Autodata - Diagnostic Trouble Codes Fault locations and probable causes - 2004 edition
Engine management Model: One Cooper Year: 2001 -04 Engine code: WIOB, WllB System: Siemens EMS 2000 Under steering column General information 0 Refer to the front of this manual for general test conditions, terminology, detailed descriptions of wiring faults and a general trouble shooter for electrical and mechanical faults. Accessing and erasing The engine control module (ECM) fault memory can only be accessed and erased using diagnostic equipment connected to the data link connector (DLC). Trouble code identification I EOBD type BMW type Fault kcation I Probable cause I I PO - I Refer to EOBD trouble code table - PI106 PI107 4358 4359 PI lo8 Manifold absolute pressure (MAP) sensor - Wiring short to earth, MAP sensor I 4360 1 signal too low at full load for low engine speed PI 109 PI122 PI123 PI125 4361 4386 4387 4389 Manifold absolute pressure (MAP) sensor - signal too low at engine stop Manifold absolute pressure (MAP) sensor - signal too low at idle Manifold absolute pressure - too high under deceleration Accelerator pedal position (APP) sensor 1 - low input Acceterator pedal position (APP) sensor 1 - high input Throttle position (TP) sensor, AIB - small rangelperformance problem Wiring short to earth, poor connection, sensor supply, MAP sensor Wiring short to earth, poor connection, MAP sensor Throttle valve sticking, air leak Wiring short to earth, APP sensor Wiring short to positive, APP sensor Wiring, TP sensor
Model: One Cooper MINI 1;. I EOBD type / BMW type I FauH 10cation Probable cause PI126 PI143 PI144 PI222 PI 223 PI224 PI 226 P1229 PI234 4390 4419 4420 4642 4643 4644 4646 4649 4660 Throttle position (TP) sensor, NB -large range1 performance problem Heated oxygen sensor (H02S) 2, bank 1 - signal too high Heated oxygen sensor (H02S) 2, bank 1 - signal too low Accelerator pedal position (APP) sensor 2 - low input Accelerator pedal position (APP) sensor 2 - high input Accelerator pedal position (APP) sensor 112 - rangelperformance problem Electronic throttle system (ETS) - malfunction Throttle position (TP) sensor - adaptation failure Fuel pump (FP) relay, primary circuit - low Wiring, TP sensor 7 Engine management Wiring short to positive, catalytic converter, fuel pressure high, H02S Wiring short to earth, poor connection, exhaust leak, fuel pressure low, H02S Wiring short to earth, APP sensor PI236 1 4662 I Fuel pump (FP) relay, primary circuit - high I Wiring short to positive, fuel pump relay P1237 PI 238 PI239 PI 240 4663 4664 4665 4672 Wiring short to positive, APP sensor Wiring, APP sensor Throttle valve tightlsticking, ETS ETS Wiring open circuitlshort to earth, fuel pump relay PI241 I 4673 1 Manifold absolute pressure (MAP) sensor 2 - Wiring short to earth, MAP sensor signal too low at full load for low engine speed PI 242 PI320 PI321 PI366 4674 4896 4897 4966 Manifold absolute pressure (MAP) sensor 2 - low input Manifold absolute pressure (MAP) sensor 2 - high input Manifold absolute pressure (MAP) sensor 2 - signal too low at engine stop Manifold absolute pressure (MAP) sensor 2 - signal too low at idle Wiring short to earth, MAP sensor Wiring short to positive, MAP sensor Wiring short to earth, poor connection, sensor supply, MAP sensor Wiring short to earth, poor connection, MAP sensor P1367 1 4967 I Ignition coil B, primarylsecondary circuit - low I Wiring short to earth, ignition coil PI 570 PI571 PI572 PI 573 PI 574 5488 5489 5490 5491 5492 Manifold absolute pressure (MAP) sensor 2 - too high in deceleration Flywheel adaptation for misfire detection - range Flywheel adaptation for misfire detection - performance Ignition coil A, primarylsecondary circuit - low Engine control module (ECM), sensor supply circuit A - low output Engine control module (ECM), sensor supply circuit A - high output Engine control module (ECM), sensor supply circuit A - noisy signal Engine control module (ECM), sensor supply circuit B - low output Engine control module (ECM), sensor supply circuit B - high output Throttle valve sticking, air leak - - Wiring short to earth, ignition coil Wiring short to earth, ECM Wiring short to positive, ECM Wiring, interference Wiring short to earth, ECM Wiring short to positive, ECM 1 451 1 Eng~ne management
- Page 400 and 401: Model: Mazda2 Mazda6 Tribute '--- L
- Page 402 and 403: I MAZDA ~5.1 Year: 1989-03 323 (BG)
- Page 404 and 405: 1 404 ................ MAZDA 1 b-->
- Page 406 and 407: , -' - MAZDA Model 323 (BG) 323 Est
- Page 408 and 409: I FJ,;-'; Engine managementltransmi
- Page 410 and 411: 1 i, 5: .I Engine managementltransm
- Page 412 and 413: 11 2 Engine managementltransmission
- Page 414 and 415: I-.,) Model: Engine management~tran
- Page 416 and 417: Model: 3231Estate 1,6 8VIl6V (BGIBW
- Page 418 and 419: Engine management Year: 1998-04 A1
- Page 420 and 421: I MERCEDES-BENZ Model: FEngine mana
- Page 422 and 423: ME RCED ESIBE NZ Model. Engine mana
- Page 424 and 425: 1 424 I,,,.,,,,,,, IAutodata ME RCE
- Page 426 and 427: I Engine management Trouble code id
- Page 428 and 429: ME RCEDES-BE NZ Model: C18012001200
- Page 430 and 431: ME RC ED ESIB E NZ I Engine managem
- Page 432 and 433: lMERCEDESIBE NZ Model: C180/200/200
- Page 434 and 435: CL42015001600 (140) SLK2OOl2OOW230W
- Page 436 and 437: M E RC E D ESIB E NZ Model C1801200
- Page 438 and 439: 1 438 I,,,,,,,,,,, kJAutodata MERCE
- Page 440 and 441: Engine management Trouble code iden
- Page 442 and 443: I Engine management P type I Fault
- Page 444 and 445: I Engine management P type I Fau. l
- Page 446 and 447: I bJiil MERCEDES-BENZ Model. C-Clas
- Page 448 and 449: Model: C-Class (202) E-Class (124)
- Page 452 and 453: fa J MINI Model: One Cooper Engine
- Page 454 and 455: I Engine management Model: One D Ye
- Page 456 and 457: Engine management Model: Galant 1,8
- Page 458 and 459: ITransrnission Model: Galant I Year
- Page 460 and 461: I ' I. !'1 MITSUBISHI Model: w Year
- Page 462 and 463: MITSUB1SH1 Model: Galant ShogunlPaj
- Page 464 and 465: Engine management Erasing Switch ig
- Page 466 and 467: Engine manayerrler luirarisrr~~ss~u
- Page 468 and 469: NISSAN Model: Sunny l,4/l,6/2,O Sun
- Page 470 and 471: - , I NISSAN Model: Almera l,5/l,8
- Page 472 and 473: Year: 2001 -04 Engine code: KA24E,
- Page 474 and 475: 6' s Model: Almera l,5/l,8 Almera T
- Page 476 and 477: I r Y' NISSAN Model: Almera l,5/1,8
- Page 478 and 479: . I L Engine -- Flash type rnanagem
- Page 480 and 481: "&2" 2 -" , I-_ NlSSAN Model: Alrne
- Page 482 and 483: NISSAN Model: Almera 2,OD Primera 2
- Page 484 and 485: Model: Micra Alrnera Prirnera Seren
- Page 486 and 487: 1 PEUGEOT Model: I06 1,011,111,311,
- Page 488 and 489: Erasing Method 2 Ensure ignition sw
- Page 490 and 491: Engine management Model: 106 1,011,
- Page 492 and 493: I PEUGEOT Model: 106 1,0/1,1/1,4/1,
- Page 494 and 495: ?I PEUGEOT I Engine management Mode
- Page 496 and 497: Engine management Year: 2002-04 Eng
- Page 498 and 499: 1 PEUGEOT Engine management Model:
Engine management<br />
Model: One Cooper<br />
Year: 2001 -04<br />
Engine code: WIOB, WllB<br />
System: Siemens EMS 2000<br />
Under steering column<br />
General information<br />
0 Refer to the front of this manual for general test conditions,<br />
terminology, detailed descriptions of wiring faults <strong>and</strong> a<br />
general trouble shooter for electrical <strong>and</strong> mechanical faults.<br />
Accessing <strong>and</strong> erasing<br />
The engine control module (ECM) fault memory can only be<br />
accessed <strong>and</strong> erased using diagnostic equipment<br />
connected to the data link connector (DLC).<br />
<strong>Trouble</strong> code identification<br />
I EOBD type BMW type <strong>Fault</strong> kcation<br />
I Probable cause<br />
I I<br />
PO - I Refer to EOBD trouble code table -<br />
PI106<br />
PI107<br />
4358<br />
4359<br />
PI lo8 Manifold absolute pressure (MAP) sensor - Wiring short to earth, MAP sensor<br />
I 4360 1 signal too low at full load for low engine speed<br />
PI 109<br />
PI122<br />
PI123<br />
PI125<br />
4361<br />
4386<br />
4387<br />
4389<br />
Manifold absolute pressure (MAP) sensor -<br />
signal too low at engine stop<br />
Manifold absolute pressure (MAP) sensor -<br />
signal too low at idle<br />
Manifold absolute pressure - too high under<br />
deceleration<br />
Accelerator pedal position (APP) sensor 1 -<br />
low input<br />
Acceterator pedal position (APP) sensor 1 -<br />
high input<br />
Throttle position (TP) sensor, AIB - small<br />
rangelperformance problem<br />
Wiring short to earth, poor connection, sensor<br />
supply, MAP sensor<br />
Wiring short to earth, poor connection,<br />
MAP sensor<br />
Throttle valve sticking, air leak<br />
Wiring short to earth, APP sensor<br />
Wiring short to positive, APP sensor<br />
Wiring, TP sensor