UNDERWAY REPLENISHMENT NWP 4-01.4 - Historic Naval Ships ...

More documents

Recommendations

Info

NWP 4-01.4MACHINED GROOVEB END (SHOWN BELOW)FLANGE TO FEMALE SPLIT CLAMPA END (SHOWN BELOW)FUEL RISERSPLIT CLAMPHOSE COUPLINGHOSEDROP BOLTGASKETSLOTTEDFLANGEFLOATING RINGFLANGEA END - RECEIVING SHIPB END - DELIVERY SHIPFigure 3-12. Breakable-Spool, NATO Quick-Release Coupling3.7.4.5 Quick-Release Coupling, 2-1/2 Inch(63.5 mm). This coupling is used only when ships areunable to use the D-2 nozzle system.3.7.4.6 Type D-2 Nozzle and Receiver. The D-2nozzle (NAVSEA Drawing 571-6821693) shown inFigure 3-13 is the standard fuel coupling for all 2-1/2-inch (63.5 mm) alongside delivery rigs. The couplingis a quick-operating, dry-break device. Connectionrequires a 30° turn while pushing the two halves together.Once connected, the internal flow valve on thenozzle end is rotated to full open, which depresses thepoppet type of check valve in the receiving half. Whenthe valve is open, the nozzle cannot be disconnectedfrom the receiver (NAVSEA Drawing 571-6821656).To disconnect, the valve must first be closed; then thenozzle is rotated back 30° until free of the receiver.3-16 ORIGINAL
NWP 4-01.4Figure 3-13. Type D-2 Nozzle for 2-1/2-Inch (65.3 mm) Hose Rig3.7.4.7 Auto Disconnect Coupling, 2-1/2 inch(63.5 mm). The auto disconnect coupling protects thehose from overtension failure, thereby preventing inadvertentfuel spillage. If the rigging or rig controlshould fail and the hose tensions, the coupling willdry-break between 500 and 700 lb (227 and 318 kg).The coupling may be vented and re-attached once therig is stabilized.3.7.4.8 Elbow, 90 Degree, 2-1/2 inch (63.5 mm).The elbow adapter provides a connection point to securethe hose rig to the receiving ship and smoothlylead the hose forward to the riser connection.3.7.5 Spanwire Weak-Link End Fitting. Theweak-link end fitting (Figure 3-14a) is the preferredFAS spanwire end fitting. There are two sizes: (1) the3/4-inch (19.0 mm) spanwire end fitting (designed tofail at 30,000 lb (13,608 kg)), and (2) the 7/8-inch (22.2mm) spanwire end fitting (designed to fail at 35,000 lb(15,876 kg)). For fueling methods other than probe, orwhen sending the span wire to a receiving stationpadeye that has a long link for Robb or NATO fuelingoperations, install a shackle and pelican hook as shownin Figure 3-14c.WARNINGThe weak link end fitting must be used on anyspanwire that does not have a slip clutch.The non-weak-link end fitting (Figure 3-14b) maybe used instead of the weak-link end fitting on any spanwire that has a slip clutch. (This applies to all Navystandard spanwire winches and some carrier automatictension span wires.)WARNINGThe non-weak-link end fitting must not beused on any spanwire that does not have aslip clutch.3-17 ORIGINAL
Page 1:
NWP 4-01.4NAVAL WARFARE PUBLICATION
Page 10 and 11:
NWP 4-01.4PageNo.3.7.4 Fueling Coup
Page 12 and 13:
NWP 4-01.4PageNo.4.17 REFERENCES ..
Page 14 and 15:
NWP 4-01.4PageNo.6.9.5 Emergency Br
Page 16 and 17:
NWP 4-01.4PageNo.8.3 PREPARING SHIP
Page 18 and 19:
NWP 4-01.4PageNo.10.9 CARGO STAGING
Page 20 and 21:
NWP 4-01.4E.6.3 Reports ...........
Page 22 and 23:
NWP 4-01.4LIST OF ILLUSTRATIONSPage
Page 24 and 25:
NWP 4-01.4PageNo.Figure 5-9. Easing
Page 26 and 27:
NWP 4-01.4PageNo.Figure 8-6. Typica
Page 29 and 30:
NWP 4-01.4RECORD OF CHANGESChange N
Page 31 and 32:
NWP 4-01.4LIST OF ACRONYMS/ABBREVIA
Page 33 and 34:
NWP 4-01.4PREFACEThe information co
Page 35 and 36:
NWP 4-01.4FM ORIGINATORTO COMLOGGRU
Page 37 and 38:
NWP 4-01.4CHAPTER 1Concepts of Repl
Page 39 and 40:
NWP 4-01.4The replenishment capabil
Page 41 and 42:
NWP 4-01.4small units to the lee si
Page 43 and 44:
1-7 ORIGINALFigure 1-3. Developing
Page 45:
STATIONPRODUCTAOETotal Time: 5 hrs.
Page 48 and 49:
NWP 4-01.41. Attaining and maintain
Page 50 and 51:
NWP 4-01.4COURSE TO PERMIT FLIGHTOP
Page 52 and 53:
1234562-6 ORIGINALFigure 2-2. Flag
Page 54 and 55:
NWP 4-01.43. When ships are yawing
Page 56 and 57:
NWP 4-01.4a. The conning officer of
Page 58 and 59: NWP 4-01.4TRANSFER HEADSLACK WIRE R
Page 60 and 61: NWP 4-01.44. Retrieve rigs in accor
Page 62 and 63: NWP 4-01.4TYPE IVA, CLASS 2SCREW-PI
Page 64 and 65: NWP 4-01.4METHOD OF SENDING SHOTLIN
Page 66 and 67: NWP 4-01.41-1/8 INCH (28.5 mm) CRCM
Page 68 and 69: a. DAYGREENREDYELLOWWHITEGREENYELLO
Page 70 and 71: NWP 4-01.44. The control ship unsna
Page 72 and 73: NWP 4-01.4ITEM KEY QUANTITYALLEN WR
Page 74 and 75: NWP 4-01.4SIGNALRomeoDisplayed onfo
Page 76 and 77: NWP 4-01.45. Seeing that all attach
Page 78 and 79: NWP 4-01.4c. No. 1 (retrieving) sad
Page 80 and 81: NWP 4-01.41. A minimum of 150 watts
Page 82 and 83: NWP 4-01.42.6.7 Rig Loads. Loads on
Page 84 and 85: NWP 4-01.43. Anticipated schedule o
Page 86 and 87: NWP 4-01.4RIG APPLICATIONFUEL SPAN
Page 88 and 89: NWP 4-01.42. Cigarette lighters and
Page 90 and 91: NWP 4-01.4Most containers of inflam
Page 93 and 94: NWP 4-01.4CHAPTER 3Liquid Cargo Tra
Page 95 and 96: NWP 4-01.4AOE-1AOE-6416321854310651
Page 97 and 98: NWP 4-01.41. Spanwire attachment po
Page 99 and 100: NWP 4-01.43.7.3.1.2 2-1/2 Inch (63.
Page 101 and 102: NWP 4-01.4TROLLEY CARRIAGEMESSENGER
Page 103 and 104: 3-11 ORIGINALFigure 3-7. Delivering
Page 105 and 106: 112ATTACH END OF SPANWIRE TO CONVEN
Page 107: NWP 4-01.4VALVEGASKETSPRING-TENSION
Page 111 and 112: NWP 4-01.43.7.6 Miscellaneous Fitti
Page 113 and 114: NWP 4-01.4NOSE SHIELDPROBE20"(508.0
Page 115 and 116: NWP 4-01.4Figure 3-18. Fuel STREAM
Page 117 and 118: NWP 4-01.4FLOW-THRU SADDLETYPE (B)S
Page 119 and 120: NWP 4-01.4INBOARD SADDLE WHIPONE LI
Page 121 and 122: NWP 4-01.4SPANWIREMESSENGERATTACHME
Page 123 and 124: NWP 4-01.4STAR MESSENGER5/8" (15.8
Page 125 and 126: NWP 4-01.4NoteA remating line must
Page 127 and 128: NWP 4-01.4trolley carriage for use
Page 129 and 130: NWP 4-01.43.10.7 2-1/2-Inch (63.5 m
Page 131 and 132: NWP 4-01.4Figure 3-29. Double-Hose
Page 133 and 134: NWP 4-01.4(1) DELIVERY SHIP1. Posit
Page 135 and 136: NWP 4-01.4(4) DELIVERY SHIPHaul in
Page 137 and 138: NWP 4-01.43.13 CASUALTY CONTROLIf s
Page 139 and 140: NWP 4-01.4FUEL STREAM RIGEQUIPMENT*
Page 141 and 142: NWP 4-01.4FUEL STREAM RIGEQUIPMENT*
Page 143: NWP 4-01.4FUEL STREAM RIGEQUIPMENT*
Page 146 and 147: NWP 4-01.4WIRESADDLEWHIP#3ANTITOPPL
Page 148 and 149: NWP 4-01.4(2) RECEIVING SHIP1. Rece
Page 150 and 151: NWP 4-01.4d. Secure the coupling to
Page 152 and 153: NWP 4-01.4EQUIPMENTMATERIALLENGTH I
Page 154 and 155: NWP 4-01.44.10.5 Retrieving the Clo
Page 156 and 157: NWP 4-01.4TROLLEY NO. 4TROLLEY NO.
Page 158 and 159:
NWP 4-01.417. Shackle saddle whip a
Page 160 and 161:
NWP 4-01.4FORWARDEASING OUT LINE1"
Page 162 and 163:
NWP 4-01.44.11.2.4.2 Receiving Ship
Page 164 and 165:
NWP 4-01.4ROPE PENDANTFWDFUEL ORWAT
Page 166 and 167:
NWP 4-01.44.17 REFERENCESATP 16, Re
Page 168 and 169:
NWP 4-01.4NONTENSIONEDSPANWIRE RIGC
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
NWP 4-01.45.6.4 Fueling Couplings.
Page 176 and 177:
NWP 4-01.4SIGNALMEANINGDAY NIGHT RE
Page 178 and 179:
NWP 4-01.4RING GEAR (DRIVENBY GEARB
Page 180 and 181:
NWP 4-01.4SECURING ADAPTER CLAMP2'-
Page 182 and 183:
5-10 ORIGINALFigure 5-7. Float Asse
Page 184 and 185:
HOSE EASING-OUT LINE2-1/2" (63.5 mm
Page 186 and 187:
NWP 4-01.4LEGENDNO.DESCRIPTIONHOSE
Page 188 and 189:
DETAIL: MODIFIED BREAKABLE SPOOL AT
Page 190 and 191:
5-18 ORIGINALFigure 5-12. Delivery
Page 192 and 193:
NWP 4-01.4MESSENGERFAIRLEAD BLOCK12
Page 194 and 195:
MESSENGER TO CLEATNWP 4-01.4PEAR-SH
Page 196 and 197:
NWP 4-01.4EASING-OUT LINE2. Upon re
Page 198 and 199:
NWP 4-01.4HOSE AND 3-1/2" (88.9 mm)
Page 200 and 201:
NWP 4-01.4400' (121.9 m) 1-1/2" (38
Page 202 and 203:
NWP 4-01.4ITEM NOMENCLATURE QUANTIT
Page 204 and 205:
1" (25.4 mm) PELICAN HOOKTENSIONED
Page 206 and 207:
NWP 4-01.42. One reserve radio tran
Page 208 and 209:
NWP 4-01.410. Attaches the riding l
Page 210 and 211:
NWP 4-01.45.8.9.1 MSC 4020-4 Discha
Page 212 and 213:
NWP 4-01.45.9 REFERENCESATP 16, Rep
Page 214 and 215:
Tanker(MS/SS)RadioCallSignDWT (2) L
Page 216 and 217:
NWP 4-01.4DECK DEPARTMENT1. Purge a
Page 219 and 220:
NWP 4-01.4CHAPTER 6Solid Cargo Tran
Page 221 and 222:
NWP 4-01.4transfer, when no other a
Page 223 and 224:
NWP 4-01.46.3.5 Transfer of Ammunit
Page 225 and 226:
NWP 4-01.47. If the receiving ship
Page 227 and 228:
NWP 4-01.4position and remains exte
Page 229 and 230:
NWP 4-01.4(see Figure 6-5). When us
Page 231 and 232:
NWP 4-01.4KINGPOST (M-FRAME TYPE SH
Page 233 and 234:
NWP 4-01.4OUTHAUL(TENSIONED)STREAMT
Page 235 and 236:
NWP 4-01.4(a)POSITIVE LOCK CHAIN(b)
Page 237 and 238:
NWP 4-01.4SINGLE-PALLET LOADSUSE EI
Page 239 and 240:
NWP 4-01.4TRAVELINGSURFSTAR LATCH A
Page 241 and 242:
NWP 4-01.4STREAM rigs in order of p
Page 243 and 244:
NWP 4-01.4OUTHAULSTAR LATCHASSEMBLY
Page 245 and 246:
NWP 4-01.4PUSH STAR LATCHES INBOARD
Page 247 and 248:
NWP 4-01.4TWO STOPS ARE ATTACHED 35
Page 249 and 250:
NWP 4-01.4SURFSTAR LATCH ASSEMBLYST
Page 251 and 252:
NWP 4-01.4(3) DELIVERY SHIPThe SURF
Page 253 and 254:
NWP 4-01.4TWO STOPS ARE ATTACHED 35
Page 255 and 256:
NWP 4-01.49. Ensure that all necess
Page 257 and 258:
NWP 4-01.4transfer head. Inhaul win
Page 259 and 260:
NWP 4-01.4RAM TENSIONERTENSIONED HI
Page 261 and 262:
NWP 4-01.43. After the easing-out l
Page 263 and 264:
NWP 4-01.4NoteThe receiving station
Page 265 and 266:
NWP 4-01.4MK II5,700 (2,584 KG) CAP
Page 267 and 268:
NWP 4-01.4FIXED PADEYEORPENDANTTENS
Page 269 and 270:
NWP 4-01.412. When slings are engag
Page 271 and 272:
NWP 4-01.4a.OUTHAULTENSIONEDHIGHLIN
Page 273 and 274:
NWP 4-01.45. Position the return lo
Page 275 and 276:
NWP 4-01.4STREAM rigs are capable o
Page 277 and 278:
NWP 4-01.4MK 6 STRONGBACK+ +(GULLWI
Page 279 and 280:
NWP 4-01.4STREAM Rigs for All Ships
Page 281:
NWP 4-01.4STREAM Rigs for All Ships
Page 284 and 285:
NWP 4-01.4NONTENSIONEDRIG (Note 1)D
Page 286 and 287:
1.0W1.0W1.0W1.0WNWP 4-01.41.07WPROP
Page 288 and 289:
ALL PREVENTERS ANDGUYS ARE NOT SHOW
Page 290 and 291:
NWP 4-01.44. Fake down the rig mess
Page 292 and 293:
NWP 4-01.4PREFERRED RIGACCEPTABLE R
Page 294 and 295:
NWP 4-01.45. Adjust the wire, so th
Page 296 and 297:
NWP 4-01.4station, passing the line
Page 298 and 299:
NWP 4-01.4BURTON RIGDELIVERY SHIPEQ
Page 300 and 301:
NWP 4-01.4BURTON RIGRECEIVING SHIPE
Page 303 and 304:
NWP 4-01.4CHAPTER 8Personnel Transf
Page 305 and 306:
NWP 4-01.4STREAMTROLLEYHIGHLINESTOP
Page 307 and 308:
NWP 4-01.4STREAM TROLLEYCARGODROP R
Page 309 and 310:
NWP 4-01.42. Attach the inhaul to t
Page 311 and 312:
NWP 4-01.4NoteCoil the easing-out l
Page 313 and 314:
NWP 4-01.46. Signal the delivery st
Page 315 and 316:
NWP 4-01.4NoteDo not install the tr
Page 317 and 318:
NWP 4-01.4CHAPTER 9Personnel, Light
Page 319 and 320:
NWP 4-01.4FOR TRANSFER CHAIRLINK AN
Page 321 and 322:
14"(355.6 mm)9-5 ORIGINALFigure 9-3
Page 323 and 324:
NWP 4-01.4Transfer personnel intern
Page 325 and 326:
NWP 4-01.4DELIVERY SHIP EQUIPMENT C
Page 327 and 328:
NWP 4-01.4CHAPTER 10Vertical Replen
Page 329 and 330:
NWP 4-01.4CARRIERS/AIR CAPABLE SHIP
Page 331 and 332:
NWP 4-01.410.2.2.3 Ship-Produced In
Page 333 and 334:
NWP 4-01.410.5.3 Forklift Trucks. F
Page 335 and 336:
NWP 4-01.4HOISTING SLING MK 105WITH
Page 337 and 338:
NWP 4-01.4UPPER EYE (ENCASED IN POL
Page 339 and 340:
NWP 4-01.410.6 VERTREP PREPARATIONS
Page 341 and 342:
NWP 4-01.4CBCADBSTEP 2STEP 1DDABCST
Page 343 and 344:
NWP 4-01.4LATCHLOCKSWAGED STOPBAILD
Page 345 and 346:
NWP 4-01.41. TO OPEN HOOK — Grasp
Page 347 and 348:
NWP 4-01.4NoteSteadying line is ten
Page 349 and 350:
NWP 4-01.4H-46VERTREPLINE4' (1.21 M
Page 351 and 352:
NWP 4-01.4WARNINGIn the case of the
Page 353 and 354:
NWP 4-01.4WARNINGWhen making up ret
Page 355 and 356:
NWP 4-01.410.11 NIGHT VERTREPShips
Page 357 and 358:
NWP 4-01.4WARNINGRotor downwash cre
Page 359 and 360:
NWP 4-01.42. After landing, the air
Page 361 and 362:
NWP 4-01.410.16.5.2 Communications.
Page 363:
NWP 4-01.45. Personnel being caught
Page 366 and 367:
NWP 4-01.4SAFETYGRAM(Mark X in appr
Page 368 and 369:
NWP 4-01.4WARNINGContains phosphate
Page 370 and 371:
NWP 4-01.4-4,000(1,814)RECEIVING SH
Page 373 and 374:
NWP 4-01.4APPENDIX CReplenishment O
Page 375 and 376:
NWP 4-01.4STANDARD PROCEDURES (Para
Page 377 and 378:
NWP 4-01.4STANDARD PROCEDURES (Para
Page 379 and 380:
NWP 4-01.4EMERGENCY BREAKAWAY (Para
Page 381:
NWP 4-01.4APPENDIX DReplenishment C
Page 384 and 385:
NWP 4-01.4REPLENISHMENT CHECKLISTEn
Page 386 and 387:
NWP 4-01.4REPLENISHMENT CHECKLISTNi
Page 388 and 389:
NWP 4-01.4REPLENISHMENT CHECKLISTFu
Page 390 and 391:
NWP 4-01.4REPLENISHMENT CHECKLISTST
Page 392 and 393:
NWP 4-01.4REPLENISHMENT CHECKLISTFu
Page 394 and 395:
NWP 4-01.4REPLENISHMENT CHECKLISTSy
Page 396 and 397:
NWP 4-01.419. Replenishment complet
Page 398 and 399:
NWP 4-01.4E.4 ADMINISTRATIVE PROCED
Page 400 and 401:
NWP 4-01.4as to risk hazard to the
Page 402 and 403:
NWP 4-01.4— spelled out — and t
Page 405 and 406:
NWP 4-01.4APPENDIX GReplenishment R
Page 407 and 408:
NWP 4-01.4APPENDIX HMetric Weights
Page 409:
NWP 4-01.4LENGTHinches x 25.4 = mmi
Page 413 and 414:
NWP 4-01.4APPENDIX JAstern FAS Hose
Page 415 and 416:
NWP 4-01.4PARTS LISTPART NO.DESCRIP
Page 417 and 418:
NWP 4-01.43. Place hose crimper (6)
Page 419 and 420:
NWP 4-01.4OPERATING INSTRUCTIONS FO
Page 421 and 422:
NWP 4-01.4APPENDIX KStation-Keeping
Page 423 and 424:
NWP 4-01.4APPENDIX LPotable Water T
Page 425 and 426:
NWP 4-01.4INDEXAPageNo.Abnormal ope
Page 427 and 428:
NWP 4-01.4Streaming the lay-on-deck
Page 429 and 430:
NWP 4-01.4Hoists, signal flag .....
Page 431 and 432:
NWP 4-01.4Oil spill prevention ....
Page 433 and 434:
NWP 4-01.4PageNo.STREAM support leg
Page 435 and 436:
NWP 4-01.4PageNo.Staging:Cargo ....
Page 437:
NWP 4-01.4LIST OF EFFECTIVE PAGESEf
show all

UNDERWAY REPLENISHMENT NWP 4-01.4 - Historic Naval Ships ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?