Manual - Pine Tree Stove Shoppe
Manual - Pine Tree Stove Shoppe Manual - Pine Tree Stove Shoppe
308.9 WOODTHIS APPLIANCE IS DESIGNED TO BURN NATURAL WOOD ONLY. DO NOT BURN TREATEDWOOD, COAL, CHARCOAL, COLOURED PAPER, CARDBOARD, SOLVENTS OR GARBAGE. THISAPPLIANCE HAS NOT BEEN TESTED WITH AN UNVENTED GAS LOG SET. TO REDUCE RISK OF FIREOR INJURY, DO NOT INSTALL AN UNVENTED GAS LOG SET INTO THE APPLIANCE.HIGHER EFFICIENCIES AND LOWER EMISSIONS GENERALLY RESULT WHEN BURNING AIR DRIEDSEASONED HARDWOODS, AS COMPARED TO SOFTWOODS OR TOO GREEN OR FRESHLY CUTHARDWOODS.BURNING WET UNSEASONED WOOD CAN CAUSE EXCESSIVE CREOSOTE ACCUMULATION. WHENIGNITED IT CAN CAUSE A CHIMNEY FIRE THAT MAY RESULT IN A SERIOUS HOUSE FIRE.DO NOT STORE FUEL WITHIN THE CLEARANCE TO COMBUSTIBLES, OR IN THE SPACE REQUIREDFOR RE-FUELING AND ASH REMOVAL.BURNING WET, UNSEASONED WOOD CAN CAUSE EXCESSIVE CREOSOTE ACCUMULATION. WHENIGNITED IT CAN CAUSE A CHIMNEY FIRE THAT MAY RESULT IN A SERIOUS HOUSE FIRE.When loading the appliance, ensure that the upper fibre baffles are not forced out of position. For maximum efficiency, when theappliance is thoroughly hot, load it fully to the top of the door opening and burn at a medium low setting. The whiteness of thebricks and the cleanliness of the glass are good indicators of your operating efficiency. Not enough heat is produced when only afew pieces of wood are burned or the wood may not burn completely.Fuel for the appliance must not be stored closer than the required clearances to combustibles (heat sensitive material).NEVER STORE WOOD IN THE ASH PAN COMPARTMENT (if applicable).NOTE: When loading the appliance, ensure to keep fuel back from the glass. If coals are to accumulate on the front lip,there is a chance they will fall out when the door is opened.Burn only dry, clean unpainted wood that has been seasoned. It produces more heat and less soot or creosote. Freshly cutwood contains about 50% moisture while after proper seasoning only about 20% of the water remains. As wood is burned, thiswater boils off consuming energy that should be used in heating. The wetter the wood, the less heat is given off and the morecreosote is produced. Dry fi rewood has cracks in the end of the grain.Both hardwood and softwood burn equally well inthis appliance but hardwood is denser, will weighmore per cord and burn a little slower and longer.Firewood should be split, stacked in a mannerthat air can get to all parts of it and covered inearly spring to be ready for burning that fall. Dryfirewood has cracks in the end grain.Cut the wood so that it will fi t horizontally, frontto back, making for easier loading and less of a likelihood that the wood will rollonto the glass.DO’S• Build a hot fi re.• Use only dry wood.• Several pieces of medium sized wood are betterthan a few big pieces.• Clean chimney regularly.• Refuel frequently using medium sized wood.• “Fine Tune” the air settings for optimum performance.DONT’S• Take ash out immediately. Let it accumulate to adepth of at least one inch. A good ash layer providesfor a longer lasting and better burning fire.• Burn wet wood.• Close the door too soon or damper down too quickly.• Burn one large log rather than two or three smaller,more reasonably sized logs.• Burn at continually “low setting”, if glass door isconstantly blackened. This means the fireboxtemperature is too low.87.1AW415-0762 / B / 11.12.10
9.0 REPLACEMENTSContact your dealer or the factory for questions concerning prices and policies on replacement parts. Normallyall parts can be ordered through your Authorized dealer / distributor.FOR WARRANTY REPLACEMENT PARTS, A PHOTOCOPY OF THE ORIGINAL INVOICE WILL BEREQUIRED TO HONOUR THE CLAIM.When ordering replacement parts always give the following information:• Model & Serial Number of appliance• Installation date of appliance• Part number• Description of part• Finish* IDENTIFIES ITEMS WHICH ARE NOT ILLUSTRATED. FORFURTHER INFORMATION, CONTACT YOUR AUTHORIZED DEALER.COMPONENTSREF NO. 1100PL 1100C 1400PL 1400C DESCRIPTION1* W090-0001 W090-0001 W090-0001 W090-0001 BRICK - # 12* W090-0002 W090-0002 W090-0002 W090-0002 BRICK - # 23* W090-0003 W090-0003 N/A N/A BRICK - # 34* W090-0004 W090-0004 W090-0004 W090-0004 BRICK - # 4 LEFT5* W090-0005 W090-0005 W090-0005 W090-0005 BRICK - # 4 RIGHT6* W090-0016 W090-0016 W090-0016 W090-0016 BRICK - # 5! WARNINGFAILURE TO POSITION THE PARTSIN ACCORDANCE WITH THISMANUAL OR FAILURE TO USE ONLYPARTS SPECIFICALLY APPROVEDWITH THIS APPLIANCE MAYRESULT IN PROPERTY DAMAGE ORPERSONAL INJURY.7* W090-0017 W090-0017 W090-0017 W090-0017 BRICK - # 68* W090-0018 W090-0018 W090-0018 W090-0018 BRICK - # 89* W090-0019 W090-0019 W090-0019 W090-0019 BRICK - # 910* N/A W135-0278** N/A W135-0278** CASTING, ASH LIP11 W710-0013 N/A W710-0013 N/A ASH LIP12 W010-0347 W010-0347 W010-0347 W010-0347 AIRWASH GASKET & SHIELD13* W570-0007 W570-0007 W570-0007 W570-0007 SCREWS FOR MANIFOLD & SHIELD14* W018-0077 W018-0077 N/A N/A #10 FIBRE BAFFLE15* N/A N/A W018-0078 W018-0078 #11 FIBRE BAFFLE16* EP-11MS EP-11MS EP-14MS EP-14MS MANIFOLD SHIELD17 KB-35 KB-35 KB-35 KB-35 VARIABLE SPEED CONTROL C/W KNOB18* W580-0006 W580-0001 W580-0005 W580-0005 COMPLETE BRICK SET19 W510-0001 N/A W510-0001 N/A 5/16” PLUG20* W290-0087 N/A W290-0087 N/A GASKET, ASH OPENING21 N/A W135-0282** N/A W135-0442** CAST TOP22 N/A W135-0281** N/A W135-0443** CAST SIDES23 N/A W135-0280** N/A W135-0280** CAST LEG24 N/A W135-0279** N/A W135-0279** CAST DOOR25* N/A N/A N/A W135-0441 CAST LID26 W325-0045 W325-0045 W325-0045 W325-0045 SPRING HANDLE LARGE27 W325-0044 W325-0044 W325-0044 W325-0044 SPRING HANDLE SMALL** For available colours, add these letters to the base part number.41.131COLOURPorcelain BrownPainted Wrought IronFINISH- N- WIW415-0762 / B / 11.12.10
- Page 1 and 2: INSTALLER: LEAVE THIS MANUAL WITH T
- Page 3 and 4: 31.0 INSTALLATION OVERVIEW1400PL IL
- Page 5 and 6: 52.1 DIMENSIONSBCADE1400PL ILLUSTRA
- Page 7 and 8: 2.4 GENERAL INFORMATION! WARNINGDO
- Page 9 and 10: 93.0 PRE-INSTALLATION PREPARATION3.
- Page 11 and 12: 113.6 MOBILE HOME! WARNINGDO NOT IN
- Page 13 and 14: 4.1 CHIMNEY! WARNINGNEVER INSTALL A
- Page 15 and 16: 154.1.2 ADDING SECTIONSAdd chimney
- Page 17 and 18: 174.1.4 TYPICAL THROUGH THE WALLIf
- Page 19 and 20: 195.0 FINISHING5.1 LEG INSTALLATION
- Page 21 and 22: 215.6 BRICKS AND BAFFLES INSTALLATI
- Page 23 and 24: 237.0 OPERATION! WARNINGALWAYS OPER
- Page 25 and 26: 257.3 LIGHTING A FIRE7.3.1 FLASH FI
- Page 27 and 28: 278.3 RUNAWAY OR CHIMNEY FIREA CHIM
- Page 29: 8.7 CARE OF GLASSIf the glass is no
- Page 33 and 34: 3310.0 TROUBLE SHOOTING! WARNINGTUR
- Page 35 and 36: 3512.0 SERVICE HISTORY43.1W415-0762
9.0 REPLACEMENTSContact your dealer or the factory for questions concerning prices and policies on replacement parts. Normallyall parts can be ordered through your Authorized dealer / distributor.FOR WARRANTY REPLACEMENT PARTS, A PHOTOCOPY OF THE ORIGINAL INVOICE WILL BEREQUIRED TO HONOUR THE CLAIM.When ordering replacement parts always give the following information:• Model & Serial Number of appliance• Installation date of appliance• Part number• Description of part• Finish* IDENTIFIES ITEMS WHICH ARE NOT ILLUSTRATED. FORFURTHER INFORMATION, CONTACT YOUR AUTHORIZED DEALER.COMPONENTSREF NO. 1100PL 1100C 1400PL 1400C DESCRIPTION1* W090-0001 W090-0001 W090-0001 W090-0001 BRICK - # 12* W090-0002 W090-0002 W090-0002 W090-0002 BRICK - # 23* W090-0003 W090-0003 N/A N/A BRICK - # 34* W090-0004 W090-0004 W090-0004 W090-0004 BRICK - # 4 LEFT5* W090-0005 W090-0005 W090-0005 W090-0005 BRICK - # 4 RIGHT6* W090-0016 W090-0016 W090-0016 W090-0016 BRICK - # 5! WARNINGFAILURE TO POSITION THE PARTSIN ACCORDANCE WITH THISMANUAL OR FAILURE TO USE ONLYPARTS SPECIFICALLY APPROVEDWITH THIS APPLIANCE MAYRESULT IN PROPERTY DAMAGE ORPERSONAL INJURY.7* W090-0017 W090-0017 W090-0017 W090-0017 BRICK - # 68* W090-0018 W090-0018 W090-0018 W090-0018 BRICK - # 89* W090-0019 W090-0019 W090-0019 W090-0019 BRICK - # 910* N/A W135-0278** N/A W135-0278** CASTING, ASH LIP11 W710-0013 N/A W710-0013 N/A ASH LIP12 W010-0347 W010-0347 W010-0347 W010-0347 AIRWASH GASKET & SHIELD13* W570-0007 W570-0007 W570-0007 W570-0007 SCREWS FOR MANIFOLD & SHIELD14* W018-0077 W018-0077 N/A N/A #10 FIBRE BAFFLE15* N/A N/A W018-0078 W018-0078 #11 FIBRE BAFFLE16* EP-11MS EP-11MS EP-14MS EP-14MS MANIFOLD SHIELD17 KB-35 KB-35 KB-35 KB-35 VARIABLE SPEED CONTROL C/W KNOB18* W580-0006 W580-0001 W580-0005 W580-0005 COMPLETE BRICK SET19 W510-0001 N/A W510-0001 N/A 5/16” PLUG20* W290-0087 N/A W290-0087 N/A GASKET, ASH OPENING21 N/A W135-0282** N/A W135-0442** CAST TOP22 N/A W135-0281** N/A W135-0443** CAST SIDES23 N/A W135-0280** N/A W135-0280** CAST LEG24 N/A W135-0279** N/A W135-0279** CAST DOOR25* N/A N/A N/A W135-0441 CAST LID26 W325-0045 W325-0045 W325-0045 W325-0045 SPRING HANDLE LARGE27 W325-0044 W325-0044 W325-0044 W325-0044 SPRING HANDLE SMALL** For available colours, add these letters to the base part number.41.131COLOURPorcelain BrownPainted Wrought IronFINISH- N- WIW415-0762 / B / 11.12.10
Change language