ClorTec Onsite Hypochlorite Generation Systems - Ohiowater.org

More documents

Recommendations

Info

76Larger units exhaust hot air from the room allowing thesystems to operate without raising the room. Optionalwater cooled units available. All Rectifiers are UL andCSA certified
MCT Series Power Supply• Designed to run “cool” underextreme thermal conditions• Low temperature rise- 37°/32° Crise with a 45° C ambient.• 180° C class H insulation system• Increased reliability• Fully controlled full-wave bridgerectifier for lower RMS currentscreatesminimum heat• Extremely high PIV (peak inversevoltage) rating (1600V) on SCR’s• Fans and heat sink for addedcooling/air circulation• Solid State Relay• Proven Reliable Firing board77
Page 6 and 7:
Consumables UsageFor each lb. equiv
Page 8 and 9:
Salt• Typical salt is a solar dri
Page 10 and 11:
Advantages of the ClorTec Rectifier
Page 12 and 13:
12Water is sent through a twin tank
Page 14 and 15:
Cell TemperatureOptimum CellEfficie
Page 16 and 17:
16System at standby
Page 18 and 19:
18At 45 seconds
Page 20 and 21:
20Depending on the region we have f
Page 22 and 23:
22Recent Safety Innovations
Page 24 and 25:
24Standard PLC packages integrate e
Page 26 and 27: Heaters• All stainless steel tank
Page 28 and 29: What is the backup?What about redun
Page 30 and 31: Summary• ClorTec has developed a
Page 32 and 33: On-Site Hypochlorite Generators•
Page 34 and 35: RMS System Configurations34 34
Page 36 and 37: RMS Benefits• Eliminates thermal
Page 38 and 39: RMS Rover- Enhanced EngineeredDesig
Page 40 and 41: RMS Rover Installation• Simple pr
Page 42 and 43: RMS Rover Mixing• The RMS Rover b
Page 44 and 45: RMS Rover Disinfection Options• D
Page 46 and 47: RMS Rover Disinfection Injection-Ch
Page 48 and 49: 48RMS Ancillary Equipment
Page 50 and 51: LiquidChem Chiller Features• Dual
Page 55 and 56: Liquid ChemChiller• 3” thick ur
Page 57 and 58: Reservoir Management System (RMS)
Page 59 and 60: Typical Water Softener Configuratio
Page 61 and 62: 61The softened water is fed to a br
Page 63 and 64: 63Saturated brine is fed & mixed wi
Page 65 and 66: 65CT 450 and larger systems use eit
Page 67 and 68: 67Clear cell casing provides indica
Page 69 and 70: 69Plate design allows for self clea
Page 71 and 72: ClorTec Today• Over 3500 installa
Page 73 and 74: Introduction to ClorTecHistory• 1
Page 75: 75Rectifiers ranging from 65 to 300
Page 79 and 80: 79HDPE and FRP tanks available
Page 81 and 82: 81Multiple tanks are used for large
Page 83 and 84: 83Hydrogen Dilution Air & Vent Syst
Page 85 and 86: Recommended Venting• Vent Stack w
Page 87 and 88: The ClorTec DesignSeven tier safety
Page 89 and 90: Electrolytic Cell Layers of Protect
Page 91 and 92: Recommend skid mounted dosing pumps
Page 93 and 94: Dosing Control Philosophy• Recent
Page 95 and 96: Dosing Controller Options (cont’d
Page 97 and 98: Dosing Controller Options (cont’d
Page 99 and 100: Hydra-Cell Pumps•Wobble Plate Des
Page 101 and 102: 101If an alarm is registered the po
Page 103 and 104: 103Heaters & Chillers A range of op
Page 105 and 106: 105RMS
Page 107 and 108: 107500 gallon/5000 pound brine tank
Page 109 and 110: 109Redundant 72 ton Brine makers
show all

ClorTec Onsite Hypochlorite Generation Systems - Ohiowater.org

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?