I&O Manual - Solaris Water Heaters - Categories On Thermal ...

More documents

Recommendations

Info

63159847311SIDE VIEW OFGAS VALVE102 260Figure 27: Gas Train (SOL-500 )(Reference Table 8)
KeyNo. DescriptionGas Trains: Reference Figure 27(Quantity)Part NumberSOL-5001 Main Gas Valve Body (1)816SOL051023Main Gas Valve Flange(s) 3/4” NPT —Main Gas Valve Flange(s) 1” NPT(2) 816SOL0503Main Gas Valve Flange(s) 1-1/4” NPT —Main Gas Valve Flange(s) 1-1/2” NPT —Manual Gas Valve 1” NPT(2) 816SOL0015Manual Gas Valve 1-1/4” NPT —Manual Gas Valve 1-1/2” NPT —4 Pilot Gas Valve (1) 816SOL05015 Pilot Gas Valve Flange 1/2” NPT (1) 816SOL05026 Manual Gas Valve 1/2” NPT (1) 816SOL00107 Insulation Grommet (1) 820SOL00018 High Gas Pressure Switch (Optional) (1) 801SOL00069 Low Gas Pressure Switch (Optional) (1) 801SOL000510 G18 Test Nipple (2) 816SOL000111 Hose Barb (2) 816SOL0002Table 8: Gas Train Components61
Page 1 and 2:
INSTALLATION, OPERATING ANDSERVICE
Page 3 and 4:
WARNINGThis water heater requires r
Page 5 and 6:
WaterheaterModelNumberINPUT(MBH)GRO
Page 7 and 8:
5. For water heater located in an u
Page 9 and 10: B. General Guidelines1. Vent system
Page 12 and 13: 12Figure 4: Recommended Separate Ho
Page 14 and 15: E. Optional Separate Horizontal Ven
Page 16 and 17: SEE TABLE 0Figure 8: Separate Horiz
Page 18 and 19: 18Figure 9: Vertical Vent Installat
Page 20 and 21: IV. Water Piping and Trim1. WATER T
Page 22 and 23: escape of air trapped in the water
Page 24 and 25: 24Figure 13: Safety & Drain Valve I
Page 26 and 27: Table 5: Maximum Capacity of Schedu
Page 28 and 29: SolarisLadder DiagramNOTES:1. IF LO
Page 30 and 31: VII. Modular InstallationA. General
Page 32 and 33: Figure 17: Modular Water heater Con
Page 34 and 35: VIII. System Start-upA. Safe operat
Page 36 and 37: FOR YOUR SAFETY READ BEFORE OPERATI
Page 38 and 39: Figure 22: SOL500-1500 Pilot Valve1
Page 40 and 41: Secondsfor OneRevolutionTable 7:
Page 42 and 43: A. General Guidelines1. A thorough
Page 44 and 45: I. Check Combustion and Safety Cont
Page 46 and 47: C. Trouble Shooting GuideAlarm Mess
Page 48 and 49: X. Thermal Solutions Water heater C
Page 50 and 51: Label 101175-04RJ-11(6 pin)Boiler P
Page 52 and 53: D. SETUP MENUDisplayWWSDLL StartTri
Page 54 and 55: E. Boiler Configuration MenuDisplay
Page 56 and 57: G. Setpoints MenuDisplayOperational
Page 58 and 59: XI. Repair PartsAll Solaris ® Seri
Page 62 and 63: 12KeyNo.Manifold Orifice AssemblyDe
Page 64 and 65: 6 59738412Key No. Description Quant
Page 66 and 67: SERVICE RECORDDateService Performed
Page 68: LIMITED WARRANTYSubject to the term
show all

I&O Manual - Solaris Water Heaters - Categories On Thermal ...

Create successful ePaper yourself

Delete template?

Save as template?