Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
I Model: Lupo Polo 1,3 PololClassiclEstate GolfNentolBoralCabrio VOLKSWAGEN Beetle Passat Corrado (00192-95) Sharan I Engine management VAG type 5-digit 1 EOBD type I Fault location I Probable cause 18008 18009 I Engine control module (ECM) - Wiring, engine control relay supply voltage 18010 1801 1 1801 2 PI600 PI602 PI603 PI 604 1 Battery, alternator, wiring open circuit 1801 4 I I Rough mad signal - circuit mahbnction I ABS control module trouble code@) stored, CAN data bus 18016 18017 1801 8 PI608 PI 609 PI610 Engine control module (ECM) - supply voltage low from ignition switch Engine control module (ECM)- supply vottage low from battery Engine control module (ECM)- defective Engine control module (ECM)- defective Engine control module (ECM)- defective I earltl 1801 9 I Malfunction indicator lamp (MIL) - short to Wiring short to earth 18020 1 PI612 I Engine control module (ECM) - coding I Incorrectly coded 18021 18023 Battery was disconnected, battery discharged, alternator, wiring open circuit, fuse ECM ECM 18024 1 PI616 I Glow plug warning lamp -short to positive I Wiring short to positive 18025 18026 18027 18028 18029 18030 I8031 18032 18033 18034 18037 18038 18039 18040 I I PI613 PI 61 5 PI618 PI619 PI620 PI 621 PI 623 PI 624 Power steering pressure (PSP) switch - circuit malfunction Engine control module (ECM) - crash switch-off trigpred Malfunction indicator lamp (MIL) - open circuitfshort to positive Engine oil temperature (EOT) sensor - rancref~erformance problem Wiring, PSP switch Airbag triggered ECM Glow plug warning lamp - open circuitfshort Bulb, wiring open circuitlshort to earth to earth Glow plug relay - short to positive Wiring short to positive, glow plug relay Glow plug relay - open circuit/short to earth Wiring open circuitkhort to earth, glow plug relay Instrument panel, ECTsignal - open circuit/ short to positive I Instrument panel, ECT signal - implausible lnsttument panel. ECTsignal - short to earth signal CAN data bus - no signal Malfunction indicator lamp (MIL) - request signal active Wiring open circuitlshort to positive Engine oil level, wiring, EOT sensor Wiring open circuitkhort to positive, instrument panel Wiring short to earth, instrument panel Wiring, instrument panel, ECT sensor I I CAN data bus. TCM - incorrect signal TCM trouble code(s) stored, TCM incorrectly coded, wiring, matching resistor in ECM PI 626 PI 629 PI 630 PI631 PI 632 CAN data bus, TCM - no signal CAN data bus, cruise control - no signal Accelerator pedal position (APP) sensor 1 - low input Accelerator pedal position (APP) sensor 1 - high input Acceterator pedal position (APP) sensor - supply voltage Trouble code@) stored in other system(s), wiring, matching resistor in ECM Trouble code@) stored in other system(s) TCM trouble code@) stored, TCM incorrectly coded, wiring, matching resistor in ECM Cruise control trouble code(s) stored, wiring, matching resistor in ECM Wiring short to earth, APP sensor Wiring short to positive, APP sensor Operating voltage too highflow, wiring
Model: Lupo Polo 1,3 PololClassiclEstate GolfNentolBoralCabrio Beetle Passat Corrado (08192-95) Sharan CaddylPickup TransporterlCaravelle LT 2,5 SDlITDl Engine management vAG type 5-digit EOBD type 1 Fault location Probable cause 18041 18042 18043 18044 18045 18047 18048 18050 18053 PI633 PI634 PI 635 PI640 PI642 PI645 Accelerator pedal position (APP) sensor 2 - low input Accelerator pedal position (APP) sensor 2 - high input CAN data bus, AC - no signal 18056 1 PI 648 1 CAN data bus - defective I Wiring, matching resistor in ECM 18057 18058 18060 Wiring short to earth, APP sensor Wiring short to positive, APP sensor 18061 1 PI653 I ABS control module - svstem malfunction I Trouble codelsl stored 18062 18064 18065 18066 18067 18068 18069 18070 AC control module trouble code(s) stored, wiring, matching resistor in ECM PI636 CAN data bus, SRS - no signal SRS control module trouble code(s) stored, wiring, matching resistor in ECM CAN data bus, electronic CE - no signal code(s) stored, wiring, matching resistor 1 PI639 Accelerator pedal position (APP) Wiring, APP sensor sensor 112 - rangelperformance problem PI649 PI650 PI652 PI 654 PI 656 PI657 PI658 PI659 PI 660 PI661 PI 662 Engine control module (ECM)- defective SRS control module - system malfunction CAN data bus, 4WD - no signal CAN data bus, ABS - no signal CAN data bus, instrumentation - no signal Transmission control module (TCM) - svstem malfunction Instrumentation control module - system malfunction AC signal - short to earth AC signal - short to positive CAN data bus, cruise control - incorrect signal Engine cootant blower motor, speed 1 - short to positive Engine coolant blower motor, speed 1 - short to earth Engine coolant blower motor, speed 2 - short to positive Engine coolant blower motor, speed 2 - short to earth ECM Trouble code(s) stored 4WD trouble code(s) stored, wiring, matching resistor in ECM ABS control module trouble code(s) stored, wiring, matching resistor in ECM Instrumentation control module trouble code(s) stored, wiring, matching resistor in ECM Trouble code(s) stored Trouble code stored for engine oil level1 temperature sensor Wiring short to earth Wiring Cruise control trouble code(s) stored, wiring, matching resistor in ECM Wiring short to positive, engine coolant blower motor Wiring short to earth, engine coolant blower motor Wiring short to positive, engine coolant blower motor Wiring short to earth, engine coolant blower motor 18071 1 PI663 1 Injector, activation - short to positive I Wiring short to positive, ECM 18072 1 PI664 1 Injector, activation - current circuit I Wiring open circuiffshort to earth 18073 1 PI665 1 Injector - mechanical fault 1 Injector 18074 1 PI666 ( Injector 1 - current circuit 1 Wiring open circuiffshort to earth 18075 18076 18077 PI667 PI668 PI669 Injector 2 - current circuit Injector 3 - current circuit Injector 4 - current circuit Wiring open circuiffshort to earth Wiring open circuiffshort to earth Wiring open circuiffshort to earth /Autodata Ename manaaement 755
- Page 704 and 705: Trouble code identification EOBD ty
- Page 706 and 707: VAUXHALL-OPEL Model: Vectra-C 1,6 F
- Page 708 and 709: VAUXHALL-OPEL Model: Vectra-C 1,6 F
- Page 710 and 711: I I 1% VAUXHALL-OPEL Mode I Transmi
- Page 712 and 713: VAUXHALL-OPEL Model Corsa-BTTigra A
- Page 714 and 715: Year: Transmission 1995-98 General
- Page 716 and 717: I Year: 1994-97 Transmission Genera
- Page 718 and 719: I I VAUXHALL-OPEL ~odel: Immobilize
- Page 720 and 721: 1-41 IVAuXHALL-OPEL Yodel: Zafira C
- Page 722 and 723: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 724 and 725: Engine management Model: Lupo Polo
- Page 726 and 727: Engine management Model: Lupo Polo
- Page 728 and 729: VOLKSWAGEN Model Lupo Polo 1,3 Polo
- Page 730 and 731: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 732 and 733: Model: ~upo polo 1,3 PololClassiclE
- Page 734 and 735: VOLKSWAGEN Model Lupo Polo 1,3 Polo
- Page 736 and 737: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 738 and 739: Engine management Model. Lupo Polo
- Page 740 and 741: I VOLKSWAGEN Model: Lupo Polo 1,3 P
- Page 742 and 743: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 744 and 745: 1 744 I,.,,,,,,,, /AUfodata I Engin
- Page 746 and 747: Engine management Model: Lupo Polo
- Page 748 and 749: Engine management Model: Lupo Polo
- Page 750 and 751: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 752 and 753: Engine management Model: Lupo Polo
- Page 756 and 757: 1 756 I,,,.,,,.,,, /Autodata VOLKSW
- Page 758 and 759: 1 I,,,,,,,,,, 758 /Autodata F e man
- Page 760 and 761: I Engine management Erasing Method
- Page 762 and 763: 1 762 I,,,,,,,,,,,, /Autodata - J V
- Page 764 and 765: 1 VOLKSWAGEN Model: Polo 1 ,O5/l,3
- Page 766 and 767: VOLKSWAGEN Model: GolfNento 1,4 (-0
- Page 768 and 769: VOLKSWAGEN Model: GolfNento 1,4 (+0
- Page 770 and 771: Erasing Ensure ignition switched OF
- Page 772 and 773: Engine management Engine code: Syst
- Page 775 and 776: I Year: 03\95-96 I Engine code: 1E
- Page 777 and 778: 4 Model: Lupo PololClassiclEstate G
- Page 779 and 780: Trouble code identification VAG typ
- Page 781 and 782: Model: Lupo PololClassiclEstate Gol
- Page 783 and 784: Model: Lupo PololClassiclEstate Gol
- Page 785 and 786: General information Refer to the fr
- Page 787 and 788: :-$yp"' 00545 00596 00638 00641 006
- Page 789 and 790: Beetle Passat Corrado (10194-95) Sh
- Page 791 and 792: CaddyIPickup TransporterICaravelle
- Page 793 and 794: Mel: 440/460/ VOLVO Engine manageme
- Page 795 and 796: Trouble code identification Scanner
- Page 797 and 798: EFI-355 EFI-411 EFI-414 EFI-415 EFI
- Page 799 and 800: Model: SN40 1,6/1,8/1,9/2,0 SN40 1,
- Page 801 and 802: V70 2,4ITurbo C70 2,O Turbo C70 2,3
- Page 803 and 804: Model: S60 2,012,3 Turbo S60 2,4lTu
Model: Lupo Polo 1,3 PololClassiclEstate GolfNentolBoralCabrio<br />
Beetle Passat Corrado (08192-95) Sharan<br />
CaddylPickup TransporterlCaravelle LT 2,5 SDlITDl<br />
Engine management<br />
vAG type<br />
5-digit<br />
EOBD type 1<br />
<strong>Fault</strong> location<br />
Probable cause<br />
18041<br />
18042<br />
18043<br />
18044<br />
18045<br />
18047<br />
18048<br />
18050<br />
18053<br />
PI633<br />
PI634<br />
PI 635<br />
PI640<br />
PI642<br />
PI645<br />
Accelerator pedal position (APP)<br />
sensor 2 - low input<br />
Accelerator pedal position (APP)<br />
sensor 2 - high input<br />
CAN data bus, AC - no signal<br />
18056 1 PI 648 1 CAN data bus - defective I Wiring, matching resistor in ECM<br />
18057<br />
18058<br />
18060<br />
Wiring short to earth, APP sensor<br />
Wiring short to positive, APP sensor<br />
18061 1 PI653 I ABS control module - svstem malfunction I <strong>Trouble</strong> codelsl stored<br />
18062<br />
18064<br />
18065<br />
18066<br />
18067<br />
18068<br />
18069<br />
18070<br />
AC control module trouble code(s) stored, wiring,<br />
matching resistor in ECM<br />
PI636 CAN data bus, SRS - no signal<br />
SRS control module trouble code(s) stored,<br />
wiring, matching resistor in ECM<br />
CAN data bus, electronic CE - no signal code(s) stored, wiring, matching resistor<br />
1<br />
PI639 Accelerator pedal position (APP)<br />
Wiring, APP sensor<br />
sensor 112 - rangelperformance problem<br />
PI649<br />
PI650<br />
PI652<br />
PI 654<br />
PI 656<br />
PI657<br />
PI658<br />
PI659<br />
PI 660<br />
PI661<br />
PI 662<br />
Engine control module (ECM)- defective<br />
SRS control module - system malfunction<br />
CAN data bus, 4WD - no signal<br />
CAN data bus, ABS - no signal<br />
CAN data bus, instrumentation - no signal<br />
Transmission control module (TCM) -<br />
svstem malfunction<br />
Instrumentation control module - system<br />
malfunction<br />
AC signal - short to earth<br />
AC signal - short to positive<br />
CAN data bus, cruise control - incorrect<br />
signal<br />
Engine cootant blower motor, speed 1 -<br />
short to positive<br />
Engine coolant blower motor, speed 1 -<br />
short to earth<br />
Engine coolant blower motor, speed 2 -<br />
short to positive<br />
Engine coolant blower motor, speed 2 -<br />
short to earth<br />
ECM<br />
<strong>Trouble</strong> code(s) stored<br />
4WD trouble code(s) stored, wiring, matching<br />
resistor in ECM<br />
ABS control module trouble code(s) stored,<br />
wiring, matching resistor in ECM<br />
Instrumentation control module trouble code(s)<br />
stored, wiring, matching resistor in ECM<br />
<strong>Trouble</strong> code(s) stored<br />
<strong>Trouble</strong> code stored for engine oil level1<br />
temperature sensor<br />
Wiring short to earth<br />
Wiring<br />
Cruise control trouble code(s) stored, wiring,<br />
matching resistor in ECM<br />
Wiring short to positive, engine coolant blower<br />
motor<br />
Wiring short to earth, engine coolant blower<br />
motor<br />
Wiring short to positive, engine coolant blower<br />
motor<br />
Wiring short to earth, engine coolant blower<br />
motor<br />
18071 1 PI663 1 Injector, activation - short to positive I Wiring short to positive, ECM<br />
18072 1 PI664 1 Injector, activation - current circuit I Wiring open circuiffshort to earth<br />
18073 1 PI665 1 Injector - mechanical fault 1 Injector<br />
18074 1 PI666 ( Injector 1 - current circuit 1 Wiring open circuiffshort to earth<br />
18075<br />
18076<br />
18077<br />
PI667<br />
PI668<br />
PI669<br />
Injector 2 - current circuit<br />
Injector 3 - current circuit<br />
Injector 4 - current circuit<br />
Wiring open circuiffshort to earth<br />
Wiring open circuiffshort to earth<br />
Wiring open circuiffshort to earth<br />
/<strong>Autodata</strong><br />
Ename manaaement<br />
755
Change language