Download - Trade Garage Equipment

Four Post Surface LiftSM40/AR40/SM55/SM55W/AR55/AR55WPARTSBREAKDOWNIMPORTANT: When ordering parts or requesting service always give exact modeland power unit serial number. Model number is shown on nameplate attached tolatch release valve. Power unit serial number is located on side of power unit.OWNERS RECORDComplete informationat right and keep ina safe place.© October 2007 by Rotary Lift. All rights reserved. CO6941.3Date Installed _________________________________Installed in Bay # ______________________________Power Unit Serial # _____________________________Power Unit Model # ____________________________Lift Serial # ___________________________________Lift Model # __________________________________NOTE: For replacement parts -See your nearest Rotary Parts Distributor.LP20099PB2-70-6Rev. F 10/10/2007*PLP20099 *

MODELS:AR55-45, AR55-5131322330*Column cut out to show Latch Bar2827294631920367812433342625353913521421221191516171810122

ITEMNO.123456789101112131415161718192021222324252627282930313233343536373839PARTSDESCRIPTIONR.H. (Adjust.) Runway AssemblyL.H. (Fixed) Runway Assembly (Includes cylinder, cables and sheaves)1/2"- 13NC x 1 1/4", Flg. Whiz Lock HHCS (High Strength)Wheel StopRamp Chock Assembly5/32" x 1" Lg. Cotter Pin5/8" Push-nut Fastener — TRW #PW625019 Or EqualHinge PinRamp ChockRamp Chock Slide#10-24 PNHDMS x 3/4" Lg.#10-24 Hex NutTriangular Wheel ChockHydraulic CylinderCable Pull BarCable Retaining Bar1 3/8"-6NC Hex Nut1 3/8"-6NC Hex Jam NutFront YokeFront Yoke Ass'y. (Including Latches)Rear YokeRear Yoke Ass'y. (Including Latches)ColumnPower Unit ColumnPower Unit5/8" Anchor Bolt7/8"-9NC Hex Nut7/8"-9NC Hex Jam Nut7/8" Flat WasherLatch Bar3/4"-10NC Hex Jam Nut3/4"-10NC Hex NutRear Slip Plate KitFiller PlateControl Box1/4"-20NC x 5/8" Flange Whiz-Lock HHCS Zinc PlatedNANAToe Guard SwitchAR55-45S120101S11010740279FC134-13S11001641202FC179-4FC134-99S120072FC134-334005040633FC320S130002S120075S1200684077140773S120308S110103S120309S110104S110049S120345*P1165/P3165FC5228407654076641073S1203124075940760FC5249FC5102FA749042000NANAS130050PART NO.AR55-51S120099S110108************************************** Two different power units were used. Please verifyyour exact model number before ordering replacementparts.3* Part number in left column applies.

MODELS:SM55-45, SM55-51, SM40-43, SM55W5131322330*Column cut out to show Latch Bar282729463192078124262533361352143721221191516171810124

ITEMNO.12R.H. (Adjust.) Runway AssemblyL.H. (Fixed) Runway AssemblyDESCRIPTION(Includes cylinder, cables and sheaves)PARTSSM40-43S120334S110117SM55W51S120340S110109PART NO.SM55-45S120085S110105SM55-51S120067S1101063456789101112131415161718192021222324252627282930313233343536371/2"-13NC x 1 1/4", Flg. Whiz Lock HHCS (High Strength)Wheel StopRamp Chock Assembly5/32" x 1" Lg. Cotter Pin5/8" Push-nut Fastener — TRW #PW625019 Or EqualHinge PinRamp ChockRamp Chock Slide#10-24 PNHDMS x 3/4" Lg.#10-24 Hex NutTriangular Wheel ChockHydraulic CylinderCable Pull BarCable Retaining Bar1 3/8"-6NC Hex Nut1 3/8"-6NC Hex Jam NutFront YokeFront Yoke Ass'y. (Including Latches)Rear YokeRear Yoke Ass'y. (Including Latches)ColumnPower Unit ColumnPower Unit5/8" Anchor Bolt7/8"-9NC Hex Nut7/8"-9NC Hex Jam Nut7/8" Flat WasherLatch Bar3/4"-10NC Hex Jam Nut3/4"-10NC Hex NutControl BoxNANAToe Guard SwitchFlush Mount Ramp40279FC342S11001641202FC179-4FC134-99S120072FC134-334005040633FC320S130002S120075S1200684077140773S120308S110103S120309S110104S110049S120314*P1081/P3081FC5228407654076641073S1203124075940760FA7490NANAS130050FC327*FC5804-19*******************S120345*P1165/P3165*********************************S120345*P1165/P3165******************LEFT S110090RIGHT S110091****************P1165/P3165************* Two different power units were used. Please verifyyour exact model number before ordering replacementparts.5* Part number in left column applies.

MODELS:AR40-43, AR55W5131322330*Column cut out to show Latch Bar282734294678243192037135362637412513521421221191516171810126

ITEMNO.1234567891011121314151617181920212223242526272829303132333435363738394041PARTSPART NO.DESCRIPTIONAR40-43 AR55W51R.H. (Adjust.) Runway AssemblyS120338 S120344L.H. (Fixed) Runway Assembly (Includes cylinder, cables and sheaves) S110119 S1101101/2"- 13NC x 1 1/4", Flg. Whiz Lock HHCS (High Strength)40279*Wheel StopFC5804-19 *S110016LEFT S110090Ramp Chock AssemblyRIGHT S1100915/32" x 1" Lg. Cotter Pin41202*5/8" Push-nut Fastener — TRW #PW625019 Or EqualFC179-4 *Hinge PinFC134-99 *Ramp ChockS120072 *Ramp Chock SlideFC134-33 *#10-24 PNHDMS x 3/4" Lg.40050*#10-24 Hex Nut40633*Triangular Wheel ChockFC320*Hydraulic CylinderS130002 *Cable Pull BarS120075 *Cable Retaining BarS120068 *1 3/8"-6NC Hex Nut40771*1 3/8"-6NC Hex Jam Nut40773*Front YokeS120308 *Front Yoke Ass'y. (Including Latches)S110103 *Rear YokeS120309 *Rear Yoke Ass'y. (Including Latches)S110104 *ColumnS110049 *Power Unit ColumnS120314 S120345Power Unit*P1081/P3081 *P1165/P31655/8" Anchor BoltFC5228 *7/8"-9NC Hex Nut40765*7/8"-9NC Hex Jam Nut40766*7/8" Flat Washer41073*Latch BarS120312 *3/4"-10NC Hex Jam Nut40759*3/4"-10NC Hex Nut40760*Optional Flush Mount RampTurning Radius Gauge AssemblyTurntable Guide BarRetaining CableControl Box1/4"-20NC x 5/8" Flange Whiz-Lock HHCS Zinc PlatedNANAToe Guard SwitchLEFT FC329RIGHT FC328FA5157FA5153-1S130043FA749042000NANAS130050**S120196******* Two different power units were used. Please verifyyour exact model number before ordering replacementparts.* Part number in left column applies.7

4173169232120191110151825222627132412714685211ITEMNO.1YOKE END DETAILITEMDESCRIPTION PART NO. DESCRIPTIONNO.PART NO.5/16"-18NC x 3/4" Lg. HHCS 40252 15 SpacerFC5706-92 Sheave Pin34567891011121314SheaveYoke Sheave SpacerSlider1/4"-20NC HHTS x 1/2" Lg.Guard1/4" Plain WasherCotter Pin, 1/8" x 1 1/4"Latch ShaftWasher1/4" Hairpin Cotter Pin (Ø.05" wire)Clevis PinLatchStandardChrome PlatedFC5224-21FC5728-7FC5804-2FC5927-10FC5706-1640067FC5802-184078041201FC5901-7FC5301-9841901FA2230-12FC5706-101617181920212223242526273/8" Snap Ring TRUARC #5304-37Slack Cable RollerKickerExtension SpringClevis Pin1/4" Flat WasherAir CylinderElbowClevis1/4"-28NF Hex NutLimit SwitchBolt and Nut41410FC553-21S120103FC522-25S13005140782S110019S110020FC5224-39FC5706-740622(1 Hole) S130139(2 Hole) S1301402 req'd.

RIGHT FRONTCLOSED YOKECABLE ROUTINGRIGHT REARPULL BAR2314LEFT FRONTPULL BAR2314LEFT REAR*CABLE RETAINER NOT SHOWN FOR CLARITYCABLESPART NO.ITEM DESCRIPTION -43 -45's -51's1234Right Front CableLeft Front CableRight Rear CableLeft Rear CableS130079S130077S130081S130018S130075S130026S130081S130018S130076S130024S130081S130018

LEFT HAND RUNWAY1243ITEM NO.1234SHEAVE DETAILDESCRIPTIONSheavePlastic Bearing5/16"-18NC HSBHCS x 1/2" Lg.Sheave PinPART NO.FC5804-2FC5843-340225FC555-1165432ITEM NO.123HYDRAULIC HOSE DETAILDESCRIPTIONClevis Pin3/16* x 1 1/4* Lg. Cotter Pin#10 - 24NC SlottedHHTS x 5/8* Lg.PART NO.FC5346-1412474002910456ClampStrip GrommetHoseFA2239-1FC5317-12FC5798

To Control Box13121ITEM NO.123AIR LATCH AIRLINE DETAILDESCRIPTION1/4* Airline Tubing (50' roll)Union TeeUnionPART NO.FA2230-2FC5225-46FC5225-98LEFT REARLIMIT SWITCH 3ATTACH TO LSI & LS8IN CONTROL BOXLEFT RUNWAYLEFT FRONTLIMIT SWITCH 1*RIGHT RUNWAY** THESE SWITCHES MUST BE WIRED AT INSTALLATIONWIRE IN SERIESNORMALLY CLOSEDRIGHT REARLIMIT SWITCH 4RIGHT FRONTLIMIT SWITCH 2LIMIT SWITCH WIRINGITEMNO.1234DESCRIPTIONLeft Front SwitchRight Front SwitchLeft Rear SwitchRight Rear SwitchPART NO.FC5916-12FC5916-13FC5888-12FC5888-1311

3ITEM NO.1FRL DETAILDESCRIPTION#10-24 x 3/4" Hex SHCSPART NO.AP000272412345#10-24 Nylon Lock NutAdapter BracketElbowFilter/Regulator/Lubricator40811S120612FC147-7S13008045657243ITEM NO.1234567INTERNAL AIRLINE PARTS (if equipped)DESCRIPTIONRecoil HoseMale ElbowFemale BulkheadRunway TubingTubingMale Run TeeMale Branch TeePART NO.FC147-14FC147-7FC147-1FC147-6FC5313-2FC147-3FC147-51123Retainer Cable Detail (if equipped)ITEM NO.12345678DESCRIPTION1/4" x 20NC Hex NutAirline Retainer Cable (182"/206")Airline Retainer Cable (158")Recoil Hose3/8" Nut3/8" LockwasherRetainer Bracket3/8"-16NC x 3/4" Lg. HHCS3/8" Flat WasherPART NO.40625S130078XS130063-4066040845FC147-9401304082046875Rotary World Headquarters2700 Lanier DriveMadison, IN 47250, USAwww.rotarylift.comNorth America Contact InformationTech. Support: p 800.445.5438f 800.578.5438e userlink@rotarylift.comSales: p 800.640.5438f 800.578.5438e userlink@rotarylift.com© Rotary ® , Printed in U.S.A., All RightsReserved. Unless otherwise indicated,ROTARY, DOVER and all other trademarks are property of Dover Corporation and its 12affiliates.World Wide Contact InformationWorld Headquarters/USA: 1.812.273.1622Canada: 1.905.812.9920European Headquarters/Germany: +49.771.9233.0United Kingdom: +44.178.747.7711Australasia: +60.3.7660.0285Latin America / Caribbean: +54.3488.431.608Middle East / Northern Africa: +49.771.9233.0