MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

the Synthetic Organic Chemical Units located outside industrial area/estate are listed atS.N. 5(f) under Category ‘A’ and appraised at the Central levelM/s Meridian Sunmica & Laminates Pvt. Ltd. has proposed for expansion ofPhenol Formaldehyde and Melamine Formaldehyde Resin Manufacturing Unit at Sy.No. 1743 & 1761/1, Village Gangad, Taluka Dholka, District Ahmedabad, Gujarat. Totalplot area is 38631 m 2 . Following products will be manufactured :S.N. Product Existing (MTPM) Proposed(MTPM)Capacityexpansion(MTPM)after1 Phenol Formaldehyderesin2 MelamineFormaldehyde resin120 600 72040 200 240Multicyclone followed by dust collector are installed in the existing steam boiler andthermic fluid heater. Scrubber will be provided to methanol dryer. Water requirementfrom ground water source will be increased from 40 M3/day to 46.8 m 3 /day afterexpansion. Effluent generation will be increased from 2.5 m 3 /day to 3.3 m 3 /day. Effluentwill be treated in ETP based on photo fentonprocess and treated water will beevaporated to achieve zero discharge. Domestic effluent will be disposed through septictank followed by soak pit. ETP sludge will be sent to TSDF. Resin waste will beincinerated in the common incineration facility. Waste oil will be sent to authorizedreprocessors. Greenbelt will be developed in 12850 m 2 .After detailed deliberations, the Expert Appraisal Committee prescribed thefollowing TORs for preparation of EIA/EMP report:1. A separate chapter on status of compliance of Environmental Conditions grantedby State/Centre to be provided. As per circular dated 30 th May, 2012 issued byMoEF, a certified report by RO, MoEF on status of compliance of conditions onexisting unit to be provided in EIA/EMP report.2. Executive summary of the project3. Justification of the project.4. Promoters and their back ground.5. Regulatory framework.6. A map indicating location of the project and distance from severely polluted area.7. Project location and plant layout.8. Infrastructure facilities including power sources.9. Total cost of the project alongwith total capital cost and recurring cost/annum forenvironmental pollution control measures.10. Project site location alongwith site map of 10 km area and site details providingvarious industries, surface water bodies, forests etc.11. Environment clearance for the existing unit issued by the Ministry (reasons, if notobtained), Consent to Operate and Authorization accorded by the MPCB.12. Data for the stack emissions, fugitive emissions; water requirement and waterbalance chart; wastewater generation, treated effluent quality, re-utilization anddisposal of solid/hazardous waste for the existing unit.
13. Present land use based on satellite imagery for the study area of 10 km radius.Details of land availability for the project alongwith supporting document.14. Location of National Park/Wild life sanctuary/Reserve forest within 10 km radiusof the project.15. Permission from the State Forest Department regarding the impact of theproposed plant on the surrounding reserve forests.16. Details of the total land and break-up of the land use for green belt and otheruses.17. List of products alongwith the production capacities.18. Detailed list of raw material required and source, mode of storage.19. Manufacturing process details alongwith the chemical reactions and process flowchart.20. Action plan for the transportation of raw material and products.21. Site-specific micro-meteorological data using temperature, relative humidity,hourly wind speed and direction and rainfall is necessary.22. Ambient air quality monitoring at 6 locations within the study area of 5 km., aerialcoverage from project site as per NAAQES notified on 16 th September, 2009.Location of one AAQMS in downwind direction.23. One season site-specific micro-meteorological data using temperature, relativehumidity, hourly wind speed and direction and rainfall and AAQ data (exceptmonsoon) for PM 10 , SO 2 , NOx, CO, NH 3 including VOCs shall be collected. Themonitoring stations shall take into account the pre-dominant wind direction,population zone and sensitive receptors including reserved forests. Data forwater and noise monitoring shall also be included.24. Air pollution control measures proposed for the effective control ofgaseous/process emissions within permissible limits.25. Name of all the solvents to be used in the process and details of solvent recoverysystem.26. Design details of ETP, incinerator, if any alongwith boiler, scrubbers/bag filtersetc.27. Details of water and air pollution and its mitigation plan28. Action plan to control ambient air quality as per NAAQS Standards notified by theMinistry on 16 th September, 2009.29. An action plan prepared by SPCB to control and monitor secondary fugitiveemissions from all the sources.30. Determination of atmospheric inversion level at the project site and assessmentof ground level concentration of pollutants from the stack emission based on sitespecificmeteorological features. Air quality modelling for proposed plant.31. Permission from CGWA/SGWA for the drawl of 46.8 m 3 /day ground water. Waterbalance chart including quantity of effluent generated recycled and reused andeffluent discharge.32. Attempt to be made for reduction for usage of water.33. Complete scheme of effluent treatment. Characteristics of untreated and treatedeffluent to meet the standard.34. Zero discharge effluent concepts to be adopted.35. Ground water quality monitoring minimum at 6 locations shall be carried out.Geological features and Geo-hydrological status of the study area and ecologicalstatus (Terrestrial and Aquatic).36. The details of solid and hazardous wastes generation, storage, utilization anddisposal particularly related to the hazardous waste calorific value of hazardous
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17:
Ministry’s Regional Office at Ban
Page 18 and 19:
iv.Secondary fugitive emissions sha
Page 20 and 21:
EIA/EMP. Leather/skin/hide processi
Page 22 and 23:
By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25:
y M/s K. P. R. Industries (India) L
Page 26 and 27:
chlorine storage area shall be prov
Page 28 and 29:
ii.Bag filter alongwith stack of ad
Page 30 and 31:
Points Latitude LongitudeA 23 o 12
Page 32 and 33:
authorization or membership of TSDF
Page 34 and 35:
proposed expansion is Rs.1, 663 Cro
Page 36 and 37:
These analysis should include trace
Page 38 and 39:
49. A note on the impact of drawl o
Page 40 and 41:
a language other than English, an E
Page 42 and 43:
eserved forests, wildlife sanctuari
Page 44 and 45:
37. Impact of the transport of the
Page 46 and 47:
66. Impact of the project on local
Page 48 and 49:
project will be 56.51 MW, which wil
Page 50 and 51:
31. Sources of secondary emissions,
Page 52 and 53:
59. All stock piles will have to be
Page 54 and 55:
Grain size analysis of quartziteRev
Page 56 and 57:
1. Measures shall be taken to mitig
Page 58 and 59:
On 17.6.2010, application was submi
Page 60 and 61:
6. Regular monitoring of influent a
Page 62 and 63:
2. Bag filter alongwith stack of ad
Page 64 and 65:
vii) All the solvent storage tanks
Page 66 and 67:
v) Total fresh water requirement fr
Page 68 and 69:
5. Cathodic protection shall be pro
Page 70 and 71:
SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73:
35. Ground water monitoring minimum
Page 75 and 76:
2.4.8. Proposed Integrated Cement P
Page 77 and 78:
vii) As proposed, Industrial efflue
Page 79 and 80:
After detailed deliberations, the C
Page 81 and 82:
Solvent red 135Solvent red168Solven
Page 83 and 84:
556, 560, 561/1, Village Dudhwada,
Page 85 and 86:
22 nd March, 2012 for Anand distric
Page 87 and 88:
xviii. In case the commercial viabi
Page 89 and 90:
SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92:
eneficial purposes. Domestic efflue
Page 93 and 94:
Distillery Units are listed at S.N.
Page 95 and 96:
during rainy season by flowing alon
Page 97 and 98:
i. Distillery unit should be based
Page 99 and 100:
Chemicals Industry (Bulk Drugs & In
Page 101 and 102:
vi)Trade effluent should be segrega
Page 103 and 104:
PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106:
xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108:
2.5.14. Setting up of Di-methyl Sul
Page 109 and 110:
concerned Authority and a copy subm
Page 111 and 112:
viii. All the issues raised during
Page 113 and 114:
2.5.17. Manufacture of Phenol Forma
Page 115 and 116:
ix)Green belt should be developed i
Page 117 and 118:
v. The company should make the arra
Page 119 and 120: xxvi.xxvii.Company should have own
Page 121 and 122: xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124: Water based drilling fluid will be
Page 125 and 126: vii.viii.ix.The company should cons
Page 127 and 128: awarded during the 18 th Meeting of
Page 129 and 130: iii.iv.Water based drilling mud sho
Page 131 and 132: ‘Operator’ on 30.06.2010. Block
Page 133 and 134: 3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136: 25. Details of all environment and
Page 137 and 138: In the NPK mixtures plant, Unit wil
Page 139 and 140: 41. Action plan for rainwater harve
Page 141 and 142: composted with press mud. Fly ash o
Page 143 and 144: 42. What is the hierarchical system
Page 145 and 146: 12. Present land use based on satel
Page 147 and 148: IA.II (I) dated 4 th August, 2009,
Page 149 and 150: 14. List of products alongwith the
Page 151 and 152: iii. Authenticated English translat
Page 153 and 154: 27. Action plan to control ambient
Page 155 and 156: 2.5.30. Expansion of Synthetic Orga
Page 157 and 158: 16. List of products alongwith the
Page 159 and 160: i. All documents shall be properly
Page 161 and 162: 24. Lagoon capacity for sugar unit
Page 163 and 164: S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166: 44. Socio-economic development acti
Page 167 and 168: 6. A map indicating location of the
Page 169: (a) Does the company have a well la
Page 173 and 174: 52. Any litigation pending against
Page 175 and 176: 12. Project site location alongwith
Page 177 and 178: 51. Public hearing to be conducted
Page 179 and 180: 20. Air pollution control measures
Page 181 and 182: The Committee decided that the prop
Page 183 and 184: 31. Treatment of phenol in the effl
Page 185 and 186: located outside the notified indust
Page 189 and 190: 11011/381/2006-IA II (I) dated 11 t
Page 191 and 192: e ground water. Oily effluent will
Page 193 and 194: xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196: with a capacity of 4.5 KL/day. No N
Page 197 and 198: to 90 % and will be sold as cattle
Page 199 and 200: xiv. Dedicated parking facility for
Page 201 and 202: vii) As proposed, Industrial efflue
Page 203 and 204: i) Ambient air quality data should
Page 205 and 206: Discarded drums and empty bags will
Page 207 and 208: project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210: 0.7Crores. No wildlife sanctuary/ r
Page 211 and 212: The project authorities and their c
Page 215 and 216: 26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218: 4. Regulatory framework5. A map ind
Page 219 and 220: the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

Create successful ePaper yourself

Delete template?

Save as template?