268954910-Renault-Scenic.pdf

More documents

Recommendations

Info

MECHANICAL COMPONENT CONTROLS Clutch circuit: Bleeding 37A JH3 or JR5 or ND0 or PK4 or TL4 There are several versions of pipe with and without a filter: Filling position for pipe with filter. Pipe without filter. 141810 Filling position for pipe with filter. 141812 Filling position for pipe with filter. a Prefill the clutch pipe using the syringe. 141813 141811 a Plug the prefilled pipe on the master cylinder end to stop any brake fluid from escaping. 37A-77
MECHANICAL COMPONENT CONTROLS Clutch circuit: Bleeding 37A JH3 or JR5 or ND0 or PK4 or TL4 V - BLEED PROCEDURE AFTER A REMOVING A COMPONENT OF THE HYDRAULIC CIRCUIT. a Keep the clutch pedal in the upper position using a strap attached to the steering wheel to ensure continuity of the hydraulic circuit during the bleed operation. Note: Take care not to disrupt the adjustment of the clutch start of travel switch. a Remove the bleed plug from the clutch slave cylinder. a Connect a transparent pipe of sufficient length to the bleed hole (at least thirty centimeters) in order to place it at the same height as the reservoir. 141809 a Prefill the hydraulic tappet using the new syringe (by gravity). a Refit the part(s) concerned. a Open the bleed screw. a Fill the brake fluid master cylinder reservoir until brake fluid flows out of the bleed screw. Note: The transparent pipe must remain at the same height as the master cylinder reservoir to prevent air from entering inside the clutch circuit. a Connect a new syringe containing 60 ml of approved brake fluid to the end of the transparent pipe. a Slowly inject the entire contents of the syringe into the hydraulic clutch circuit without injecting any of the air from the top section of the syringe. a Close the bleed screw. a Remove the transparent pipe from the bleed hole. a Refit the bleed plug. a Top up the brake fluid level in the master cylinder reservoir. a Disengage and engage the clutch quickly around twenty times. a Check that the clutch system is operating correctly. a Repeat the bleed operation if necessary. a Check the adjustment of the switch. (see 37A, Mechanical component controls, Clutch pedal switch: Removal - Refitting, page 37A-51) (37A, mechanical control elements). 37A-78
Page 1 and 2:
3 Chassis 30A GENERAL INFORMATION 3
Page 4 and 5:
Contents 37A MECHANICAL COMPONENT C
Page 6 and 7:
GENERAL INFORMATION Brake circuit B
Page 8 and 9:
GENERAL INFORMATION Brake circuit T
Page 10 and 11:
GENERAL INFORMATION Brake: Specific
Page 12 and 13:
GENERAL INFORMATION Axle assemblies
Page 14 and 15:
GENERAL INFORMATION Underbody heigh
Page 16 and 17:
GENERAL INFORMATION Front axle: Tig
Page 18 and 19:
GENERAL INFORMATION Front axle: Adj
Page 20 and 21:
GENERAL INFORMATION Front axle: Adj
Page 22 and 23:
GENERAL INFORMATION Rear axle: Adju
Page 24 and 25:
GENERAL INFORMATION Rear axle: Adju
Page 26 and 27:
FRONT AXLE COMPONENTS Front brake p
Page 28 and 29:
FRONT AXLE COMPONENTS Front brake h
Page 30 and 31:
FRONT AXLE COMPONENTS Front brake c
Page 32 and 33:
FRONT AXLE COMPONENTS Front brake c
Page 34 and 35:
FRONT AXLE COMPONENTS Front brake d
Page 36 and 37:
FRONT AXLE COMPONENTS Front drivesh
Page 38 and 39:
Page 40 and 41:
FRONT AXLE COMPONENTS Front hub car
Page 42 and 43:
FRONT AXLE COMPONENTS Spring and fr
Page 44 and 45:
FRONT AXLE COMPONENTS Spring and fr
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
FRONT AXLE COMPONENTS Front axle su
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
REAR AXLE COMPONENTS Rear brake pad
Page 64 and 65:
REAR AXLE COMPONENTS Rear brake cal
Page 66 and 67:
REAR AXLE COMPONENTS Rear brake cal
Page 68 and 69:
REAR AXLE COMPONENTS Rear brake dis
Page 70 and 71:
REAR AXLE COMPONENTS Rear brake dis
Page 72 and 73:
REAR AXLE COMPONENTS Brake pipe: Re
Page 74 and 75:
REAR AXLE COMPONENTS Bearing: Remov
Page 76 and 77:
REAR AXLE COMPONENTS Rear suspensio
Page 78 and 79:
REAR AXLE COMPONENTS Shock absorber
Page 80 and 81:
REAR AXLE COMPONENTS Rear axle rubb
Page 82 and 83:
REAR AXLE COMPONENTS Complete rear
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
WHEELS AND TYRES Wheel: Removal - R
Page 90 and 91:
WHEELS AND TYRES Wheel: Removal - R
Page 92 and 93:
WHEELS AND TYRES Wheel: Balancing 3
Page 94 and 95:
WHEELS AND TYRES Tyres: Identificat
Page 96 and 97:
WHEELS AND TYRES Tyres: Removal - R
Page 98 and 99:
WHEELS AND TYRES Tyre inflation pre
Page 100 and 101:
WHEELS AND TYRES Wheel rim: Identif
Page 102 and 103:
WHEELS AND TYRES Spare wheel winch:
Page 104 and 105:
WHEELS AND TYRES Run flat tyres: Id
Page 106 and 107:
WHEELS AND TYRES Run flat tyres: Re
Page 108 and 109:
WHEELS AND TYRES Run flat tyres 35A
Page 110 and 111:
WHEELS AND TYRES Run flat tyres 35A
Page 112 and 113:
TYRE PRESSURE MONITOR SSPP: List an
Page 114 and 115:
TYRE PRESSURE MONITOR Pressure sens
Page 116 and 117:
STEERING ASSEMBLY Steering rack: Re
Page 118 and 119:
STEERING ASSEMBLY Track rod: Remova
Page 120 and 121:
STEERING ASSEMBLY Axial ball joint
Page 122 and 123:
STEERING ASSEMBLY Axial ball joint
Page 124 and 125:
STEERING ASSEMBLY Steering column:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
STEERING ASSEMBLY Steering rack gai
Page 132 and 133:
STEERING ASSEMBLY Intermediate shaf
Page 134 and 135:
STEERING ASSEMBLY Intermediate shaf
Page 136 and 137:
STEERING ASSEMBLY Steering wheel: R
Page 138 and 139:
MECHANICAL COMPONENT CONTROLS Maste
Page 140 and 141:
MECHANICAL COMPONENT CONTROLS Maste
Page 142 and 143:
MECHANICAL COMPONENT CONTROLS Brake
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 150 and 151:
Page 152 and 153:
MECHANICAL COMPONENT CONTROLS Vacuu
Page 154 and 155:
MECHANICAL COMPONENT CONTROLS Vacuu
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165: MECHANICAL COMPONENT CONTROLS Brake
Page 170 and 171: MECHANICAL COMPONENT CONTROLS Parki
Page 176 and 177: MECHANICAL COMPONENT CONTROLS Clutc
Page 192 and 193: MECHANICAL COMPONENT CONTROLS Gear
Page 194 and 195: MECHANICAL COMPONENT CONTROLS Gear
Page 218 and 219: ELECTRONIC PARKING BRAKE Emergency
Page 220 and 221: ELECTRONIC PARKING BRAKE Control un
Page 222 and 223: ELECTRONIC PARKING BRAKE Control un
Page 224 and 225: ELECTRONIC PARKING BRAKE Handle: Re
Page 226 and 227: ANTI-LOCK BRAKING SYSTEM Hydraulic
Page 228 and 229: ANTI-LOCK BRAKING SYSTEM Brake hydr
Page 246 and 247: ANTI-LOCK BRAKING SYSTEM ABS with E
Page 248 and 249: ANTI-LOCK BRAKING SYSTEM Yaw speed
show all

268954910-Renault-Scenic.pdf

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?