268954910-Renault-Scenic.pdf

More documents

Recommendations

Info

STEERING ASSEMBLY Steering rack gaiter: Removal - Refitting 36A REMOVAL REFITTING I - REMOVAL PREPARATION OPERATION a Position the vehicle on a two-post lift (see Vehicle: Towing and lifting) (02A, Lifting equipment). a Remove: -the front wheel (see 35A, Wheels and tyres, Wheel: Removal - Refitting, page 35A-1) , - the track rod, (see 36A, Steering assembly, Track rod: Removal - Refitting, page 36A-3) - the wheel alignment adjusting lock nut. II - OPERATION FOR REMOVAL OF PART CONCERNED I - REFITTING PREPARATION OPERATION a Always replace: - the steering box gaiter, - the retaining clips. a Clean the contact surfaces between the steering box and the gaiter using SURFACE CLEANER (see Vehicle: Parts and ingredients for the repairwork) . a Coat the gaiter bearing face on the axial ball joint with SILICONE LUBRICANT (see Vehicle: Parts and ingredients for the repairwork) to prevent the gaiter from twisting. Note: Be sure to centre the steering to ensure the air in the gaiters is equalised. Note: Be careful not to damage the gaiters: risk of irreversible damage. a 105678 II - REFITTING OPERATION FOR PART CONCERNED a Refit: -a new steering box gaiter, - new retaining clips. Note: When removing the steering gaiter, blast the gaiter surfaces with compressed air to eliminate any impurities that could enter the steering box. a Remove the gaiter retaining clip (1) a Cut the gaiter retaining clip (2) . a Remove the gaiter (3) . III - FINAL OPERATION. a Refit: - the wheel alignment adjustment lock nut, - the track rod, (see 36A, Steering assembly, Track rod: Removal - Refitting, page 36A-3) -the front wheel (see 35A, Wheels and tyres, Wheel: Removal - Refitting, page 35A-1) . a Check the axle geometry (see 30A, General information, Axle assemblies: Check, page 30A-8) . a If necessary, adjust the axle assemblies' geometry (see 30A, General information, Front axle: Adjusting, page 30A-16) . 36A-15
STEERING ASSEMBLY Bulkhead seal: Removal - Refitting 36A Essential equipment diagnostic tool REMOVAL a Remove the front axle subframe (see 31A, Front axle components, Front axle sub-frame: Removal - Refitting, page 31A-26) . a Unclip the bulkhead seal using a screwdriver. 101352 REFITTING a To refit, proceed in the reverse order of removal. a Note: - The universal joint cam bolt and nut must be replaced. WARNING Connect the battery. - carry out the necessary programming ( (see 80A, Battery) ). - Program the torque and angle sensor and make the necessary configurations using the diagnostic tool (see the fault finding manual). 36A-16
Page 1 and 2:
3 Chassis 30A GENERAL INFORMATION 3
Page 4 and 5:
Contents 37A MECHANICAL COMPONENT C
Page 6 and 7:
GENERAL INFORMATION Brake circuit B
Page 8 and 9:
GENERAL INFORMATION Brake circuit T
Page 10 and 11:
GENERAL INFORMATION Brake: Specific
Page 12 and 13:
GENERAL INFORMATION Axle assemblies
Page 14 and 15:
GENERAL INFORMATION Underbody heigh
Page 16 and 17:
GENERAL INFORMATION Front axle: Tig
Page 18 and 19:
GENERAL INFORMATION Front axle: Adj
Page 20 and 21:
GENERAL INFORMATION Front axle: Adj
Page 22 and 23:
GENERAL INFORMATION Rear axle: Adju
Page 24 and 25:
GENERAL INFORMATION Rear axle: Adju
Page 26 and 27:
FRONT AXLE COMPONENTS Front brake p
Page 28 and 29:
FRONT AXLE COMPONENTS Front brake h
Page 30 and 31:
FRONT AXLE COMPONENTS Front brake c
Page 32 and 33:
FRONT AXLE COMPONENTS Front brake c
Page 34 and 35:
FRONT AXLE COMPONENTS Front brake d
Page 36 and 37:
FRONT AXLE COMPONENTS Front drivesh
Page 38 and 39:
Page 40 and 41:
FRONT AXLE COMPONENTS Front hub car
Page 42 and 43:
FRONT AXLE COMPONENTS Spring and fr
Page 44 and 45:
FRONT AXLE COMPONENTS Spring and fr
Page 46 and 47:
Page 48 and 49:
Page 50 and 51:
FRONT AXLE COMPONENTS Front axle su
Page 52 and 53:
Page 54 and 55:
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Page 62 and 63:
REAR AXLE COMPONENTS Rear brake pad
Page 64 and 65:
REAR AXLE COMPONENTS Rear brake cal
Page 66 and 67:
REAR AXLE COMPONENTS Rear brake cal
Page 68 and 69:
REAR AXLE COMPONENTS Rear brake dis
Page 70 and 71:
REAR AXLE COMPONENTS Rear brake dis
Page 72 and 73:
REAR AXLE COMPONENTS Brake pipe: Re
Page 74 and 75:
REAR AXLE COMPONENTS Bearing: Remov
Page 76 and 77:
REAR AXLE COMPONENTS Rear suspensio
Page 78 and 79:
REAR AXLE COMPONENTS Shock absorber
Page 80 and 81: REAR AXLE COMPONENTS Rear axle rubb
Page 82 and 83: REAR AXLE COMPONENTS Complete rear
Page 88 and 89: WHEELS AND TYRES Wheel: Removal - R
Page 90 and 91: WHEELS AND TYRES Wheel: Removal - R
Page 92 and 93: WHEELS AND TYRES Wheel: Balancing 3
Page 94 and 95: WHEELS AND TYRES Tyres: Identificat
Page 96 and 97: WHEELS AND TYRES Tyres: Removal - R
Page 98 and 99: WHEELS AND TYRES Tyre inflation pre
Page 100 and 101: WHEELS AND TYRES Wheel rim: Identif
Page 102 and 103: WHEELS AND TYRES Spare wheel winch:
Page 104 and 105: WHEELS AND TYRES Run flat tyres: Id
Page 106 and 107: WHEELS AND TYRES Run flat tyres: Re
Page 108 and 109: WHEELS AND TYRES Run flat tyres 35A
Page 110 and 111: WHEELS AND TYRES Run flat tyres 35A
Page 112 and 113: TYRE PRESSURE MONITOR SSPP: List an
Page 114 and 115: TYRE PRESSURE MONITOR Pressure sens
Page 116 and 117: STEERING ASSEMBLY Steering rack: Re
Page 118 and 119: STEERING ASSEMBLY Track rod: Remova
Page 120 and 121: STEERING ASSEMBLY Axial ball joint
Page 122 and 123: STEERING ASSEMBLY Axial ball joint
Page 124 and 125: STEERING ASSEMBLY Steering column:
Page 132 and 133: STEERING ASSEMBLY Intermediate shaf
Page 134 and 135: STEERING ASSEMBLY Intermediate shaf
Page 136 and 137: STEERING ASSEMBLY Steering wheel: R
Page 138 and 139: MECHANICAL COMPONENT CONTROLS Maste
Page 140 and 141: MECHANICAL COMPONENT CONTROLS Maste
Page 142 and 143: MECHANICAL COMPONENT CONTROLS Brake
Page 152 and 153: MECHANICAL COMPONENT CONTROLS Vacuu
Page 154 and 155: MECHANICAL COMPONENT CONTROLS Vacuu
Page 170 and 171: MECHANICAL COMPONENT CONTROLS Parki
Page 176 and 177: MECHANICAL COMPONENT CONTROLS Clutc
Page 178 and 179: MECHANICAL COMPONENT CONTROLS Clutc
Page 180 and 181:
MECHANICAL COMPONENT CONTROLS Clutc
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
MECHANICAL COMPONENT CONTROLS Gear
Page 194 and 195:
MECHANICAL COMPONENT CONTROLS Gear
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
ELECTRONIC PARKING BRAKE Emergency
Page 220 and 221:
ELECTRONIC PARKING BRAKE Control un
Page 222 and 223:
ELECTRONIC PARKING BRAKE Control un
Page 224 and 225:
ELECTRONIC PARKING BRAKE Handle: Re
Page 226 and 227:
ANTI-LOCK BRAKING SYSTEM Hydraulic
Page 228 and 229:
ANTI-LOCK BRAKING SYSTEM Brake hydr
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240 and 241:
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
ANTI-LOCK BRAKING SYSTEM ABS with E
Page 248 and 249:
ANTI-LOCK BRAKING SYSTEM Yaw speed
show all

268954910-Renault-Scenic.pdf

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?