268954910-Renault-Scenic.pdf

More documents

Recommendations

Info

MECHANICAL COMPONENT CONTROLS Clutch pedal switch: Removal - Refitting 37A 5 SPEED MANUAL GBOX or 6 SPEED MANUAL GBOX REFITTING II - REFITTING THE CLUTCH PEDAL SWITCHES I - WHEN REMOVING AND REFITTING OR WHEN REPLACING A CLUTCH PEDAL SWITCH CRUISE CONTROL a Depress the clutch pedal by hand. a Position the start of travel switch on the pedal assembly. a Lock the start of travel switch by turning it one quarter of a turn clockwise. a Support the return of the clutch pedal. a 108434 Note: The clutch pedal switch has an automatic adjustment feature, adapting to the pedal position. The automatic adjustment makes a clicking noise when in operation. WARNING Handle the switch (3) with care. Only operate the piston (4) to adjust the dimension (X) . The switch must be replaced: - if the piston (4) is separated from the switch (3) , -if more than three adjustments to the dimension (X) are necessary during the operation. a Measure dimension (X) of the piston (4) . If the dimension (X) is less than 17 mm, carefully pull on the end of the piston (4) to adjust the dimension (X) between the values 17 mm minimum and 18 mm maximum. a Connect clutch switch connector. DOOR OPEN SYST. 433 NML a Position the end of travel switch on the pedal assembly. a Lock the end of travel switch by turning it one quarter of a turn clockwise. a Depress the clutch pedal by hand. Note: The clutch pedal switch has an automatic adjustment feature, adapting to the pedal position. The automatic adjustment makes a clicking noise when in operation. a Support the return of the clutch pedal. a Connect clutch switch connector. III - FINAL OPERATION a Be sure to carry out a repair check using diagnostic tool. 37A-53
MECHANICAL COMPONENT CONTROLS Manual gearbox selector cable: Removal - Refitting 37A AJ0 or DP0 or JH3 or JR5 or ND0 or PK4 or TL4 I - REMOVAL II - REFITTING a Precautions to be taken when removing and refitting the gear cable end pieces to avoid tearing the plastic guide tube and damaging the ball joints. 121257 a To remove the gear control cables from their ball joints, use an open-ended spanner as shown above. This prevents the control cables from being damaged. 121258 121259 a To refit, use pliers to clip the gear control cables to the ball joints. a Perform rapid gearchanges for all gears for 20 seconds. Check that the cables are not unclipped. 37A-54
Page 1 and 2:
3 Chassis 30A GENERAL INFORMATION 3
Page 4 and 5:
Contents 37A MECHANICAL COMPONENT C
Page 6 and 7:
GENERAL INFORMATION Brake circuit B
Page 8 and 9:
GENERAL INFORMATION Brake circuit T
Page 10 and 11:
GENERAL INFORMATION Brake: Specific
Page 12 and 13:
GENERAL INFORMATION Axle assemblies
Page 14 and 15:
GENERAL INFORMATION Underbody heigh
Page 16 and 17:
GENERAL INFORMATION Front axle: Tig
Page 18 and 19:
GENERAL INFORMATION Front axle: Adj
Page 20 and 21:
GENERAL INFORMATION Front axle: Adj
Page 22 and 23:
GENERAL INFORMATION Rear axle: Adju
Page 24 and 25:
GENERAL INFORMATION Rear axle: Adju
Page 26 and 27:
FRONT AXLE COMPONENTS Front brake p
Page 28 and 29:
FRONT AXLE COMPONENTS Front brake h
Page 30 and 31:
FRONT AXLE COMPONENTS Front brake c
Page 32 and 33:
FRONT AXLE COMPONENTS Front brake c
Page 34 and 35:
FRONT AXLE COMPONENTS Front brake d
Page 36 and 37:
FRONT AXLE COMPONENTS Front drivesh
Page 38 and 39:
Page 40 and 41:
FRONT AXLE COMPONENTS Front hub car
Page 42 and 43:
FRONT AXLE COMPONENTS Spring and fr
Page 44 and 45:
FRONT AXLE COMPONENTS Spring and fr
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
FRONT AXLE COMPONENTS Front axle su
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
REAR AXLE COMPONENTS Rear brake pad
Page 64 and 65:
REAR AXLE COMPONENTS Rear brake cal
Page 66 and 67:
REAR AXLE COMPONENTS Rear brake cal
Page 68 and 69:
REAR AXLE COMPONENTS Rear brake dis
Page 70 and 71:
REAR AXLE COMPONENTS Rear brake dis
Page 72 and 73:
REAR AXLE COMPONENTS Brake pipe: Re
Page 74 and 75:
REAR AXLE COMPONENTS Bearing: Remov
Page 76 and 77:
REAR AXLE COMPONENTS Rear suspensio
Page 78 and 79:
REAR AXLE COMPONENTS Shock absorber
Page 80 and 81:
REAR AXLE COMPONENTS Rear axle rubb
Page 82 and 83:
REAR AXLE COMPONENTS Complete rear
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
WHEELS AND TYRES Wheel: Removal - R
Page 90 and 91:
WHEELS AND TYRES Wheel: Removal - R
Page 92 and 93:
WHEELS AND TYRES Wheel: Balancing 3
Page 94 and 95:
WHEELS AND TYRES Tyres: Identificat
Page 96 and 97:
WHEELS AND TYRES Tyres: Removal - R
Page 98 and 99:
WHEELS AND TYRES Tyre inflation pre
Page 100 and 101:
WHEELS AND TYRES Wheel rim: Identif
Page 102 and 103:
WHEELS AND TYRES Spare wheel winch:
Page 104 and 105:
WHEELS AND TYRES Run flat tyres: Id
Page 106 and 107:
WHEELS AND TYRES Run flat tyres: Re
Page 108 and 109:
WHEELS AND TYRES Run flat tyres 35A
Page 110 and 111:
WHEELS AND TYRES Run flat tyres 35A
Page 112 and 113:
TYRE PRESSURE MONITOR SSPP: List an
Page 114 and 115:
TYRE PRESSURE MONITOR Pressure sens
Page 116 and 117:
STEERING ASSEMBLY Steering rack: Re
Page 118 and 119:
STEERING ASSEMBLY Track rod: Remova
Page 120 and 121:
STEERING ASSEMBLY Axial ball joint
Page 122 and 123:
STEERING ASSEMBLY Axial ball joint
Page 124 and 125:
STEERING ASSEMBLY Steering column:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
STEERING ASSEMBLY Steering rack gai
Page 132 and 133:
STEERING ASSEMBLY Intermediate shaf
Page 134 and 135:
STEERING ASSEMBLY Intermediate shaf
Page 136 and 137:
STEERING ASSEMBLY Steering wheel: R
Page 138 and 139:
MECHANICAL COMPONENT CONTROLS Maste
Page 140 and 141: MECHANICAL COMPONENT CONTROLS Maste
Page 142 and 143: MECHANICAL COMPONENT CONTROLS Brake
Page 152 and 153: MECHANICAL COMPONENT CONTROLS Vacuu
Page 154 and 155: MECHANICAL COMPONENT CONTROLS Vacuu
Page 170 and 171: MECHANICAL COMPONENT CONTROLS Parki
Page 176 and 177: MECHANICAL COMPONENT CONTROLS Clutc
Page 192 and 193: MECHANICAL COMPONENT CONTROLS Gear
Page 194 and 195: MECHANICAL COMPONENT CONTROLS Gear
Page 218 and 219: ELECTRONIC PARKING BRAKE Emergency
Page 220 and 221: ELECTRONIC PARKING BRAKE Control un
Page 222 and 223: ELECTRONIC PARKING BRAKE Control un
Page 224 and 225: ELECTRONIC PARKING BRAKE Handle: Re
Page 226 and 227: ANTI-LOCK BRAKING SYSTEM Hydraulic
Page 228 and 229: ANTI-LOCK BRAKING SYSTEM Brake hydr
Page 240 and 241:
ANTI-LOCK BRAKING SYSTEM Brake hydr
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
ANTI-LOCK BRAKING SYSTEM ABS with E
Page 248 and 249:
ANTI-LOCK BRAKING SYSTEM Yaw speed
show all

268954910-Renault-Scenic.pdf

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?