MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

project will be 56.51 MW, which will be sourced from the Captive Power Plant (40 MW),WHRB (2X9 MW) and AVVNL (Ajmer Vidyut Vitran Nigam Ltd.). Additional D.G Set of 5MW is proposed for emergency.All major sources of air pollution of cement plant will be provided with BagHouses/Bag filters, ESPs to maintain the PM emission level below 50 mg/Nm 3 .Particulate emissions of CPP (WHRB) will be controlled with ESPs to maintain the PMemission level below 100 mg/Nm 3 . All material transfer points will be provided with bagfilters to entrap the emissions at the source itself. Clinker & fly ash will be stored in siloand gypsum in covered yard. Total fresh water requirement is 6,244 KLD (Existing 2,571KLD & Additional 3,673 KLD), which will be met from the ground water, mine sump water& Gambhiri Reservoir. No industrial wastewater will be generated in the Cement Plant.Domestic wastewater generated from Cement Plant/Colony will be treated in the existingSTP. The treated water will be utilized for greenbelt development/horticulture activities.Rain water harvesting is also proposed. No solid waste will be generated in cementmanufacturing process. Fly ash from CPP will be utilized for manufacture of cement.Dust collected from various pollution control equipments will be recycled back to theprocess. STP Sludge will be utilized as manure for green belt development within theplant premises.After detailed deliberations, the Committee prescribed following TORs forundertaking detailed EIA/EMP study:1. Executive summary of the project2. Photographs of the existing and proposed plant area.3. Copies of coal linkage documents4. Compliance to the conditions stipulated in the Environmental Clearance / NOCgranted by the SPCB.5. A certified report of the status of compliance of the conditions stipulated in theenvironmental clearance and Consent to Operate for the ongoing I existingoperation of the project by the Regional Office of the Ministry of Environment andForests and SPCB.6. Recent monitoring report from SPCB, which shall include data on AAQ, waterquality, solid waste etc. shall be submitted.7. Has the unit received any notice under the Section 5 of Environment (Protection)Act, 1986 or relevant Sections of Air and Water Acts? If so, compliance to thenotice(s)8. A line diagram/flow sheet for the process and EMP9. The earlier questionnaire for industry sector should be submitted while submittingEIA/EMP.10. A site location map on Indian map of 1:10, 00,000 scale followed by1:50,000/1:25,000 scale on an A3/A2 sheet with at least next 10 Kms of terrainsi.e. circle of 10 kms and further 10 kms on A3/A2 sheets with properlongitude/latitude/heights with min. 100/200 m. contours should be included. 3-Dview i.e. DEM (Digital Elevation Model) for the area in 10 km radius from theproposal site.11. Present land use should be prepared based on satellite imagery. High-resolutionsatellite image data having 1m-5m spatial resolution like quickbird, Ikonos, IRSP-6 pan sharpened etc. for the 10Km radius area from proposed site. The sameshould be used for land used/land-cover mapping of the area.12. Break up of small, medium and large farmers from whom the land is beingacquired. If small farmers are involved, a detailed R&R plan.
13. Location of national parks / wildlife sanctuary / reserve forests within 10 km.radius should specifically be mentioned. A map showing land use / land cover,reserved forests, wildlife sanctuaries, national parks, tiger reserve etc. in 10 kmof the project site.14. Project site layout plan to scale using AutoCAD showing raw materials, fly ashand other storage plans, bore well or water storage, aquifers (within 1 km.)dumping, waste disposal, green areas, water bodies, rivers/drainage passingthrough the project site should be included.15. Details and classification of total land (identified and acquired) should beincluded.16. Proposal should be submitted to the Ministry for environment clearance only afteracquiring total land. Necessary documents indicating acquisition of land shouldbe included.17. Rehabilitation & Resettlement (R & R) should be as per policy of the State Govt.and a detailed action plan should be included.18. Permission and approval for the use of forest land and recommendations of theState Forest Department regarding impact of proposed expansion on thesurrounding reserve forests, if applicable, should be included.19. A list of industries containing name and type in 10 km radius shall beincorporated.20. Residential colony should be located in upwind direction.21. List of raw material required and source along with mode of transportation shouldbe included. All the trucks for raw material and finished product transportationmust be “Environmentally Compliant”.22. Petrological and Chemical analysis and other chemical properties of rawmaterials used (with GPS location of source of raw material) i.e. ores, minerals,rock, soil, coal, iron, dolomite quartz etc. using high definition and precisioninstruments mentioning their detection range and methodology such DigitalAnalyzers, AAS with Graphite furnace, ICPMS, MICRO-WDXRF, EPMA, XRD,Nano studies or at least as per I30-10500 and WHO norms. These analysisshould include trace element and metal studies like Cr (vi) Ni, Fe, As, Pb, Zn, Hg,Se, S etc. Presence of radioactive elements (U, Th etc.).23. Petrography, grain size analysis and Major element analysis of raw material andsoil from project site and raw material should be done on the same parametersalong with analysis for SiO 2 , Al 2 O 3 , MgO, MnO, K 2 O, CaO, FeO, Fe 2 O 3 , P 2 O 5 ,H 2 O, CO 2.24. If the rocks, ores, raw material has trace elements their petrography, oremicroscopy, XRD, elemental mapping EPMA, XRF is required to quantify theamount present in it and hence future risk involved while using it andmanagement plan.25. Studies for fly ash, muck disposal, slurry, sludge material and solid wastegenerated should also be included, if the raw materials used has trace elementsand a management plan.26. Manufacturing process details for all the cement plant, captive power plant andmine should be included.27. Possibility of installation of WHRB will be explored and details included28. Mass balance for the raw material and products should be included.29. Energy balance data for all the components including proposed power plantshould be incorporated.30. Site-specific micro-meteorological data using temperature, relative humidity,hourly wind speed and direction and rainfall should be collected.
Page 1: MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5: 5. Regular monitoring of influent a
Page 6 and 7: The revised draft EIA/EMP report sh
Page 8 and 9: vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11: 4. Secondary fugitive emissions fro
Page 12 and 13: µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15: permission for drawl of 16 MGD of w
Page 16 and 17: Ministry’s Regional Office at Ban
Page 18 and 19: iv.Secondary fugitive emissions sha
Page 20 and 21: EIA/EMP. Leather/skin/hide processi
Page 22 and 23: By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25: y M/s K. P. R. Industries (India) L
Page 26 and 27: chlorine storage area shall be prov
Page 28 and 29: ii.Bag filter alongwith stack of ad
Page 30 and 31: Points Latitude LongitudeA 23 o 12
Page 32 and 33: authorization or membership of TSDF
Page 34 and 35: proposed expansion is Rs.1, 663 Cro
Page 36 and 37: These analysis should include trace
Page 38 and 39: 49. A note on the impact of drawl o
Page 40 and 41: a language other than English, an E
Page 42 and 43: eserved forests, wildlife sanctuari
Page 44 and 45: 37. Impact of the transport of the
Page 46 and 47: 66. Impact of the project on local
Page 50 and 51: 31. Sources of secondary emissions,
Page 52 and 53: 59. All stock piles will have to be
Page 54 and 55: Grain size analysis of quartziteRev
Page 56 and 57: 1. Measures shall be taken to mitig
Page 58 and 59: On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 66 and 67: v) Total fresh water requirement fr
Page 68 and 69: 5. Cathodic protection shall be pro
Page 70 and 71: SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73: 35. Ground water monitoring minimum
Page 75 and 76: 2.4.8. Proposed Integrated Cement P
Page 77 and 78: vii) As proposed, Industrial efflue
Page 79 and 80: After detailed deliberations, the C
Page 81 and 82: Solvent red 135Solvent red168Solven
Page 83 and 84: 556, 560, 561/1, Village Dudhwada,
Page 85 and 86: 22 nd March, 2012 for Anand distric
Page 87 and 88: xviii. In case the commercial viabi
Page 89 and 90: SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92: eneficial purposes. Domestic efflue
Page 93 and 94: Distillery Units are listed at S.N.
Page 95 and 96: during rainy season by flowing alon
Page 97 and 98: i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?