I&O Manual - Solaris Water Heaters - Categories On Thermal ...
I&O Manual - Solaris Water Heaters - Categories On Thermal ... I&O Manual - Solaris Water Heaters - Categories On Thermal ...
XI. Repair PartsAll Solaris ® Series Repair Parts may be obtained through your local Thermal Solutionsrepresentative. Should you require assistance in locating a Thermal Solutions representative inyour area, or have questions regarding the availability of Thermal Solutions products or repair parts,please contact Thermal Solutions Customer Service at (717) 239-7642 or Fax (877) 501-5212.627910758431Figure 25: Combustion ChamberKeyNo. Description Part Number1. Combustion Chamber SOL-5001 Base/Bottom Panel 618SOL05042 Left Side Panel Assembly 618SOL00213 Right Side Panel Assembly 618SOL00314 Air Box Cover 718SOL05035 Air Box Assembly 618SOL050516 Canopy Assembly 618SOL05107 Side Insulation 820SOL00208 Front Insulation 820SOL05039 Bottom Insulation 820SOL050010 Back Insulation 820SOL050258
3142Figure 26: Burner TrayKeyNo. Description Part NumberQuantityPer Model1. Burner Tray SOL-5001 3 Burner Assembly 102017-01 22 Ignitor Assembly 812SOL0010 13 Gasket, Burner Mounting Plate 820SOL0004 24 Gasket, Ignitor Assembly 820SOL0005 159
- Page 7 and 8: 5. For water heater located in an u
- Page 9 and 10: B. General Guidelines1. Vent system
- Page 12 and 13: 12Figure 4: Recommended Separate Ho
- Page 14 and 15: E. Optional Separate Horizontal Ven
- Page 16 and 17: SEE TABLE 0Figure 8: Separate Horiz
- Page 18 and 19: 18Figure 9: Vertical Vent Installat
- Page 20 and 21: IV. Water Piping and Trim1. WATER T
- Page 22 and 23: escape of air trapped in the water
- Page 24 and 25: 24Figure 13: Safety & Drain Valve I
- Page 26 and 27: Table 5: Maximum Capacity of Schedu
- Page 28 and 29: SolarisLadder DiagramNOTES:1. IF LO
- Page 30 and 31: VII. Modular InstallationA. General
- Page 32 and 33: Figure 17: Modular Water heater Con
- Page 34 and 35: VIII. System Start-upA. Safe operat
- Page 36 and 37: FOR YOUR SAFETY READ BEFORE OPERATI
- Page 38 and 39: Figure 22: SOL500-1500 Pilot Valve1
- Page 40 and 41: Secondsfor OneRevolutionTable 7:
- Page 42 and 43: A. General Guidelines1. A thorough
- Page 44 and 45: I. Check Combustion and Safety Cont
- Page 46 and 47: C. Trouble Shooting GuideAlarm Mess
- Page 48 and 49: X. Thermal Solutions Water heater C
- Page 50 and 51: Label 101175-04RJ-11(6 pin)Boiler P
- Page 52 and 53: D. SETUP MENUDisplayWWSDLL StartTri
- Page 54 and 55: E. Boiler Configuration MenuDisplay
- Page 56 and 57: G. Setpoints MenuDisplayOperational
- Page 60 and 61: 63159847311SIDE VIEW OFGAS VALVE102
- Page 62 and 63: 12KeyNo.Manifold Orifice AssemblyDe
- Page 64 and 65: 6 59738412Key No. Description Quant
- Page 66 and 67: SERVICE RECORDDateService Performed
- Page 68: LIMITED WARRANTYSubject to the term
3142Figure 26: Burner TrayKeyNo. Description Part NumberQuantityPer Model1. Burner Tray SOL-5001 3 Burner Assembly 102017-01 22 Ignitor Assembly 812SOL0010 13 Gasket, Burner Mounting Plate 820SOL0004 24 Gasket, Ignitor Assembly 820SOL0005 159