Material Safety Data Sheet - FL Selenia

Material Safety Data Sheet
Page: 1 of
Infosafe No. 5FUE6 Issue Date : February 2008 ISSUED by FUCHS
Product Name :
AKROS MULTI VT
Not classified as hazardous
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY/UNDERTAKING
Product Name AKROS MULTI VT
Product Code 3296
Product Use Universal transmission tractor oil (U.T.T.O) for farm tractor with wet brake.
Company Name FL Selenia S.p.A
Address 49 McIntyre Road Sunshine
Victoria 3020 Australia
Telephone
Number/Fax
Tel: 03 9300 6400
Fax: 03 9300 6401
Email flselenia.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients
Name CAS Proportion Hazard Symbol Risk Phrase
Refined mineral oil
Ingredients determined
not to be hazardous
3. HAZARDS IDENTIFICATION
n/allocated
n/applicable
60-100 %
to 100
Inhalation Inhalation of vapours (from heating), mists or aerosols can produce respiratory
irritation and may result in headaches, dizziness and possible nausea.
Ingestion Not a likely source of exposure, however, may be harmful if swallowed in large
amounts. Potential symptoms include nausea, diarrhoea, abdominal pain and
vomiting.
Skin Repeated or prolonged skin contact may lead to irritation.
Eye Product may cause slight to moderate irritation to the eyes.
4. FIRST AID MEASURES
Inhalation Remove victim from exposure - avoid becoming a casualty. Seek medical advice if
effects persist.
Ingestion DO NOT induce vomiting because of risk of aspiration. Wash out mouth with water
and obtain medical attention.
Skin Wash with plenty of soap and water. Seek medical advice if effects persist.
Eye If contact with the eye(s) occur, wash with copious amounts of water for
approximately 15 minutes holding eyelids(s) open. Take care not to rinse
contaminated water into the non-effected eye. If irritation develops seek medical
attention.
First Aid Facilities Normal washroom facilities.
Advice to Doctor Treat symptomatically.
5. FIRE FIGHTING MEASURES
Extinguishing Media Use CO2, dry chemical or foam. Use water spray. Use water jet to keep containers
cool.
Specific Hazards
Hazardous
Combustion Products
Combustion is likely to give rise to a complex mixture of airborne solid and
liquid particulates and gases, including carbon monoxide, oxides of sulphur, and
unidentified organic and inorganic compounds.
Protective Equipment Fire fighters to wear self-contained breathing apparatus if risk of exposure to
vapour or products of combustion.
Flash Point 208°C/typical
Flammability Will burn if involved in a fire.
Explosion Data Not applicable
6. ACCIDENTAL RELEASE MEASURES
Spills & Disposal
Personal Precautions Avoid contact with skin and eyes. Avoid standing on spilled product as loose
3

Material Safety Data Sheet
Page: 2 of
Infosafe No. 5FUE6 Issue Date : February 2008 ISSUED by FUCHS
Product Name :
AKROS MULTI VT
Not classified as hazardous
beads cause a slip hazard.
Environmental Prevent contamination of soil and water. Inform local authorities if this cannot
Precautions be prevented.
Other Information In event of large spill: Collect and seal in properly labelled drums for disposal.
In the event of a small spill: Use absorbent (soil or sand, sawdust, inert
material, vermiculite). Observe all relevant local and international regulations.
7. HANDLING AND STORAGE
Handling Avoid prolonged or repeated contact with skin and eyes . Only use in wellventilated
areas. Ensure a high level of personal hygiene is maintained when using
this product. That is; always wash hands before eating, drinking, smoking or using
the toilet
Storage Store in a well ventilated place away from ignition sources, oxidizing agents
foodstuffs and clothing. Keep containers closed when not in use. Do not allow dust
to accumulate. Keep only in original container. Prevent ingress of water.
Additional
information on
precautions for use
Packaging Not regulated.
Observe standard safety precautions and good work practices. Do not
continue to use contaminated clothing
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
National Exposure
Standards
Respiratory
Protection
Oil mists:
TLV/TWA (8 h) - 5mg/m3
TLV/STEL - 10mg/m3
Not normally required. If oil mist cannot be controlled, a respirator fitted with
an organic vapour cartridge combined with a particulate pre-filter should be used.
Eye Protection Wear safety glasses or full face shield if splashes are likely to occur.
Hand Protection Neoprene or nitrile rubber gloves.
Personal Protective
Equipment
Body Protection Appropriate protective clothing. Wash contaminated clothing and protective
equipment before storing/re-using.
Eng. Controls Maintain concentration below recommended exposure limit.
Hygiene Measures Wash hands before eating, drinking, smoking and using the toilet.
Technical Protective
Measures
Use with adequate ventilation.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance Viscous liquid.
Boiling Point > 300°C
Solubility in Water Insoluble
Specific Gravity 0.880 @ 15°C/typical
(H2O=1)
Vapour Pressure < 0.1 mmHg @ 25°C
Viscosity 11.2 cSt @ 100°C
Volatile Component None
Flash Point 208°C/typical
Flammability Will burn if involved in a fire.
Explosion Properties Not applicable
Other Information * Typical values only - Consult product information sheet.
10. STABILITY AND REACTIVITY
This product is stable under normal conditions of use.
Materials to Avoid Strong oxidizing agents. Acids. Bases
3

Material Safety Data Sheet
Page: 3 of
Infosafe No. 5FUE6 Issue Date : February 2008 ISSUED by FUCHS
Product Name :
Hazardous
Decomposition
Products
AKROS MULTI VT
Not classified as hazardous
Carbon dioxide Carbon monoxide Sulphur dioxide Oxides of nitrogen Hydrogen
sulphide
Conditions to Avoid Heat, flames and sparks.
11. TOXICOLOGICAL INFORMATION
Toxicology
Information
No adverse health effects are expected if this product is used in accordance
with this Safety Data Sheet.
Inhalation Inhalation of vapours (from heating), mists or aerosols can produce respiratory
irritation and may result in headaches, dizziness and possible nausea.
Ingestion Not a likely source of exposure, however, may be harmful if swallowed in large
amounts. Potential symptoms include nausea, diarrhoea, abdominal pain and
vomiting.
Skin Repeated or prolonged skin contact may lead to irritation.
Eye Product may cause slight to moderate irritation to the eyes.
12. ECOLOGICAL INFORMATION
Information on
Ecological Effects
It is not readily biodegradable and has the potential to bioaccumulate.
Environ. Protection Non-biodegradable.
Avoid contaminating waterways.
13. DISPOSAL CONSIDERATIONS
Waste Disposal Contain - prevent contamination of drains and waterways. Observe local
regulations.
14. TRANSPORT INFORMATION
Storage and
Transport
15. REGULATORY INFORMATION
Poisons Schedule Not Scheduled
Packaging &
Labelling
Not regulated.
16. OTHER INFORMATION
References * NOHSC:2011 National Code of Practice for the Preparation of Material Safety Data
Sheets
* NOHSC:1008 Approved Criteria for Classifying Hazardous Substances
* NOHSC:10005 List of Designated Hazardous Substances
* NOHSC:1005 Control of Workplace Hazardous Substances, National Model Regulations
* NOHSC:2007 Control of Workplace Hazardous Substances, National Code of Practice
* NOHSC:1003 Exposure Standards for Atmospheric Contaminants in the Occupational
Environment, National Exposure Standards
* NOHSC:3008 Exposure Standards for Atmospheric Contaminants in the Occupational
Environment, Guidance Note
* NOHSC:1015 Storage and Handling of Workplace Dangerous Goods, National Standard
* NOHSC:2017 Storage and Handling of Workplace Dangerous Goods, National Code of
Practice
* SUSDP, Standard for the Uniform Scheduling of Drugs and Poisons
* ADG, Australian Dangerous Goods Code
* MSDS of component materials
Last Change Supercedes Issue Date: N/A
Reason(s) for issue: First Issue
Poisons Schedule Not Scheduled
...End Of MSDS...
3