I&O Manual - Solaris Water Heaters - Categories On Thermal ...
I&O Manual - Solaris Water Heaters - Categories On Thermal ... I&O Manual - Solaris Water Heaters - Categories On Thermal ...
12KeyNo.Manifold Orifice AssemblyDescriptionWater HeaterModelSOL-5001 Manifold Orifice Assembly 812SOL05002a Natural Gas Prejet812SOL00342b Liquid Propane (LP) Gas Prejet 812SOL0001Figure 28: Manifold Orifice Assembly62
678513234Heat Exchanger Assembly (SOL-500)Key No. Description QuantityPart NumberSOL-5001 Heat Exchanger 1 603SOL05102 Immersion Well 2 801604563 Inlet/Outlet Temp. Sensor 2 801SOL00104A Temp/Pressure Gauge 0-100PSI 1 103470-014B Temp/Pressure Gauge 0-200PSI 1 103470-024C Temp/Pressure Gauge 0-250PSI 1 103470-035 Water Flow Switch 1 801601756 Center Tube Baffles 8 718SOL05197 Front Tube Baffle 1 102269-028 Rear Tube Baffle 1 102270-02Figure 29: Heat Exchanger Assembly (SOL-500)63
- Page 12 and 13: 12Figure 4: Recommended Separate Ho
- Page 14 and 15: E. Optional Separate Horizontal Ven
- Page 16 and 17: SEE TABLE 0Figure 8: Separate Horiz
- Page 18 and 19: 18Figure 9: Vertical Vent Installat
- Page 20 and 21: IV. Water Piping and Trim1. WATER T
- Page 22 and 23: escape of air trapped in the water
- Page 24 and 25: 24Figure 13: Safety & Drain Valve I
- Page 26 and 27: Table 5: Maximum Capacity of Schedu
- Page 28 and 29: SolarisLadder DiagramNOTES:1. IF LO
- Page 30 and 31: VII. Modular InstallationA. General
- Page 32 and 33: Figure 17: Modular Water heater Con
- Page 34 and 35: VIII. System Start-upA. Safe operat
- Page 36 and 37: FOR YOUR SAFETY READ BEFORE OPERATI
- Page 38 and 39: Figure 22: SOL500-1500 Pilot Valve1
- Page 40 and 41: Secondsfor OneRevolutionTable 7:
- Page 42 and 43: A. General Guidelines1. A thorough
- Page 44 and 45: I. Check Combustion and Safety Cont
- Page 46 and 47: C. Trouble Shooting GuideAlarm Mess
- Page 48 and 49: X. Thermal Solutions Water heater C
- Page 50 and 51: Label 101175-04RJ-11(6 pin)Boiler P
- Page 52 and 53: D. SETUP MENUDisplayWWSDLL StartTri
- Page 54 and 55: E. Boiler Configuration MenuDisplay
- Page 56 and 57: G. Setpoints MenuDisplayOperational
- Page 58 and 59: XI. Repair PartsAll Solaris ® Seri
- Page 60 and 61: 63159847311SIDE VIEW OFGAS VALVE102
- Page 64 and 65: 6 59738412Key No. Description Quant
- Page 66 and 67: SERVICE RECORDDateService Performed
- Page 68: LIMITED WARRANTYSubject to the term
678513234Heat Exchanger Assembly (SOL-500)Key No. Description QuantityPart NumberSOL-5001 Heat Exchanger 1 603SOL05102 Immersion Well 2 801604563 Inlet/Outlet Temp. Sensor 2 801SOL00104A Temp/Pressure Gauge 0-100PSI 1 103470-014B Temp/Pressure Gauge 0-200PSI 1 103470-024C Temp/Pressure Gauge 0-250PSI 1 103470-035 <strong>Water</strong> Flow Switch 1 801601756 Center Tube Baffles 8 718SOL05197 Front Tube Baffle 1 102269-028 Rear Tube Baffle 1 102270-02Figure 29: Heat Exchanger Assembly (SOL-500)63