Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
ITransrnission Model: Galant I Year: 1994-00 Under fascia, drive General information Refer to the front of this manual for general test conditions, terminology, detailed descriptions of wiring faults and a general trouble shooter for electrical and mechanical faults. 0 Trouble codes are displayed by using the transmission neutral indicator lamp. 0 The transmission control module (TCM) fault memory can also be checked using diagnostic equipment connected to the data link connector (DLC). 0 Trouble codes may not be displayed if battery voltage is low. Accessing Ensure ignition switched OFF. Bridge data link connector (DLC) terminal 1 and earth m. Switch ignition ON. Count transmission neutral indicator lamp flashes. Note trouble codes. Compare with trouble code table. Each trouble code consists of two groups of one or more indicator lamp flashes H. Long flashes indicate the 'tens' of the trouble code H [A]. Short flashes indicate the 'units' of the trouble code H [Dl. A short pause separates each trouble code group H [Cl. A long pause separates each trouble code [El. For example: Trouble code 22 displayed H. - - -- Erasing Ensure ignition switched OFF. Disconnect battery earth lead. Wait 15 seconds. Reconnect battery earth lead. Repeat checking procedure to ensure no data remains in TCM fault memory. WARNING: Disconnecting the battery may erase memory from electronic units (e.g. radio, clock).
4 MITSUBISHI Transmission Trouble code identification Flash type 11 12 I I Fault location I Throttle position (TP) sensor/accelerator pedal position (APP) sensor - malfunction Throttle position (TP) sensorlaccelerator pedal position (APP) sensor - malfunction Throttle position (TP) sensorlaccelerator pedal position (APP) sensor - malfunction I I TPIAPP sensor incorrect adjustment 15 I Transmission fluid temperature (TFT) sensor - malfunction I Wiring open circuit, TFT sensor 21 22 25 26 32 33 34 36 42 43 I Crankshaft position (CKP) sensor - circuit malfunction Transmission input shaft speed sensor - circuit malfunction Transmission output shaft speed sensor - circuit malfunction Wide open throttle (WOT) switch - malfunction Brake pedal position (BPP) switch - circuit malfunction Transmission reversellow gear selection solenoid - circuit malfunction Transmission under-drive solenoid - circuit malfunction Transmission second solenoid - circuit malfunction Overdrive solenoid - circuit malfunction Damper dutch system control solenoid - circuit malfunction First gear, ratio - out of limits Wiring Second gear, ratio - out of limits Third gear, ratio - out of limits I Fourth gear, ratio - out of limits - Wiring short circuit, TPIAPP sensor Wiring open circuit, TP sensor - --- - Wiring, CKP sensor Wiring openlshort circuit, transmission input shaft speed sensor Wiring openlshort circuit, transmission output shaft speed sensor short circuit, WOT switch Wirinq openlshort circuit, BPP switch Wiring openlshort circuit, transmission reversellow gear selection solenoid Wiring openlshort circuit, transmission under-drive solenoid Wiring openlshort circuit, transmission second solenoid Wiring openlshort circuit, overdrive solenoid I Reverse gear, ratio - out of limits Wiring, 51 Transmission control module (TCM)/engine control module (ECM)l Wiring, ECM, TCM traction control module - communication malfunction 1 Damper clutch system - defective 56 71 Transmission system relay - circuit malfunction Transmission neutral indicator lamp - circuit malfunction Transmission control module (TCM) - defective Wiring openlshort circuit, damper clutch control solenoid, TCM Wiring, transmission inputloutput shaft speed sensors, transmission Wiring, transmission inputloutput shaft speed sensors, transmission Wiring, transmission inputloutput shaft speed sensors, transmission Wiring, transmission inputloutput shaft speed sensors, transmission transmission inputloutput shaft speed sensors, transmission Wiring openlshort circuit, damper clutch system Wiring open circuitlshort to earth, transmission system relay, TCM Wiring short to earth, transmission neutral indicator lamp, TCM TCM 4
- Page 408 and 409: I FJ,;-'; Engine managementltransmi
- Page 410 and 411: 1 i, 5: .I Engine managementltransm
- Page 412 and 413: 11 2 Engine managementltransmission
- Page 414 and 415: I-.,) Model: Engine management~tran
- Page 416 and 417: Model: 3231Estate 1,6 8VIl6V (BGIBW
- Page 418 and 419: Engine management Year: 1998-04 A1
- Page 420 and 421: I MERCEDES-BENZ Model: FEngine mana
- Page 422 and 423: ME RCED ESIBE NZ Model. Engine mana
- Page 424 and 425: 1 424 I,,,.,,,,,,, IAutodata ME RCE
- Page 426 and 427: I Engine management Trouble code id
- Page 428 and 429: ME RCEDES-BE NZ Model: C18012001200
- Page 430 and 431: ME RC ED ESIB E NZ I Engine managem
- Page 432 and 433: lMERCEDESIBE NZ Model: C180/200/200
- Page 434 and 435: CL42015001600 (140) SLK2OOl2OOW230W
- Page 436 and 437: M E RC E D ESIB E NZ Model C1801200
- Page 438 and 439: 1 438 I,,,,,,,,,,, kJAutodata MERCE
- Page 440 and 441: Engine management Trouble code iden
- Page 442 and 443: I Engine management P type I Fault
- Page 444 and 445: I Engine management P type I Fau. l
- Page 446 and 447: I bJiil MERCEDES-BENZ Model. C-Clas
- Page 448 and 449: Model: C-Class (202) E-Class (124)
- Page 450 and 451: Engine management Model: One Cooper
- Page 452 and 453: fa J MINI Model: One Cooper Engine
- Page 454 and 455: I Engine management Model: One D Ye
- Page 456 and 457: Engine management Model: Galant 1,8
- Page 460 and 461: I ' I. !'1 MITSUBISHI Model: w Year
- Page 462 and 463: MITSUB1SH1 Model: Galant ShogunlPaj
- Page 464 and 465: Engine management Erasing Switch ig
- Page 466 and 467: Engine manayerrler luirarisrr~~ss~u
- Page 468 and 469: NISSAN Model: Sunny l,4/l,6/2,O Sun
- Page 470 and 471: - , I NISSAN Model: Almera l,5/l,8
- Page 472 and 473: Year: 2001 -04 Engine code: KA24E,
- Page 474 and 475: 6' s Model: Almera l,5/l,8 Almera T
- Page 476 and 477: I r Y' NISSAN Model: Almera l,5/1,8
- Page 478 and 479: . I L Engine -- Flash type rnanagem
- Page 480 and 481: "&2" 2 -" , I-_ NlSSAN Model: Alrne
- Page 482 and 483: NISSAN Model: Almera 2,OD Primera 2
- Page 484 and 485: Model: Micra Alrnera Prirnera Seren
- Page 486 and 487: 1 PEUGEOT Model: I06 1,011,111,311,
- Page 488 and 489: Erasing Method 2 Ensure ignition sw
- Page 490 and 491: Engine management Model: 106 1,011,
- Page 492 and 493: I PEUGEOT Model: 106 1,0/1,1/1,4/1,
- Page 494 and 495: ?I PEUGEOT I Engine management Mode
- Page 496 and 497: Engine management Year: 2002-04 Eng
- Page 498 and 499: 1 PEUGEOT Engine management Model:
- Page 500 and 501: 1 PEUGEOT I Engine management Model
- Page 502 and 503: 1 502 I,,,,,,,,,, Engine management
- Page 504 and 505: Model: 406 2,lD Turbo 605 2,lD Turb
- Page 506 and 507: PEUGEOT Model: 806 1,9D Turbo Year:
4<br />
MITSUBISHI<br />
Transmission<br />
<strong>Trouble</strong> code identification<br />
Flash type<br />
11<br />
12<br />
I<br />
I<br />
<strong>Fault</strong> location<br />
I<br />
Throttle position (TP) sensor/accelerator pedal position (APP)<br />
sensor - malfunction<br />
Throttle position (TP) sensorlaccelerator pedal position (APP)<br />
sensor - malfunction<br />
Throttle position (TP) sensorlaccelerator pedal position (APP)<br />
sensor - malfunction<br />
I<br />
I TPIAPP sensor incorrect adjustment<br />
15 I Transmission fluid temperature (TFT) sensor - malfunction I Wiring open circuit, TFT sensor<br />
21<br />
22<br />
25<br />
26<br />
32<br />
33<br />
34<br />
36<br />
42<br />
43<br />
I<br />
Crankshaft position (CKP) sensor - circuit malfunction<br />
Transmission input shaft speed sensor - circuit malfunction<br />
Transmission output shaft speed sensor - circuit malfunction<br />
Wide open throttle (WOT) switch - malfunction<br />
Brake pedal position (BPP) switch - circuit malfunction<br />
Transmission reversellow gear selection solenoid - circuit<br />
malfunction<br />
Transmission under-drive solenoid - circuit malfunction<br />
Transmission second solenoid - circuit malfunction<br />
Overdrive solenoid - circuit malfunction<br />
Damper dutch system control solenoid - circuit malfunction<br />
First gear, ratio - out of limits<br />
Wiring<br />
Second gear, ratio - out of limits<br />
Third gear, ratio - out of limits<br />
I Fourth gear, ratio - out of limits<br />
-<br />
Wiring short circuit, TPIAPP sensor<br />
Wiring open circuit, TP sensor<br />
- --- -<br />
Wiring, CKP sensor<br />
Wiring openlshort circuit, transmission<br />
input shaft speed sensor<br />
Wiring openlshort circuit, transmission<br />
output shaft speed sensor<br />
short circuit, WOT switch<br />
Wirinq openlshort circuit, BPP switch<br />
Wiring openlshort circuit, transmission<br />
reversellow gear selection solenoid<br />
Wiring openlshort circuit, transmission<br />
under-drive solenoid<br />
Wiring openlshort circuit, transmission<br />
second solenoid<br />
Wiring openlshort circuit, overdrive<br />
solenoid<br />
I<br />
Reverse gear, ratio - out of limits<br />
Wiring,<br />
51 Transmission control module (TCM)/engine control module (ECM)l Wiring, ECM, TCM<br />
traction control module - communication malfunction 1<br />
Damper clutch system - defective<br />
56<br />
71<br />
Transmission system relay - circuit malfunction<br />
Transmission neutral indicator lamp - circuit malfunction<br />
Transmission control module (TCM) - defective<br />
Wiring openlshort circuit, damper clutch<br />
control solenoid, TCM<br />
Wiring, transmission inputloutput shaft<br />
speed sensors, transmission<br />
Wiring, transmission inputloutput shaft<br />
speed sensors, transmission<br />
Wiring, transmission inputloutput shaft<br />
speed sensors, transmission<br />
Wiring, transmission inputloutput shaft<br />
speed sensors, transmission<br />
transmission inputloutput shaft<br />
speed sensors, transmission<br />
Wiring openlshort circuit, damper clutch<br />
system<br />
Wiring open circuitlshort to earth,<br />
transmission system relay, TCM<br />
Wiring short to earth, transmission<br />
neutral indicator lamp, TCM<br />
TCM<br />
4