Manual - JÃ¸tul stoves and fireplaces

More documents

Recommendations

Info

138914 Rev. Q 8/28/122!!Suggested Tools for Installation and Service• External regulator (for Propane only)• Piping which complies with local code• Manual shut-off valve -T-Handle required in Massachusetts• Sediment trap - if required by code• Tee joint• Pipe wrench• Pipe sealant• 10 mm open end wrench• 1/2”, 7/16” open end wrench• Phillips head screwdriver• Flat head screwdriver• 1/4” nut driverWARNINGHOT GLASS WILLCAUSE BURNS.DO NOT TOUCH GLASSUNTIL COOLED.NEVER ALLOW CHILDRENTO TOUCH GLASS.AVERTISSEMENTUne surface vitrée chaudepeut causer des brûlures.Laisser refroidir la surface vitréeavant d’y toucher.Ne perettex jamais à unenfantde toucher la surface vitrée.THIS OWNER’S MANUAL PROVIDES INFORMATION TOENSURE SAFE INSTALLATION AND EFFICIENT, DEPENDABLEOPERATION OF YOUR FIREPLACE INSERT. PLEASE READTHESE INSTRUCTIONS IN THEIR ENTIRETY AND MAKE THEMAVAILABLE TO ANYONE USING OR SERVICING THIS GASINSERT.DO NOT ATTEMPT TO ALTER OR MODIFY THE CONSTRUCTIONOF THIS APPLIANCE OR ITS COMPONENTS. ANYMODIFICATION OR ALTERATION WILL VOID THE WARRANTY,CERTIFICATION AND LISTING OF THIS APPLIANCE.THIS HEATER MUST BE INSTALLED AND MAINTAINED BY AQUALIFIED SERVICE AGENCY.• Work Gloves• Safety glasses• Torx T-20 screwdriver• Tin snipsInstallation Requirements for theCommonwealth of MassachusettsTHIS PRODUCT MUST BE INSTALLED BY ALICENSED MASTER OR JOURNEYMAN PLUMBEROR GAS-FITTER WHEN INSTALLED IN THECOMMONWEALTH OF MASSACHUSETTS.1. If there is not one already present, on eachfloor level where there are bedroom(s), acarbon monoxide detector and alarm shallbe placed in the living area outside thebedroom(s). The carbon monoxide detectorshall comply with NFPA 720 (2005 Edition).2. A carbon monoxide detector shall:a) Be located in the room that houses theappliance or equipment;b) Be either hard-wired or battery poweredor both; andc) Shall comply with NFPA 720 (2002Edition).3. A Product-approved vent terminal must beused, and if applicable, a Product-approvedair intake must be used. Installationshall be in strict compliance with themanufacturer’s instructions. A copy ofthe installation instructions must remainwith the appliance or equipment at thecompletion of the installation.We recommend thatour gas products beinstalled and serviced byprofessionals who arecertified in the U.S. bythe National FireplaceInstitute® (NFI) as NFI GasSpecialists.72.41%Jøtul GF 370 DV
138914 Rev. Q 8/28/12Table of ContentsInstallation & Service Tools ..................2Specifications................................................... 4General Information.......................................5Safety Information ........................................ 6InstallationHearth Requirements ..........................7Clearances...............................................7Vent RequirementsApproved Vent Manufacturers.......... 8Vertical Termination............................ 8Masonry Chimney Conversion.......... 9Horizontal Termination......................10Vent Termination Clearances.............11Vent Restriction Adjustments.......... 12Vent Termination Diagram................ 13Stove Assembly1. Glass Frame Removal ...................142. Routing the Power Supply ..........143. Gas Connection..............................144. Gas Pressure................................... 155. Fuel Conversion..............................166. High Altitude Adjustment..........187. Skamol Panel Installation............198. Reflective Panel Installation.......199. River Rock Installation..................1910. StarFire Glass Installation...........1911. Log Set Installation......................2012. Outer Decorative Glass Panels... 2113. System Check ............................... 2214. Flame Picture Adjustment...........23OperationSystem Overview ............................... 24Control Functions................................25Wiring Diagrams................................. 28MaintenanceAnnual Cleaning.................................30.Glass Replacement.............................30Battery Replacement ......................... 31Accent Lamp Replacement ............... 31Illustrated Replacement Parts........... 32 - 35AppendixMobile Home Installation................ 36Correct Optional Flame Pictures .... 36Waranty Statement.......................................37Lighting Instructions .................................. 39Unpacking the Stove1. Before beginning the installation, inspect the stovefor shipping damage and immediately report anyevidence of damage to your dealer.2. Confirm stove contents.The Jøtul GF 370 DV includes the following looseitems shipped in the Miscellaneous Hardware bag;• 4 mm hex key - used to remove thefront glass panel for access to the firebox.• Remote Control Transmitter• Remote Control Wall Mount Bracket• Extension Power Cord• M6 x 12 mm hex bolts, 4 - used withOuter Decorative Glass Panels.• Propane Fuel Conversion Kit 1568003. Confirm Firebox Components.The firebox accessories have been packed inseparate boxes, and will include one or more of thefollowing items:• Traditional Log Set 156789• StarFire Glass 156815, Clear or 157342, Black• River Rocks 157428• Skamol Panels 156816• Reflective Glass Panels 156817• Tumbled Stones 1572294. Remove Pallet Screw. See fig. 1.Figure 1.Pallet screw location3
Page 1: Jøtul GF 370 DVDirect Vent Gas Sto
Page 6 and 7: 138914 Rev. Q 8/28/123.0 Safety Inf
Page 8 and 9: 138914 Rev. Q 8/28/12Venting Requir
Page 10 and 11: 138914 Rev. Q 8/28/12Horizontal Ter
Page 12 and 13: 138914 Rev. Q 8/28/12Vent Restricti
Page 14 and 15: 138914 Rev. Q 8/28/12Stove Assembly
Page 16 and 17: 138914 Rev. Q 8/28/125. Fuel Conver
Page 18 and 19: 138914 Rev. Q 8/28/126. High Altitu
Page 20 and 21: 138914 Rev. Q 8/28/12Tumbled Stones
Page 22 and 23: 138914 Rev. Q 8/28/1210. Initial Sy
Page 24 and 25: 138914 Rev. Q 8/28/12Jøtul GF 370
Page 26 and 27: 138914 Rev. Q 8/28/12Remote Transmi
Page 28 and 29: 138914 Rev. Q 8/28/12SPARKELECTRODE
Page 30 and 31: 138914 Rev. Q 8/28/12MaintenanceThi
Page 32 and 33: 138914 Rev. Q 8/28/1223 32024283431
Page 34 and 35: 138914 Rev. Q 8/28/12Figure 66. Spu
Page 36 and 37: 138914 Rev. Q 8/28/12Appendix AMobi
Page 38 and 39: 138914 Rev. Q 8/28/12Your stove has
Page 40: August, 2012138914-Q138914 Rev. Q 8

Manual - JÃ¸tul stoves and fireplaces

Create successful ePaper yourself

Delete template?

Save as template?