MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

More documents

Recommendations

Info

methodology includes biomass size reduction, pretreatment technology, enzymeshydrolysis, fermentation followed by distillation process & the effluent so produced willbe reused to have zero discharge. Utilities such as boiler, heater and DG set will not beinstalled and sourced from existing unit.Additionally, PAs informed the Committee that ambient air quality monitoring wascarried out at 9 locations during March, 2011 – May 2011 and submitted data indicatesPM 10 (48.8-86.2 ug/m 3 ), SO 2 (18.1-24.2 ug/m 3 ) andNO x (10.2-14.9 ug/m 3 ). Ammoniavapour will be passed through chilled water for ammonia condensation followed byscrubber. The recovered ammonia will be reused into the process. Water requirementfrom ground water source will be 31 m3/day. Effluent generation will be from fermenterwashing and lignin separation, which will be recycling into process. Spent wash will beconcentrated in MEE followed by incinerator. Lignin will be burnt in boiler.Environment Clearance for the existing distillery unit has been accorded by the Ministry’sletter no. J-11011/219/2003-IA-II(I) dated 11 th July, 2006. Committee deliberated uponthe compliance report and the project proponent responded satisfactory.The Committee deliberated upon the issues raised during the Public Hearing /Public Consultation meeting conducted by the UP Pollution Control Board on 2 nd April,2012. The issues raised during public hearing were benefit from projects, treatment ofwastewater, air pollution, raw materials etc and have satisfactorily been responded bythe project proponent and incorporated in the final EIA/EMP report.After detailed deliberations, the Committee found the final EIA/EMP reportadequate and suggested to stipulate following specific conditions alongwith otherenvironmental conditions while considering for accord of environmental clearance:i. Ethanol production shall be based on Lignocellulosic Biomass.ii. As proposed, utilities such as boiler, heater etc shall be sourced from the existingunit.iii. Ammonia vapour will be passed through chilled water for ammonia condensationfollowed by scrubber. The recovered ammonia will be reused into the processiv. Total fresh water requirement from ground water should not exceed 31m3/dayand prior permission for drawl of ground water should be obtained fromthe CGWA/SGWA.v. Spent wash generation from molasses should not exceed 8 Kl/Kl of alcoholrespectively. Spent wash will be concentrated in MEE followed by incineratortoachieve zero discharge. Effluent generation will be from fermenter washing andlignin separation, which will be recycled into process.vi. Spent wash should be stored in impervious lagoon with HDPE lining as perCPCB guidelines and should be kept in proper condition to prevent ground waterpollution. Storage capacity of spent wash lagoon should be for 5 days.vii. As proposed, no effluent from distillery and co-generation power plant should bedischarged outside the premises and Zero discharge should be adopted.
viii. All the issues raised during the public hearing/consultation meeting held on 2 ndApril, 2012should be satisfactorily implemented.2.5.16. Manufacture of Nicotine and its Derivatives (35 MTPM) at Sy. No.317, 321 Paiki,305, Village Rakhial, Taluka Thasra, District Kheda, Gujarat by M/s NICO OrgoMarketing Pvt. Ltd.– (TOR to EC).The project authorities and their consultant (Kadam Environmental consultant)gave a detailed presentation on the salient features of the project and proposedenvironmental protection measures to be undertaken as per Draft Terms of References(TORs) awarded during the 21 st Meeting of the Expert Appraisal Committee (Industry)held during 23 rd -24 th March, 2011 for preparation of EIA/EMP. All the Nicotine and itsderivative manufacturing units, if located outside notified industrial area are listed at S.N.5(f) under Category ‘A’ and appraised at the Central level.M/s NICO Orgo Marketing Pvt. Ltd. have proposed for the manufacture ofNicotine and its Derivatives (35 MTPM) at Sy. No.317, 321 Paiki, 305, Village Rakhial,Taluka Thasra, District Kheda, Gujarat. Total plot area is 2,346 m 2 . Nearest town isDakor at 0.5 m. Shedhi River, Mahisagar River and Narmada canal are located at 0.33km, 10.17 km and 3.75 km respectively. No national park/wildlife sanctuary/reserveforests are located within 10 Km. Rs. 16.71 Lakhs and Rs. 0.85 Lakhs/annum areearmarked towards capital cost and recurring cost per annum for pollution controlmeasures. Total cost of the project is Rs. 1.00 Crore. Following products will bemanufactured:Production of Nicotine and its Derivatives : 35 MTPM (as100%):S.N. Products1 Nicotine Alkaloid2. Nicotine Sulphate3. Nicotine Tartrate4. Nicotine Polacryrex Resin5. Other Nicotine DerivativesAdditionally, PAs informed the Committee that ambient air quality monitoring wascarried out at 7 locations during May-June, 2011 and submitted data indicates as PM 10(29 – 141 ug/m 3 ), NO x (10 – 64.7 ug/m 3 ) and SO 2 (8–43 ug/m 3 ). Solvent will berecovered through single stage condenser using cool water for circulation.. Total fresh water requirement from ground water source will 20 m 3 /day.Industrial effluent generation will be 40 m 3 /day. Effluent (28 m3/day) will be recirculatedin the process. Remaining effluent will be treated in effluent treatment plant and treatedwater will be recycled/reused within the factory premises. Domestic effluent (0.8 m 3 /day)will be treated in septic tank followed by soak pit. No effluent will be discharged outsidethe premises and ‘Zero’ discharge will be adopted. Waste/used oil (25 l/yrs) will be soldto authorized recyclers / re-processors. Process solid waste will be neutralizedand usedfor manure. Power (100 KVA/MT of product) will be sourced from MGVCL.
Page 1:
MINUTES OF2 ND RECONSTITUTED EXPERT
Page 4 and 5:
5. Regular monitoring of influent a
Page 6 and 7:
The revised draft EIA/EMP report sh
Page 8 and 9:
vi.vii.viii.ix.Risk and Disaster Ma
Page 10 and 11:
4. Secondary fugitive emissions fro
Page 12 and 13:
µg/m 3 , 6 µg/m 3 to 21.3 µg/m 3
Page 14 and 15:
permission for drawl of 16 MGD of w
Page 16 and 17:
Ministry’s Regional Office at Ban
Page 18 and 19:
iv.Secondary fugitive emissions sha
Page 20 and 21:
EIA/EMP. Leather/skin/hide processi
Page 22 and 23:
By-products1 HCl 0 16.95 16.952 Amm
Page 24 and 25:
y M/s K. P. R. Industries (India) L
Page 26 and 27:
chlorine storage area shall be prov
Page 28 and 29:
ii.Bag filter alongwith stack of ad
Page 30 and 31:
Points Latitude LongitudeA 23 o 12
Page 32 and 33:
authorization or membership of TSDF
Page 34 and 35:
proposed expansion is Rs.1, 663 Cro
Page 36 and 37:
These analysis should include trace
Page 38 and 39:
49. A note on the impact of drawl o
Page 40 and 41:
a language other than English, an E
Page 42 and 43:
eserved forests, wildlife sanctuari
Page 44 and 45:
37. Impact of the transport of the
Page 46 and 47:
66. Impact of the project on local
Page 48 and 49:
project will be 56.51 MW, which wil
Page 50 and 51:
31. Sources of secondary emissions,
Page 52 and 53:
59. All stock piles will have to be
Page 54 and 55:
Grain size analysis of quartziteRev
Page 56 and 57:
1. Measures shall be taken to mitig
Page 58 and 59:
On 17.6.2010, application was submi
Page 60 and 61: 6. Regular monitoring of influent a
Page 62 and 63: 2. Bag filter alongwith stack of ad
Page 64 and 65: vii) All the solvent storage tanks
Page 66 and 67: v) Total fresh water requirement fr
Page 68 and 69: 5. Cathodic protection shall be pro
Page 70 and 71: SEIAA, Karnataka on 5.7.2011 after
Page 72 and 73: 35. Ground water monitoring minimum
Page 75 and 76: 2.4.8. Proposed Integrated Cement P
Page 77 and 78: vii) As proposed, Industrial efflue
Page 79 and 80: After detailed deliberations, the C
Page 81 and 82: Solvent red 135Solvent red168Solven
Page 83 and 84: 556, 560, 561/1, Village Dudhwada,
Page 85 and 86: 22 nd March, 2012 for Anand distric
Page 87 and 88: xviii. In case the commercial viabi
Page 89 and 90: SPM (0.0308ug/m 3 ), HC (8.87ug/m 3
Page 91 and 92: eneficial purposes. Domestic efflue
Page 93 and 94: Distillery Units are listed at S.N.
Page 95 and 96: during rainy season by flowing alon
Page 97 and 98: i. Distillery unit should be based
Page 99 and 100: Chemicals Industry (Bulk Drugs & In
Page 101 and 102: vi)Trade effluent should be segrega
Page 103 and 104: PM 10 (29 - 141 ug/m 3 ), NO x (10
Page 105 and 106: xi.xii.xiii.xiv.i. In case the comm
Page 107 and 108: 2.5.14. Setting up of Di-methyl Sul
Page 109: concerned Authority and a copy subm
Page 113 and 114: 2.5.17. Manufacture of Phenol Forma
Page 115 and 116: ix)Green belt should be developed i
Page 117 and 118: v. The company should make the arra
Page 119 and 120: xxvi.xxvii.Company should have own
Page 121 and 122: xi.xii.xiii.xiv.vii.viii.ix.Treated
Page 123 and 124: Water based drilling fluid will be
Page 125 and 126: vii.viii.ix.The company should cons
Page 127 and 128: awarded during the 18 th Meeting of
Page 129 and 130: iii.iv.Water based drilling mud sho
Page 131 and 132: ‘Operator’ on 30.06.2010. Block
Page 133 and 134: 3 95 O 06’22.74” 10 O 01’46.6
Page 135 and 136: 25. Details of all environment and
Page 137 and 138: In the NPK mixtures plant, Unit wil
Page 139 and 140: 41. Action plan for rainwater harve
Page 141 and 142: composted with press mud. Fly ash o
Page 143 and 144: 42. What is the hierarchical system
Page 145 and 146: 12. Present land use based on satel
Page 147 and 148: IA.II (I) dated 4 th August, 2009,
Page 149 and 150: 14. List of products alongwith the
Page 151 and 152: iii. Authenticated English translat
Page 153 and 154: 27. Action plan to control ambient
Page 155 and 156: 2.5.30. Expansion of Synthetic Orga
Page 157 and 158: 16. List of products alongwith the
Page 159 and 160: i. All documents shall be properly
Page 161 and 162:
24. Lagoon capacity for sugar unit
Page 163 and 164:
S.N. Product Capacity (MTPD)1 Urea
Page 165 and 166:
44. Socio-economic development acti
Page 167 and 168:
6. A map indicating location of the
Page 169 and 170:
(a) Does the company have a well la
Page 171 and 172:
13. Present land use based on satel
Page 173 and 174:
52. Any litigation pending against
Page 175 and 176:
12. Project site location alongwith
Page 177 and 178:
51. Public hearing to be conducted
Page 179 and 180:
20. Air pollution control measures
Page 181 and 182:
The Committee decided that the prop
Page 183 and 184:
31. Treatment of phenol in the effl
Page 185 and 186:
located outside the notified indust
Page 187 and 188:
38. Action plan for rainwater harve
Page 189 and 190:
11011/381/2006-IA II (I) dated 11 t
Page 191 and 192:
e ground water. Oily effluent will
Page 193 and 194:
xv.xvi..xvii.xviii.xix.xx.xxi.xxii.
Page 195 and 196:
with a capacity of 4.5 KL/day. No N
Page 197 and 198:
to 90 % and will be sold as cattle
Page 199 and 200:
xiv. Dedicated parking facility for
Page 201 and 202:
vii) As proposed, Industrial efflue
Page 203 and 204:
i) Ambient air quality data should
Page 205 and 206:
Discarded drums and empty bags will
Page 207 and 208:
project is PM (1.775 ug/m 3 ), SO 2
Page 209 and 210:
0.7Crores. No wildlife sanctuary/ r
Page 211 and 212:
The project authorities and their c
Page 213 and 214:
38. Action plan for rainwater harve
Page 215 and 216:
26 Methyl Ethyl ketone 200027 4-Nit
Page 217 and 218:
4. Regulatory framework5. A map ind
Page 219 and 220:
the environmental or forest norms /
Page 221 and 222:
12. Location of National Park/Wild
Page 223 and 224:
45. What is the hierarchical system
Page 225 and 226:
After detailed deliberations, the E
Page 227 and 228:
46. Corporate Environmental Respons
Page 229 and 230:
12. Project site location alongwith
Page 231 and 232:
i. All documents shall be properly
Page 233 and 234:
17. Ambient air quality monitoring
Page 235 and 236:
vi.vii.The final EIA-EMP report sub
Page 237 and 238:
11. Manufacturing process details o
Page 239 and 240:
iv. The letter/application for EC s
Page 241 and 242:
21. The suspended particulate matte
Page 243 and 244:
51. Details of Corporate Social Res
Page 245 and 246:
31. M/s Bhushan Steel Limited p32.
show all

MINUTES OF2ND RECONSTITUTED EXPERT APPRAISAL ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?