Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
Model: Avensis 1,611,812,O Avensis 2,OD Turbo Engine management Flash type BIP type Fault location Probable cause 19 - 21 I - - 22 24 25 - - 26 I - I System too rich, bank 1 31 31 Wiring, accelerator pedal position (APP) sensor1 switch, ECM Accelerator pedal position (APP) sensorlswitch - circuit malfunction Heated oxygen sensor (H02S) 1, I Wiring, H02S. ECM bank 1 - circuit malfunction Engine coolant temperature (ECT) Wiring, ECT sensor, ECM sensor - circuit malfunction Intake air temperature (IAT) sensor - Wiring, IAT sensor, ECM circuit matfunction System too lean, bank 1 Fuel pressure, wiring, injector, H02S, MAP sensor, ECT sensor. ECM Wiring, MAP sensor, ECM 32 rn I - I Module coding plug - malfunction I Wiring, module coding plug, ECM 32 33 0 33 rn 35 - - - - - I - I Manifold Manifold absolute pressure (MAP) sensor - circuit malfunction Mass air Row (MAF) sensor - circuit malfunction Air leak, fuel pressure, wiring, injector, H02S, MAP sensor. ECT sensor. ECM Wiring, MAF sensor, ECM Injector - matfunction Wiring, injector, ECM Idle speed control (ISC) system - Wiring, IAC valve, ECM malfunction Intake manifold air control solenoid 2 - Wiring, intake manifold air control solenoid 2, ECM malfunction absolute pressure (MAP) Wiring, MAP sensor, MAP sensor control solenoid, sensor, TC system - circuit hoses blocked/disconnected, ECM malfunction 42 I - Vehicle speed sensor (WS) - circuit I Wiring, speedometer, VSS, ECM malfunction Wiring, KS, ECM sure fuel pump control solenoids, 3s-FEl4A-FEl7A-FE rn 2C-TE H ICD-FTV
L - Model: MR2 1,6 MR2 2,O Year: 1985-00 Engine code: 3s-FE, 3s-GE, 4A-GE System: TCCS TOYOTA Engine management General information Refer to the front of this manual for general test conditions, terminology, detailed descriptions of wiring faults and a general trouble shooter for electrical and mechanical faults. 0 Trouble codes are displayed by the malfunction indicator lamp (MIL). Accessing 4A-GE - without airflow meter Switch ignition ON. Bridge data link connector (DLC) terminals El and TEI (T) a. If no trouble codes are stored, the lamp will flash once every 4,5 seconds O. Individual short flashes display trouble code El. Warning lamp flash duration: 0,5 second El [A]. A 0,5 second pause separates each flash El [B]. A 2,5 second pause separates each trouble code El [C]. For example: Trouble codes 2 and 4 displayed a. Trouble codes are repeated 4,5 seconds after last trouble code El [Dl. Count MIL flashes. Note trouble codes. Compare with trouble code table. Switch ignition OFF. Remove bridge wire. Rectify faults as necessary. OFF
- Page 564 and 565: 'I k4 ;c SUB Model: 9-3 2,O Turbo 9
- Page 566 and 567: 1"; C jy SAAB Model: 9-3 2,O Turbo
- Page 568 and 569: Model: 9-3 2,2D Turbo (Engine manag
- Page 570 and 571: ?, 'I vg SAAB Model: 9-3 2,2D Turbo
- Page 572 and 573: I'I.+. ,>I SAAB I Engine management
- Page 574 and 575: I Transmission Model: 900 9-3 9-5 E
- Page 576 and 577: Arosa lbizalcordoba 1,011,411,611,8
- Page 578 and 579: 1 578 I,,,,,,,,,,, /Autodata Engine
- Page 580 and 581: I Engine management 5-digit type Fa
- Page 582 and 583: Engine management Probable cause 23
- Page 584 and 585: I Engine management Trouble code id
- Page 586 and 587: pJ M SEAT Model: Arosa IbizalCordob
- Page 588 and 589: 1 / Model: Arosa IbizalCordoba Tole
- Page 590 and 591: Model: Favorit 1,3 Favorit VanlForm
- Page 592 and 593: IEngine management Erasing Method 1
- Page 594 and 595: Fabia FeliciaNanlPick-up Octavia 78
- Page 596 and 597: Year: Immobilizer Model: Fabia Feli
- Page 598 and 599: Engine management I Erasing NOTE: F
- Page 600 and 601: TOYOTA Model: Corolla 1,3 Corolla 1
- Page 602 and 603: I Engine management I Except 4A-GE
- Page 604 and 605: t- Engine management Model: Corolla
- Page 606 and 607: T OYOTA I Engine management Model:
- Page 608 and 609: TOYOTA Model: Carina 11 1,6 Carina
- Page 610 and 611: Model: Carina E 1,6/1,8/2,0 Carina
- Page 612 and 613: Model: Avensis 1,611,8/2,0 Avensis
- Page 616 and 617: I Engine management ON OFF 5 MA B A
- Page 618 and 619: Model: MR2 1,6 MR2 2,O 3s-FE13S-GE
- Page 620 and 621: Engine management I ~~~ A B A C A B
- Page 622 and 623: Model: Celica 1,6 Celica 1,8 Celica
- Page 624 and 625: 1 TOYOTA Engine management Model: S
- Page 626 and 627: Located on main throttle butterfly
- Page 628 and 629: Model: Picnic 2,O Picnic 2,2D Turbo
- Page 630 and 631: TOYOTA Model: Previa 2,4 Year: 1990
- Page 632 and 633: I=a management Trouble code identif
- Page 634 and 635: Erasing NOTE: Fuse removal duration
- Page 636 and 637: Transmission Model: Carina E Year:
- Page 638 and 639: I Transmission Model: Year: Avensis
- Page 640 and 641: Transmission Model: Celica 2,O I 19
- Page 642 and 643: Transmission Model: Picnic Year: 19
- Page 644 and 645: d$i TEl(T) TSTC NOTE: Engine contro
- Page 646 and 647: Transmission Model: RAV4 Year: 1994
- Page 648 and 649: [I]- SOHC - engine bay, LH [2] - DO
- Page 650 and 651: Model: Corolla Year: 1995-01100 Und
- Page 652 and 653: Immobilizer Year: 1995-98 I General
- Page 654 and 655: Immobilizer Model: Avensis I Year:
- Page 656 and 657: RH engine bay General information R
- Page 658 and 659: T OWTA Model: Celica Year: 1995-99
- Page 660 and 661: General Information 0 Refer to the
- Page 662 and 663: . Model: Previa 1 Year: 1996-04100
Model: Avensis 1,611,812,O Avensis 2,OD Turbo<br />
Engine management<br />
Flash type BIP type <strong>Fault</strong> location Probable cause<br />
19<br />
-<br />
21 I -<br />
-<br />
22<br />
24<br />
25<br />
-<br />
-<br />
26<br />
I -<br />
I System too rich, bank 1<br />
31<br />
31<br />
Wiring, accelerator pedal position (APP) sensor1<br />
switch, ECM<br />
Accelerator pedal position (APP)<br />
sensorlswitch - circuit malfunction<br />
Heated oxygen sensor (H02S) 1, I Wiring, H02S. ECM<br />
bank 1 - circuit malfunction<br />
Engine coolant temperature (ECT) Wiring, ECT sensor, ECM<br />
sensor - circuit malfunction<br />
Intake air temperature (IAT) sensor - Wiring, IAT sensor, ECM<br />
circuit matfunction<br />
System too lean, bank 1<br />
Fuel pressure, wiring, injector, H02S, MAP sensor,<br />
ECT sensor. ECM<br />
Wiring, MAP sensor, ECM<br />
32 rn I - I Module coding plug - malfunction I Wiring, module coding plug, ECM<br />
32<br />
33 0<br />
33 rn<br />
35<br />
-<br />
-<br />
-<br />
-<br />
-<br />
I - I<br />
Manifold<br />
Manifold absolute pressure (MAP)<br />
sensor - circuit malfunction<br />
Mass air Row (MAF) sensor - circuit<br />
malfunction<br />
Air leak, fuel pressure, wiring, injector, H02S,<br />
MAP sensor. ECT sensor. ECM<br />
Wiring, MAF sensor, ECM<br />
Injector - matfunction<br />
Wiring, injector, ECM<br />
Idle speed control (ISC) system - Wiring, IAC valve, ECM<br />
malfunction<br />
Intake manifold air control solenoid 2 - Wiring, intake manifold air control solenoid 2, ECM<br />
malfunction<br />
absolute pressure (MAP) Wiring, MAP sensor, MAP sensor control solenoid,<br />
sensor, TC system - circuit<br />
hoses blocked/disconnected, ECM<br />
malfunction<br />
42<br />
I -<br />
Vehicle speed sensor (WS) - circuit I Wiring, speedometer, VSS, ECM<br />
malfunction<br />
Wiring, KS, ECM<br />
sure fuel pump control solenoids,<br />
3s-FEl4A-FEl7A-FE<br />
rn 2C-TE<br />
H ICD-FTV