MSDS Search - Printable MSDS #837998 - ChemCenters

MSDS Search - Printable MSDS #837998------------------------------------------------------------------------------MATERIAL SAFETY DATA SHEET Page 1MSDS ID: 091701 Revised 8/16/99BOSCODUR 9RBOSTIK INC. Replaces 8/16/99------------------------------------------------------------------------------------------------------------------------------------------------------------SECTION 1- CHEMICAL PRODUCT AND COMPANY IDENTIFICATION------------------------------------------------------------------------------MSDS NUMBER: 091701PRODUCT NAME: BOSCODUR 9RCHEMICAL FAMILY: Solvent Based Curing AgentCOMPANY:EMERGENCY RESPONSE NUMBERS:Bostik Inc.Transportation:211 Boston St. In case of emergency, Call:Middleton, MA 01949 800-227-0332Product Safety and Environmental:978-777-0100------------------------------------------------------------------------------SECTION 2- INGREDIENT AND EXPOSURE LIMIT INFORMATION------------------------------------------------------------------------------COMPONENT CAS NUMBER WT PERCENT* OEL** OSHA PELBUTYRALDEHYDE-MONOBUTYLAMINE 68411-19-8 1 to 5% Not Listed Not ListedCONDENSATION PRODUCTCYCLOHEXANE 110-82-7 .5 to 1.5% 300 ppm 300 ppmLEAD MONOXIDE 1317-36-8 10 to 30% 0.050 mg/M3 Not ListedPHENOL,4-(1,1-DIMETHYLPROPYL) 68555-98-6 1 to 5% Not Listed Not ListedSOLVENT NAPHTHA 64742-89-8 10 to 30% 400 ppm Not Listed(PETROLEUM), LIGHT ALIPH.TOLUENE 108-88-3 30 to 60% 50 ppm 100 ppm* If the total percentage is less than 100, the balance of this product isnot considered to be hazardous as defined under OSHA's Hazard CommunicationStandard (29 CFR 1910.1200).** The Bostik recommended Occupational Exposure Limit (OEL) value representsthe lower of the US OSHA PEL, ACGIH TLV, or Manufacturer's Recommended Limit.N/A = Not Available, N/D = Not Determined------------------------------------------------------------------------------SECTION 3- HAZARDS IDENTIFICATION------------------------------------------------------------------------------http://www.bostik.com/msds/msdsprint.asp?id=837998&p=0 (1 of 8) [9/6/2001 12:55:08 PM]

MSDS Search - Printable MSDS #837998POTENTIAL HEALTH CONSIDERATIONSHMIS HAZARD RATINGSHealth: 2Flammability: 3Reactivity: 1Protection: GNote: Numeric Hazard Ratings are intended only to indicate the relativehazard of the product. Users must read and understand the entireMaterial Safety Data Sheet prior to use of this product.CANADIAN WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM (WHMIS) CLASS --Class B2 - Flammable LiquidD2B- Other Toxic Effects, Skin and Eye IrritantLIKELY ROUTES OF ENTRYIngestion, Contact, Inhalation.TARGET ORGANSCentral Nervous System, Lung, Skin.POTENTIAL IMMEDIATE EFFECTS FROM OVEREXPOSURECONTACT, SKIN and EYEIngredient causes skin and eye irritation, causing a rash or reddeningon contact. Eye contact may lead to permanent damage if not treatedpromptly.SKIN ABSORPTIONIngredient is readily absorbed through skin leading to potentialsystemic effects such as dizziness or headaches.INHALATIONHazardous if inhaled. Inhalation may lead to systemic and local effectssuch as irritation of throat and mucous membranes, dizziness orheadaches.INGESTIONToxic when ingested. Causes gastrointestinal discomfort and vomiting.High doses could lead to death.POTENTIAL LONG-TERM EFFECTS FROM OVEREXPOSURE:CANCER INFORMATIONNone of the ingredients in this product exceeding 0.1% are on the IARC,NTP, or OSHA lists of carcinogenic hazards.CHRONIC EFFECTSLong-term overexposure to the solvents in this product may lead toheadaches, loss of appetite, nausea, liver and kidney damage,http://www.bostik.com/msds/msdsprint.asp?id=837998&p=0 (2 of 8) [9/6/2001 12:55:08 PM]

MSDS Search - Printable MSDS #837998drying and cracking of skin. Some solvents have been shown to causehazardous reproductive effects.SYMPTOMS OF OVEREXPOSUREIrritation, headache, dizziness, giddiness, lightheadedness, drowsiness,lethargy, breathing difficulty, chest pain, coughing, dry skin, abdominalpain, cramps, nausea, vomiting.MEDICAL CONDITIONS AGGRAVATED BY EXPOSUREAsthma, dermatitis, and liver or kidney diseases.NOTES TO MD AND OTHER HEALTH RELATED INFORMATIONIf overexposure to the solvents in this product is suspected, testingshould include nervous system and brain effects including recent memory,mood, concentration, headaches and altered sleep patterns. Liver andkidney function should be evaluated.------------------------------------------------------------------------------SECTION 4- FIRST AID MEASURES------------------------------------------------------------------------------CONTACT, SKIN AND EYEEYES: IMMEDIATELY flush eyes with large amounts of water for at least 15minutes, occasionally lifting upper and lower lids. Seek medicalattention.SKIN: Quickly remove contaminated clothing. Immediately wash contaminatedskin with large amounts of soap and water. Seek medical attentionif irritation or rash or other symptoms develop.INHALATIONRemove victim to fresh air. Begin rescue breathing if breathing hasstopped. Transfer to a medical facility.INGESTIONDO NOT INDUCE VOMITING. IMMEDIATELY call a hospital or poison controlcenter. If the victim is conscious and not convulsing, give 1 or 2glasses of water to dilute the chemical. If the victim is convulsingor unconscious DO NOT give anything by mouth, ensure that the victim'sairway is open and lay victim on his/her side with the head lower thanthe body. Seek medical attention.------------------------------------------------------------------------------SECTION 5- FIRE FIGHTING MEASURES------------------------------------------------------------------------------FLAMMABILITY DATAFLASH POINT Deg F: 31Deg C: -0.6LOWER EXPLOSIVE LIMIT %: 1.13 % (Calculated)UPPER EXPLOSIVE LIMIT %: 7.07 % (Calculated)AUTOIGNITION POINT Deg F: N/Ahttp://www.bostik.com/msds/msdsprint.asp?id=837998&p=0 (3 of 8) [9/6/2001 12:55:08 PM]

MSDS Search - Printable MSDS #837998HANDLING and STORAGE PRECAUTIONSSolvents used in this product are EXTREMELY FLAMMABLE. Store in a cool,dry area out of direct sunlight. Store away from all sources of ignition.Use only non-sparking tools when opening and closing containers. Metalcontainers should be grounded or bonded. Use only in well ventilatedareas.------------------------------------------------------------------------------SECTION 8- EXPOSURE CONTROLS AND PERSONAL PROTECTION------------------------------------------------------------------------------VENTILATION CONTROLSVentilation must maintain vapors below the PEL/TLV exposure limits.Local exhaust is preferred, but general ventilation may be acceptableto meet exposure limits.RESPIRATORY PROTECTIONWhere the potential exists to exceed the PEL or TLV, use a MSHA/NIOSHapproved full facepiece respirator with an organic vapor cartridge/canister. Increased protection is provided by full facepiece poweredair purifying respirators.EYE PROTECTIONWear splash proof chemical goggles and face shield when working withliquid adhesive, unless full facepiece respiratory protection is worn.SKIN PROTECTIONAvoid skin contact with solvent based adhesive. Wear solvent resistantgloves and clothing. Safety equipment suppliers/manufacturers canprovide recommendations on the most protective glove/clothingmaterial for your operation.------------------------------------------------------------------------------SECTION 9- PHYSICAL AND CHEMICAL PROPERTIES------------------------------------------------------------------------------APPEARANCE:A cream colored liquid with an aromaticsolvent odor.SPECIIFIC GRAVITY: 0.96 (WATER = 1)DENSITY:8.01 POUNDS PER GALLONSOLUBILITY IN WATER: 0.0 %PERCENT VOLATILE (WEIGHT): 76.5VOLATILE ORGANIC COMPOUND: 734 g/lVAPOR PRESSURE: 57.0pH:N/ABOILING POINT:201 to 232 deg FVAPOR DENSITY: 3.3EVAPORATION RATE:2.6 (Butyl Acetate=1)ODOR THRESHOLD:N/DOCTANOL/WATER COEFFICIENT: N/D------------------------------------------------------------------------------SECTION 10- STABILITY AND REACTIVITY------------------------------------------------------------------------------http://www.bostik.com/msds/msdsprint.asp?id=837998&p=0 (5 of 8) [9/6/2001 12:55:08 PM]

MSDS Search - Printable MSDS #837998D008 Lead Monoxide < 1000 ppmD018 Benzene < 1000 ppmIf the product has been altered, particularly to the point wherefilterable solids are present at over a 0.5% level, classificationis a complex issue and depends on the level of contaminants in the liquidportion combined with an extract of the solid portion. Your HazardousWaste Removal will be able to assist you in this case.It is also a D001 Characteristic Ignitable Waste.------------------------------------------------------------------------------SECTION 14- TRANSPORT INFORMATION------------------------------------------------------------------------------DOT/TDG/IATA/IMDG PROPER SHIPPING NAMEFlammable liquids, n.o.s. (Naphtha, Toluene), 3, UN1993, PG II------------------------------------------------------------------------------SECTION 15- REGULATORY INFORMATION------------------------------------------------------------------------------SARA TITLE III -- THE FOLLOWING COMPONENTS ARE LISTED UNDER SECTION 313:CAS NUMBER CHEMICAL NAME110-82-7 CYCLOHEXANE108-88-3 TOLUENECALIFORNIA PROPOSITION 65 --CHEMICALS SHOWN BELOW WHICH ARE NOT LISTED IN SECTION II ARE PRESENT ATTRACE LEVELS BELOW THOSE CONSIDERED HAZARDOUS BY OSHA.CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER:CAS NUMBER CHEMICAL NAME71-43-2 BENZENECHEMICALS KNOWN TO THE STATE OF CALIFORNIA AS DEVELOPMENTAL HAZARDS:CAS NUMBER CHEMICAL NAME108-88-3 TOLUENECHEMICALS KNOWN TO THE STATE OF CALIFORNIA AS MALE REPRODUCTIVE HAZARDS:No Components Listed.CHEMICALS KNOWN TO THE STATE OF CALIFORNIA AS FEMALE REPRODUCTIVE HAZARDS:No Components Listed.TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY STATUS --All the components of this product are either listed on the TSCA ChemicalSubstance Inventory or are exempted from listing.CANADIAN DOMESTIC SUBSTANCE LIST STATUS --All components of this product are listed in either the Canadian DomesticSubstances List (DSL) or Non-domestic Substances List (NDSL).EUROPEAN UNION EINECS LIST STATUS --EINECS Status Not Determined.http://www.bostik.com/msds/msdsprint.asp?id=837998&p=0 (7 of 8) [9/6/2001 12:55:08 PM]