Field Operations Guide - Kentucky Transportation Cabinet

More documents

Recommendations

Info

FOG-402ChapterSHOULDERS(B000)SubjectPaving Machine or Grader Leveling &Patching with Bituminous Mix(B020)DESCRIPTIONPaving machine or grader leveling and patching of paved shoulders withbituminous material to correct shoulder surface irregularities and failures(Section Required)SCHEDULING Temperature requirements restrict the effective placement ofbituminous materials with a paving machine or grader to the warmermonths.RECOMMENDEDPERSONNEL Highway Superintendent (1)Highway Equipment Operator (5)Traffic Control (3)RECOMMENDEDEQUIPMENT Crew cab (1)Pickup truck (pilot vehicle) (1)Distributor (1)Paving machine or grader (1)Truck trailer* (1)Truck tractor* (1)Water truck (1)Dump truck(2, distance may require more)Roller (1)*Use of track-mounted paving machine requires truck tractor and trailer.RECOMMENDEDMATERIALS Bituminous mix (60 tons)Liquid asphalt(57 gallons)Chip (as necessary)10/11 Page 1 of 2
SHOULDERS (B000)Paving Machine or Grader Leveling & Patching with Bituminous Mix (B020)FOG-402ENVIRONMENTALIMPACTS Precondition equipment before loading bituminous material. Do not use diesel fuel. Return tool-cleaning solvents to the lot. Follow procedures in the Environmental Handbook (2.1.1, “CleaningAsphalt Tools and Equipment”) for cleaning at the end of the job.PERFORMANCEVALUESFUNCTION Hours Per Unit 1.200 Daily Expectation 60 Accomplishment UnitTonFE01RECOMMENDEDPROCEDURE1. Discuss with crew the requirements of the job. Emphasize safety.2. Place traffic-control devices as necessary.3. Clean surface, if required, prior to application of tack coat to surface.4. Apply tack coat of heated liquid asphalt to existing surface, makingsure entire surface area is covered. Allow tack to “break” beforepaving.5. Apply bituminous mix with paver or grader in layers no more thantwo inches or less than one inch in depth (square ends).6. Roll for proper compaction after each layer.7. Check for proper crown or cross slope before leaving project. Correctany deficiencies.8. Remove traffic-control devices.Special Note: Determine accomplishment before leaving job site.10/11 Page 2 of 2
Page 1:
COMMONWEALTH OF KENTUCKYTRANSPORTAT
Page 4 and 5:
FOG-01TABLE OF CONTENTS01 TABLE OF
Page 6: TABLE OF CONTENTSFOG-01600 ROADSIDE
Page 9 and 10: TABLE OF CONTENTSFOG-011400 SIGNING
Page 11 and 12: INTRODUCTIONDesign of This ManualFO
Page 13 and 14: FOG-103ChapterINTRODUCTIONSubjectPe
Page 15 and 16: INTRODUCTIONReportingACCOUNT STRIPR
Page 18 and 19: DIVISION OF MAINTENANCEActivity Cod
Page 20 and 21: DIVISION OF MAINTENANCEAccomplishme
Page 22 and 23: FOG-301ChapterSURFACE(A000)SubjectP
Page 26 and 27: FOG-303ChapterSURFACE(A000)SubjectA
Page 30 and 31: FOG-305ChapterSURFACE(A000)SubjectS
Page 32 and 33: FOG-306ChapterSURFACE(A000)SubjectJ
Page 34 and 35: FOG-307ChapterSURFACE(A000)SubjectJ
Page 36 and 37: FOG-308ChapterSURFACE(A000)SubjectM
Page 38 and 39: SURFACE (A000)Routine Traffic-Bound
Page 40 and 41: SURFACE (A000)Patching with Traffic
Page 42 and 43: FOG-312ChapterSURFACE(A000)SubjectV
Page 46 and 47: FOG-314ChapterSURFACE(A000)SubjectS
Page 50 and 51: FOG-317ChapterSURFACE(A000)SubjectB
Page 54 and 55: FOG-401ChapterSHOULDERS(B000)Subjec
Page 78 and 79: ROADSIDE GENERAL (C000)Repair to Ro
Page 80 and 81: ROADSIDE GENERAL (C000)Repair to La
Page 82 and 83: ROADSIDE GENERAL (C000)Rest Area At
Page 84 and 85: FOG-505ChapterROADSIDE GENERAL(C000
Page 86 and 87: ROADSIDE GENERAL (C000)Litter Clean
Page 88 and 89: ROADSIDE GENERAL (C000)Litter Clean
Page 90 and 91: ROADSIDE GENERAL (C000)Dead Animal
Page 94 and 95: ROADSIDE GENERAL (C000)Energy-Absor
Page 96 and 97: ROADSIDE GENERAL (C000)Fence Repair
Page 98 and 99: ROADSIDE GENERAL (C000)Repair or In
Page 100 and 101: ROADSIDE GENERAL (C000)Repair or In
Page 106 and 107:
ROADSIDE AGRONOMY (E000)Brush & Tre
Page 108 and 109:
ROADSIDE AGRONOMY (E000)Mechanical
Page 110 and 111:
FOG-604ChapterROADSIDE AGRONOMY(E00
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
ROADSIDE AGRONOMY (E000)Mechanical
Page 130 and 131:
Page 132 and 133:
MOWING (F000)Slope Mowing (F050)REC
Page 134 and 135:
FOG-703ChapterMOWING(F000)SubjectHa
Page 136 and 137:
FOG-705ChapterMOWING(F000)SubjectTy
Page 138 and 139:
FOG-706ChapterMOWING(F000)SubjectTy
Page 140 and 141:
FOG-707ChapterMOWING(F000)SubjectCo
Page 142 and 143:
FOG-801ChapterBRIDGE(H000)SubjectBr
Page 144 and 145:
BRIDGE (H000)Cleaning Bridge Decks
Page 146 and 147:
BRIDGE (H000)Bridge Joint Sealing (
Page 148 and 149:
FOG-805ChapterBRIDGE(H000)SubjectRe
Page 150 and 151:
FOG-806ChapterBRIDGE(H000)SubjectMa
Page 152 and 153:
Page 154 and 155:
FOG-808ChapterBRIDGE(H000)SubjectPa
Page 156 and 157:
FOG-809ChapterBRIDGE(H000)SubjectCo
Page 158 and 159:
FOG-810ChapterBRIDGE(H000)SubjectEr
Page 160 and 161:
Page 162 and 163:
FOG-813ChapterBRIDGE(H000)SubjectFe
Page 164 and 165:
FOG-815ChapterBRIDGE(H000)SubjectMi
Page 166 and 167:
FOG-901ChapterROADWAY DRAINAGE(J000
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
ROADWAY DRAINAGE (J000)Ditching Usi
Page 180 and 181:
ROADWAY DRAINAGE (J000)Ditching Usi
Page 182 and 183:
ROADWAY DRAINAGE (J000)Paved & Rock
Page 184 and 185:
ROADWAY DRAINAGE (J000)Cleaning Dra
Page 186 and 187:
Page 188 and 189:
SNOW & ICE (K000)Plowing (K010)RECO
Page 190 and 191:
SNOW & ICE (K000)Spreading Salts &
Page 192 and 193:
SNOW & ICE (K000)Plowing & Spreadin
Page 194 and 195:
SNOW & ICE (K000)Anti-Icing (K040)R
Page 196 and 197:
FOG-1006ChapterSNOW & ICE(K000)Subj
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
SNOW & ICE (K000)Stockpiling & Load
Page 204 and 205:
SNOW & ICE (K000)Miscellaneous Snow
Page 206 and 207:
EXTRAORDINARY (M000)Emergency Repai
Page 208 and 209:
EXTRAORDINARY (M000)Emergency Repai
Page 210 and 211:
EXTRAORDINARY (M000)Emergency Relie
Page 212 and 213:
EXTRAORDINARY (M000)—Emergency Wo
Page 214 and 215:
FOG-1106ChapterEXTRAORDINARY(M000)S
Page 216 and 217:
FOG-1201ChapterSERVICE & OVERHEAD(N
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
FOG-1301ChapterINSPECTION(P000)Subj
Page 236 and 237:
INSPECTION (P000)Maintenance Rating
Page 238 and 239:
FOG-1304ChapterINSPECTION(P000)Subj
Page 240 and 241:
SIGNINGS & MARKINGS (T000)Painting
Page 242 and 243:
Page 244 and 245:
Page 246 and 247:
SIGNINGS & MARKINGS (T000)Hand-Plac
Page 248 and 249:
SIGNINGS & MARKINGS (T000)Pavement
Page 250 and 251:
FOG-1407ChapterSIGNINGS & MARKINGS(
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
Page 258 and 259:
Page 260 and 261:
SIGNINGS & MARKINGS (T000)Placement
Page 262 and 263:
SIGNINGS & MARKINGS (T000)Replaceme
Page 264 and 265:
Page 266 and 267:
Page 268 and 269:
Page 270 and 271:
Page 272 and 273:
Page 274 and 275:
Page 276 and 277:
Page 278 and 279:
FOG-1501ChapterTRAFFIC(T000)Subject
Page 280 and 281:
Page 282 and 283:
Page 284 and 285:
TRAFFIC (T000)Traffic Signal Modifi
Page 286 and 287:
TRAFFIC (T000)Highway Lighting Inst
Page 288 and 289:
TRAFFIC (T000)Maintenance of Electr
Page 290 and 291:
TRAFFIC (T000)Maintenance of Naviga
Page 292 and 293:
Page 294 and 295:
Page 296 and 297:
Page 298 and 299:
Page 300 and 301:
ALPHABETICAL INDEXC (cont.)Contract
Page 302 and 303:
ALPHABETICAL INDEXNNavigation Light
Page 304 and 305:
ALPHABETICAL INDEXS (cont.)Special
Page 306 and 307:
EXHIBITTable 1. Acreage—Right of
Page 308 and 309:
EXHIBITTable 3. Square Yards of Roa
Page 310 and 311:
EXHIBITTable 5. Lineal Feet Covered
Page 312 and 313:
EXHIBITTable 7. Tons of Aggregate R
Page 314 and 315:
EXHIBITTable 9. Loose & Compacted W
Page 316 and 317:
EXHIBIT—Table 11. Cubic Yards of
Page 318 and 319:
EXHIBITTable 13. Number of Board Fe
Page 320 and 321:
EXHIBITTable 15. Conversion Factors
Page 322:
EXHIBITTable 17. Conversion Factors
show all

Field Operations Guide - Kentucky Transportation Cabinet

Create successful ePaper yourself

Delete template?

Save as template?