268954910-Renault-Scenic.pdf

More documents

Recommendations

Info

FRONT AXLE COMPONENTS Front axle sub-frame: Removal - Refitting 31A EQT LEVEL SPORT II - REFITTING OPERATION FOR PART CONCERNED a Refit the subframe equipment. a Strap the sub-frame onto the component jack. a Refit: - the sub-frame, - the bracket, - the engine tie-bar . a Tighten to torque: - the front wheel arch liners (see Front wheel arch liner: Removal - Refitting) (55A, Exterior protection), - the front wheels (see 35A, Wheels and tyres, Wheel: Removal - Refitting, page 35A-1) , - the universal joint. a Torque tighten the universal joint bolt (24 Nm). a Remove the safety strap(s) from the radiator. a Adjust the axle assemblies (see 30A, General information, Axle assemblies: Check, page 30A-8) . - the subframe bracket bolts (62 Nm), - the subframe tie-rod bolts (105 Nm), - the engine tie-bar bolts on the engine (180 Nm), - the engine tie-bar bolts on the subframe (105 Nm). III - FINAL OPERATION. a Refit: - the pivots on their support, - the subframe stiffener strut, - the anti-roll bar tie bars, - the ball joints. a Tighten to torque: - the pivot bolts (72 Nm), - the subframe stiffener strut bolts (62 Nm), - the anti-roll bar tie bar nuts (44 Nm). - the track rod end nuts (37 Nm), - the lower ball joint nuts (100 Nm). a Connect the wheel speed sensor connector. a Clip the wheel speed sensor wiring. a Refit: - the height sensor ball joint, - the radiator cross member, - the side panels. a Tighten to torque: - the radiator cross member front bolts (105 Nm), - the radiator cross member rear nuts (21 Nm), - the side panel bolts (21 Nm). a Refit: - the engine undertray, 31A-36
FRONT AXLE COMPONENTS Front anti-roll bar: Removal - Refitting 31A Tightening torquesm anti-roll bar - sub-frame mounting bolts steering rack - subframe mounting bolts 2.1 daNm 10.5 daNm REMOVAL a Mount the vehicle on a two post lift. a Remove: - the front axle sub-frame (see 31A, Front axle components, Front axle sub-frame: Removal - Refitting, page 31A-26) , - the steering rack - sub-frame mounting bolts, - the steering rack, - the anti-roll bar - sub-frame mounting bolts, - the anti-roll bar. REFITTING a Proceed in the reverse order to removal. WARNING Make sure the anti-roll bar mounting bracket lugs are correctly positioned in the sub-frame apertures. a Torque tighten: - the anti-roll bar - sub-frame mounting bolts (2.1 daNm), - the steering rack - sub-frame mounting bolts (10.5 daNm). 31A-37
Page 1 and 2:
3 Chassis 30A GENERAL INFORMATION 3
Page 4 and 5:
Contents 37A MECHANICAL COMPONENT C
Page 6 and 7:
GENERAL INFORMATION Brake circuit B
Page 8 and 9:
GENERAL INFORMATION Brake circuit T
Page 10 and 11: GENERAL INFORMATION Brake: Specific
Page 12 and 13: GENERAL INFORMATION Axle assemblies
Page 14 and 15: GENERAL INFORMATION Underbody heigh
Page 16 and 17: GENERAL INFORMATION Front axle: Tig
Page 18 and 19: GENERAL INFORMATION Front axle: Adj
Page 20 and 21: GENERAL INFORMATION Front axle: Adj
Page 22 and 23: GENERAL INFORMATION Rear axle: Adju
Page 24 and 25: GENERAL INFORMATION Rear axle: Adju
Page 26 and 27: FRONT AXLE COMPONENTS Front brake p
Page 28 and 29: FRONT AXLE COMPONENTS Front brake h
Page 30 and 31: FRONT AXLE COMPONENTS Front brake c
Page 32 and 33: FRONT AXLE COMPONENTS Front brake c
Page 34 and 35: FRONT AXLE COMPONENTS Front brake d
Page 36 and 37: FRONT AXLE COMPONENTS Front drivesh
Page 40 and 41: FRONT AXLE COMPONENTS Front hub car
Page 42 and 43: FRONT AXLE COMPONENTS Spring and fr
Page 44 and 45: FRONT AXLE COMPONENTS Spring and fr
Page 50 and 51: FRONT AXLE COMPONENTS Front axle su
Page 62 and 63: REAR AXLE COMPONENTS Rear brake pad
Page 64 and 65: REAR AXLE COMPONENTS Rear brake cal
Page 66 and 67: REAR AXLE COMPONENTS Rear brake cal
Page 68 and 69: REAR AXLE COMPONENTS Rear brake dis
Page 70 and 71: REAR AXLE COMPONENTS Rear brake dis
Page 72 and 73: REAR AXLE COMPONENTS Brake pipe: Re
Page 74 and 75: REAR AXLE COMPONENTS Bearing: Remov
Page 76 and 77: REAR AXLE COMPONENTS Rear suspensio
Page 78 and 79: REAR AXLE COMPONENTS Shock absorber
Page 80 and 81: REAR AXLE COMPONENTS Rear axle rubb
Page 82 and 83: REAR AXLE COMPONENTS Complete rear
Page 88 and 89: WHEELS AND TYRES Wheel: Removal - R
Page 90 and 91: WHEELS AND TYRES Wheel: Removal - R
Page 92 and 93: WHEELS AND TYRES Wheel: Balancing 3
Page 94 and 95: WHEELS AND TYRES Tyres: Identificat
Page 96 and 97: WHEELS AND TYRES Tyres: Removal - R
Page 98 and 99: WHEELS AND TYRES Tyre inflation pre
Page 100 and 101: WHEELS AND TYRES Wheel rim: Identif
Page 102 and 103: WHEELS AND TYRES Spare wheel winch:
Page 104 and 105: WHEELS AND TYRES Run flat tyres: Id
Page 106 and 107: WHEELS AND TYRES Run flat tyres: Re
Page 108 and 109: WHEELS AND TYRES Run flat tyres 35A
Page 110 and 111:
WHEELS AND TYRES Run flat tyres 35A
Page 112 and 113:
TYRE PRESSURE MONITOR SSPP: List an
Page 114 and 115:
TYRE PRESSURE MONITOR Pressure sens
Page 116 and 117:
STEERING ASSEMBLY Steering rack: Re
Page 118 and 119:
STEERING ASSEMBLY Track rod: Remova
Page 120 and 121:
STEERING ASSEMBLY Axial ball joint
Page 122 and 123:
STEERING ASSEMBLY Axial ball joint
Page 124 and 125:
STEERING ASSEMBLY Steering column:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
STEERING ASSEMBLY Steering rack gai
Page 132 and 133:
STEERING ASSEMBLY Intermediate shaf
Page 134 and 135:
STEERING ASSEMBLY Intermediate shaf
Page 136 and 137:
STEERING ASSEMBLY Steering wheel: R
Page 138 and 139:
MECHANICAL COMPONENT CONTROLS Maste
Page 140 and 141:
MECHANICAL COMPONENT CONTROLS Maste
Page 142 and 143:
MECHANICAL COMPONENT CONTROLS Brake
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
MECHANICAL COMPONENT CONTROLS Vacuu
Page 154 and 155:
MECHANICAL COMPONENT CONTROLS Vacuu
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
MECHANICAL COMPONENT CONTROLS Parki
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
MECHANICAL COMPONENT CONTROLS Clutc
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
MECHANICAL COMPONENT CONTROLS Gear
Page 194 and 195:
MECHANICAL COMPONENT CONTROLS Gear
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
ELECTRONIC PARKING BRAKE Emergency
Page 220 and 221:
ELECTRONIC PARKING BRAKE Control un
Page 222 and 223:
ELECTRONIC PARKING BRAKE Control un
Page 224 and 225:
ELECTRONIC PARKING BRAKE Handle: Re
Page 226 and 227:
ANTI-LOCK BRAKING SYSTEM Hydraulic
Page 228 and 229:
ANTI-LOCK BRAKING SYSTEM Brake hydr
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240 and 241:
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
ANTI-LOCK BRAKING SYSTEM ABS with E
Page 248 and 249:
ANTI-LOCK BRAKING SYSTEM Yaw speed
show all

268954910-Renault-Scenic.pdf

Create successful ePaper yourself

Delete template?

Save as template?