AUTUmN/WiNTER 2010 ISSUE 20 (PDF) - Energy Safe Victoria

More documents

Recommendations

Info

6www.energysafe.vic.gov.auESV alerts certifyingbody following“explosions” inschools’ ovensThe approval certificate for athermostat featured in at least twodomestic ovens has been suspendedfollowing incidents of burns beingreceived in the cookery classroomsat some schools.The most recent incident occurred at StaughtonCollege, Melton South, in early May. The classteacher received slight burns to her face andarm in the incident when a cooker exploded.ESV is aware of two other incidents – one ina Tasmanian school earlier this year, the otherat Kyneton Secondary College in March 2008.Following the explosion at Melton South, ESVinformed the Australian Gas Association (AGA),the certifying body of the particular thermostat,of the incidents.ESV also requested that the approval certificatefor the thermostat in question be suspendedbecause of the apparent unsafe operatingconditions being experienced.The AGA has now advised that the certificatehas been suspended.ESV also informed the Victorian EducationDepartment of the situation. Schools were thencontacted and advised that the two models ofovens featuring the thermostat are not to beused until further notice.ESV has asked the manufacturer of the twoovens for a list of the models incorporatingthe thermostat and details of any designchanges, if any, incorporated into thecookers over the years.The manufacturer has advised that it has notinstalled the thermostat in its ovens since 2006.Kyneton Secondary CollegeIn early March 2008 ESV received a report ofan “immediately dangerous situation” with anupright domestic cooker at the college followingan incident where a student was injured dueto an oven explosion.ESV inspectors found that the front plate ofthe thermostat that engages the outer pin ofthe safety magnet device compartment wasin a depressed location.Under normal operating conditions the frontplate would return to its normal non-operatingposition and will allow the pin of the safetydevice to return to its correct location whenthe oven is turned off.Subsequently all the cookers at the school werechecked and two others were found to have thesame problem with sticking thermostats.The thermostats in the three cookers werereplaced with new ones. There have been nofurther reports of problems with these cookers.Launceston Church Grammar School,TasmaniaA few days before the incident in the classroomat Melton South, the Office of the Director ofGas Safety Tasmania alerted ESV of a cookerexplosion and injury to a student at the school..The thermostat in question was incorporatedin the cooker involved. It was the second timesuch an incident had occurred with the particularcooker. Again there had been an injury.Investigations found the cookers involved in theKyneton and Launceston school incidents weredifferently badged models but were virtuallyidentical and made by the same manufacturer.Staughton College, Melton SouthIn the Staughton College incident, the classteacher received slight burns to her face andarm in the incident.ESV inspectors were told that the victim wascrouching in front of the oven and was openingthe door when the oven exploded. She couldnot recall having pressed any ignition buttons.Although investigators could not find a faultwith the oven identified as being involved in theincident, they looked at four other appliancesand discovered a problem due to a stickingthermostat – as per the other two schools –in one of the other ovens.Gas-fired generatorsto power publichousing in VictoriaA revolutionary new combined heatingand power system for Victoria’spublic housing residents will reducecarbon emissions and energy bills forvulnerable Victorians, Housing MinisterRichard Wynne announced recently.Mr Wynne said that under the scheme, theState Government would work with CeramicFuel Cells Limited (CFCL) to install 30 BlueGenceramic fuel cells in homes later this year.ESV has worked with CFCL by streamliningthe regulatory process so as not to hinder thedevelopment of the system.As there is currently no Australian Standardfor solid oxide (ceramic) fuel cells, ESV hasclassified the BlueGen unit as a Type Bappliance and dealt with it accordingly.With the proposed development of a specificAustralian Standard for ceramic fuel cells, theBlueGen unit will be re-classified as a Type Aappliance and ultimately be mass certified byone of Australia’s Certifying Bodies.The Minister said the $1.35 million projectrepresented the world’s first installation ofBlueGen units in public housing.He said the units are designed to last 15 yearsand their effectiveness and energy efficiencywill be evaluated after two years.The BlueGen unit is a mini-generator thatconverts natural gas into electricity and heat.The electricity supplies power to the house andgenerates heat to create hot water, removing theneed for a separate household hot water unit.“The exciting part of BlueGen is that it is highlyefficient, generating electricity with only abouta third as much greenhouse gas emissioncompared to the current Victorian system,”Mr Wynne said.The generator.Thermostat sticking Note safety device pin is compressed open.Thermostat in a non-operational position.An off spot from theUK’s Daily TelegraphnewspaperCommenting on a complaint from a Mr. ArthurPurdey about a large gas bill, a spokesman forNorth West Gas said, “We agree it was ratherhigh for the time of year. It’s possible Mr. Purdeyhas been charged for the gas used up duringthe explosion that destroyed his house.”
Stolen forkliftand containerhits powerlinesIt’s a mystery which has not been solvedand possibly never will be.How did a person who attempted to steal whatturned out to be an empty shipping containerat a transport depot in Laverton North not sufferelectrocution or serious injury when it hit the66kV overhead powerlines?Another mystery was how the culprit managedto access and start up a large forklift which isbanned from that section of the yard becauseof the height of the line?And what was the purpose of trying to stealan empty shipping container?Authorities were so concerned at what might havehappened, searches were conducted in the yardand nearby in case the culprit was dead or injured.The 66kV line involved supplies the Toyotaplant at Altona.A “classic”lightingarrangementESV Installation Safety EnforcementOfficer, Greg Johnson, holds whatmust be termed a “classic” homemadelighting arrangement.A vigilant electrician discovered the apparatusin a shed on a property in Melbourne whencalled there to carry out some work andhanded it to ESV.It featured a 40 watt tube of a type whichhas not been available for at least 20 years.Some of its features:> > Connected by tunnel terminals at oneend and a lamp holder at the other;> > Starter and connector also connectedby tunnel terminals;> > Put together on a fence paling whichwould also be a few years old.Greg said: “It was remarkable the lightingarrangement was still operating. It hasprobably worked all day and every dayfor as long as anyone can remember.“Equally amazing and much more of a worrywas that it did not catch fire due to the heatfrom the ballast connected to the wood.”7The scene at the transport depot when a shipping container brought downpowerlines. Also the forklift involved and a view of burn marks on one tyre.Autumn/Winter 2010 ISSUE 20Power pole with rotten base topples overHow’s this for being in the right placeat the right time!In late April ESV enforcement officers Keith VanDer Zyden and Greg Johnson were attendingan investigation in Albert Park.When they left site and drove around the cornerthey came across a distribution network polewhich had literally just fallen over. Fortunatelythere were no injuries – the only damage to thehome was the dislodging of a capping brick onthe front fence. It was extraordinary there wasnot more damage.As can be seen in the photos, the wires werekeeping the pole standing – rather than the poleholding the wires in the air, as there was not anysound wood left in the base of the pole.The distribution company’s control room wasinformed immediately. The scene was kept safeuntil repair crews arrived.With the cables live, it was fortunate Keith andGreg were on hand so quickly.The fallen power poll – and its condition.Compliance Officer Greg Johnson with the “interesting”home-made light fitting showing both ends.
Page 8 and 9: Victorian Bushfires RoyalCommission
Page 10 and 11: Beware carbon monoxide -the silent
Page 12 and 13: 12www.energysafe.vic.gov.auAnother
Page 14 and 15: 14www.energysafe.vic.gov.auA disput
Page 16 and 17: 16www.energysafe.vic.gov.auQ: The a
Page 18: 18www.energysafe.vic.gov.auPower co
Page 21 and 22: Positive responses for ESV fromstak
Page 23 and 24: ESV issues importantsafety advice o
Page 26 and 27: 26www.energysafe.vic.gov.auNew Elec
Page 28 and 29: Guidance notes for the electricaltr
Page 30 and 31: New gas installation or changeover-
Page 32: ESV_Advert(LIVE).indd 126/5/08 4:23

AUTUmN/WiNTER 2010 ISSUE 20 (PDF) - Energy Safe Victoria

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?