Technicians Handbook - Historic Naval Ships Association

More documents

Recommendations

Info

Publications and DocumentsVarious publications, some of which are discussed below, are available for guidance in maintenancework or for reference and study. In general, these publications are available from the Naval Publicationsand Forms Center through the supply system.NAVAL SHIPS' TECHNICAL MANUAL (NSTM).—The Naval Ships' Technical Manual(NSTM) is a prime reference for information on NAVSEA equipment. Chapter 400, Electronics, is mostuseful as it provides major policies and instructions pertaining to electronics work and material underNAVSEA and NAVELEX responsibility. Other chapters of interest to electrical and electronicstechnicians are:300 Electrical Plant General302 Electric Motors and Controllers310 Electric Power Generators and Conversion Equipment320 Electric Power Distribution Systems330 Lighting430 Interior Communication Installations434 Motion Picture Equipment491 Electrical Measuring and Test Instruments510 Ventilating, Heating, Cooling, and Air-Conditioning Systems for Surface Ships532 Liquid-Cooling Systems for Electronic Equipment9006 Submarine Antennas and Masts634 Deck CoveringsELECTRONICS INSTALLATION AND MAINTENANCE BOOK (EIMB).—The ElectronicsInstallation and Maintenance Book series supplements instructions and data supplied in equipmenttechnical manuals. The EIMB is intended to reduce time-consuming research on electronic equipment andcircuit theory. These handbooks fall into two categories: general information and equipment-orientedhandbooks. The latter includes general test procedures, adjustments, and general servicing information.All handbooks of the series are listed below.TITLEGENERALNUMBERSGeneralSE000-00-ElM-100Installation Standards0967-LP-000-0110Electronic Circuits 0967-000-0120Test Methods & Practices0967-LP-000-0130Reference Data 0967-000-0140EMI Reduction 0967-000-0150General MaintenanceSE000-00-EIM-160EQUIPMENT-ORIENTEDCommunicationsSE000-00-EIM-010RadarSE000-00-EIM-020SonarSE000-00-EIM-030Test EquipmentSE000-00-EIM-040Radiac 0967-000-0050CountermeasuresSE000-00-EIM-071-142
ENGINEERING INFORMATION BULLETIN (EIB).—The Engineering Information Bulletin ispublished biweekly and distributed to all naval ships and electronics installation and maintenanceactivities. It is authoritative and is a means of rapid dissemination of advanced hull, mechanical,electronic, electrical, and related equipment information. It includes information concerning approvedbeneficial suggestions, electronics field changes, mechanical alterations (MECHALTS), installationtechniques, maintenance notes and practices, and technical manual availabilities, advance change notices,and distribution.EQUIPMENT TECHNICAL MANUALS.—Technical manuals carry information essential to theproper operation, maintenance, and repair of specific equipment. These manuals may occasionally containerrors. In those cases, change notices are provided to correct the manuals. Updates because of equipmentchanges are also provided. These changes must be installed in the technical manuals to maintain accuracyand to prevent the loss of man-hours resulting from the use of obsolete data and/or schematics. TheGuide for User Maintenance of NAVSEA Technical Manuals, NAVSEA S005-AA-GYD-030/TMMP,provides information on identifying, ordering, deficiency reporting, and updating technical manuals.NAVSUP PUBLICATION 2002.—NAVSUP 2002 is the Navy Stock List of Publication andForms and provides NSNs for ordering Navy publications and their changes. Each edition is issuedquarterly and supersedes the previous one in its entirety. It is produced in microfiche only and containsthree sections:Section 1—FormsSection 2—PublicationsSection 3—NAVAIR Technical DirectivesDECKPLATE.—The deckplate is a technical periodical published monthly by NAVSEA. Itcontains information on design, construction, conversion, operation, maintenance, and repair of Navyvessels and their equipment. It also includes articles on personnel safety, service hints, and adoptedbeneficial suggestions.NAVAL SAFETY CENTER PUBLICATIONS.—The Naval Safety Center publishes bulletinsand several periodicals to keep Navy personnel informed on the subject of accident prevention.• Ship Safety Bulletin—This monthly newsletter contains safety notes and accident data.• Fathom—This quarterly magazine contains a review of surface ship and submarine accidentprevention and safety articles.• Approach—This magazine is a monthly review of articles concerning aviation safety andaccident prevention.• MECH—MECH is a bimonthly review of aviation maintenance related mishaps,material/personnel hazards, and general aviation ground safety.TRAINING MANUALS (TRAMANS).—Training manuals are designed to give enlisted personnelbackground knowledge for the proper performance of their assigned jobs. Electrical and electronic theoryand operation and maintenance information on pertinent equipment are presented at different rating levelsin the TRAMANs written for the technical rates.1-143
Page 1 and 2:
SPECIAL PUBLICATIONSeptember 1998Na
Page 3 and 4:
PREFACESpecial Publications (SPs) a
Page 5 and 6:
TABLE OF CONTENTSCHAPTERPAGE1. The
Page 7 and 8:
Module 11, Microwave Principles, ex
Page 9:
Student CommentsCourse Title:NEETS
Page 12 and 13:
• Be cautious when working in voi
Page 14 and 15:
Electric ShockElectric shock may ca
Page 16 and 17:
In this situation, the immediate ad
Page 18 and 19:
Lean or rock forward with elbows lo
Page 20 and 21:
possible) over the wound and firmly
Page 22 and 23:
(1) NEAREST THE WOUND and (2) BETWE
Page 24 and 25:
Shock• Be sure you draw the tourn
Page 26 and 27:
Liquids should be administered spar
Page 28 and 29:
drinks or stimulants. Get the victi
Page 30 and 31:
Figure 1-11.—RC time constants.Fi
Page 32 and 33:
Ac current formulas are:Ohm's law f
Page 34 and 35:
Parallel inductors without coupling
Page 36 and 37:
Another way to calculate reactive p
Page 38 and 39:
ResistanceRESISTANCE is the opposit
Page 40 and 41:
Since:Transformer power:1-30
Page 42 and 43:
WARNINGRf voltages may be induced i
Page 44 and 45:
Alpha is always less than 1 for a c
Page 46 and 47:
WavelengthCAUTIONBecause vacuum tub
Page 48 and 49:
Minimum radar range = (pulse width
Page 50 and 51:
Log or dBGain or mw11 12.510 109 88
Page 52 and 53:
Table 1-1.—CB Style Capacitor Par
Page 54 and 55:
Table 1-3.—CYR10 Style Capacitor
Page 56 and 57:
Figure 1-16.—Ceramic capacitor co
Page 58 and 59:
Table 1-4.—Principal Applications
Page 60 and 61:
Figure 1-18.—Resistor color code.
Page 62 and 63:
MilitaryspecificationMIL-R-39005MIL
Page 64 and 65:
Figure 1-19.—Color code for trans
Page 66 and 67:
Figure 1-21.—Transistor lead iden
Page 68 and 69:
numbers and part numbers can be fou
Page 70 and 71:
SizeTable 1-10.—Current-Carrying
Page 72 and 73:
Jan TypeOverallDiameter (ins)Table
Page 74 and 75:
Table 1-13.—MS Connector Identifi
Page 76 and 77:
Figure 1-23.—Insert arrangements
Page 78 and 79:
Figure 1-25.—Typical BNC connecto
Page 80 and 81:
Figure 1-28.—Attaching HN connect
Page 82 and 83:
Table 1-16.—N Series Connectors w
Page 84 and 85:
Insulation, Heat Shrinkable Sleevin
Page 86 and 87:
Table 1-19.—Shrinkable Tubing Par
Page 88 and 89:
Table 1-21.—New Style Military Fu
Page 90 and 91:
Conversion and Equivalent TablesTab
Page 92 and 93:
Table 1-24.—Conversion Chart—Co
Page 94 and 95:
Table 1-24.—Conversion Chart—Co
Page 96 and 97:
Figure 1-33.—Electrical symbols.
Page 98 and 99:
Figure 1-34.—Electronic/logic sym
Page 100 and 101:
Figure 1-34.—Electronic/logic sym
Page 102 and 103: Figure 1-34.—Electronic/logic sym
Page 104 and 105: Figure 1-35.—Fiber optic symbols.
Page 106 and 107: Table 1-26.—Frequency Spectrum Us
Page 108 and 109: Joint Electronic Type Designation S
Page 110 and 111: Table 1-29.—Microcircuit Part Num
Page 112 and 113: Table 1-29.—Microcircuit Part Num
Page 114 and 115: CIRCUIT53MC54MC55MC56MC57MC58MC59MC
Page 116 and 117: CIRCUITQAQDQXRARDRW4SNSPTD1TD2TD5TD
Page 118 and 119: CIRCUIT4JZ5JZ6JZ7JZ8JZ9JZ10JZ11JZTa
Page 120 and 121: CIRCUITX29JX34JX40JX41JX42JX43JX44J
Page 122 and 123: Table 1-34.—Common LogarithmsN 0
Page 124 and 125: Table 1-35.─Trigonometric Functio
Page 130 and 131: Table 1-36.—Julian Date CalendarD
Page 132 and 133: Table 1-38.—Effects of Heat and H
Page 134 and 135: Table 1-40.—Old and New Specifica
Page 136 and 137: Remember to use the proper safety p
Page 138 and 139: Figure 1-38.—Computation of phase
Page 140 and 141: Figure 1-40.—Lissajous patterns f
Page 142 and 143: Figure 1-42.—Octopus schematic di
Page 144 and 145: Figure 1-46.—Combination displays
Page 146 and 147: • A military alteration that chan
Page 148 and 149: numbers. They can be easily convert
Page 150 and 151: support equipment. All aircraft equ
Page 154 and 155: REFERENCESAfloat Shopping Guide, NA
Page 156: NEETS, Module 9, Introduction to Wa
show all

Technicians Handbook - Historic Naval Ships Association

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?