
Transmission Ruid temperature VFT)<br />
sensor - rangelperformance problem<br />
Transmission fluid temperature (TFT)<br />
sensor - low input<br />
Probable cause<br />
Wiring, ECM, TCM<br />
Battery, alternator, wiring, TCM<br />
ATF level incorrect, towing weight limit exceeded,<br />
transmission internal wiring, TFT sensor<br />
Wiring, hydraulic fault, clutchlvalve body<br />
Wiring, accelerator cable adjustment, kick-down<br />
switch, TP sensor<br />
Wiring, fuse<br />
Wiring, ABS trouble code@) stored, incorrect ABS<br />
control module<br />
Wiring, APP sensor signal from ECM, ECM trouble<br />
code(s) stored<br />
Incorrectly coded<br />
Wiring, tiptronic gear selection switch<br />
<strong>Trouble</strong> codes 01312101314 stored, ECM incorrectly<br />
coded, faulty enginelcomponent(s), ECM<br />
ATF level, clutch slipping, TCC solenoid, valve body<br />
defective<br />
Ignition switched ON with TCM disconnected, wiring,<br />
ECM, TCM<br />
Wiring, selector lever lock solenoid<br />
<strong>Trouble</strong> code@) stored in other system@), wiring<br />
Wiring, ECM trouble code(s) stored, ECM incorrectly<br />
coded, wiring<br />
ABS control module trouble code(s) stored, wiring -<br />
Wiring, stop lamp switch<br />
TCM<br />
TCM<br />
TCM<br />
Wiring, stop lamp switch, ECM, TCM<br />
Wiring, TR sensor<br />
Wiring, TFT sensor<br />
Wiring, TFT sensor<br />
Wiring, TFT sensor<br />
--