MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

v) Total fresh water requirement from Gujarat Water Infrastructure Limited should notexceed 1520 m 3 /day and prior permission should be obtained from the concernedAuthority.vi)vii)Industrial effluent shall not exceed 336 m 3 /day. As proposed, Process effluent fromvenyl sulphone after recovery of sodium sulphate shall be sent to incinerator. HighTDS effluent stream should be passed through stripper followed by MEE.Condensate and low COD/Low TDS effluent stream should be treated in ETP.Treated water shall be recycled/reused within factory premises. ‘Zero’ effluentdischarge should be adopted and no effluent will be discharged outside thepremises.All the solvent storage tanks should be connected with vent condensers withchilled brine circulation.viii)ix)As proposed, high calorific value waste should be sent to cement industries. ETPsludge, process inorganic, evaporation salt and incinerator salt should be disposedoff to the TSDF. The fly ash from boiler should be sold to brickmanufacturers/cement industry.Incinerator alongwith its pollution control device shall be designed as per CPCBguidelines.x) The company should obtain Authorization for collection, storage and disposal ofhazardous waste under the Hazardous Waste (Management, Handling and Trans-Boundary Movement) Rules, 2008 and amended as on date for management ofHazardous wastes and prior permission from GPCB should be obtained fordisposal of solid / hazardous waste in the TSDF. Measures should be taken forfire-fighting facilities in case of emergency.xi) Solvent management should be as follows :‣ Reactor should be connected to chilled brine condenser system‣ Reactor and solvent handling pump should have mechanical seals to preventleakages.‣ The condensers should be provided with sufficient HTA and residence time so asto achieve more than 95% recovery‣ Solvents should be stored in a separate space specified with all safety measures.‣ Proper earthing should be provided in all the electrical equipment wherever solventhandling is done.‣ Entire plant where solvents are used should be flame proof. The solvent storagetanks should be provided with breather valve to prevent losses.xv)As proposed, green belt should be developed in 33% of the total plant area.xvi) Occupational health surveillance of the workers should be done on a regular basisand records maintained as per the Factories Act.xvii) All the commitments made to the public during public hearing/public consultationmeeting held on 1 st February, 2011 should be satisfactorily implemented andadequate budget provision should be made accordingly.
2.3.8. Pesticide Manufacturing Unit at K-2/1/1, Additional MIDC, Taluka Mahal, DistrictRaigad, Maharashtra by M/s Astec Life Science Ltd. (TOR to EC).Project proposal was considered in the 36 th Expert Appraisal Committee(Industry-2) meeting held during 11 th – 12 th June, 2012and the Committee desiredfollowing information:1. VOC in the ambient air to be monitored.2. Odour control scheme to be provided.3. Effluent treatment scheme based on segregation of effluent into high TDS, highCOD and low COD/TDS effluent streams.4. Reassess hazardous waste generation and its management.5. Details of incinerator.Project proponent vide letter dated 29th August, 2012 submitted abovementioned additional information.After detailed deliberations, the Committee found the submitted additionalInformation satisfactory and suggested to stipulate following specific conditionsalongwith other environmental conditions while considering for accord of environmentalclearance:i. National Emission Standards for Pesticide Manufacturing and Formulation Industryissued by the Ministry vide G.S.R. 46(E) dated 3 rd February, 2006 and amended timeto time shall be followed by the unit.ii.iii.Bag filter alongwith adequate stack height shall be provided to coal fired boiler tocontrol the particulate matter emissions within 50 mg/m 3 .Two stage scrubbing system shall be provided to process vent to control HCNemissions. The scrubbed water shall be sent to ETP for further treatment. Efficiencyof scrubber shall be monitored regularly and maintained properly. Scrubbers ventshall be provided with on-line detection and alarm system to indicate higher thanpermissible value of controlled parameters. At no time, the emission levels shall gobeyond the prescribed standards. The system shall be interlocked with the pollutioncontrol equipments so that in case of any increase in pollutants beyond permissiblelimits, plant shall be automatically stopped. Stack monitoring shall be done regularlyand report shall be submitted to Maharashtra Pollution Control Board (MPCB) andthe Ministry’s regional office at Bhopal.iv. For further control of fugitive emissions, following steps shall be followed :1. Closed handling system shall be provided for chemicals.2. Reflux condenser shall be provided over reactor.3. System of leak detection and repair of pump/pipeline based on preventivemaintenance.4. The acids shall be taken from storage tanks to reactors through closedpipeline. Storage tanks shall be vented through trap receiver and condenseroperated on chilled water.
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17: Ministry’s Regional Office at Ban
Page 18 and 19: iv.Secondary fugitive emissions sha
Page 20 and 21: EIA/EMP. Leather/skin/hide processi
Page 22 and 23: By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25: y M/s K. P. R. Industries (India) L
Page 26 and 27: chlorine storage area shall be prov
Page 28 and 29: ii.Bag filter alongwith stack of ad
Page 30 and 31: Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 48 and 49: project will be 56.51 MW, which wil
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 68 and 69: 5. Cathodic protection shall be pro
Page 70 and 71: SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73: 35. Ground water monitoring minimum
Page 75 and 76: 2.4.8. Proposed Integrated Cement P
Page 77 and 78: vii) As proposed, Industrial efflue
Page 79 and 80: After detailed deliberations, the C
Page 81 and 82: Solvent red 135Solvent red168Solven
Page 83 and 84: 556, 560, 561/1, Village Dudhwada,
Page 85 and 86: 22 nd March, 2012 for Anand distric
Page 87 and 88: xviii. In case the commercial viabi
Page 89 and 90: SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92: eneficial purposes. Domestic efflue
Page 93 and 94: Distillery Units are listed at S.N.
Page 95 and 96: during rainy season by flowing alon
Page 97 and 98: i. Distillery unit should be based
Page 99 and 100: Chemicals Industry (Bulk Drugs & In
Page 101 and 102: vi)Trade effluent should be segrega
Page 103 and 104: PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106: xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108: 2.5.14. Setting up of Di-methyl Sul
Page 109 and 110: concerned Authority and a copy subm
Page 111 and 112: viii. All the issues raised during
Page 113 and 114: 2.5.17. Manufacture of Phenol Forma
Page 115 and 116: ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

Create successful ePaper yourself

Delete template?

Save as template?