MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

preparation of EIA/EMP.All Synthetic Organic Chemicals Industry located inside thenotified industrial area/estate are listed at S.N. 5(f) under category ‘B’ and appraised atState level. However, applicability of general condition due to project location withininterstate boundary, proposal is treated as category ‘A’ and appraised at Central Level.M/s Shri Hap Chemicals Enterprises Pvt. Ltd. (Unit –II) has proposed forexpansion of Rubber Processing Chemicals at Plot No. A2/2225, 2226, Phase-III, GIDCVapi, Tehsil Pardi, District Valsad, Gujarat. Plant is located within the 10 Km of Unionterritory boundary i.e. Daman. No forest land is involved. No court case/ litigation ispending against the project. Plot area is 3602.48 m 2 . Total project cost is Rs 2.5 crores.Following products will be manufactured.S.N. Product Quantity (MTPM)Existing Additional After totalproposed proposedexpansion1 Rubber Processing Chemicals such asAccelerators75 350 425Adequated stack height is provided to gas fired boiler. Caustic scrubbing system isprovided to (Chlorination) process vent. Bagfilter is provided to dryer. Cyclone separatorfollowed by bagfilter is provided to grinder. For the proposed expansion, adequate stackheight will be provided to gas fired boiler. Caustic scrubbing system will be provided toprocess vent of chlorination. Ag filter will be provided to dryers. Cyclone separatoralongwith bagfilter will be provided to grinder. Fresh water consumption will be increasedfrom 55 m 3 /day to 286 m 3 /day after expansion. Industrial effluent generation will be 180m 3 /day and treated in ETP. Treated water will be discharged to CETP for furthertreatment and them to sea. ETP waste will be sent to TSDF. Used oil will be sent toauthorized recyclers/ re-processors. Power requirement will be 3000 KVA from GEB.Coal will be used as fuel.After detailed deliberations, the Expert Appraisal Committee prescribed thefollowing ToRs for preparation of EIA/EMP:1. Executive summary of the project2. Justification of the project.3. Project location and plant layout.4. Promoters and their back ground.5. Regulatory framework6. Environment clearance for the existing unit issued by the Ministry (reasons, if notobtained), Consent to Operate and Authorization accorded by the GPCB.7. Data for the stack emissions, fugitive emissions; water requirement and waterbalance chart; wastewater generation, treated effluent quality, re-utilization anddisposal of solid/hazardous waste for the existing unit.8. A map indicating location of the project and distance from severely polluted area9. A copy of Gazette Notification issued by the Govt. of Gujarat indicating locationof the project in notified GIDC should be included necessarily.10. Infrastructure facilities including power sources.11. Total cost of the project alongwith total capital cost and recurring cost/annum forenvironmental pollution control measures.
12. Project site location alongwith photographs of the project site and site map of 10km area and site details providing various industries, surface water bodies,forests etc.13. Present land use based on satellite imagery for the study area of 10 km radius.14. Location of National Park/Wild life sanctuary/Reserve Forest within 10 km radiusof the project.15. Details of the total land and break-up of the land use for green belt and otheruses.16. List of products alongwith the production capacities.17. Detailed list of raw material required and source, mode of storage andtransportation.18. Manufacturing process details alongwith the chemical reactions and process flowchart.19. Site-specific micro-meteorological data using temperature, relative humidity,hourly wind speed and direction and rainfall is necessary.20. Ambient air quality monitoring at 6 locations within the study area of 5 km., aerialcoverage from project site as per NAAQES notified on 16 th September, 2009.Location of one AAQMS in downwind direction.21. One season site-specific micro-meteorological data using temperature, relativehumidity, hourly wind speed and direction and rainfall and AAQ data (exceptmonsoon) for PM 10 , SO 2 , NOx including HC and VOCs should be collected. Themonitoring stations should take into account the pre-dominant wind direction,population zone and sensitive receptors including reserved forests. Data forwater and noise monitoring should also be included.22. Air pollution control measures proposed for the effective control of gaseousemissions within permissible limits.23. Name of all the solvents to be used in the process and details of solvent recoverysystem.24. Design details of ETP, incinerator, if any along with control of Dioxin & Furan,boiler, scrubbers/bag filters etc.25. Details of water and air pollution and its mitigation plan26. Action plan to control ambient air quality as per NAAQES Standards notified bythe Ministry on 16 th September, 2009.27. An action plan to control and monitor secondary fugitive emissions from all thesources.28. Determination of atmospheric inversion level at the project site and assessmentof ground level concentration of pollutants from the stack emission based on sitespecificmeteorological features. Air quality modelling for proposed plant.29. Permission for the drawl of 286 m 3 /day water from the concerned agency. Waterbalance chart including quantity of effluent generated recycled and reused anddischarged.30. Action plan for ‘Zero’ discharge of effluent should be included.31. Ground water quality monitoring minimum at 6 locations should be carried out.Geological features and Geo-hydrological status of the study area and ecologicalstatus (Terrestrial and Aquatic).32. The details of solid and hazardous wastes generation, storage, utilization anddisposal particularly related to the hazardous waste calorific value of hazardouswaste and detailed characteristic of the hazardous waste.33. Precautions to be taken during storage and transportation of hazardouschemicals should be clearly mentioned and incorporated.
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17:
Ministry’s Regional Office at Ban
Page 18 and 19:
iv.Secondary fugitive emissions sha
Page 20 and 21:
EIA/EMP. Leather/skin/hide processi
Page 22 and 23:
By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25:
y M/s K. P. R. Industries (India) L
Page 26 and 27:
chlorine storage area shall be prov
Page 28 and 29:
ii.Bag filter alongwith stack of ad
Page 30 and 31:
Points Latitude LongitudeA 23 o 12
Page 32 and 33:
authorization or membership of TSDF
Page 34 and 35:
proposed expansion is Rs.1, 663 Cro
Page 36 and 37:
These analysis should include trace
Page 38 and 39:
49. A note on the impact of drawl o
Page 40 and 41:
a language other than English, an E
Page 42 and 43:
eserved forests, wildlife sanctuari
Page 44 and 45:
37. Impact of the transport of the
Page 46 and 47:
66. Impact of the project on local
Page 48 and 49:
project will be 56.51 MW, which wil
Page 50 and 51:
31. Sources of secondary emissions,
Page 52 and 53:
59. All stock piles will have to be
Page 54 and 55:
Grain size analysis of quartziteRev
Page 56 and 57:
1. Measures shall be taken to mitig
Page 58 and 59:
On 17.6.2010, application was submi
Page 60 and 61:
6. Regular monitoring of influent a
Page 62 and 63:
2. Bag filter alongwith stack of ad
Page 64 and 65:
vii) All the solvent storage tanks
Page 66 and 67:
v) Total fresh water requirement fr
Page 68 and 69:
5. Cathodic protection shall be pro
Page 70 and 71:
SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154:
27. Action plan to control ambient
Page 155 and 156:
2.5.30. Expansion of Synthetic Orga
Page 157 and 158:
16. List of products alongwith the
Page 159 and 160:
i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178: 51. Public hearing to be conducted
Page 179 and 180: 20. Air pollution control measures
Page 181 and 182: The Committee decided that the prop
Page 183 and 184: 31. Treatment of phenol in the effl
Page 185 and 186: located outside the notified indust
Page 187 and 188: 38. Action plan for rainwater harve
Page 189 and 190: 11011/381/2006-IA II (I) dated 11 t
Page 191 and 192: e ground water. Oily effluent will
Page 193 and 194: xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196: with a capacity of 4.5 KL/day. No N
Page 197 and 198: to 90 % and will be sold as cattle
Page 199 and 200: xiv. Dedicated parking facility for
Page 201 and 202: vii) As proposed, Industrial efflue
Page 203 and 204: i) Ambient air quality data should
Page 205 and 206: Discarded drums and empty bags will
Page 207 and 208: project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210: 0.7Crores. No wildlife sanctuary/ r
Page 211 and 212: The project authorities and their c
Page 213 and 214: 38. Action plan for rainwater harve
Page 215 and 216: 26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218: 4. Regulatory framework5. A map ind
Page 219 and 220: the environmental or forest norms /
Page 221 and 222: 12. Location of National Park/Wild
Page 223 and 224: 45. What is the hierarchical system
Page 225 and 226: After detailed deliberations, the E
Page 227: 46. Corporate Environmental Respons
Page 231 and 232: i. All documents shall be properly
Page 233 and 234: 17. Ambient air quality monitoring
Page 235 and 236: vi.vii.The final EIA-EMP report sub
Page 237 and 238: 11. Manufacturing process details o
Page 239 and 240: iv. The letter/application for EC s
Page 241 and 242: 21. The suspended particulate matte
Page 243 and 244: 51. Details of Corporate Social Res
Page 245 and 246: 31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?