MR-911 MSDS - Mannington

MATERIAL SAFETY DATA SHEETSECTION 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATIONProduct Name: MR-911Chemical Name:Water Based Acrylic Rubber & Vinyl Flooring AdhesiveProduct Use/Class: AdhesiveCompany Information:Mannington Mills, Inc.P.O. Box 30 - Route 4575 Mannington Mills RoadSalem, New Jersey 08079Phone Numbers: General: (856) 935-3000Product Emergency: (866) 359-5602Spill Response: (800) 424-9300Effective Date: 1-08-09 Supersedes Date:Reason for Revision:SECTION 2 - COMPOSITION / INFORMATION ON INGREDIENTSChemical Name CAS Number Weight % Exposure GuidelinesACGIH - TLV OSHA - PELTWA STEL TWA CeilingAcrylic Co-Proprietary 60-64 NA NA NA NAPolymerCalcium Carbonate 1317-65-3 35-39 10 mg/m 3 10mg/m 3 10mg/m 3 10mg/m 3Propylene Glycol 57-55-6

Skin Contact: No known effectsInhalation: No known effectsIngestion: Not likely to occur. If swallowed,, no side effects known.Chronic/ Carcinogenicity:IARC: Not suspected as human carcinogenOSHA: Not suspected as human carcinogenNTP: Not suspected as human carcinogenOther: None knownSECTION 4 - FIRST AID MEASURESIf in Eyes:Immediately flush eyes with plenty of water for at least 15 minutes. Contact a physician ifirritation occurs.If on Skin: Wash affected area with soap and water. If irritation persists, seek medical attention.If Inhaled: Remove to fresh air. Contact physician if irritation occurs.If Swallowed: If swallowed, induce vomiting and seek medical attention.SECTION 5 - FIRE FIGHTING MEASURESFlash Point: NoneLower Explosive Limit (LEL) %: NoneUpper Explosive Limit (UEL) %: NoneAuto-Ignition Temperature: Not EstablishedOSHA Flammability Classification: III BHazardous Products of Combustion: Carbon monoxide, carbon dioxide, smoke fumes , hydrocarbonfragments and nitrogen oxidesExtinguishing Media: Water Spray, Carbon Dioxide, Chemical Foam, Dry ChemicalUnusual Fire and Explosion Hazards: None knownFire Fighting Equipment: Respiratory (Self Contained Apparatus) and eye protection required.Miscellaneous Advice:Refer to Section 10 for additional information.SECTION 6 - ACCIDENTAL RELEASE MEASURESPersonal Precautions: Wear Protective ClothingMethods for Clean-up: Soak up material with Sand or Clay. Place contaminated material in non-leakingcontainer. Wash area thoroughly with water.Refer to Section 13 for disposal information.Refer to Sections 14 and 15 for reportable quantity information.SECTION 7 - HANDLING AND STORAGEHandling: Use good hygiene practices. Refer to Section 8. KEEP OUT OF REACH OF CHILDREN.Storage: Store above 40 deg F)Consult the Mannington Professional Installation Handbook for additional information onhandling and storage.2

SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTIONEngineering Controls: Normal room ventilationRespiratory Protection: Not normally required with good ventilationEye Protection: Wear splash goggles if contact with material is likelyHand and Skin Protection: Wear gloves if contact with material is likelyOther Protective Equipment:Hygienic Practices: Always wash hands before eating, smoking or using toilet facilities. Do notsmoke in any chemical handling or storage area. Food or beverages should not be consumedanywhere this product is handled or stored. Wash thoroughly after handling.SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIESAppearance: White pasteWater Solubility: SolublePhysical State: PasteBoiling Point: 212 0 FVolatiles (Wt. %): < 1gram/literVolatiles (Vol. %): 27Odor: Low OdorVapor Pressure: Same as waterVapor Density: Same as waterMelting Point: Not ApplicableSpecific Gravity: 1.165pH: 8 - 9Evaporation Rate: Same as waterDecomposition Temperature: Not EstablishedFlash Point: NoneSECTION 10 - STABILITY AND REACTIVITYConditions to Avoid: None knownMaterials to Avoid: None knownStability: StableHazardous Reactions: Will not occurHazardous Polymerization: Will not occur.Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, hydrocarbon fragments, andnitrogen oxidesSECTION 11 - TOXICOLOGICAL INFORMATIONProduct LD50 (Oral): No DataProduct LD50 (Dermal): No DataProduct LC50: No DataImmediate (Acute) Effects: May irritate eyesDelayed (Sub-chronic & Chronic) Effects: None knownSECTION 12 - ECOLOGICAL INFORMATIONNo information available.3

SECTION 13 - DISPOSAL CONSIDERATIONSUS EPA RCRA Status: N.A.Disposal Considerations: N.A.Disposal Method: N.A.Miscellaneous:Disposal should be done in accordance with all local, state and federal(40 CFRPart 261) regulations. May incinerate at an EPA approved facility.PROPER WASTE DISPOSAL IS THE ERESPONSIBILITY OF THE OWNER OF THE WASTE!SECTION 14 - TRANSPORT INFORMATIONThe information provided in this section is for information only. Please apply the appropriateregulations to properly classify your shipment for transport.DOT Proper Shipping Name: N.A.DOT Hazard Class: NoneDOT UN/NA Number: N.A.Packing Group: N.A.Emergency Response Guide Number: N.A.Other:SECTION 15 - REGULATORY INFORMATIONU.S. Federal Regulations: N.A.SARA Section 312: NASARA Section 313: NoneToxic Substances Control Act: All components listedOther: California Proposition 65- This product contains the following chemical(s) known to the state ofCalifornia to cause cancer, birth defects or reproductive harm. None KnownSECTION 16 - OTHER INFORMATIONProduct Use:Floor covering adhesiveHazard Ratings Health Fire Reactivity Additional InformationSuggested NFPA Rating 1 1 0Suggested HMIS Rating 1 1 0Disclaimer:Although the information and recommendations set forth herein (hereinafter "Information") are presented ingood faith and believed to be correct as of the date of hereof, the company makes no representations as to thecompleteness or accuracy thereof. Information is supplied upon the condition that the persons receiving samewill make their own determination as to its suitability for their purposes prior to use. In no event will thecompany be responsible for damages of any nature whatsoever resulting from the use of or reliance uponInformation. NO REPRESENTATIONS OR WARRANTIES, ETHER EXPRESS OR IMPLIED, OFMERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR OF ANY OTHER NATURE AREMADE HEREUNDER WITH RESPECT TO INFORMATION OR THE PRODUCT TO WHICHINFORMATION REFERS.Product Use:4

Reason for Revision:Prepared By:Legend:N.E. - Not EstablishedS - SkinN.A. - Not Availableppm - Parts per MillionN/A - Not Applicable° F. - Degrees FahrenheitC - Ceiling (Exposure Levels)° C. - Degrees CentigradePEL - Permissible Exposure LimitsSTEL - Short-Term Exposure LimitOEL - Occupational Exposure LimitCIH - Certified Industrial HygienistTSCA - Toxic Substances Control ActTWA - Time Weighted AverageNFPA - National Fire Protection AssociationTLV - Exposure Limits Developed by ACCIHMSHA - Mine Safety and Health AdministrationNIOSH - National Institute for Occupational SafetyOSHA - Occupational Safety and Health AdministrationHAZCOM - Hazard Communication Standard (29CFR1910.1200)ACGIH - American Conference of Government Industrial HygienistsCERCLA - Comprehensive Environmental Response, Comprehensive and Liability Act5