Manual - Pine Tree Stove Shoppe

More documents

Recommendations

Info

103.4 FLOOR PROTECTIONIf the appliance is to be installed on top of a combustible fl oor, it must be placed on an approved non-combustiblehearth pad, that extends 8” beyond the appliance sides and back and 18” to the front. The reduced clearancefrom the back of the appliance may result in the appliance pad terminating shorter than 8” beyond theappliance.JKIJMINIMUM FLOOR PROTECTIONFRONT (I) SIDES (J) BACK (K)CANADA 18” 8” 8”USA 16” 8” 8”NOTE: If a section of horizontal chimney connector is used, floor protection isrequired under the chimney connector and 2” beyond each side.3.5 OUTSIDE AIR! WARNINGIF ROOM AIR STARVATION OCCURS BECAUSE THE FRESH AIR INTAKE IS BLOCKED WITH ICE,LEAVES, ETC., OR BECAUSE THE APPLIANCE DOOR WAS LEFT OPEN, OR DUE TO A STRONGEXHAUST FAN OPERATING ETC., DANGEROUS FUMES AND SMOKE FROM THE OPERATING APPLI-ANCE COULD BE DRAWN INTO THE ROOM.The following are signs that a outside air kit may be required:• When there is combustion present: Wood burns poorly, smoke spills, back-draft takes place and yourchimney does not draw steadily.• In the winter there is too much condensation on the windows.• Opening a window seems to alleviate the above symptoms.• A ventilation system is installed in the house.• Other devices are present that exhaust house air.• The house has tight fi tting windows and/or is equipped with a well-sealed vapour barrier.A. Connection from the appliance’s air intake to the outside ismandatory in mobile homes only, either through a hole in thewall or through the hole in the fl oor to line up with the knock outin the leg model or the hole in the pedestal base.B. Use a fresh air kit. Secure the aluminum liner by fl aring the endonce it is inserted through the hole in the base of the leg orpedestal model. If the air intake is through the fl oor, the hole inthe pedestal back must be covered with sheet metal to avoidcold air spillage into the room. A cover plate is available fromyour Wolf Steel Ltd. dealer. Avoid cutting away fl oor joists, wallstuds, electrical wires or plumbing. Seal around the outside pipewith insulation to prevent drafts.C. Attach the rear knockout plate (located inside the ash pan forshipping purposes).W415-0762 / B / 11.12.10
113.6 MOBILE HOME! WARNINGDO NOT INSTALL IN SLEEPING ROOM.THE STRUCTURAL INTEGRITY OF THE MOBILE HOME FLOOR, WALL AND CEILING/ROOF MUST BEMAINTAINED.THE APPLIANCE MUST BE PROVIDED WITH OUTSIDE COMBUSTION AIR.THE APPLIANCE MUST BE BOLTED TO THE FLOOR.INSTALL ACCORDING TO 24 CFR, PART 3280 (HUD).USE A CHIMNEY CERTIFIED FOR WOOD BURNING UL 103 S629, TYPE HT (2100°F).MODEL 1100PL, 1100C, 1400PL, and 1400C ARE APPROVED FOR INSTALLATION IN MOBILE HOMESIN THE UNITED STATES ONLY.For specifi c clearances, see “MINIMUMCLEARANCES TO COMBUSTIBLES” section.The appliance must be installed between ceilingjoists, with radiation shield and roof fl ashing, so thatthe structural strength, insulation and waterproofqualities of the home are not lessened. Seal withsilicone to maintain a vapour barrier at the chimneyand outside air pipe penetrations.RAIN CAPMOBILE HOMEROOF FLASHINGRADIATION SHIELDCEILING SUPPORTTRIM COLLARREMOVE TOALLOW FORTRANSPORATIONAPPLIANCEBOLTED TO FLOORHEARTH PADOUTSIDE AIR CONNECTIONTHROUGH WALL OR FLOORW415-0762 / B / 11.12.10
Page 1 and 2: INSTALLER: LEAVE THIS MANUAL WITH T
Page 3 and 4: 31.0 INSTALLATION OVERVIEW1400PL IL
Page 5 and 6: 52.1 DIMENSIONSBCADE1400PL ILLUSTRA
Page 7 and 8: 2.4 GENERAL INFORMATION! WARNINGDO
Page 9: 93.0 PRE-INSTALLATION PREPARATION3.
Page 13 and 14: 4.1 CHIMNEY! WARNINGNEVER INSTALL A
Page 15 and 16: 154.1.2 ADDING SECTIONSAdd chimney
Page 17 and 18: 174.1.4 TYPICAL THROUGH THE WALLIf
Page 19 and 20: 195.0 FINISHING5.1 LEG INSTALLATION
Page 21 and 22: 215.6 BRICKS AND BAFFLES INSTALLATI
Page 23 and 24: 237.0 OPERATION! WARNINGALWAYS OPER
Page 25 and 26: 257.3 LIGHTING A FIRE7.3.1 FLASH FI
Page 27 and 28: 278.3 RUNAWAY OR CHIMNEY FIREA CHIM
Page 29 and 30: 8.7 CARE OF GLASSIf the glass is no
Page 31 and 32: 9.0 REPLACEMENTSContact your dealer
Page 33 and 34: 3310.0 TROUBLE SHOOTING! WARNINGTUR
Page 35 and 36: 3512.0 SERVICE HISTORY43.1W415-0762

Manual - Pine Tree Stove Shoppe

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?