MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

(0.04695ug/m 3 ), SO 2 (0.01485ug/m 3 ) and NOx (0.02731ug/m 3 ).Cyclone separatorfollowed by bagfilter alongwith stack (30m) will be provided to proposed agro waste firedboiler. Scrubbing arrangement will be provided to Incinerator. Solvent will be recovered.Total fresh water requirement will be increased from 16 m 3 /day to 176 m 3 /dayafter expansion and met from ground water. The total wastewater generation will beincreased from 5.7 m 3 /day to121m 3 /day and out of which, industrial wastewatergeneration will be increased from 3.8 m 3 /day to 121 m 3 /day. Industrial effluent will besegregated into high COD, high TDS and low COD/TDS effluent streams. High CODeffluent stream will be incinerated. High TDS effluent will be treated through RO. LowCOD/TDS effluent will treated in ETP. Committee advised them that high TDS effluentshould be treated with steam stripper before sending through the RO. Rejects from ROshould be evaporated in MEE. Treated effluent will be recycled and reused with factorypremises. No additional treated effluent will be sent to CETP of M/s ECPL.However,effluent (3.8 m3/day) generated from the existing unit will be sent to CETP of M/s EICL,Umaraya. Sewage will be treated through septic tank and soak pit.ETP sludge will be sent to TSDF, NECL. Spent solvent and process waste will besent for incineration of CHWI, NECL. Used oil will be sold to registered re-processor.Discarded containers will be sold to GPCB authorized dealer after decontamination. Acopy of membership of TSDF operated by M/s Nandesari Environmental Control Ltd. issubmitted. Green belt will be developed in 2,460 m 2 , out of 7,670 m 2 total land. Powerrequirement (100 KW) will be met from GEB. Agro waste consumption will be increasedfrom 0.7 TPD to2.8 TPD. DG set (125 KVA) will be installed as standby.The Committee deliberated upon the issues raised during the Public Hearing /Public Consultation meeting conducted by the Gujarat Pollution Control Board on 2 ndMarch, 2012. The issues raised during public hearing were water consumption and itssource, use of rainwater harvesting, fire station, use surface water instead of Narmadawater, ETP capacity, local employment, proper chemical storage etc.In response, projectproponent informed that ETP of capacity 113 m3/day will be installed to cater additionaleffluent load. Treated water will be recycled/ reused. Air pollution control device will beinstalled. Employment would be mostly given to locals as in the existing unit and trainingwould be provided for the same and have satisfactorily been responded by the projectproponent and incorporated in the final EIA/EMP report.After deliberations, the Committee desired following additional information:1. Recommendation on project proposal from Gujarat Pollution Control Board to besubmitted.2. Revised effluent treatment scheme considering entire plant zero discharge.3. Detailed specification of incinerator.The proposal is deferred till the desired information is submitted. The aboveinformation shall be provided with the uploading of minutes on the website.2.5.4. Single Super Phosphate (Powder & Granular, 1500 MTPD), N 2 SiF6, 130 MTPD),NPK Fertilizer (Powder & Granular, 500 MTPD), LABASA (500 MTPD), BenzeneSulphonyl Chooride (20 MTPD), Sulphone (1.26 MTPD) at Sy. No. 525, 532, 554-
556, 560, 561/1, Village Dudhwada, Tehsil Padra, District Vadodara, Gujarat by M/sBodal Agrotech Ltd (TOR to EC).EIA/EMP report was prepared by M/s Ramans Enviro Services Pvt. Ltd andEQMS India Pvt. Ltd. While presenting their case before the Committee, representativeof M/s EQMS India Pvt. Ltd informed that he has not gone through the EIA/EMP report.After deliberations, the Committee desired following:1. To revalidate the entire EIA/EMP report by the QCI/NABET accredited and sectorspecific Consultants.2. Recommendation on project proposal from Gujarat Pollution Control Board to besubmitted.The proposal is deferred till the desired information is submitted.2.5.5. Exploratory Drilling of Oil and Gas in 13 Wells in Onshore Block CB-ONN-2009/8(136 sq.km), at Dholka and Khambhat, District Ahmedabad and Anand, Gujarat byM/s Jay Polychem (India) Ltd. (TOR to EC).The project authorities and their consultant (Kadam EnvironmentalConsultants)gave a detailed presentation on the salient features of the project andproposed environmental protection measures to be undertaken as per Draft Terms ofReferences (TORs) awarded during the 23 rd Meeting of the Expert Appraisal Committee(Industry) held during 30 th – 31 st May, 2011 for preparation of EIA/EMP.All the Offshoreand Onshore Drilling projects are listed at S.N. 15(b) under Category ‘A’ and appraisedat the Central level.M/s Jay Polychem (India) Ltd. have proposed for the Exploratory Drilling of Oiland Gas in 13 Wells in Onshore Block CB-ONN-2009/8 (136 sq.km), at Dholka andKhambhat, District Ahmedabad and Anand, Gujarat. Exploration contract was awardedwas signed on 30 th June, 2010. Petroleum Exploration License (PEL) awarded by theGovernment of India to start exploration activities to M/s Jay Polychem (India) Ltd on22 nd October, 2010. 13 exploratory wells are proposed for drilling. Total project area of13 Blocks is 136 sq. km. Nearest town is Dholka (5.5 km) and Ahmedabad (35.5 km). .Sabarmati River is passing through the block area, which is 0.5 Km and 1.7 Km awayfrom B well and Kheda well respectively. Vatrake River is at 6 km. Project cost is USD13 Million (for 13 wells). Rs. 58.50 Lakhs/well is earmarked for expenditure onenvironmental matters. No national park/ wildlife sanctuary/eco sensitive area is locatedwithin 10 km. Sabarmati river passes through the SE edge of the block. Exploration workin the block was originally carried out by the ONGC and subsequently by GSPCL. Coordinatesof the blocks are:Point Longitude LatitudeDeg. Min. Sec. Deg. Min. Sec.A. 72 20 13.82 22 40 30.35B 72 24 47.22 22 40 30.35C 72 29 16.38 22 40 34.6D 72 29 12.5 22 39 14.9D 72 27 41.0 22 39 13
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17:
Ministry’s Regional Office at Ban
Page 18 and 19:
iv.Secondary fugitive emissions sha
Page 20 and 21:
EIA/EMP. Leather/skin/hide processi
Page 22 and 23:
By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25:
y M/s K. P. R. Industries (India) L
Page 26 and 27:
chlorine storage area shall be prov
Page 28 and 29:
ii.Bag filter alongwith stack of ad
Page 30 and 31:
Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 48 and 49: project will be 56.51 MW, which wil
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 66 and 67: v) Total fresh water requirement fr
Page 68 and 69: 5. Cathodic protection shall be pro
Page 70 and 71: SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73: 35. Ground water monitoring minimum
Page 75 and 76: 2.4.8. Proposed Integrated Cement P
Page 77 and 78: vii) As proposed, Industrial efflue
Page 79 and 80: After detailed deliberations, the C
Page 81: Solvent red 135Solvent red168Solven
Page 85 and 86: 22 nd March, 2012 for Anand distric
Page 87 and 88: xviii. In case the commercial viabi
Page 89 and 90: SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92: eneficial purposes. Domestic efflue
Page 93 and 94: Distillery Units are listed at S.N.
Page 95 and 96: during rainy season by flowing alon
Page 97 and 98: i. Distillery unit should be based
Page 99 and 100: Chemicals Industry (Bulk Drugs & In
Page 101 and 102: vi)Trade effluent should be segrega
Page 103 and 104: PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106: xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108: 2.5.14. Setting up of Di-methyl Sul
Page 109 and 110: concerned Authority and a copy subm
Page 111 and 112: viii. All the issues raised during
Page 113 and 114: 2.5.17. Manufacture of Phenol Forma
Page 115 and 116: ix)Green belt should be developed i
Page 117 and 118: v. The company should make the arra
Page 119 and 120: xxvi.xxvii.Company should have own
Page 121 and 122: xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124: Water based drilling fluid will be
Page 125 and 126: vii.viii.ix.The company should cons
Page 127 and 128: awarded during the 18 th Meeting of
Page 129 and 130: iii.iv.Water based drilling mud sho
Page 131 and 132: ‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?