XR1045 Operation Manual - Xtreme Manufacturing

OperationCold Starting2. Turn key in Ignition switch clockwise to thePREHEAT position and hold the key at PREHEAT forapproximately one (1) minute.XR1045NOTE: If the engine fails to start on the first try, waituntil the engine and starter come to a complete stopbefore cranking the engine again.5. After the engine starts, allow the engine to idle forapproximately 60 seconds.6. Apply the service brake pedal and disengage theParking Brake switch.Jump StartingJump start or replace the battery of the reach forklift whenthe battery is discharged to the point that it will not crankthe starter.Figure 7-10. Hold Key At PREHEAT.3. Turn key in Ignition switch clockwise to theSTART position. WarningFigure 7-11. Turn Key In Ignition Switch To START.4. Release the key immediately after the engine starts.The Ignition switch will automatically return to RUN.NOTE: The PREHEAT and START positions are springloaded.When the key is released, the Ignition switchwill automatically return to the RUN position.Figure 7-12. Ignition Switch Automatically Returns To RUN.Lead-acid batteries produce flammable andpotentially explosive gases. To avoid death or seriousinjury when checking, testing, or charging batteries:• DO NOT use smoking materials near batteries.• Keep arcs, sparks, and open flames away frombatteries.• Provide ventilation for flammable vapors• Wear proper personal protective equipment,including safety glasses.Fluid in electric storage batteries contains sulfuricacid, which is poison and can cause severe chemicalburns. Avoid all contact of fluid with eyes, skin,or clothing. Use protective gear when handlingbatteries. DO NOT tip a battery beyond a 45° anglein any direction.If contact does occur, follow these First Aidsuggestions:• External contact - Flush with water.• Eyes - Flush with water (including under the eyelids)for at least 15 minutes and get medical attentionimmediately. Flushing must begin immediately toavoid permanent eye tissue damage.• Internal contact - Drink large quantities of wateror milk to dilute stomach contents. Do not inducevomiting. Get medical attention immediately.Important - In case of internal contact, do not givefluids that induce vomiting.Page 52Xtreme Manufacturing, LLC