I&O Manual - Solaris Water Heaters - Categories On Thermal ...

More documents

Recommendations

Info

12KeyNo.Manifold Orifice AssemblyDescription<strong>Water</strong> HeaterModelSOL-5001 Manifold Orifice Assembly 812SOL05002a Natural Gas Prejet812SOL00342b Liquid Propane (LP) Gas Prejet 812SOL0001Figure 28: Manifold Orifice Assembly62
678513234Heat Exchanger Assembly (SOL-500)Key No. Description QuantityPart NumberSOL-5001 Heat Exchanger 1 603SOL05102 Immersion Well 2 801604563 Inlet/Outlet Temp. Sensor 2 801SOL00104A Temp/Pressure Gauge 0-100PSI 1 103470-014B Temp/Pressure Gauge 0-200PSI 1 103470-024C Temp/Pressure Gauge 0-250PSI 1 103470-035 <strong>Water</strong> Flow Switch 1 801601756 Center Tube Baffles 8 718SOL05197 Front Tube Baffle 1 102269-028 Rear Tube Baffle 1 102270-02Figure 29: Heat Exchanger Assembly (SOL-500)63
Page 1 and 2:
INSTALLATION, OPERATING ANDSERVICE
Page 3 and 4:
WARNINGThis water heater requires r
Page 5 and 6:
WaterheaterModelNumberINPUT(MBH)GRO
Page 7 and 8:
5. For water heater located in an u
Page 9 and 10:
B. General Guidelines1. Vent system
Page 12 and 13: 12Figure 4: Recommended Separate Ho
Page 14 and 15: E. Optional Separate Horizontal Ven
Page 16 and 17: SEE TABLE 0Figure 8: Separate Horiz
Page 18 and 19: 18Figure 9: Vertical Vent Installat
Page 20 and 21: IV. Water Piping and Trim1. WATER T
Page 22 and 23: escape of air trapped in the water
Page 24 and 25: 24Figure 13: Safety & Drain Valve I
Page 26 and 27: Table 5: Maximum Capacity of Schedu
Page 28 and 29: SolarisLadder DiagramNOTES:1. IF LO
Page 30 and 31: VII. Modular InstallationA. General
Page 32 and 33: Figure 17: Modular Water heater Con
Page 34 and 35: VIII. System Start-upA. Safe operat
Page 36 and 37: FOR YOUR SAFETY READ BEFORE OPERATI
Page 38 and 39: Figure 22: SOL500-1500 Pilot Valve1
Page 40 and 41: Secondsfor OneRevolutionTable 7:
Page 42 and 43: A. General Guidelines1. A thorough
Page 44 and 45: I. Check Combustion and Safety Cont
Page 46 and 47: C. Trouble Shooting GuideAlarm Mess
Page 48 and 49: X. Thermal Solutions Water heater C
Page 50 and 51: Label 101175-04RJ-11(6 pin)Boiler P
Page 52 and 53: D. SETUP MENUDisplayWWSDLL StartTri
Page 54 and 55: E. Boiler Configuration MenuDisplay
Page 56 and 57: G. Setpoints MenuDisplayOperational
Page 58 and 59: XI. Repair PartsAll Solaris ® Seri
Page 60 and 61: 63159847311SIDE VIEW OFGAS VALVE102
Page 64 and 65: 6 59738412Key No. Description Quant
Page 66 and 67: SERVICE RECORDDateService Performed
Page 68: LIMITED WARRANTYSubject to the term
show all

I&O Manual - Solaris Water Heaters - Categories On Thermal ...

Create successful ePaper yourself

Delete template?

Save as template?