More documents

Recommendations

Info

Wastewater/DrainageWilo-Drain TM/TMW, TS 40-65, TS 40/12, TS 40/16, CPProduct DescriptionWilo-Drain CPSingle-stage excavation ditch pumpType keyExample: Wilo-Drain CP 32/17-1~230CP Contractor Pump32 Nominal diameter (DN 32, DN 50, DN 80)/17 Maximum delivery head [m]1~230 AC motor3~400 Three-phase motorApplicationsDraining of excavation ditches, basements, shafts and ponds. Thepump is perfectly suited for use in fountains.DesignSubmersible pump with double mechanical seal. It is designed to beparticularly hard-wearing and robust. The electrical drive is sealedfrom the flow medium by means of 2 mechanical seals and an internaloil seal chamber. The motor compartment is filled with oil.The hydraulic system is equipped with multi-vane impellers.Scope of deliveryFully assembled pump with 10 m power cable and alternating currentor Three-phase plug, installation and operating manual.20 As of: 06/2004 - Subject to change without prior notice
Wastewater/DrainageWilo-Drain TM/TMW, TS 40-65, TS 40/12, TS 40/16, CPPump Equipment/FunctionPump Equipment/FunctionWilo-DrainTM/TMW 32Wilo-DrainTS 40Wilo-DrainTS 50Wilo-DrainTS 65Wilo-DrainTS 40/12/16Wilo-DrainCP 32/50/80Operating mode S3 (intermittent service)Frequency switching/h [%] 25 25 25 25 25 –Max. frequency switching/h 60 70 50 40 50 –Recommended frequency switching/h 20 20 20 20 20 –Operating mode S1 (continuous service)Motor below water • • • • • •Motor above water – – – – – •Pump/motor sealsIn pumping medium area: Mechanical seal • • • • • •On the motor compartment side: Mechanical seal – – – – – •Shaft seal • • • • • –Oil seal chamber • • • • • •DesignWet sump installation Stationary • • • • • •Portable • • • • • •Submersible • • • • • •Open multi-vane impeller • • • • – –Closed multi-vane impeller – – – – – •Free-flow impeller – – – – •TurbulatorMaterials•(TMW only)•(CP 32/23 andCP 80 only)– – – – –Motor Cast aluminium – – – – – •Stainless steel • • • • • –Pump Plastic • • • • • –EquipmentMotor monitor (temperature)Cast iron – – – – – •••(3~400 Vmodel only)Explosion protection – –•(3~400 Vmodel only)•(3~400 Vmodel only)• – •• – –Forced-flow casing cooling • – – – –Pre-assembled • – – – • –•(CP 80 only)Power cable [m]310 for: TM 32/8 and 10 10 10 5 10TMW 32/11HDDetachable power cable – • • • – •Attached float switch –/• optional optional – • –Built-in check valve body – • – – • –Capacitor box for 1~230 V – • • • –•(CP 32/17only)Hose connection – – – – • –Submersible pumps• = available, – = not availableAs of: 06/2004 - Subject to change without prior notice21
Page 1 and 2: ContentsProduct Overview and Fields
Page 3 and 4: Product Overview and Fields of Appl
Page 5 and 6: General Notes and AbbreviationsWear
Page 7 and 8: ContentsSubmersible pumpsSewage/Fae
Page 9 and 10: Sewage DisposalPlanning GuideWastew
Page 11 and 12: Submersible PumpsProduct Advantages
Page 17: Wastewater/DrainageWilo-Drain TM/TM
Page 21 and 22: Wastewater/DrainageWilo-Drain TM/TM
Page 23 and 24: Wastewater/DrainageWilo-Drain TM/TM
Page 25 and 26: Wastewater/DrainageWilo-Drain TS 40
Page 27 and 28: Wastewater/DrainageWilo-Drain TS 40
Page 29 and 30: Wastewater/DrainageWilo-Drain CP 32
Page 31 and 32: Wastewater/DrainageWilo-Drain LP 40
Page 33 and 34: Wastewater/DrainageWilo-Drain LP 40
Page 35 and 36: Wastewater/DrainageWilo-Drain TC 40
Page 41 and 42: Wastewater/DrainageWilo-Drain TP 50
Page 47 and 48: Hot WaterWilo-Drain TMT/TMC, VCPump
Page 49 and 50: Hot WaterWilo-Drain TMT/TMCPump Cur
Page 51 and 52: Sewage/FaecesWilo-Drain TP 40 S/25,
Page 55 and 56: Sewage/FaecesWilo-Drain TP 40 SPump
Page 59 and 60: Sewage/FaecesWilo-Drain STC 80/100,
Page 69 and 70:
Sewage/FaecesWilo-Drain STC 80/100,
Page 71 and 72:
Sewage/FaecesWilo-Drain STC 80/100,
Page 73 and 74:
Sewage/FaecesWilo-Drain STC 80/100P
Page 75 and 76:
ISewage/FaecesWilo-Drain STC 80/100
Page 77 and 78:
Sewage/FaecesWilo-Drain STS 80/100P
Page 79 and 80:
ISewage/FaecesWilo-Drain STS 80/100
Page 81 and 82:
Sewage/FaecesWilo-Drain TP 80, TP 1
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
ISewage/FaecesWilo-Drain TP 80, TP
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Sewage/FaecesWilo-Drain Electrical
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Sewage/FaecesSubmersible pumpsAs of
Page 101 and 102:
ContentsLifting plants/Wet sump pum
Page 103 and 104:
Lifting PlantsProduct AdvantagesWil
Page 105 and 106:
Lifting PlantsProduct AdvantagesWil
Page 107 and 108:
Condensate/Wastewater/Drainage Wate
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Sewage/FaecesWilo-DrainLift KHProdu
Page 121 and 122:
Sewage/FaecesWilo-DrainLift KHTechn
Page 123 and 124:
Sewage/FaecesWilo-DrainLift S, M, L
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Sewage/FaecesWilo-DrainLift SPump C
Page 131 and 132:
Sewage/FaecesWilo-DrainLift SMechan
Page 133 and 134:
Sewage/FaecesWilo-DrainLift MDimens
Page 135 and 136:
Sewage/FaecesWilo-DrainLift LDimens
Page 137 and 138:
Sewage/FaecesWilo-DrainLift LTypica
Page 139 and 140:
Sewage/FaecesWilo-DrainLift XLDimen
Page 141 and 142:
Page 143 and 144:
Sewage/FaecesWilo-DrainLift XXLDime
Page 145 and 146:
Sewage/FaecesWilo-DrainLift XXLDime
Page 147 and 148:
Wet Sump Pumping StationsProduct Ad
Page 149 and 150:
Wet Sump Pumping StationsWilo-Drain
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
NotesAs of: 06/2004 - Subject to ch
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173:
show all

Contents

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?