MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

2.7.7. Resin (Phenol Formaldehyde Resins 500 MTPM; Melamine FormaldehydeResins 100 MTPM and Urea Formaldehyde Resins 100 MTPM) at Sy. No. 43/1,Village Nandasan, Taluka Kadi, District Mehsana, Gujarat by M/s DecentLaminates Pvt. Ltd. (TOR to EC)The project authorities and their consultant gave a detailed presentation on thesalient features of the project and proposed environmental protection measures to beundertaken as per Draft Terms of References (TORs) awarded during the 22 nd Meetingof the Expert Appraisal Committee (Industry) held during 29 th – 30 th April, 2011forpreparation of EIA/EMP. All the Synthetic Organic Chemicals Industry located outsidethe notified industrial area/estate are listed at S.N. 5(f) under category ‘A’ and appraisedat Central level.M/s Decent Laminates Pvt. Ltd. have proposed for the Resin (PhenolFormaldehyde Resins 500 MTPM; Melamine Formaldehyde Resins 100 MTPM andUrea Formaldehyde Resins 100 MTPM) at Sy. No. 43/1, Village Nandasan, TalukaKadi, District Mehsana, Gujarat. Total project area is 9228 m 2 . PAs confirmed that thisproject will be established in the existing premises. No wildlife sanctuary / reserve forestare located within 10 Km distance. Total cost of the project is Rs. 40.00 Lakhs.Following products will be manufactured:S.N. Name of the Products Existing Proposed Totaladdition1. Laminates sheets 28000pieces/month-- 28000pieces/month2. Phenol Formaldehyde -- 500 MTPM 500 MTPMResins3 Melamine Formaldehyde -- 100 MTPM 100 MTPMResins4 Urea Formaldehyde -- 100 MTPM 100 MTPMResinsAdditionally, PAs informed the Committee that ambient air quality monitoring wascarried out at 6 locations during May, 2011 to June, 2011 and submitted data indicatesas PM 10 (52–84 ug/m3), SO2 (14.1 – 25.9 ug/m3), NOx (15.4-27.0 ug/m3) and VOC(18–58 ug/m3). Incremental ground level concentration due to proposed project is SP(0.98 ug/m 3 ), SO 2 (0.168 ug/m 3 ) and NOx (0.130 ug/m 3 ). Multi-Cyclone separator alongwith stack (30 m) will be provided to control saw dust/lignite fired boiler/thermic fluidheater.Total ground water requirement from ground water source will increase from 7.5m 3 /day to 20 m 3 /day after proposed project. Industrial wastewater generation willincrease from 0.075 m 3 /day to 2.25 m 3 /day. Effluent will be treated in effluent treatmentplant followed by evaporator to achieve zero discharge. Domestic effluent will be treatedin septic tank followed by soak pit.
Discarded drums and empty bags will be sent back to suppliers or sold to SPCBapproved vendors. Waste / used oil (0.5 KLPA) will be sold to authorized recyclers / reprocessors.ETP sludge will sent to TSDF. Organic waste residue will be sent tocommon hazardous waste incineration facility.Green belt will be developed in 33 % of plant area. Total power requirement is180 KVA. Coal/lignite (20 TPD) will be used as fuel. DG set (180 KVA) will be installed.The Committee deliberated on the issues raised during the Public Hearing /Public Consultation meeting conducted by the Gujarat Pollution Control Board on 4 thMay, 2012. The issues raised during public hearing were regarding air emissions, localemployments, show cause notice issued by the GPCB etc. and have satisfactorily beenresponded by the project proponent and incorporated in the final EIA/EMP report. TheCommittee noted that unit is engaged in the manufacturing of laminated sheet in theexisting unit and laminated sheet manufacturing is not covered under EIA Notification,2006.After detailed deliberations, the Committee found the final EIA/EMP reportadequate and suggested to stipulate following specific conditions alongwith otherenvironmental conditions while considering for accord of environmental clearance:i) Ambient air quality data should be collected as per NAAQS standards notified bythe Ministry on 16 th September, 2009.ii) Regular monitoring of Volatile Organic Compounds (VOCs) should be carriedout.iii) Bag filter alongwith stack of adequate height should be provided to coal/lignitefired boiler/thermic fluid heater.iv) Fugitive emissions in the work zone environment, product, raw materials storagearea etc. should be regularly monitored. The emissions should conform to thelimits imposed by GPCB.v) Wet scrubber should be provided to control process emissions. Methanol shouldbe recovered from the process area.vi) Total fresh water requirement from ground water source should not exceed 20m 3 /day and prior permission should be obtained from the CGWA/SGWA.vii) As proposed, Industrial effluent will be treated in ETP. Treated effluent should bereused/recycled within the factory premises. Water quality of treated effluent shallmeet the norms prescribed by CPCB/SPCB.viii) As proposed Phenol should be extracted/treated from the effluent before sendingto the ETP.ix) The company should obtain Authorization for collection, storage and disposal ofhazardous waste under the Hazardous Waste (Management, Handling andTrans-Boundary Movement) Rules, 2008 and amended as on date formanagement of Hazardous wastes and prior permission from GPCB should be
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17:
Ministry’s Regional Office at Ban
Page 18 and 19:
iv.Secondary fugitive emissions sha
Page 20 and 21:
EIA/EMP. Leather/skin/hide processi
Page 22 and 23:
By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25:
y M/s K. P. R. Industries (India) L
Page 26 and 27:
chlorine storage area shall be prov
Page 28 and 29:
ii.Bag filter alongwith stack of ad
Page 30 and 31:
Points Latitude LongitudeA 23 o 12
Page 32 and 33:
authorization or membership of TSDF
Page 34 and 35:
proposed expansion is Rs.1, 663 Cro
Page 36 and 37:
These analysis should include trace
Page 38 and 39:
49. A note on the impact of drawl o
Page 40 and 41:
a language other than English, an E
Page 42 and 43:
eserved forests, wildlife sanctuari
Page 44 and 45:
37. Impact of the transport of the
Page 46 and 47:
66. Impact of the project on local
Page 48 and 49:
project will be 56.51 MW, which wil
Page 50 and 51:
31. Sources of secondary emissions,
Page 52 and 53:
59. All stock piles will have to be
Page 54 and 55:
Grain size analysis of quartziteRev
Page 56 and 57:
1. Measures shall be taken to mitig
Page 58 and 59:
On 17.6.2010, application was submi
Page 60 and 61:
6. Regular monitoring of influent a
Page 62 and 63:
2. Bag filter alongwith stack of ad
Page 64 and 65:
vii) All the solvent storage tanks
Page 66 and 67:
v) Total fresh water requirement fr
Page 68 and 69:
5. Cathodic protection shall be pro
Page 70 and 71:
SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120:
xxvi.xxvii.Company should have own
Page 121 and 122:
xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124:
Water based drilling fluid will be
Page 125 and 126:
vii.viii.ix.The company should cons
Page 127 and 128:
awarded during the 18 th Meeting of
Page 129 and 130:
iii.iv.Water based drilling mud sho
Page 131 and 132:
‘Operator’ on 30.06.2010. Block
Page 133 and 134:
3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136:
25. Details of all environment and
Page 137 and 138:
In the NPK mixtures plant, Unit wil
Page 139 and 140:
41. Action plan for rainwater harve
Page 141 and 142:
composted with press mud. Fly ash o
Page 143 and 144:
42. What is the hierarchical system
Page 145 and 146:
12. Present land use based on satel
Page 147 and 148:
IA.II (I) dated 4 th August, 2009,
Page 149 and 150:
14. List of products alongwith the
Page 151 and 152:
iii. Authenticated English translat
Page 153 and 154: 27. Action plan to control ambient
Page 155 and 156: 2.5.30. Expansion of Synthetic Orga
Page 157 and 158: 16. List of products alongwith the
Page 159 and 160: i. All documents shall be properly
Page 161 and 162: 24. Lagoon capacity for sugar unit
Page 163 and 164: S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166: 44. Socio-economic development acti
Page 167 and 168: 6. A map indicating location of the
Page 169 and 170: (a) Does the company have a well la
Page 171 and 172: 13. Present land use based on satel
Page 173 and 174: 52. Any litigation pending against
Page 175 and 176: 12. Project site location alongwith
Page 177 and 178: 51. Public hearing to be conducted
Page 179 and 180: 20. Air pollution control measures
Page 181 and 182: The Committee decided that the prop
Page 183 and 184: 31. Treatment of phenol in the effl
Page 185 and 186: located outside the notified indust
Page 187 and 188: 38. Action plan for rainwater harve
Page 189 and 190: 11011/381/2006-IA II (I) dated 11 t
Page 191 and 192: e ground water. Oily effluent will
Page 193 and 194: xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196: with a capacity of 4.5 KL/day. No N
Page 197 and 198: to 90 % and will be sold as cattle
Page 199 and 200: xiv. Dedicated parking facility for
Page 201 and 202: vii) As proposed, Industrial efflue
Page 203: i) Ambient air quality data should
Page 207 and 208: project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210: 0.7Crores. No wildlife sanctuary/ r
Page 211 and 212: The project authorities and their c
Page 213 and 214: 38. Action plan for rainwater harve
Page 215 and 216: 26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218: 4. Regulatory framework5. A map ind
Page 219 and 220: the environmental or forest norms /
Page 221 and 222: 12. Location of National Park/Wild
Page 223 and 224: 45. What is the hierarchical system
Page 225 and 226: After detailed deliberations, the E
Page 227 and 228: 46. Corporate Environmental Respons
Page 229 and 230: 12. Project site location alongwith
Page 231 and 232: i. All documents shall be properly
Page 233 and 234: 17. Ambient air quality monitoring
Page 235 and 236: vi.vii.The final EIA-EMP report sub
Page 237 and 238: 11. Manufacturing process details o
Page 239 and 240: iv. The letter/application for EC s
Page 241 and 242: 21. The suspended particulate matte
Page 243 and 244: 51. Details of Corporate Social Res
Page 245 and 246: 31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

Create successful ePaper yourself

Delete template?

Save as template?