One Shot Canned Air - Hornady.com

MATERIAL SAFETYDATA SHEETOne Shot Canned AirMSDS REV. DATE: 10/18/10SECTION 1: PRODUCT AND COMPANY IDENTIFICATIONPRODUCT NAME: Hornady One Shot Canned AirTRADE NAMES: Hornady One Shot Canned AirSYNONYMS: Canned Air, Duster, Press CleanerPART NUMBERS: 99900MANUFACTURER/ DISTRIBUTOR: Hornady Manufacturing CompanyADDRESS: 3625 W. Old Potash HwyGrand Island, NE 68803EMERGENCY PHONE: 800-338-3220CHEMTREC PHONE: 800-424-9300 CHEMTREC INTERNATIONAL: +703-527-3887OTHER CALLS: (308) 382-1390PRODUCT USE: Blowing particles, dust, debris from equipment and work surfacesPREPARED BY: M. SpencerHMIS® RatingsHEALTH 1FLAMMABILITY 4REACTIVITY 0PERSONAL PROTECTION ASECTION 2: COMPOSITION/INFORMATION ON INGREDIENTSHAZARDOUS INGREDIENTS:OSHA PEL ACGIH TLVNAME CAS# %WT 313 TWA (ppm) TWA (ppm)1,1 Difluoroethane 75-37-6 >98% No N/A N/ASECTION 2 NOTES:Exposure limit of 1000ppm established by DuPontSECTION 3: HAZARDS IDENTIFICATIONEMERGENCY OVERVIEW: Do not take internally. Flammable, keep away from sources of ignition. Symptoms of overexposure includenausea, headache, weakness; temporary nervous system depression including dizziness, confusion incoordination, drowsiness orunconciousness. Severe overexposure may be fatal.EYE CONTACT: Contact with liquid form of product can cause frostbite;SKIN CONTACT: Contact with liquid form of product can cause frostbite;INHALATION: Vapor is heavier than air and can cause suffocation by reducing oxygen available for breathing. Breathing high concentrationsof vapor may cause lightheadedness, giddiness, shortness of breath, and may lead to narcosis, cardiac irregularities, unconsciousness ordeath. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS OF THE CAN MAY BEHARMFUL OR FATAL.ACUTE HEALTH HAZARDS: Irritation (eyes, skin, respiratory tract), frostbite, nervous system depression.CHRONIC HEALTH HAZARDS: Central nervous system damage, kidney damage.MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Conditions that afflict the following organs may be aggravated byexposure to this product: Lungs, kidneys, skin.CARCINOGENICITYOSHA: NoOTHER: See section 15IARC: NoSECTION 3 NOTES:PAGE 1 OF 5

MATERIAL SAFETYDATA SHEETOne Shot Canned AirMSDS REV. DATE: 10/18/10SECTION 4: FIRST AID MEASURESINHALATIONIf high concentrations are inhaled, immediately remove to fresh air. Keep person calm. If not breathing, give artificial respiration. If breathing isdifficult, give oxygen. Call a physician.SKIN CONTACTIn case of contact, immediately flush skin with plenty of water for at least 15 minutes. Treat for frostbite if necessary, by gently warmingaffected area.EYE CONTACTIn case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Call a physician.INGESTIONIngestion is not considered a potential route of exposureSECTION 4 NOTES: Notes to PhysiciansBecause of possible disturbances of cardiac rhythm, catecholamine drugs, such as epinephrine, should be used with special caution only insituations of emergency lifesupport.SECTION 5: FIRE-FIGHTING MEASURESBOILING POINT (Deg. F): -13SPECIFIC GRAVITY (Water = 1): 1.00VAPOR PRESSURE (mmHg): 62 psigPERCENT VOLATILE BY WEIGHT (%): 100%VAPOR DENSITY (Air = 1): >1EVAPORATION RATE (BA = 1): >1SOLUBILITY IN WATER: SubstantialREACTIVITY IN WATER: NoneAPPEARANCE AND ODOR: Clear gas at standard temperature and pressure with a slight ethereal odor; FINISHED PACKAGE: Aerosolcontainer filled with liquefied gas.FLASH POINT: -58ºFFLAMMABLE LIMITS IN AIR - % BY VOLUME: LEL=3.9, UEL=16.9EXTINGUISHER MEDIA: Dry chemical, carbon dioxide, foamAUTO-IGNITION TEMPERATURE: 849ºFSPECIAL FIRE FIGHTING PROCEDURES: Water may be used to cool closed containers to prevent pressure build-up and possible burstingwhen exposed to high temperatures. Firemen should wear full turnout gear and self-contained, positive pressure, respiratory equipment.Hazardous decomposition products may include hydrofluoric acid and possibly carbonyl fluoride.UNUSUAL FIRE AND EXPLOSION HAZARDS: Although aerosols are classified as nonflammable by 16CFR1500.3(c)(6) of the FederalHazardous Substance Act, C.P.S.C. Regs, this product does contain flammable ingredients and therefore should not be used or stored nearany open flames or ignition sources. Contents under pressure. Keep temperature of containers below 110 deg. F. to prevent bursting.Exposure to temperature above 120 deg. F. may cause can to burst with violence and cause injury.SECTION 5 NOTES:SECTION 6: ACCIDENTAL RELEASE MEASURESACCIDENTAL RELEASE MEASURES:NOTE: Review FIRE FIGHTING MEASURES and HANDLING sections before proceeding with clean-up. Use appropriatePERSONAL PROTECTIVE EQUIPMENT during clean-up.If a spill can cause a concentration in excess of 1,000 ppm, turn off valves and ignition sources. Evacuate area. Ventilate area, especially lowplaces where heavy vapors might collect. Wear self-contained breathing apparatus (SCBA).If this product is spilled and not recovered, or is recovered as a waste for treatment or disposal, the CERCLA Reportable Quantity is 100 lbs.(Release of an unlisted Hazardous Waste characteristic of ignitability).SECTION 6 NOTES:PAGE 2 OF 5

MATERIAL SAFETYDATA SHEETOne Shot Canned AirMSDS REV. DATE: 10/18/10SECTION 7: HANDLING AND STORAGEPRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Liquid contents may cause frostbite on contact with skin; therefore, do nottilt, shake, or turn can upside down before or during use. Do not store above 110 Deg. F. Do not use or store near any open flames or ignitionsources.OTHER PRECAUTIONS: Contents under pressure. Do not puncture or incinerate. Exposure to temperatures above 120 Deg. F may causecan to burst with violence and cause injury. Vapors are heavier than air and will collect in low areas.SECTION 7 NOTES: Refer to section 5 for firefighting equipment and procedures, and section 10 for reactivity information.SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTIONENGINEERING CONTROLS: Provide room ventilation as needed to maintain exposures below PEL.VENTILATION: For anticipated product usage, normal room ventilation is generally adequate. Local exhaust should be used when largeamounts are released. Mechanical exhaust should be used in low or enclosed places.RESPIRATORY PROTECTION: Not generally needed for normal product use. If levels cannot be maintained below PEL, a Self-containedbreathing apparatus (SCBA) is required.EYE PROTECTION: Safety glasses with side shields are recommended.SKIN PROTECTION: Not generally needed, however chemical resistant gloves may be desireable due to the possibility of liquid exposureand frostbite.OTHER PROTECTIVE CLOTHING OR EQUIPMENT:WORK HYGIENIC PRACTICES: Because the use of this product is generally associated with handling firearm cartridges and/or components,always wash hands thoroughly after use and before eating, drinking or using tobacco to reduce exposure to lead and other products of firearmdischarge.SECTION 8 NOTES:SECTION 9: PHYSICAL AND CHEMICAL PROPERTIESAPPEARANCE: N/A (dispensed as colorless gas)ODOR: Slight etherealPHYSICAL STATE: Pressurized liquid, dispensed as colorless gas.pH AS SUPPLIED: N/ApH (Other): N/ABOILING POINT: -25ºC (-13ºF)MELTING POINT: N/AFREEZING POINT: N/AVAPOR PRESSURE (mmHg): 62 psig @ 25° CVAPOR DENSITY (AIR = 1): 2.4SPECIFIC GRAVITY (H2O = 1): 0.90 g/cc @ 25°C (liquid)EVAPORATION RATE: 9.00 (n-Butyl Acetate)SOLUBILITY IN WATER: 0.28 WT% @ 25ºCPERCENT SOLIDS BY WEIGHT: N/APERCENT VOLATILE: 100% (Wt)VOLATILE ORGANIC COMPOUNDS (VOC): 1,1 DifluoroethaneMOLECULAR WEIGHT: 66.05VISCOSITY: N/ASECTION 9 NOTES:PAGE 3 OF 5

MATERIAL SAFETYDATA SHEETOne Shot Canned AirMSDS REV. DATE: 10/18/10SECTION 10: STABILITY AND REACTIVITYSTABILITY: Stable under normal conditions.CONDITIONS TO AVOID (STABILITY): Extreme heat (over 110°F), contact with ignition sources.INCOMPATIBILITY (MATERIAL TO AVOID): Incompatible with alkali or alkaline earth metals (powdered Al, Zn, Be, etc.).HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: Hazardous decomposition products may include hydrofluoric acid and possiblycarbonyl fluoride. Material may be decomposed by high temperatures (glowing metals or embers, flame, etc.)HAZARDOUS POLYMERIZATION: Will not occurSECTION 11: TOXICOLOGICAL INFORMATIONTOXICOLOGICAL INFORMATION:LD-50 (oral)LC-50(inhalation)IDLH1,1 Difluoroethane>1500 mg/kg (rat)977 gm/m 3 (2hrinhalation- mouse)N/ASECTION 12: ECOLOGICAL INFORMATIONECOLOGICAL INFORMATION: This product has no ecological information available.SECTION 13: DISPOSAL CONSIDERATIONSWASTE DISPOSAL METHOD: Unused liquid product that has become waste may be considered hazardous and must disposed ofaccordingly. The user of this product is responsible for correctly classifying waste and seeing that it is disposed of in accordance with allfederal, state and local laws.RCRA HAZARD CLASS: D001_________________________________________________________________________________________________________________SECTION 14: TRANSPORT INFORMATIONTRANSPORTATION INFORMATION – DOMESTIC GROUNDShipping Name:1,1-DifluoroethaneHazard Class: 2.1UN Number:UN1030Packing Group:N/AHazard Label: Not required for domestic ground shipping per DOT-SP 11516Carton Marking: 1,1-Difluoroethane, 2.1, UN1030. Inside Containers comply with DOT-SP 11516A current copy of DOT-SP 11516 must be maintained at each facility where the package is offered or reoffered for transportation.NOTE: For domestic shipments, outer boxes must be marked with designation DOT-E11516 as well as shipping name, hazard class (2.1)and UN number. Domestic shipments are exempt from labeling and shipping paper requirements except when transported by air.PAGE 4 OF 5

MATERIAL SAFETYDATA SHEETOne Shot Canned AirMSDS REV. DATE: 10/18/10TRANSPORTATION INFORMATION – DOMESTIC AIRShipping Name:1,1-DifluoroethaneHazard Class: 2.1UN Number:UN1030Packing Group:N/AHazard Label:Flammable Gas, Cargo Aircraft OnlyCarton Marking: 1,1-Difluoroethane, 2.1, UN1030. Inside Containers comply with DOT-SP 11516A copy of DOT-SP 11516 must be carried aboard each aircraft used to transport this product.TRANSPORTATION INFORMATION – IMDGShipping Name:1,1-DifluoroethaneHazard Class: 2.1UN Number:UN1030Packing Group:N/AHazard Label:Flammable GasCarton Marking:1,1-Difluoroethane, 2.1, UN1030.SECTION 14 NOTES:SECTION 15: REGULATORY INFORMATIONU.S. FEDERAL REGULATIONSTSCA (TOXIC SUBSTANCE CONTROL ACT): Intentional ingredients of this product are listed.CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT): 1,1 Difluoroethane: 100 lbs.SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT):311/312 HAZARD CATEGORIES: Acute, Fire, Pressure.313 REPORTABLE INGREDIENTS: see section 1STATE REGULATIONS (Right-To-Know):CA. PROPOSITION 65:The following statement is made in order to comply with the California Safe Drinking Water and Toxic Enforcement Act of 1986:WARNING This product contains the following substance known to the state of California to cause cancer:NoneSECTION 15 NOTES: Not intended to be all-inclusive, only selected regulations represented.SECTION 16: OTHER INFORMATIONCONSUMER PRODUCT SAFETY ACT CERTIFICATION: This product was evaluated by Hornady Manufacturing Company and is certified tobe in compliance with the provisions of the Consumer Product Safety Act, the Federal Hazardous Substances Act, and the Poison PreventionPackaging Act, as applicable. This product was manufactured at 1323 Conshohocken Road, Plymouth Meeting, PA 19462. The date ofmanufacture is stamped on the product container. No testing is required to certify compliance with the above mentioned regulations.DISCLAIMER: Hornady Manufacturing Company believes the information contained in this MSDS to be accurate and complete as of the dateof publication, however no responsibility is assumed for the suitability of this data to the end user or for omissions or errors in its content. Thissheet should be provided to all who use, handle, transport or store the material in question.PAGE 5 OF 5