Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
VAUXHALL-OPEL Model Astra-G 2,2 SpeedsterNX220 2,2 Vectra-C 2,012,2 I Engine management Trouble code identification EOBD type Fault location I Probable cause Refer to EOBD trouble code table I - Throttle position sensor - circuit malfunction I Wiring, throttle valve positioner, ECM Accelerator pedal position (APP) sensor - circuit malfunction Heated oxygen sensor (H02S) 1, bank 1 - malfunction Heated oxygen sensor (H02S) 1, bank 1 - malfunction Wiring, APP sensor, ECM Wiring, H02S, ECM I Wiring, H02S. ECM -- Heated oxygen sensor (H02S) I, bank I - insufficient Wiring, oxygen sensor heater, exhaust system switching 1-leaking, H0; Heated oxygen sensor (H02S) 2, bank 1 -enrichment lean Heated oxygen sensor (H02S) 2 - voltage high Fuel system - lean during acceleration Throttle ~osition sensor 2 - circuit malfunction Throttle position sensor 112 - signal variation Accelerator pedal position (APP) sensor 112 - signal variation Accelerator pedal position (APP) sensor 1 - circuit malfunction Accelerator pedal position (APP) sensor 113 - signal variation Accelerator pedal position (APP) sensor 2 - circuit malfunction Randomlmultiple cylinder(s) - misfire detected Ignition diagnostic module - malfunction Crankshaft position sensor (CKP) - variation not learned Ignition diagnostic module - malfunction Cylinder 1 - misfire detected Cylinder 2 - misfire detected Cylinder 3 - misfire detected Cylinder 4 - misfire detected Crankshaft position sensor (CKP)lcamshaft position (CMP) sensor - signal variation Wiring, H02S, ECM I I Fuel filter, fuel pump relay, fuel pump, H02S, injectors Wiring short circuit to positive, fuel pressure high, fuel contamination, injector(s) leaking, H02S, ECM Wiring open circuitlshort circuit to groundlshort circuit to positive, throttle valve positioner, ECM Wiring, throttle valve positioner, ECM Wiring, APP sensor, ECM Wiring open circuitlshort circuit to ground/short I circuit to positive, APP sensor, ECM Wiring, APP sensor, ECM Wiring open circuitlshort circuit to groundlshort circuit to positive, APP sensor, ECM Mechanical fault, wiring, ignitionlfuel system, mass air flow (MAF) sensor, fuel pump relay, manifold absolute pressure (MAP) sensor, intake leak I Wiring, ignition diagnostic module, ECM Spark plug, wiring, ignition coil, ignition diagnostic module -- Learning procedure not performed Wiring, ignition diagnostic module, ECM Spark plug, wiring, ignition coil, ignition diagnostic module Spark plug, wiring, ignition coil, ignition diagnostic module Spark plug, wiring, ignition coil, ignition diagnostic module CKP sensor, CMP sensor, camshaft alignment, mechanical fault Rough road signal - signal error / ABS control module trouble code(s) stored Exhaust gas recirculation (EGR) solenoid valve Throttle position adaption - signal variation Wiring open circuitlshort circuit to ground, supply wire, EGR valve, ECM Wiring, throttle valve positioner, ECM
I Model: Astra-G 2,2 SpeedsterNX220 2,2 Vectra-C 2,012,2 OPEL-VAUXHALL 8" Engine management I Probable cause I PI514 I Electronic throttle control - malfunction Wiring, MAP sensor, ECM PI 51 5 PI516 PI 523 PI 574 P 1 539 I Throttle commandlactual throttle position - signal variation Throttle actuator control position - signal variation Throttle actuator control position - signal variation Traction control system (TCS), torque request circuit Brake light switch - malfunction Engine stall detected - malfunction Wiring, throttle valve sticking, throttle valve positioner, ECM Wiring, throttle valve positioner, ECM Wiring, throttle valve positioner, ECM Wiring open circuitlshort circuit to groundlshort circuit to positive, ABS control module trouble code@) stored, ECM Wiring, brake light switch, ECM PI610 I Immobilizer control module - program error lmmobilizer control module incorrectly programmed PI611 PI612 PI 61 3 Immobilizer control module - coding Immobilizer control module - incorrecffno signal Immobilizer control module - incorrectfno siclnal ECM PI 614 I lmmobilizer control module - incorrect signal Incorrect key PI621 I Engine control module (ECM) - memory performance ECM PI633 PI635 PI 639 1 Sensor supply voltage - circuit I malfunction PI 680 Engine control module (ECM), ignition supply voltage Sensor supply voltage - circuit 1 malfunction Accelerator pedal position (APP) sensor - circuit malfunction lmmobilizer control module incorrect code entered lmmobilizer control module lmmobilizer control module Fuse, wiring open circuit, ECM Wiring short circuit to groundlpositive, ground wiring open circuit, APP sensor, ECM Wiring short circuit to groundlpositive, ground wiring open circuit, APP sensor, ECM Wiring open circuitlshort circuit to groundlshort circuit to positive, APP sensor, ECM PI681 I Throttle position sensor monitor - malfunction Wiring, throttle valve positioner, ECM PI682 El I Electronic throttle control - malfunction Wiring, throttle valve positioner, ECM PI682 H PI 700 U2lOl U2103 U2104 U2106 U2108 Main relay - contacts stuck open Transmission control module (TCM), MIL request - malfunction CAN data bus - program malfunction Engine control module (ECM), CAN data bus - malfunction detected Engine control module (ECM), CAN data bus - malfunction detected Engine control module (ECM)ltransmission control moduie (TCM) communication, CAN data bus - mahnction Engine control module (ECM)IABS control modutel traction control module communication, CAN data bus - malfunction Relay, wiring, ECM ECM, TCM ECM programming Wiring -- Wiring Wiring Wiring El GMPT-El5lE16 H Trionic 8 4
- Page 648 and 649: [I]- SOHC - engine bay, LH [2] - DO
- Page 650 and 651: Model: Corolla Year: 1995-01100 Und
- Page 652 and 653: Immobilizer Year: 1995-98 I General
- Page 654 and 655: Immobilizer Model: Avensis I Year:
- Page 656 and 657: RH engine bay General information R
- Page 658 and 659: T OWTA Model: Celica Year: 1995-99
- Page 660 and 661: General Information 0 Refer to the
- Page 662 and 663: . Model: Previa 1 Year: 1996-04100
- Page 664 and 665: General information Refer to the fr
- Page 666 and 667: VAUXHALL-OP E L Model: Agila 1,011,
- Page 668 and 669: EOBD type -. PI 551 PI 555 PI 560 E
- Page 670 and 671: Erasing NOTE: Some models 1992 -+ m
- Page 672 and 673: Vectra-B 1,611,8/2,2/2,512,6 Omega-
- Page 674 and 675: ,* d VAU)(HALLIOPEL Model: /i7;e I
- Page 676 and 677: Omega-6 Zafira Erasing The engine c
- Page 678 and 679: VAU)(HALLIOPEL Model: I k ~f, .I En
- Page 680 and 681: VAuXHALLIOPEL Model: Corsa-C 1,7TD
- Page 682 and 683: I VAUXHALL-OPEL Model: AstraIKadett
- Page 684 and 685: FEngine management CarltonlOmega-B
- Page 686 and 687: VAUXHALL-OpEL Model: AstralKadett 2
- Page 688 and 689: VAUXHAf&oPEL Model: Astra-F 1,812,O
- Page 690 and 691: Engine management Year: 1997-04 Eng
- Page 692 and 693: Omega-B 2,OTD12,2TD Zafira 2,OTD12,
- Page 694 and 695: VAUXHALL-OPEL Model: Astra-G 1.7 TD
- Page 696 and 697: EOBD type / Fault hat1011 Probable
- Page 700 and 701: Engine management Year: 1994-00 I E
- Page 702 and 703: Engine management Flash'scanner Fau
- Page 704 and 705: Trouble code identification EOBD ty
- Page 706 and 707: VAUXHALL-OPEL Model: Vectra-C 1,6 F
- Page 708 and 709: VAUXHALL-OPEL Model: Vectra-C 1,6 F
- Page 710 and 711: I I 1% VAUXHALL-OPEL Mode I Transmi
- Page 712 and 713: VAUXHALL-OPEL Model Corsa-BTTigra A
- Page 714 and 715: Year: Transmission 1995-98 General
- Page 716 and 717: I Year: 1994-97 Transmission Genera
- Page 718 and 719: I I VAUXHALL-OPEL ~odel: Immobilize
- Page 720 and 721: 1-41 IVAuXHALL-OPEL Yodel: Zafira C
- Page 722 and 723: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 724 and 725: Engine management Model: Lupo Polo
- Page 726 and 727: Engine management Model: Lupo Polo
- Page 728 and 729: VOLKSWAGEN Model Lupo Polo 1,3 Polo
- Page 730 and 731: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 732 and 733: Model: ~upo polo 1,3 PololClassiclE
- Page 734 and 735: VOLKSWAGEN Model Lupo Polo 1,3 Polo
- Page 736 and 737: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 738 and 739: Engine management Model. Lupo Polo
- Page 740 and 741: I VOLKSWAGEN Model: Lupo Polo 1,3 P
- Page 742 and 743: VOLKSWAGEN Model: Lupo Polo 1,3 Pol
- Page 744 and 745: 1 744 I,.,,,,,,,, /AUfodata I Engin
- Page 746 and 747: Engine management Model: Lupo Polo
I<br />
Model: Astra-G 2,2 SpeedsterNX220 2,2 Vectra-C 2,012,2<br />
OPEL-VAUXHALL<br />
8"<br />
Engine management I<br />
Probable cause<br />
I<br />
PI514 I Electronic throttle control - malfunction Wiring, MAP sensor, ECM<br />
PI 51 5<br />
PI516<br />
PI 523<br />
PI 574<br />
P 1 539<br />
I<br />
Throttle comm<strong>and</strong>lactual throttle position - signal<br />
variation<br />
Throttle actuator control position - signal variation<br />
Throttle actuator control position - signal variation<br />
Traction control system (TCS), torque request circuit<br />
Brake light switch - malfunction<br />
Engine stall detected - malfunction<br />
Wiring, throttle valve sticking, throttle valve<br />
positioner, ECM<br />
Wiring, throttle valve positioner, ECM<br />
Wiring, throttle valve positioner, ECM<br />
Wiring open circuitlshort circuit to groundlshort<br />
circuit to positive, ABS control module trouble code@)<br />
stored, ECM<br />
Wiring, brake light switch, ECM<br />
PI610 I Immobilizer control module - program error lmmobilizer control module incorrectly programmed<br />
PI611<br />
PI612<br />
PI 61 3<br />
Immobilizer control module - coding<br />
Immobilizer control module - incorrecffno signal<br />
Immobilizer control module - incorrectfno siclnal<br />
ECM<br />
PI 614 I lmmobilizer control module - incorrect signal Incorrect key<br />
PI621 I Engine control module (ECM) - memory performance ECM<br />
PI633<br />
PI635<br />
PI 639 1 Sensor supply voltage - circuit I malfunction<br />
PI 680<br />
Engine control module (ECM), ignition supply voltage<br />
Sensor supply voltage - circuit 1 malfunction<br />
Accelerator pedal position (APP) sensor - circuit<br />
malfunction<br />
lmmobilizer control module incorrect code entered<br />
lmmobilizer control module<br />
lmmobilizer control module<br />
Fuse, wiring open circuit, ECM<br />
Wiring short circuit to groundlpositive, ground wiring<br />
open circuit, APP sensor, ECM<br />
Wiring short circuit to groundlpositive, ground wiring<br />
open circuit, APP sensor, ECM<br />
Wiring open circuitlshort circuit to groundlshort<br />
circuit to positive, APP sensor, ECM<br />
PI681 I Throttle position sensor monitor - malfunction Wiring, throttle valve positioner, ECM<br />
PI682 El I Electronic throttle control - malfunction Wiring, throttle valve positioner, ECM<br />
PI682 H<br />
PI 700<br />
U2lOl<br />
U2103<br />
U2104<br />
U2106<br />
U2108<br />
Main relay - contacts stuck open<br />
Transmission control module (TCM), MIL request -<br />
malfunction<br />
CAN data bus - program malfunction<br />
Engine control module (ECM), CAN data bus -<br />
malfunction detected<br />
Engine control module (ECM), CAN data bus -<br />
malfunction detected<br />
Engine control module (ECM)ltransmission control<br />
moduie (TCM) communication, CAN data bus -<br />
mahnction<br />
Engine control module (ECM)IABS control modutel<br />
traction control module communication, CAN data<br />
bus - malfunction<br />
Relay, wiring, ECM<br />
ECM, TCM<br />
ECM programming<br />
Wiring<br />
--<br />
Wiring<br />
Wiring<br />
Wiring<br />
El GMPT-El5lE16<br />
H Trionic 8<br />
4