Battery Application Guide - CARQUEST Auto Parts

FOOTNOTES1 Battery gasses may need to be vented to outside.2 Check terminal post arrangement carefully!Could be top or side terminals.3 Deep cycle battery required. Watch polarity!5 Hood or cover clearance may not be sufficient.Check polarity to avoid explosion.6 Installation may take 15 to 30 mins.7 Difficult battery installation. May take 45 minutes or more.10 Need flush cover battery to fit under shield or to clear.May need to remove height adjuster.11 Battery is encased within an Active Cooling Box with an air snorkleto the outside of the engine compartment.12 Non-BCI group size. Replacement not available.15 Two batteries required. For best results, replace both.16 Vibration proof battery. Replacement not available.17 Watch polarity and clearance!Vehicle could have reverse terminal battery.18 Gr. 31 battery w/ SAE terminal posts.21 O.E. battery has special terminals. Cable change is necessary.24 OEM Used various size batteries in production.Check original battery for size and correct fit.25 Replacement battery is taller than O.E.Check height clearance before closing hood or cover.26 Replacement battery is wider than O.E.Hold-down and/or tray replacement may be necessary.27 Check O.E. CCA requirements.Replacement CCA may not be sufficient.29 Battery hold-down may need to be replaced and/or modified.Battery cable replacement may be necessary.30 Replacement battery is wider and taller than O.E.Hold-down and/or tray replacement may be necessary.31 Replacement battery is longer and wider than O.E.Hold-down and/or tray replacement may be necessary.32 Replacement battery is longer than O.E.Hold-down and/or tray replacement may be necessary.33 Height adapter may be required on Dual Terminal batteries.35 Battery w/ handle brackets will not fit.38 No info available. See Owners Manual or call Dealerfor proper size.39 Could be 6 or 12 Volt System. Assure correct battery voltageBEFORE installation!40 Battery located in wheelwell -Remove front tire to access the battery.41 Battery located under the rear seat.42 Battery located under hood, under the washer bottle.43 Battery located under hood, under the fuse box.44 Battery located under hood, under the fuse box.Power steering reservoir must be moved.Installation may take 45 minutes or more.45 Battery located under hood, under the air filter.46 Battery located in trunk. Spare tire may have to be removed48 Replacement size is not available.49 Best fit estimate. Match to original battery to assure properfit and polarity.50 OE battery is reverse terminal. U1 may be substituted.Cable change may be necessary.51 Can be used as a possible alternative to OE battery.52 Can be used as a possible alternative to OE battery with flag topost terminal adapter.53 Some models were supplied with manifold vented battery.54 Hose Adapter Kit required to properly vent battery gasses.56 Hold-down modifications may be necessary.59 When ordering battery, specify terminal adapter.70 Two, Three or Four batteries required. For best results,replace all.80 Sealed Valve-Regulated Battery Required120 Shipped with 20mm adapter.Hold-down modificationsmay be necessary.122 Shipped with 10mm adapter. Hold-down modificationsmay be necessary.132 For hot climate service.137 Battery Located Under Hood.139 Battery Located in Trunk.143 Battery gasses may need to be vented to outside.OE has replaced Gr. 76 with Gr. 79147 1 Battery - Dual Battery Opt148 Two or more batteries required. For best results, replace all.149 Amp hour rating from OE mfr is converted to approx.CCA rating (Ah x 10=approx. CCA)150 Application may use 4D/800151 Mfr. Recommended replacement battery shown,may vary from OE battery.152 Battery Located in Left Rear Tire Well. Remove Tire.155 Requires special 6-volt assembly.156 The rating shown is based upon battery industry consensus.158 Group 34 or 78159 CCA may be 660160 Some may require spl. 8-volt battery.162 Group 31 O.E. battery has non-standard SAEterminal locations and may require cable modifications.163 Direct electric start164 Gas starting engine165 12-Volt166 24-Volt167 Could be 12 or 24 Volt System. Assure correct batteryvoltage BEFORE installation!168 Air start169 Military 6TL170 Special 12-volt battery171 Electric start172 6-Volt173 Requires 4 batteries174 Requires 4 or 8 batteries175 Requires 1 or 5 batteries176 Requires 1 or 4 batteries177 Requires 1, 2 or 3 batteries178 Requires 6 batteries179 Requires 1 to 4 batteries180 Requires 2 to 8 batteries181 Requires 3 batteries182 Special Grp. 24 batt. w/ center mounted terminals required183 Special European size required186 spl. 12-volt batt.193 The listed 6-volt sizes were used during these years:(Check dimentions, clearance, & polarity carefully!)199 Some may require special Ordnance 2H or 6TL.201 Battery tray may need to be modified for replacement battery.203 Requires individual vent caps for proper hood clearance, do notfit batteries with pod type vents.204 Best fit estimate. Sensor modifications may be necessary.