febi 32380 DSG - Gear oil Article number 32380, 323

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 3 / 8SECTION 6: Accidental release measures6.1 Personal precautions, protective equipment and emergency proceduresSome risk of slipping due to spillage of product.Forms slippery surfaces with water.6.2 Environmental precautionsPrevent spread over a wide area (e.g. by containment or oil barriers).Do not discharge into the drains/surface waters/groundwater.In case the product spills into drains/surface waters/groundwater, immediately inform theauthorities.6.3 Methods and material for containment and cleaning upTake up with absorbent material (e.g. oil binder).Dispose of absorbed material in accordance within the regulations.6.4 Reference to other sectionsSee SECTION 8+13SECTION 7: Handling and storage7.1 Precautions for safe handlingNo special measures necessary if used correctly.Use only in well-ventilated areas.Use solvent-resistant equipment.Keep away from all sources of ignition - Refrain from smoking.7.2 Conditions for safe storage, including any incompatibilitiesKeep only in original container.Do not store together with oxidizing agents.Do not store together with food and animal food/diet.Keep container in a well-ventilated place.Keep container tightly closed.Protect from heat/overheating and from sun.7.3 Specific end use(s)See product use, SECTION 1.2SECTION 8: Exposure controls / personal protection8.1 Control parametersIngredients with occupationalexposure limits to be monitored (GB)not applicablebfe00079

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 4 / 88.2 Exposure controlsAdditional advice on system designEye protectionEnsure adequate ventilation on workstation.Safety glasses.Hand protection Nitrile rubber, >120 min (EN 374).The details concerned are recommendations. Please contact the glove supplier for furtherinformation.Skin protectionOtherRespiratory protectionThermal hazardsDelimitation and monitoring of theenvironmental expositionLight protective clothing.Avoid contact with eyes and skin.Wash hands before breaks and after work.Use barrier skin cream.Do not eat, drink, smoke or take drugs at work.Remove soiled clothing.not applicableSECTION 9: Physical and chemical propertiesNo information available.See SECTION 6+7.9.1 Information on basic physical and chemical propertiesFormColorOdorOdour thresholdpH-valuepH-value [1%]Boiling point [°C]liquidamber colourcharacteristicnot determinednot applicablenot applicablenot applicableFlash point [°C] > 200 (EN ISO 2592)Flammability [°C]Lower explosion limitUpper explosion limitOxidizing propertiesVapour pressure/gas pressure [kPa]Density [g/ml]Bulk density [kg/m³]Solubility in waternot determinednot applicablenot applicableno< 0,01 (20°C)0,842 (DIN 51757) (15 °C / 59,0 °F)not applicablevirtually insolublePartition coefficient [n-octanol/water] not determinedViscosity ~ 40 mm²/s 40°C (DIN 51562)Relative vapour density determinedin airEvaporation speednot determinednot determinedMelting point [°C] < -42 (DIN ISO 3016)Autoignition temperature [°C]Decomposition temperature > 65not applicable9.2 Other informationNo information available.SECTION 10: Stability and reactivity10.1 ReactivitySee SECTION 10.3.10.2 Chemical stabilityStable under normal ambient conditions (ambient temperature).bfe00079

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 5 / 810.3 Possibility of hazardous reactionsReactions with strong oxidizing agents.If product is heated above decomposition temperature toxic vapours may be released.10.4 Conditions to avoidSee SECTION 7.2.10.5 Incompatible materialsStrong oxidizing agent.10.6 Hazardous decomposition productsHydrogen sulphide (H2S).Toxic gases/vapours.SECTION 11: Toxicological information11.1 Information on toxicological effectsAcute toxicityRange [%] Substance40 - 45 Lubricating oils (petroleum), C20-50, hydrotreated neutral oil-based, CAS: 72623-87-1LD50, oral, Rat: >= 5000 mg/kg (OECD 401).LD50, dermal, Rabbit: >= 2000 mg/kg (OECD 402).LC50, inhalative, Rat: >= 5,53 mg/l (OECD 403).Serious eye damage/irritationSkin corrosion/irritationRespiratory or skin sensitisationSpecific target organ toxicity —single exposureSpecific target organ toxicity —repeated exposureMutagenicityReproduction toxicityCarcinogenicityGeneral remarksnot determinednot determinednot determinednot determinednot determinednot determinednot determinednot determinedFrequent persistent contact with the skin can cause skin irritation.Has a degreasing effect on the skin.No classification on the basis of the calculation procedure of the preparation directive.Toxicological data of complete product are not available.SECTION 12: Ecological information12.1 ToxicityRange [%] Substance40 - 45 Lubricating oils (petroleum), C20-50, hydrotreated neutral oil-based, CAS: 72623-87-1LC50, (96h), fish: > 100 mg/l (OECD 203).ErC50, (72h), Algae: > 100 mg/l (OECD 201).EC50, (48h), Crustacea: > 100 mg/l (OECD 202).12.2 Persistence and degradabilityBehaviour in environmentcompartmentsBehaviour in sewage plantBiological degradabilitynot determinedCan be separated out mechanically in purification plants.The product is not readily biodegradable.12.3 Bioaccumulative potentialNo information available.bfe00079

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 6 / 812.4 Mobility in soilNo information available.12.5 Results of PBT and vPvB assessmentBased on all available information not to be classified as PBT or vPvB respectively.12.6 Other adverse effectsNo classification on the basis of the calculation procedure of the preparation directive.Ecological data of complete product are not available.Do not discharge product unmonitored into the environment or into the drainage.SECTION 13: Disposal considerations13.1 Waste treatment methodsWaste material must be disposed of in accordance with the Directive on waste 2008/98/EC as well as other national and localregulations. It is not possible to determine a waste code for this product in accordance with the European Waste Catalogue (EWC)since it is only possible to classify it according to how it is used by the customer. The waste code is to be determined within the EU inliaison with the waste-disposal operator.ProductWaste no. (recommended)In according to RoHS!Disposal in an incineration plant in accordance with the regulations of the local authorities.130205* mineral-based non-chlorinated engine, gear and lubricating oilsContaminated packagingWaste no. (recommended) 150110*SECTION 14: Transport information14.1 UN numberSee SECTION 14.2 in accordance with UN shipping nameUncontaminated packaging may be taken for recycling.Packaging that cannot be cleaned should be disposed of as for product.14.2 UN proper shipping nameTransport by land according toADR/RIDNO DANGEROUS GOODSInland navigation (ADN)NO DANGEROUS GOODSMarine transport in accordance withIMDGNOT CLASSIFIED AS "DANGEROUS GOODS"Air transport in accordance with IATA NOT CLASSIFIED AS "DANGEROUS GOODS"14.3 Transport hazard class(es)See SECTION 14.2 in accordance with UN shipping name14.4 Packing groupSee SECTION 14.2 in accordance with UN shipping name14.5 Environmental hazardsSee SECTION 14.2 in accordance with UN shipping namebfe00079

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 7 / 814.6 Special precautions for userRelevant information under SECTION 6 to 8.14.7 Transport in bulk according to Annex II of MARPOL73/78 and the IBC Codenot applicableSECTION 15: Regulatory information15.1 Safety, health and environmental regulations/legislation specific for the substance or mixtureEEC-REGULATIONS1967/548 (1999/45); 1991/689 (2001/118); 1999/13; 2004/42; 648/2004; 1907/2006 (Reach);1272/2008; 75/324/EEC (2008/47/EC); 453/2010/ECTRANSPORT-REGULATIONS DOT-Classification, ADR (2013); IMDG-Code (2013, 36. Amdt.); IATA-DGR (2013).NATIONAL REGULATIONS (GB): EH40/2005 Workplace exposure limits (Second edition, published December 2011).CHIP 3/ CHIP 415.2 Chemical safety assessmentnot applicableSECTION 16: Other information16.1 R-phrases (SECTION 3)16.2 Hazard statements (SECTION 3)16.3 Abbreviations and acronyms:R 36: Irritating to eyes.H319 Causes serious eye irritation.H304 May be fatal if swallowed and enters airways.ADR = Accord européen relatif au transport international des marchandises Dangereuses parRouteRID = Règlement concernant le transport international ferroviaire de marchandisesdangereusesADN = Accord européen relatif au transport international des marchandises dangereuses parvoie de navigation intérieureCAS = Chemical Abstracts ServiceCLP = Classification, Labelling and PackagingDMEL = Derived Minimum Effect LevelDNEL = Derived No Effect LevelEC50 = Median effective concentrationECB = European Chemicals BureauEEC = European Economic CommunityEINECS = European Inventory of Existing Commercial Chemical SubstancesELINCS = European List of Notified Chemical SubstancesGHS = Globally Harmonized System of Classification and Labelling of ChemicalsIATA = International Air Transport AssociationIBC-Code = International Code for the Construction and Equipment of Ships carryingDangerous Chemicals in BulkIC50 = Inhibition concentration, 50%IMDG = International Maritime Code for Dangerous GoodsIUCLID = International Uniform ChemicaL Information DatabaseLC50 = Lethal concentration, 50%LD50 = Median lethal doseMARPOL = International Convention for the Prevention of Marine Pollution from ShipsPBT = Persistent, Bioaccumulative and Toxic substancePNEC = Predicted No-Effect ConcentrationREACH = Registration, Evaluation, Authorisation and Restriction of ChemicalsTLV®/TWA = Threshold limit value – time-weighted averageTLV®STEL = Threshold limit value – short-time exposure limitVOC = Volatile Organic CompoundsvPvB = very Persistent and very Bioaccumulativebfe00079

Safety Data Sheet 1907/2006/EC - REACH (GB)febi 32380 DSG - Gear oil Article number 32380, 32390Ferdinand Bilstein GmbH + Co. KGCreated: 14.02.2013, Revision 11.02.2013 Version 03. Supersedes version: 02 Page 8 / 816.4 Other informationObserve employment restrictions forpeopleVOC (1999/13/CE)Modified positionCopyright: Chemiebüro®nonot applicableSECTION 2 been added: Does not contain any PBT or vPvB substances.SECTION 4 been added: Rinse cautiously with water for several minutes. Remove contactlenses, if present and easy to do. Continue rinsing.SECTION 4 been added: If eye irritation persists: Get medical advice/attention.SECTION 4 deleted: In case of contact with eyes rinse thoroughly with plenty of water andseek medical advice.SECTION 4 been added: HeadacheSECTION 4 been added: If swallowed or in the event of vomiting, risk of product entering thelungs.SECTION 5 been added: Collect contaminated firefighting water separately, must not bedischarged into the drains.SECTION 6 been added: In case the product spills into drains/surface waters/groundwater,immediately inform the authorities.SECTION 7 been added: Keep away from all sources of ignition - Refrain from smoking.SECTION 7 been added: Protect from heat/overheating and from sun.SECTION 7 been added: Do not store together with food and animal food/diet.SECTION 8 been added: Do not eat, drink, smoke or take drugs at work.SECTION 8 been added: Remove soiled clothing.SECTION 9 been added: amber colourSECTION 9 been added: virtually insolubleSECTION 10 been added: Strong oxidizing agent.SECTION 11 been added: Frequent persistent contact with the skin can cause skin irritation.SECTION 11 been added: Has a degreasing effect on the skin.SECTION 11 been added: Toxicological data of complete product are not available.SECTION 12 been added: Can be separated out mechanically in purification plants.SECTION 12 been added: The product is not readily biodegradable.SECTION 12 been added: Based on all available information not to be classified as PBT orvPvB respectively.bfe00079